Zephyr Essentials Milano Wall Installationsanleitung

Use, Care, and Installation Guide

www.zephyronline.com

Model number:

Serial Number:

AUG15.0801 © Zephyr Ventilation LLC.

For use with models of serial numbers beginning with 24

Airﬂow Control Technology

Milano Wall

ZMI-M90BS

ZMI-M90BG

Duct pieces To t a l

Equivalent number

length x used =

3-1/4” x 10”

Rect.,

straight

1 Ft. x ( ) = Ft.

3-1/4” x 10”

Rect.to

6” round

transition

5 Ft. x ( ) = Ft.

3-1/4” x 10”

Rect.to

6” round

transition

900 elbow

20 Ft. x ( ) = Ft.

6”, 7”, 8”, 10”

Round,

900

15 Ft.

x ( ) = Ft.

6”, 7”, 8”, 10”

Round,

450

9 Ft. x ( ) = Ft.

Ft.

6”, 7”, 8”, 10”

Round,

straight

1 Ft. x ( ) = Ft.

Subtotal column1 =

Duct pieces To t a l

Equivalent number

length x used =

6”, 7”, 8”, 10”

Round, wall

cap with

damper

30 Ft. x ( ) = Ft.

Ft.

6”, 7”, 8”, 10”

Round

roof cap

30 Ft. x ( ) = Ft.

Subtotal column2 =

Subtotal column1 =

Total ductwork =

MaximumDuct Length:For satisfactory air movement,

the total duct length

should not exceed 100 equivalent feet.

6” roundto

3-1/4” x 10”

rect.

transition

1 Ft. x ( ) = Ft.

6” roundto

3-1/4” x 10”

rect.

transition

900 elbow

16 Ft. x ( ) = Ft.

7” roundto

3 1/4” x 10”

rect.

transition

8 Ft. x ( ) = Ft.

7” roundto

3-1/4” x 10”

rect.

transition

900 elbow

23 Ft. x ( ) = Ft.

elbow

7” to 6” or

8” to 7” Round

tapered

reducer

25 Ft. x ( ) = Ft.

3-1/4” x 10”

Rect.900

elbow

15 Ft. x ( ) = Ft.

3-1/4” x 10”

Rect.450

elbow

9 Ft. x ( ) = Ft.

3-1/4” x 10”

Rect.900

flat elbow

24 Ft. x ( ) = Ft.

3-1/4” x 10”

Rect.

wallcap

with damper

30 Ft. x ( ) = Ft.

Ft. x ( ) = Ft.

6”, 7“, 8”

Round

in-line

damper

Installation – Ducting Calculation Sheet

Installation – Mounting Height & Clearance

www.zephyronline.com

DUCTING

A minimum of 8” round duct is recomended to

PDLQWDLQPD[LPXPDLUÀRZHI¿FLHQF\

Always use rigid type metal ducts only. Flexible

GXFWVFRXOGUHVWULFWDLUÀRZE\XSWR

Use calculation worksheet to compute total duct

ZRUN3DJH

ALWAYS, when possible, reduce the number of

transitions and turns. If a long duct run is required,

increase duct size from 8” to 10”.

If turns or transitions are required: Install as far

away from duct opening and as far apart between

the two transitions as possible.

Minimum mount height between range top to hood

bottom should be no less than 26”.

Maximum mount height should be no higher than

34”.

It is important to install the hood at the proper

mounting height. Hoods mounted too low could

UHVXOWLQKHDWGDPDJHDQG¿UHKD]DUGZKLOHKRRGV

mounted too high will be hard to reach and will

ORRVHLWVSHUIRUPDQFHDQGHI¿FLHQF\

If available, also refer to range manufacturer’s

height clearance requirements and recommended

hood mounting height above range. Always check

your local codes for any differences.

Duct cover extension kit available for ceiling

heights up to 12 feet. Turn to page 18 for part

number and ordering information.

DAMAGE-SHIPMENT / INSTALLATION:

 3OHDVHIXOO\LQVSHFWXQLWIRUGDPDJHEHIRUH

installation.

 ,IWKHXQLWLVGDPDJHGLQVKLSPHQWUHWXUQWKH

unit to the store in which it was bought for

repair or replacement.

 ,IWKHXQLWLVGDPDJHGE\WKHFXVWRPHUUHSDLU

or replacement is the responsibility of the

customer.

 ,IWKHXQLWLVGDPDJHGE\WKHLQVWDOOHULIRWKHU

WKDQWKHFXVWRPHUUHSDLURIUHSODFHPHQWPXVW

be made by arrangement between customer

and installer.

26” min.

34” max.

min. A

min. B

max. C

min. D

min. E

max. F

Standard Extension

Hood Heights Duct Cover Duct Cover

minimum ducted (A) 26-1/2” 42“

minimum recirculating (B) 31” 46“

maximum (C) 50” 80”

Ceiling Heights

minimum ducted (D) 88-1/2” (7’ 4-1/2) 104“ (8‘ 8”)

minimum recirculating (E) 93” (7’9”) 108“ (9‘)

maximum (F) 120” (10’ ) 150” (12’ 6”)

36”

WARNING FIRE HAZARD

NEVER exhaust air or terminate duct work into spaces between walls, crawl spaces, ceiling, attics or garages.

All exhaust must be ducted to the outside, unless using the recirculating option.

Use single wall rigid Metal ductwork only.

)DVWHQDOOFRQQHFWLRQVZLWKVKHHWPHWDOVFUHZVDQGWDSHDOOMRLQWVZFHUWL¿HG6LOYHU7DSHRU'XFW7DSH

Some Ducting Options

Installation – Ducting Options

side wall cap

w/ gravity damper

Soffit or crawl space

Roof Pitch w/

Flashing & Cap

ductless

recirculating

side wall cap

w/ gravity damper

(blower

housing)

(blower

housing)

(blower

housing)

(blower

housing)

www.zephyronline.com

Installation – +RRG6SHFL¿FDWLRQV

side of hood

front of hood

top of hood

STANDARD

min. ducted - 26 1/2”

min. recirc. - 31”

max. - 50”

Z1C-01MI

min. ducted - 42”

min. recirc. - 46”

max. - 80”

13 5/8”

20 1/2”

12 13/16”

23 15/16”

6 3/8”

18 1/16”

8 3/8”

35 3/16”

4 1/8”

5 3/4”

AC In

7 15/16”

 0HDVXUHIURPUDQJHWRSWRKRRGERWWRPDQGPDUNOLQH$´

PLQLPXPIURPUDQJHWRS

2. Plum and mark center line.

 0DUNPRXQWLQJKHLJKWOLQH%´IURPOLQH$

 0DUNPRXQWLQJVSUHDGIURP&/´

 )DVWHQ0[´VFUHZVLQWRVWXGVRQOLQH%EXWGRQRW

tighten all the way. Note: Wood blocking may need to be

added behind the drywall if no studs are present. Wall

anchors may also be used but check local codes for

compliance. Failure to use suitable wall anchors and

screws to hold the weight of the hood could result in

personal injury or damage to cooking surface or counter.

5HPRYHWDSHDQGVFUHZVVHFXULQJHOHFWURQLFVPRXQWLQJ

bracket to hood. Reposition electronics mounting bracket as

VKRZQLQ),*%DQGVHFXUHWRPRWRUKRXVLQJXVLQJWKH

previously removed screws.

5HPRYHVFUHZVVHFXULQJHOHFWULFDOMXQFWLRQER[WR

HOHFWURQLFVPRXQWLQJSODWH5HPRYHMXQFWLRQER[),*%

 5HPRYHWKHDOXPLQXPPHVK¿OWHU

9. Hang hood onto the mounting screws and hand tighten each

VFUHZ),*$6HFXUHWKLUG0[´VFUHZWKURXJKLQVLGH

RIKRRGLQWRZDOOIRUH[WUDVXSSRUW),*$

10. Center and attach duct cover mounting bracket to wall just

EHORZWKHFHLOLQJRUVRI¿WXVLQJ0[´VFUHZV

11. Install electrical and duct work. Seal duct work with aluminum

duct tape. Re-install electrical junction box with cable lock and

LQVWDOOWKHHOHFWULFDO),*%

12. Power up hood and check for leaks around duct tape.

3ODFHWHOHVFRSLFGXFWFRYHUVRQWRKRRGDQGH[WHQGLQQHUWRS

GXFWFRYHUXSZDUGVDQGVHFXUHWRGXFWFRYHUEUDFNHWXVLQJ

M3.5 x 8 screws.

14. Place canopy over hood body and secure it to hood body using

[VFUHZVWKURXJK¿OWHURSHQLQJ

5HLQVWDOODOXPLQXPPHVK¿OWHU

* If using hood in recirculating mode you must secure the air diverter

plate onto wall before installing duct work and duct covers. Turn

to page 10 for more details.

11 1/4”

18 5/8”

Brackets are

pre-installed

26” min

CAUTION: At least two installers are

required due to the weight and size of the

hood.

WARNING: Electrical wiring must be done by a qualified person(s) in

accordance with all applicable codes and standards. This range hood must be

properly grounded. Turn off electrical power at service entrance before wiring.

Installation – Mounting the Hood

Cable Lock

Motor Housing

Cable Lock

$FDEOHORFNLQJFRQQHFWRUQRWVXSSOLHGPLJKW

be required by local codes. Check with local

requirements and codes, purchase and install

appropriate connector if necessary.

FIG. A

FIG. B

www.zephyronline.com

Ductless recirculation is intended for applications where an exhaust duct work is not possible to be installed.

When converted, the hood functions as a recirculating hood rather than an exhaust hood. Fumes and exhaust

IURPFRRNLQJDUHGUDZQDQG¿OWHUHGE\DVHWRIRSWLRQDOFKDUFRDO¿OWHUV7KHDLULVWKHQSXUL¿HGDQGUH

circulated back within the home.

We recommend toALWAYS exhaust air outside of the home by employing existing or installing new duct

ZRUNLISRVVLEOH7KHKRRGLVPRVWHIIHFWLYHDQGHI¿FLHQWDVDQH[KDXVWKRRG2QO\ZKHQWKHH[KDXVWRSWLRQ

is not possible should you recourse to converting the hood into a recirculating hood.

:KHQFRQYHUWHGWREHDUHFLUFXODWLQJKRRGDVHWRIFKDUFRDO¿OWHUVDUHUHTXLUHGRQWRSRILWVVWDQGDUG

Aluminum Mesh Filter set. Order according to its Part number below. The standardAluminum Mesh Filters

DUHLQWHQGHGWRFDSWXUHUHVLGXHIURPFRRNLQJDQGWKHRSWLRQDOFKDUFRDO¿OWHUVKHOSWRSXULI\IXPHVH[KDXVWHG

from cooking for re-circulation.

RECIRCULATING KIT (REQUIRED IF NO DUCTING IS USED)

.LWLQFOXGHVFKDUFRDO¿OWHUVDQGDLUGLYHUWHUSODWH

Hood Model Part No. Filters in Pkg.

ZMI-M90BG/BS ZRC-00MI 2

1. Purchase recirculating kit per the part number above

 6HFXUHDLUGLYHUWHUSODWHWRZDOOEHORZGXFWFRYHUEUDFNHW),*

&5XQ´GXFWLQJIURPWRSRIKRRGDQGVHFXUHWRDLUGLYHUWHU

plate. See manual included with recirculating kit for more

detailed instructions.

 5HPRYHDOXPLQXPPHVK¿OWHUIURPKRRG,QVWDOOFKDUFRDO¿OWHU

EUDFNHWLQVLGH¿OWHURSHQLQJ1RWHVFUHZVWRVHFXUHFKDUFRDO

¿OWHUEUDFNHWDUHDOUHDG\SUHLQVWDOOHGLQWKHKRRGDQGPXVW¿UVW

EHUHPRYHG&OLSFKDUFRDO¿OWHUVRQWRFKDUFRDO¿OWHUEUDFNHW

),*&

5H,QVWDOODOXPLQXPPHVK¿OWHU

 (QDEOHFKDUFRDO¿OWHUFKDQJHLQGLFDWRURQFRQWUROSDQHO5HIHU

GHWDLOVWRSJ

 &KDUFRDO¿OWHUVPXVWEHUHSODFHGDIWHUHYHU\KRXUVRIXVH

RUDSSUR[LPDWHO\HYHU\WRPRQWKVEDVHGRQWKHDYHUDJH

RIKUVRIGDLO\FRRNLQJWLPH7KHPLFURSURFHVVRULQ

the controls when set, will elapse and count usage time and

LQGLFDWHZKHQFKDUFRDO¿OWHUUHSODFHPHQWLVUHTXLUHGHYHU\

hours.

Charcoal Filter Replacements

Hood Model Part No. Qty to Order

ZMI-M90BS/BG Z0F-C002 2

'2127:$6+&+$5&2$/),/7(56&KDUFRDO¿OWHUVPD\QHHG

to be changed more often depending on cooking habits.

Installation – Ductless Recirculating

FIG. C

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Zephyr Essentials Dunstabzugshaube Handbücher

Zephyr Essentials

Zephyr Essentials Tornado Mini AK8400AS Installationsanleitung

Zephyr Essentials

Zephyr Essentials Siena Pro Island Installationsanleitung

Zephyr Essentials

Zephyr Essentials Anzio Island ZAZ-M90CS Installationsanleitung

Zephyr Essentials

Zephyr Essentials Vortex AK9034AS-ES Installationsanleitung

Zephyr Essentials

Zephyr Essentials Power Vortex ES Series Installationsanleitung

Zephyr Essentials

Zephyr Essentials Modena Island ZMD-M90AS Installationsanleitung

Zephyr Essentials

Zephyr Essentials Europa Savona Series Installationsanleitung

Zephyr Essentials

Zephyr Essentials Monsoon Mini Installationsanleitung

Zephyr Essentials

Zephyr Essentials ZAN-E30CS Installationsanleitung

Zephyr Essentials

Zephyr Essentials Breeze I AK1100 Series Installationsanleitung

Zephyr Essentials

Zephyr Essentials Venezia Series Bedienungsanleitung

Zephyr Essentials

Zephyr Essentials Twister AK8000BS Installationsanleitung

Zephyr Essentials

Zephyr Essentials Monsoon Mini AK9128AS Installationsanleitung

Zephyr Essentials

Zephyr Essentials ZAN-E30CBS Installationsanleitung

Zephyr Essentials

Zephyr Essentials Pyramid ZPY-E30AB Installationsanleitung

Zephyr Essentials

Zephyr Essentials Siena Pro ZSP-E48AS Installationsanleitung

Zephyr Essentials

Zephyr Essentials Twister AK8000AS-ES Installationsanleitung

Zephyr Essentials

Zephyr Essentials Spruce AK9834AS Installationsanleitung

Zephyr Essentials

Zephyr Essentials Modena ZMO-E30AS Installationsanleitung

Zephyr Essentials

Zephyr Essentials Roma Wall ZRO-E30CS Installationsanleitung

Zephyr Essentials

Zephyr Essentials Typhoon AK2100BW Installationsanleitung

Zephyr Essentials

Zephyr Essentials ACT Tempest II AK7500BS Installationsanleitung

Zephyr Essentials

Zephyr Essentials Verona Island Installationsanleitung

Zephyr Essentials

Zephyr Essentials Breeze I AK1124 Series Installationsanleitung

Beliebte Dunstabzugshaube Handbücher anderer Marken

emmeti

emmeti RECUPA MED A-140 Leitfaden

Nibe

Nibe F135 Bedienungsanleitung

Kuppersberg

Kuppersberg INTRO 60 Montage- und Wartungsanleitung

Zephyr

Zephyr Spruce AK9834BS Installationsanleitung

Hisense

Hisense MH6INBG Bedienungsanleitung

Miele

Miele DA 1255 Bedienungsanleitung

Broan

Broan 46000 Bedienungsanleitung

GE Profile PV977 Originalbetriebsanleitung

FALMEC

FALMEC FFRIA24W5FS Bedienungsanleitung

Whirlpool

Whirlpool RH2600XL-1 SERIES Bedienungsanleitung

Küppersbusch

Küppersbusch DX ISLA Bedienungsanleitung

ETNA

ETNA AV360RVS Bedienungsanleitung

JUNO

JUNO JDF603E6 Bedienungsanleitung

Miele

Miele DA 6708 D Bedienungsanleitung

Tricity Bendix

Tricity Bendix LE 150 Handbuch

AEG

AEG X68163BV1 Bedienungsanleitung

AEG

AEG 125 D Bedienungsanleitung

Smeg

Smeg KSEV97X Bedienungsanleitung