AirSep Centrox Bedienungsanleitung

INSTRUCTION MANUAL

Centrox

PSA Oxygen Concentrator

Ownership Data

Take a moment to note important information below about your AirSep Centrox PSA

Oxygen Concentrator. Keep this instruction manual, along with your invoice, to serve as

a permanent record of your purchase.

PSA Oxygen Concentrator

Model Number

Serial Number

Invoice Date

Start-up Date

AirSep Representative

Company

Contact

Address

City/Town

State

Zip/Postal Code

Country

Fax

Phone

Cell

Before you attempt to install, operate, or repair the oxygen

concentrator, read and thoroughly understand this instruction

manual. Improper operation can result in severe bodily injury,

damage to the oxygen generator, or poor performance.

Symbols/Abbreviations

Symbols are frequently used on equipment in preference to words with the intention

of lessening any possibility of misunderstanding caused by language differences.

Symbols can also permit easier comprehension of a concept within a restricted

space.

The following table is a list of symbols and denitions that may be used with AirSep

oxygen equipment. These symbols are referenced from the appropriate International

Electro-technical Commission (IEC) standards:

Symbol Description Symbol Description

ON (power switch on) 0OFF (power switch off)

No smoking Do not disassemble

Date of manufacture Consult instructions for use

Warning – Describes a hazard or

unsafe practice that if not avoided

can result in severe bodily injury,

death or property damage

See Instructions

Caution – Describes a hazard or

unsafe practice that if not avoided

can result in minor bodily injury or

property damage

Safety agency for CAN/CSA

C22.2 No. 601.1 M90 for medical

electrical equipment

Note – Provides information

important enough to emphasize

or repeat

Keep unit and accessories dry

Manufacturer

Proper disposal of waste

of electrical and electronic

equipment required

Use no oil or grease Do not expose to open ames

Catalog number Keep in the vertical position

Safety agency for CAN/CSA

C22.2 No. 601.1 M90 for medical

electrical equipment

Serial number

Fragile – handle with care

EC REP

Authorized Representative in the

European Community

Tables of Contents

1.0 Introduction

1.1 GENERAL 9

1.2 WARNINGS, CAUTIONS, AND NOTES 9

1.3 REFERENCES TO CONTROLS AND INDICATORS

WITH LABELS 9

2.0 Safety

2.1 GENERAL 11

2.2 POTENTIAL HAZARDS 11

2.3 SAFETY PUBLICATIONS 13

3.0 System Description

3.1 INTRODUCTION 15

4.0 Controls, Parts, and Connections

4.1 INTRODUCTION 17

4.2 OXYGEN CONCENTRATOR CONTROLS AND INDICATORS 17

4.3 OXYGEN CONCENTRATOR PARTS 20

4.4 AUXILIARY KITS INFORMATION (OPTIONAL) 23

4.5 CONNECTIONS 25

5.0 Installation

5.1 UNPACKING 27

5.2 PRE-INSTALLATION GUIDELINES 29

5.3 INSTALLATION INSTRUCTIONS 30

6.0 Operation

6.1 INITIAL START-UP 33

6.2 OPERATION 36

6.3 SHUTDOWN 37

6.4 NORMAL START-UP 37

6.5 START-UP AFTER AN EXTENDED SHUTDOWN 37

7.0 Maintenance/Service

7.1 WEEKLY MAINTENANCE 39

7.2 SEMI-ANNUAL MAINTENANCE 40

7.3 ANNUAL MAINTENANCE 42

7.4 PRESSURE SWITCH ADJUSTMENT PROCEDURE 43

8.0 Troubleshooting

8.1 TROUBLESHOOTING CHART 48

8.2 SOLENOID VALVE TROUBLESHOOTING 55

A. Appendix Technical Data

A.1 SPECIFICATIONS 59

A.2 DRAWINGS AND SCHEMATICS 60

B. Appendix Warranty/Returns

B.1 PRODUCT WARRANTY 65

B.2 LIMITS OF LIABILITY 66

B.3 RETURNING THE OXYGEN CONCENTRATOR OR A

COMPONENT FOR SERVICE 66

C. Appendix

C.1 OXYGEN GENERATOR DECOMMISSIONING AND DISPOSAL

GUIDELINE 69

List of Figures and Tables

Figure 3.1: Centrox Oxygen Concentrator 15

Figure 4.1: Air Compressor Module 17

Figure 4.2: PSA Concentrator Module Controls and Indicators 18

Figure 4.3: Compressor Module Internal Components 20

Figure 4.4: PSA Module Internal Components 21

Table 4.1: Optional Starter Kits for the Concentrator Purchased 23

Table 4.2: Description of the Parts included in the Starter Kits 24

Figure 4.5: Oxygen Receiver 25

Figure 5.1: General Arrangement of the Centrox Concentrator 31

Figure 6.1: PSA Module Supply Valve Assembly 36

Table 7.3: Maintenance Chart 39

Figure 7.1: Pressure Switch 44

Table A.1: Centrox Specifications 59

Figure A.1: Flow Schematic 60

Figure A.2: Wiring Schematic (120 V, 60 Hz) – PSA Module 61

Figure A.3: Wiring Schematic (240 V, 50 Hz) – PSA Module 62

Figure A.4: Wiring Schematic (120 V, 60 Hz) – Compressor Module 63

Figure A.5: Wiring Schematic (240 V, 50 Hz) – Compressor Module 64

Centrox Instruction Manual 9

AirSep Corporation

1.0 Introduction

1.1 GENERAL

This instruction manual provides a description of the AirSep Centrox Pressure Swing

Adsorption (PSA) Oxygen Concentrator as well as instructions for its installation,

operation, and maintenance. Pertinent drawings and component information are

also included.

To ensure safe operation and proper system maintenance, AirSep Corporation

recommends that you keep this instruction manual readily available for reference.

1.2 WARNINGS, CAUTIONS, AND NOTES

As you read the instruction manual, pay special attention to the Warning, Caution,

and Note messages. They identify safety guidelines or other important information

as follows:

Provides information that can prevent severe bodily injury or death.

Provides information that can prevent minor bodily injury or

property damage.

Provides information important enough to emphasize or repeat.

1.3 REFERENCES TO CONTROLS AND INDICATORS

WITH LABELS

This operating manual uses uppercase characters (e.g., ON/OFF switch) to refer

to controls and indicators. Refer to section 4 for a description of all the controls and

indicators of the oxygen concentrator.

Inhaltsverzeichnis

Andere AirSep Medizinische Geräte Handbücher

AirSep

AirSep VisionAire 5 Bedienungsanleitung

AirSep

AirSep FreeStyle 5 Bedienungsanleitung

AirSep

AirSep FreeStyle Bedienungsanleitung

AirSep

AirSep VisionAire V Bedienungsanleitung

AirSep

AirSep VisionAire 5 Bedienungsanleitung

AirSep

AirSep LifeStyle Bedienungsanleitung

AirSep

AirSep Focus Portable Bedienungsanleitung

AirSep

AirSep ELITE Bedienungsanleitung

AirSep

AirSep VisionAire 2 Bedienungsanleitung

AirSep

AirSep NewLife Bedienungsanleitung

AirSep

AirSep FreeStyle Bedienungsanleitung

AirSep

AirSep Focus Portable Bedienungsanleitung

AirSep

AirSep FreeStyle 5 Bedienungsanleitung

AirSep

AirSep LifeStyle Bedienungsanleitung

AirSep

AirSep NewLife Intensity 10 Bedienungsanleitung

AirSep

AirSep FreeStyle Bedienungsanleitung

AirSep

AirSep LifeStyle Bedienungsanleitung

AirSep

AirSep FreeStyle Bedienungsanleitung

AirSep

AirSep NewLife Intensity 10 Bedienungsanleitung

AirSep

AirSep newlife intensity Bedienungsanleitung

AirSep

AirSep Focus Portable Bedienungsanleitung

AirSep

AirSep NewLife Elite Bedienungsanleitung

Beliebte Medizinische Geräte Handbücher anderer Marken

TekTone

TekTone Tek-CARE160 Bedienungsanleitung

NeuroMetrix

NeuroMetrix Quell 2.0 Bedienungsanleitung

AMT

AMT XLR8 Bedienungsanleitung

EDAN

EDAN SONOTRAX Pro Bedienungsanleitung

Restorative Therapies

Restorative Therapies RT300 Bedienungsanleitung

Gendex

Gendex Expert DC Bedienungsanleitung

Dexcowin

Dexcowin ADX4000W Bedienungsanleitung

Libelium

Libelium MySignals Bedienungsanleitung

Acelity

Acelity V.A.C.ULTA 4 Bedienungsanleitung

Caputron

Caputron ActivaDose II tDCS Bedienungsanleitung

Plinth 2000

Plinth 2000 93CDT Bedienungsanleitung

GE SENOGRAPHE 800T Bedienungsanleitung

GE Definium 5000 Bedienungsanleitung

Kanmed

Kanmed GE-1380 Bedienungsanleitung

Huntleigh

Huntleigh FD1 Bedienungsanleitung

Stryker

Stryker SPR Plus Bedienungsanleitung

Tobii Dynavox

Tobii Dynavox I-Series Bedienungsanleitung

S-Capepod

S-Capepod Evac Cocoon Bedienungsanleitung