Amana HTGK200 Bedienungsanleitung

Side-by-Side

Refrigerator

HTGK200,

HTGK220,

HTK200 and

HTK220 1/4" Trim

andHandle

ConversionKits

Installation

Instructions

Contents

Introduction ............................................................... 2

DecoratorPanelDimensions ..................................... 2

Parts List .................................................................. 3

Procedure ................................................................. 4

Introduction

RECOGNIZE THIS SYMBOL AS A

SAFETY PRECAUTION

Caution

Toavoidpersonalinjuryandproperty

damage,observeall safety instructions.

WARNING

To avoid electrical shock which can cause

severepersonalinjury or death, disconnect

powertorefrigeratorbefore installing kit. After

installingkit, reconnect power.

Caution

Toavoidpropertydamage, protect soft vinyl or

otherflooringwithcardboard, rugs, or other

protectivematerial.

Caution

Toavoidpersonalinjury,protecthandsand

arms.Trim pieces may have sharp edges.

Readentire manual before installingkit. Confirm all parts

listed are included in kit. If parts are missing, contact

sourcefrom whom kitwas purchased.

Important

• Mechanical experience is required to install trim kit.

• Dependingoninstaller’s knowledge and skill,

installation can take from one to three hours.

• Transferfoodto an alternate cooling source.Check

refrigeratorwarrantycertificateforspecific

coverage.Warranty does not cover food loss.

• Ensuretrim pieces adhere properlyby confirming

surfacesareclean,dry and free of adhesive

residue.

• Ifunableto solve a problem duringinstallation,

contact source from whom kit was purchased.

Decorator Panel Dimensions

Listedbelow are required heightx width dimensions for

decorator panels. Panels are not supplied with this kit and

can be purchased locally.

Caution

Toavoidpersonalinjuryorpropertydamage,

refrigeratorpanelsshouldnotweighmorethan

30pounds(14kilograms) and freezer panels

shouldnot weigh more than15 pounds

(7kilogtrams).

Without Dispenser

RefrigeratorDoor 633/32" x 193/8"

(1603 mm x 492 mm)

FreezerDoor 633/32" x 133/4"

(1603 mm x 349 mm)

With Dispenser

RefrigeratorDoor 633/32" x 193/8"

(1603 mm x 492 mm)

UpperFreezerDoor 183/8" x 133/4"

(467 mm x 349 mm)

LowerFreezerDoor 3113/16"x133/4"

(808 mm x 349 mm)

Parts List

Description Qty HTK200E

Black

HTK200S

Brushed

Aluminum

HTGK200W

White HTK220E

Black

HTK220S

Brushed

Aluminum

HTGK220W

White

Top Cap, Refrigerator Door 1XXXXXX

Top Cap, Freezer Door 1XXXXXX

Bottom Cap, Refrigerator Door 1XXXXXX

Bottom Cap, Freezer Door 1XXXXXX

Hinge Cover, Right 1XXXXXX

Hinge Cover, Left 1XXXXXX

Side Trim, Refrigerator Door 1XXXXXX

Side Trim, Freezer Door 1XXXXXX

Top Trim, Refrigerator Door 1XXXXXX

Top Trim, Freezer Door 1XXXXXX

Bottom Trim, Refrigerator

Door 1XXXXXX

Bottom Trim, Freezer Door 1XXXXXX

Trim, Dispenser 2 X X X

Door Stop 2 X X X X

Handle, Freezer Door 1XXXXXX

Handle, Refrigerator Door 1XXXXXX

Toe Grille 1 X X

Handle Insert, Refrigerator

Door 1XXXXXX

Handle Insert, Freezer Door 1XXXXXX

Screw, Top Trim 6 X X

Installation Instructions 1XXXXXX

Clip, Toe Grille 2 X X

Tape, Double Back 122" X X X X X X

Procedure

Caution

Toavoidpersonalinjuryorpropertydamage,

twopeopleshouldremoveandrehangeach

door.

Caution

Toavoidpersonalinjury,protecthandsand

arms.Trim pieces may have sharp edges.

Important

Save all screws and reuse in original location.

1. Removetophandleend caps by removing screws.

2. DispenserModels

Removecrushed/cubediceswitchcoveron

dispenserbypullingforward.Removescrewsfrom

bottomof dispenser cover. Releasebottom clips on

dispensercover by placing tapededge of putty knife

underneathcoverand pulling out. Release topclips

byholding bottom of dispenser cover out andslide

upward.

3. Removedoorhandleinsertsbyplacingscrewdriver

attopof door handles inarea between handle and

insertand pulling out.

4. Pulledgeof inserts forward alonglength of handles.

Caution

Toavoidpersonalinjuryorpropertydamage,

holdhandleswhenremoving.

5. Removedoorhandlesbyremovingscrews.Bottom

insertsareremovedwithhandle.

6. Removetopdoortrim by removing screws.

7. Ifrefrigeratorhasdecorator panels, carefully slide

panelsout.On dispenser models, remove

dispensertrim.

8. Removetrim on sidesof doors byplacing taped

edgeof putty knife underneath trim and pullingout.

Caution

Toavoidpersonalinjuryorproperty

damage,temporarilytapedoorsshut.

9. Tape doors shut using masking tape.

10. Removetophingecoversbyremovingscrews.

Tracearound top hinges with a pencil. Thishelps

alignmentwhenreassembling.Ondispenser

models,unplugtophingewire connectors. Remove

top hinge screws.

WARNING

To avoid electrical shock which can cause

severepersonalinjuryordeath,greenground

wire must remain attached to hinge.

11. Remove tape fromrefrigeratordoor.Grasp

refrigeratordoorsecurelyand lift up while opening.

Thiswill free door frombottom hinge pin. Tophinge

maycome offdoor.

12. Removetoegrillebypullingforward.

Caution

Toavoidpropertydamage,drainwaterfrom

water tube into small bucket.

13. DispenserModels

Loosen water tube clamp screw. Loosen plastic

water tube union nut. Gently pull water tube away

fromunion nut and throughtube clamp.

14. Removetapefrom freezer door.Grasp freezer door

securelyand lift up while opening. This willfree

doorfrom bottom hinge pin. On dispenser models,

plastic water tube must slide through slot in bottom

doorhinge as door is raised. Top hinge willremain

attachedto door.

15. Remove bottomdoortrim by removing screws.

WheninstallingHTK200S,HTGK200W,HTK220S

andHTK220Wkits, remove door stops.Confirm

support plate is under door trim. Install new bottom

door trim by placing trim on bottom of doors. Insert

andtighten screws. When installing HTK200S,

HTGK200W,HTK220Sand HTK220W kits, install

new door stops by placing door stops on bottom of

doors.Insert and tightenscrews.

16. Rehang doors by positioning bottom sockets onto

bottom door hinge pins. Position so doors are flush

withsidesof refrigerator cabinet. Handleside of

doorsshould be approximately1/8inch(3.2

millimeters)higher than hinge sideof doors. Doors

willsettle when loaded with food. On dispenser

models,whenreplacingfreezerdoor, thread water

tubethrough bottomhinge pinand watertube clamp.

Caution

Toavoidpersonalinjuryorpropertydamage,

temporarilytape doors shut.

17. Tape doors shut using masking tape.

Important

• Ensuretrimpieces adhere properly byconfirming

surfacesareclean,dry and free of adhesive

residue.

• Discardfactory installed trim and handles.

18. Replace top hinges by placing top hinges on

refrigerator.Insertand tighten screws. On

dispensermodels,reconnect top hinge wire

connectors.Install new top hinge covers by placing

hingecoversoverhinges.On dispenser models,

carefullyplacewiresundercover to avoid pinching

wires. Insert screws and tighten.

WARNING

To avoid electrical shock which can cause

severepersonalinjuryordeath,green

groundwire must be attachedto freezer

doorhinge.

19. Install new bottom door handle caps by pushing up

into bottom of new handles until caps snap in place.

20. Install newdoorhandles by placingdoor handles on

door. Insert andtighten screws. Install newhandle

inserts by snapping in place.

Thin Section

21. Remove thin section on top handle end caps to

allowroom for panels. Discardsection. Replace

top handle end caps by placing end caps on

handles.Insert and tighten screws.

22. DispenserModels

Replacedispensercover by snapping in place.

Insert and tighten screws. Replace switch by

snappinginplace.

23. Install new top door trim by placing trim on top of

doors. Insert screws but do not completely tighten.

WheninstallingHTK200E and HTK220E, install new

color coordinated screws taped to trim.

24. DispenserModels

Installnew dispenser trim on freezer panels by

slidingtrimon bottom edge ofupper freezer door

panelandtopedgeof lower freezer door panel.

25. Slide decorator doorpanels into placeuntil panels

aresecureunder door handle inserts.

Important

Permanent, double-sided tape is used to attach some

trimpiecestorefrigerator. Beforeremovingpaperbacking,

checkplacement of trim pieces on refrigerator. Trim

piecesmay be damagedif adjustment orremoval is

attemptedafterinstallation.

26. Install side door trim by peeling off 11/2inches (38

millimeters) of backing. Place trim against bottom

cornerofrefrigeratorcabinetoveredgeofbottom

trim. After checking placement, peel off backing and

press into place. Place side door trim under edge of

top trim. Tighten top trim screws.

27. Push water tube into plastic union nut and tighten

union nut by hand. Gently pull on tube to confirm

nut is tight. Tighten water tube clamp screw.

Caution

Toavoidpropertydamage, confirm water

tubeunion nut is secure before replacing toe

grille.

28. Install new toe grille (if supplied) by inserting clips in

holesand snapping in.

Side Trim

Bottom Trim

Part No. 10722206

Printed in U.S.A. 1998 Amana Appliances

Amana, Iowa 52204

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Amana Kühlschrank Handbücher

Amana

Amana T1WG2L Bedienungsanleitung

Amana

Amana A1RXNGFYS Bedienungsanleitung

Amana

Amana BX22S5W Bedienungsanleitung

Amana

Amana AMA46S1E Bedienungsanleitung

Amana

Amana 59668142891 Bedienungsanleitung

Amana

Amana ACD2238HTS Bedienungsanleitung

Amana

Amana Distinctions Bedienungsanleitung

Amana

Amana ATB11ARW Bedienungsanleitung

Amana

Amana Top Freezer Refrigerator Bedienungsanleitung

Amana

Amana BCI21WW Bedienungsanleitung

Amana

Amana ABR1922FES Stücklistenhandbuch

Amana

Amana AFF2534FEW11 Fehlerbehebungshandbuch

Amana

Amana ARB1905CC0 Bedienungsanleitung

Amana

Amana SXD25S2 Montageanleitung

Amana

Amana A8TXEGFYB Bedienungsanleitung

Amana

Amana W10175445A Bedienungsanleitung

Amana

Amana Bottom Freezer Refrigerator Bedienungsanleitung

Amana

Amana ABB1921DEW14 Fehlerbehebungshandbuch

Amana

Amana ASD2524VES00 Bedienungsanleitung

Amana

Amana AFI2538AES12 Bedienungsanleitung

Amana

Amana ASD2522VRW Bedienungsanleitung

Amana

Amana SBDT520 Bedienungsanleitung

Amana

Amana ATB1822MR Stücklistenhandbuch

Amana

Amana ASD2524VES Bedienungsanleitung

Beliebte Kühlschrank Handbücher anderer Marken

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Bedienungsanleitung

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Bedienungsanleitung

Sharp

Sharp SJ-BA31IEXW2-EU Bedienungsanleitung

CORBERO

CORBERO CC2300MCW Bedienungsanleitung

KitchenAid

KitchenAid 2205264 Bedienungsanleitung

Stengel

Stengel KU 1101 A++ Bedienungsanleitung

NEFF

NEFF KI181 Series Bedienungsanleitung

Hoshizaki

Hoshizaki Reach-In Bedienungsanleitung

BOMANN

BOMANN KGC 213 Bedienungsanleitung

Danby

Danby DAR044A1SLDD Montageanleitung

Samsung

Samsung RF323TE Bedienungsanleitung

Beko

Beko CSA31022 Bedienungsanleitung

IKEA

IKEA FROSTIG C 185 E Bedienungsanleitung

Electrolux

Electrolux ER 6821 D Bedienungsanleitung

True

True TS-28 Bedienungsanleitung

Frigidaire

Frigidaire FSC23R5DW9 Bedienungsanleitung

Beko

Beko LSP4579W Bedienungsanleitung

Teledyne

Teledyne 6712FR and Betriebsanleitung