Xylem Bell & Gossett e-1510 Series Bedienungsanleitung

1 Introduction

NOTICE:

Read the installation, operation and maintenance instructions located

on the Xylem website before use. Improper use of the product can

cause personal injury and damage to property and may void the war‐

ranty. See e1510 Instruction Manual for complete Product Warranty.

WARNING:

Personal protective equipment should be worn when

handling this equipment. Only use properly sized certi‐

fied lifting equipment & lifting devices, including slings,

suitably rated for the weights to be lifted. Slings, when

used, must be of identical materials to avoid differences

in stretch rates. Do not use lifting devices that are frayed,

kinked, unmarked, or worn.

WARNING:

Always lock out power to the driver before you perform

any installation of maintenance tasks. Failure to discon‐

nect and lock out driver power will result in serious injury.

WARNING:

This product can expose you to chemicals including

Lead, which is known to the State of California to cause

cancer and birth defects or other reproductive harm. For

more information go to: www.P65Warnings.ca.gov.

2 Transportation Requirements

QUICKSTART GUIDE

P2004388 Rev A

Series e-1510 THE MANUAL IS AVAILABLE AT:

https://qr.xylemsales.com/c8poit

For safety and correct product usage, read the manual before this

product is used.

3 Foundation Requirements

1”

1. Pour grout here up to top surface / plane of base plate

2. Nut

3. Washer

4. Base plate

5. Shims or levelling wedges

6. Bolt sleeve

7. Anchor bolt

8. Concrete foundation

9. Position levelling wedges / shims on both sides of each anchor bolt

Notes:

• Distance from the base plate to the edge of the foundation to be greater than or equal to

1.5”.

• Foundation weight should be greater than or equal to 2.5 times of pump weight.

4 Piping Requirements

1. Check that a section of straight pipe, with a length that is a minimum of five times its di‐

ameter, is installed between the suction side of the pump and the first elbow, or that a

B&G Suction Diffuser is installed.

2. Check that there is a strong, rigid support for the suction and discharge lines.

3. Check that the suction or discharge lines are not forced into position.

4. Check that flexible piping is used on both the suction and discharge sides of the pump

when you use an isolation base.

5. Check that a B&G Triple Duty® valve is installed in the discharge line.

6. Check that the pipeline has isolation valves around the pump and has a drain valve in the

suction pipe.

5 Coupling Alignment

WARNING:

• Follow shaft alignment procedures in order to prevent cata‐

strophic failure of drive components or unintended contact of

rotating parts. Follow the coupling installation and operation

procedures from the coupling manufacturer.

• Always disconnect and lock out power to the driver before

you perform any installation or maintenance tasks. Failure to

disconnect and lock out driver power will result in serious

physical injury.

NOTICE:

Proper alignment is the responsibility of the installer and the user of the unit. Check the align‐

ment of frame-mounted units before you operate the unit. Failure to do so can result in equip‐

ment damage or decreased performance.

6 Checking Rotation

1. Lock out power to the driver.

2. Make sure that the coupling hubs are fastened securely to the shafts.

3. Unlock power to the driver.

4. Make sure that everyone is clear, and then jog the driver long enough to determine that

the direction of rotation corresponds to the arrow on the pump.

5. Lock out power to the driver.

For safety and correct product usage, read the manual before this product is used.

Xylem Inc.

8200 N. Austin Avenue, Morton Grove, IL 60053

Tel: (847) 966–3700, Fax: (847) 965–8379

www.xylem.com/bellgossett

Xylem and Bell & Gossett are registered trademarks of Xylem Inc. or one of its subsidiaries.

All other trademarks or registered trademarks are property of their respective owners.

P2004388_Rev A_en-US_2022-05_QG_Series e-1510

Andere Handbücher für Bell & Gossett e-1510 Series

Andere Xylem Wasserpumpe Handbücher

Xylem

Xylem Lowara Scuba Series Originalbetriebsanleitung

Xylem

Xylem JABSCO 23920 Series Bedienungsanleitung

Xylem

Xylem Goulds Marlow Series Handbuch

Xylem

Xylem Rule 27SA Bedienungsanleitung

Xylem

Xylem Lowara e-MPV Bedienungsanleitung

Xylem

Xylem LOWARA ESH Series Bedienungsanleitung

Xylem

Xylem Bell & Gossett TECHNOForce e-HV Series Bedienungsanleitung

Xylem

Xylem JABSCO 18660 Series Bedienungsanleitung

Xylem

Xylem GOULDS NPO Bedienungsanleitung

Xylem

Xylem Lowara SEKAMATIK 10 E 15M Series Service-Handbuch

Xylem

Xylem FLYGT Flygt 2071 Bedienungsanleitung

Xylem

Xylem LOWARA e-SHE Series Bedienungsanleitung

Xylem

Xylem wtw F 800 DIN Bedienungsanleitung

Xylem

Xylem Goulds AquaBoost Advanced Bedienungsanleitung

Xylem

Xylem Goulds J Series Bedienungsanleitung

Xylem

Xylem Jabsco 15170 Series Bedienungsanleitung

Xylem

Xylem Flygt 3085 Wartungshandbuch

Xylem

Xylem GOULDS 2GFK2412H Bedienungsanleitung

Xylem

Xylem FLOJET VFLO 5.0 Bedienungsanleitung

Xylem

Xylem Flojet G55 Series Bedienungsanleitung

Xylem

Xylem GOULDS AC8743 Bedienungsanleitung

Xylem

Xylem Lowara e-SVI Series Handbuch

Xylem

Xylem LSP0712F Bedienungsanleitung

Xylem

Xylem Lowara MP Handbuch

Beliebte Wasserpumpe Handbücher anderer Marken

Neptun

Neptun NPHW 5500 Bedienungsanleitung

Sensidyne

Sensidyne Gilian BDX-II Montage- und Bedienungsanleitung

Draper

Draper 47808 Bedienungsanleitung

Trolla

Trolla 12820 Bedienungsanleitung

Sunfab

Sunfab SVH Series Bedienungsanleitung

WilTec

WilTec 50740 Bedienungsanleitung

Fieldmann

Fieldmann FVC 5015 EK Bedienungsanleitung

Everbilt

Everbilt EFSUB5-122HD Bedienungsanleitung

Graco

Graco Husky 3300e Bedienungsanleitung

esotec

esotec 101018 Bedienungsanleitung

Becker

Becker BASIC VASF 2.80/1-0.AC230 Bedienungsanleitung

Sykes AmeriPumps

Sykes AmeriPumps GP100M Fehlerbehebungshandbuch

DUROMAX

DUROMAX XP WX Series Bedienungsanleitung

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Bedienungsanleitung

Franklin Electric

Franklin Electric IPS Bedienungsanleitung

Milton Roy

Milton Roy PRIMEROYAL Bedienungsanleitung

STA-RITE

STA-RITE ST33APP Bedienungsanleitung

GÜDE

GÜDE HWW 900 GC Bedienungsanleitung