Alliance Laundry Systems POCKET HARDMOUNT UW50P4 Bedienungsanleitung

Operation

www.comlaundry.com

Washer-Extractor

Pocket Hardmount

Instructions for Operating the

WE-4 and WE-5 Microcomputers

PHM542N

COLD / HOT / WARM /

LOW HIGH OVER

DISPLAY

CYCLE

TEMP. /

CLEAR DRAIN

STOP

ENTER

START

SOAK MEDIUM HIGH

PAUSE SPEED SPEED

ERASE

CYCLE

NUMBER

WASH / HEAT / SUPPLY

FLUSH RINSE

BUZZER

REVERSE

ADD

CYCLE

NUMBER /

ADVANCE

Part No. F232161

September 2002

UW50P4

means without the expressed written consent of the publisher.

F232161 1

Table of

Contents

Introduction......................................................................................... 3

Nameplate Location.............................................................................. 3

Replacement Parts ................................................................................ 3

Customer Service.................................................................................. 3

Safety Information.............................................................................. 5

Important Safety Instructions ............................................................... 5

Operation............................................................................................. 7

General Information.............................................................................. 7

Theory of Operation ............................................................................. 7

Start-Up................................................................................................. 8

Loading ................................................................................................. 8

Select Cycle .......................................................................................... 8

Start Cycle ............................................................................................ 8

Test Cycle ............................................................................................. 9

End of Cycle ......................................................................................... 9

LED Display ......................................................................................... 9

Test Procedure ...................................................................................... 11

Motor Thermal Overload Indicator ...................................................... 13

2F232161

Notes

F232161

Introduction

Nameplate Location

The nameplate is located at the top of the machine.

Always provide the machine’s serial number and

model number when ordering parts or when seeking

technical assistance.

Replacement Parts

If literature or replacement parts are required, contact

the source from which the machine was purchased or

contact Alliance Laundry Systems at (920) 748-3950

for the name and address of the nearest authorized

parts distributor.

Customer Service

For technical assistance, call any of the following

numbers:

(850) 718-1025

(850) 718-1026

Marianna, Florida U.S.A.

(920) 748-3121

Ripon, Wisconsin U.S.A.

PHM516N

1Nameplate

PHM516N

Notes

F232161

Safety Information

Precautionary statements (“DANGER,”“WARNING”

and “CAUTION”), followed by specific instructions,

are found in this manual and on machine decals. These

precautions are intended for the personal safety of the

operator, user, servicer, and those maintaining the

machine.

Additional precautionary statements (“IMPORTANT”

and “NOTE”) are followed by specific instructions.

IMPORTANT: The word “IMPORTANT” is used

to inform the reader of specific procedures where

minor machine damage will occur if the procedure

is not followed.

NOTE: The word “NOTE” is used to communicate

installation, operation, maintenance or servicing

information that is important but not hazard

related.

Important Safety Instructions

1. Read all instructions before using the washer.

2. Refer to the Grounding Instructions in the

installation manual for the proper grounding of

the washer.

3. Do not wash textiles that have been previously

cleaned in, washed in, soaked in, or spotted with

gasoline, dry-cleaning solvents, or other

flammable or explosive substances as they give

off vapors that could ignite or explode.

4. Do not add gasoline, dry-cleaning solvents, or

other flammable or explosive substances to the

wash water. These substances give off vapors that

could ignite or explode.

5. Under certain conditions, hydrogen gas may be

produced in a hot water system that has not been

used for two weeks or more. HYDROGEN GAS

IS EXPLOSIVE. If the hot water system has not

been used for such a period, before using a

washing machine or combination washer-dryer,

turn on all hot water faucets and let the water

flow from each for several minutes. This will

release any accumulated hydrogen gas. The gas is

flammable; do not smoke or use an open flame

during this time.

6. Do not allow children to play on or in the washer.

Close supervision of children is necessary when

the washer is used near children. This is a safety

rule for all appliances.

7. Before the washer is removed from service or

discarded, remove the door to the washing

compartment.

8. Do not reach into the washer if the wash drum is

moving.

DANGER indicates the presence of a

hazard that will cause severe personal

injury, death, or substantial property

damage if the danger is ignored.

DANGER

WARNING indicates the presence of a

hazard that can cause severe personal

injury, death, or substantial property

damage if the warning is ignored.

WARNING

CAUTION indicates the presence of a

hazard that will or can cause minor

personal injury or property damage if the

caution is ignored.

CAUTION

To reduce the risk of fire, electric shock,

serious injury or death to persons when

using your washer, follow these basic

precautions:

W023E

WARNING

Safety Information

F232161

9. Do not install or store the washer where it will be

exposed to water and/or weather.

10. Do not tamper with the controls.

11. Do not repair or replace any part of the washer, or

attempt any servicing unless specifically

recommended in the user-maintenance

instructions or in published user-repair

instructions that the user understands and has the

skills to carry out.

12. To reduce the risk of an electric shock or fire, DO

NOT use an extension cord or an adapter to

connect the washer to the electrical power source.

13. Use washer only for its intended purpose,

washing textiles.

14. ALWAYS disconnect the washer from electrical

supply before attempting any service. Disconnect

the power cord by grasping the plug, not the cord.

15. Install the washer according to the Installation

Instructions. All connections for water, drain,

electrical power and grounding must comply

with local codes and be made by licensed

personnel when required.

16. To reduce the risk of fire, textiles which have

traces of any flammable substances such as

vegetable oil, cooking oil, machine oil,

flammable chemicals, thinner, or anything

containing wax or chemicals such as in mops and

cleaning cloths, must not be put into the washer.

These flammable substances may cause the

fabric to catch on fire by itself.

17. Do not use fabric softeners or products to

eliminate static unless recommended by the

manufacturer of the fabric softener or product.

18. Keep washer in good condition. Bumping or

dropping the washer can damage safety features.

If this occurs, have washer checked by a qualified

service person.

19. Replace worn power cords and/or loose plugs.

20. Be sure water connections have a shut-off valve

and that fill hose connections are tight. CLOSE

the shut-off valves at the end of each wash day.

21. Loading door MUST BE CLOSED any time the

washer is to fill, tumble or spin. DO NOT

bypass the loading door switch by permitting the

washer to operate with the loading door open.

22. Always read and follow manufacturer’s

instructions on packages of laundry and cleaning

aids. Heed all warnings or precautions. To reduce

the risk of poisoning or chemical burns, keep

them out of the reach of children at all times

(preferably in a locked cabinet).

23. Always follow the fabric care instructions

supplied by the textile manufacturer.

24. Never operate the washer with any guards and/or

panels removed.

25. DO NOT operate the washer with missing or

broken parts.

26. DO NOT bypass any safety devices.

27. Failure to install, maintain, and/or operate this

washer according to the manufacturer’s

instructions may result in conditions which can

produce bodily injury and/or property damage.

NOTE: The WARNINGS and IMPORTANT

SAFETY INSTRUCTIONS appearing in this

manual are not meant to cover all possible

conditions and situations that may occur. Common

sense, caution and care must be exercised when

installing, maintaining, or operating the washer.

Any problems or conditions not understood should be

reported to the dealer, distributor, service agent or the

manufacturer.

F232161

Operation

General Information

This manual is designed as a guide to operating and

maintaining your washer-extractor. It also serves as an

aid to troubleshooting.

Read and be sure you understand this manual and any

other literature included with your machine before

attempting to start the machine. For warranty

purposes, keep this manual, along with any other

literature and the wiring diagrams which accompany

the machine, in a safe place for ready reference. The

first copy is included with your machine. Additional

copies are available at a nominal charge.

Theory of Operation

NOTE: When power has been turned off from the

machine and then reapplied, the display will read

“WA I T ”for approximately 30 seconds before the

display changes to “NEXT 00”.

Figure 1

U152R

1Hot Spray Valve On 4Cold Fill Valve On

2Cold Spray Valve On 5Low Level Fill Indicator

3Hot Fill Valve On 6High Level Fill Indicator

PHM543N

COLD / HOT / WARM /

LOW HIGH OVER

CLEAR DRAIN

STOP

ENTER

START

SOAK MEDIUM HIGH

PAUSE SPEED SPEED

ERASE

CYCLE

NUMBER

WASH / HEAT / SUPPLY

FLUSH RINSE

ADD

CYCLE

NUMBER /

ADVANCE

BUZZER

REVERSE

DISPLAY

CYCLE

TEMP. /

Operation

F232161

Start-Up

Turn on the main power source (breaker panel or cut-

off switch on the wall). The front panel display should

light up and show “WA I T 0 0 ”for 30 seconds followed

by “NEXT 00”which means Select Cycle. This

display will be on at all times that power is on

indicating the machine is ready for loading and

unloading.

NOTE: Throughout this manual, when display

indications are referred to, these indications will

pertain to the first four digits of the display reading

left to right. The last two digits on the right side of

the display will indicate either the last cycle used or

the current cycle in process.

To load the washer, use left hand to press the door

unlock button located on the lower right front of the

control panel. Use right hand to turn door handle to the

right. The door can then be opened.

Load linen until the machine is full. Partial loads are a

waste of energy, water and chemicals and cause

greater machine wear than full loads. If you do not

have enough to fill the basket, wait until you do.

Partial loads, if necessary, should only occur at the end

of the day. Even then, they can usually be held until

the next day when more linen is received.

IMPORTANT: If stringy items such as mop heads

are to be washed, laundry nets should be used in

order to prevent fouling of seals and drains.

Once loading is complete (you cannot overload the

machine as far as harm to the machine is concerned;

however, overloading can cause improper mechanical

action and an inferior quality wash), close and lock the

door making sure that all fabric is inside the basket.

The machine should not start or run if the door is not

both closed and locked.

Select Cycle

Find the cycle number (cycle numbers must be two-

digit numbers) of the desired wash cycle from the

cycle code list provided. Press (do not punch) with

your finger the numbers desired on the keypad and

note that this number is displayed instead of “NEXT”.

When keys are pressed on the keypad, a beep will be

heard. If an error is made, simply press the CLEAR

key and then press the numbers again. As numbers are

entered, they move from right to left on the display.

Display will show “CY12”if cycle 12 is pressed.

NOTE: In order to Clear or Enter data, the display

must be filled –i.e., no blank spaces.

Start Cycle

To start the cycle that has been selected, simply press

the START key. If the cycle number selected is not in

the computer memory, the display will show

“NOGO”. If this happens, select another cycle.

Otherwise, the display will now show the first step.

(Example: “HL01”.) This number indicates the step

number in the cycle as listed in the Selection List. As

the cycle proceeds, the display will show the step

being run and the cycle number selected.

If the door is not locked, the display will indicate

“DOOR”. If this occurs, be sure the door is closed and

locked and again press the START key. If the computer

starts but the machine does nothing, this indicates the

door hinge microswitch cam may need adjusting. The

door hinge microswitch interlocks all 120 volt power

to the controls with the exception of the computer

itself.

As the cycle progresses, the display will show the step

in the cycle that is being run as well as the cycle

number. In addition, as water is being turned on to fill

the machine, one or more of the four indicator lights

above the first four digits (left to right) in the display

will come on and stay on until the required water level

is reached. Indicator lights above the last two digits on

the right will indicate the water level(s) reached. When

the indicator light in the next to last digit is

illuminated, the low water level has been reached.

Likewise, when the light in the last digit to the right

illuminates, high water level has been reached. The

cycle will continue until its completion and, at this

time, the display will show “NEXT”.

Andere Handbücher für POCKET HARDMOUNT UW50P4

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Alliance Laundry Systems Waschmaschine Handbücher

Alliance Laundry Systems

Alliance Laundry Systems F232136R5 Fehlerbehebungshandbuch

Alliance Laundry Systems

Alliance Laundry Systems LWS01A*C series Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems FLW1525C Leitfaden

Alliance Laundry Systems

Alliance Laundry Systems CS2000 Stücklistenhandbuch

Alliance Laundry Systems

Alliance Laundry Systems TLW12C SVG Leitfaden

Alliance Laundry Systems

Alliance Laundry Systems Home Laundry Automatic Washers Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems LWS02A series Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems BWNBC2PP113TW01 Installationshandbuch

Alliance Laundry Systems

Alliance Laundry Systems SF135PV Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems CTLW-35A Leitfaden

Alliance Laundry Systems

Alliance Laundry Systems 38903R6 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems A Series Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems UWH045K1L Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 801529 Service-Handbuch

Alliance Laundry Systems

Alliance Laundry Systems A-Control Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems HF150 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems TV6000WN Service-Handbuch

Alliance Laundry Systems

Alliance Laundry Systems FLW700C Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems TC5003WN Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems W001C Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems F232135R12 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 802749r1 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems PHM1263R Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems EE1010 Bedienungsanleitung

Beliebte Waschmaschine Handbücher anderer Marken

Tricity Bendix

Tricity Bendix AW 1000 W Produkthandbuch

Panasonic

Panasonic NA-F60L5WRB Bedienungsanleitung

GE WSLP1500 Handbuch

Electrolux

Electrolux EWF1284EDW Bedienungsanleitung

LG TV2516DV3B Bedienungsanleitung

LG TH2517DSAV Bedienungsanleitung

VESTEL

VESTEL CMH-XL 7510 TE Bedienungsanleitung

AEG

AEG 74335 Bedienungsanleitung

Johnson

Johnson JWF721A Bedienungsanleitung

Beko

Beko WTE7604XLW0 Bedienungsanleitung

Danby

Danby DTT100A1WDB Montageanleitung

Amica

Amica WA 14 Ex Bedienungsanleitung

Daewoo

Daewoo DWD-F1222 Bedienungsanleitung

Bosch

Bosch WAS28461AU Bedienungsanleitung

Miele

Miele PW 6080 Vario Bedienungsanleitung

Finlux

Finlux FLX108CF220 Bedienungsanleitung

Whirlpool

Whirlpool 3LBR5132AN0 Bedienungsanleitung

Beko

Beko WKB 51231 PTMA Bedienungsanleitung