APRILIA RX 50 RACING - 2003 Bedienungsanleitung

Racing

8202401

CATALYTIC MUFFLER

USE ONLY UNLEADED PETROL IN CONFORMITY WITH THE DIN 51607 STANDARD, MIN. O.N. 95

(N.O.R.M.) AND 85 (N.O.M.M.) AND HIGH PERFORMANCE SYNTHETIC OIL FOR 2 STROKE ENGINES.

THE USE OF FUELS AND LUBRICANTS DIFFERENT FROM THOSE INDICATED CAUSES SEVERE

FUNCTIONAL INCONVENIENCES TO THE VEHICLE AND THE VOIDING OF THE aprilia GUARANTEE.

To have the catalytic converter functioning correctly for long periods and to reduce possible

problems regarding the contamination of the thermal unit and of the exhaust, it is necessary to

avoid covering long distances with the engine running at constantly low rpm.

It is sufficient to alternate these periods with periods in which the engine runs at relatively high rpm,

even if only for a few seconds, but rather frequently.

What has been stated above assumes particular importance for the cold starting of the engine: in this

case, in order to reach a rpm regime sufficient to enable the “priming” of the catalytic reaction, you just

need to make sure that the temperature of the thermal unit has reached at least 50°C, which generally

occurs a few seconds after starting the engine.

CATALYTIC SILENCER

The catalytic version of the RX50 Racign is fitted with a silencer with metal catalytic converter of the

“platinum-rhodium bivalent” type. This device provides for the oxidation of the CO (carbon monoxide)

and of the HC (unburned hydrocarbons) contained in the exhaust gases, changing them into carbon di-

oxide and steam, respectively. Due to the catalytic reaction, the high temperature reached by the ex-

haust gases results in the burning of the oil particles, thus keeping the silencer clean and eliminating

the exhaust fumes.

Avoid parking the catalytic vehicle near dry brush wood or in places easily accessible to chil-

dren, as the catalytic silencer becomes extremely hot during use; be very careful and avoid any

kind of contact before it has completely cooled down.

First edition: September 2003

Reprint: October 2003

Produced and printed by:

DECA S.r.l.

Via Risorgimento, 23/1 - Lugo (RA) - Italy

Tel. +39 - 0545 35235

Fax +39 - 0545 32844

E-mail: deca@decaweb.it

www.decaweb.it

On behalf of:

aprilia s.p.a.

via G. Galilei, 1 - 30033 Noale (VE) - Italy

Tel. +39 - 041 58 29 111

Fax +39 - 041 44 10 54

www.aprilia.com

This manual contains all the main information and the

instructions required for normal use and mainte-

nance of your vehicle.

For controls and check-ups that cannot be carried out

easily with the standard equipment supplied, we ad-

vise you to consult our Dealers who can assure you

of quick and careful servicing.

To keep your aprilia vehicle always in perfect operat-

ing conditions, we advise you to insist on Original

Spares and to have repairs carried out only by aprilia

Authorized Outlets and Official Dealers.

When ordering spare parts from the Dealers, always

quote the spares code which is stamped on a sticker

placed under the saddle. It is a good idea to make a

note of the identification code in the space provided

in this manual, so that you will always have a record

of it even if the identification sticker comes off.

All information is purely indicative and may be sub-

ject to variation without notice.

Carefully observe the instructions preceded by the

following warning signs:

Safety norms and regulations to protect

the driver and other people from severe

injuries or grave risks.

Caution norms and suggestions to avoid

damaging the vehicle and/or hurting

yourself or other people.

Indications to make the operations easier.

Technical information.

VERSION:

+Italy /Holland *Croatia

4United

Kingdom

6Switzerland #Australia

>Austria &Denmark RUnited States

of America

MPortugal ,Japan gBrazil

(Finland 2Singapore 1South Africa

$Belgium PSlovenia KNew Zealand

AGermany FIsrael %Canada

CFrance eSouth Korea

'Spain -Malaysia

)Greece @Chile

CONTENTS

Pag.

CATALYTIC MUFFLER............................................... 2

CATALYTIC SILENCER.............................................. 3

ARRANGEMENT OF THE CONTROLS ................... 18

INSTRUCTIONS FOR USE....................................... 41

MAINTENANCE ........................................................ 46

IDENTIFICATION DATA ........................................... 49

ELECTRICAL SYSTEM............................................. 68

CLEANING ................................................................ 74

LONG INACTIVITY.................................................... 74

TECHNICAL FEATURES .......................................... 75

BASIC SAFETY RULES

To drive the vehicle it is necessary to be in posses-

sion of all the requirements prescribed by law (driving

licence, minimum age, psychophysical ability, insu-

rance, state taxes, vehicle registration, number plate,

etc.).

Gradually get to know the vehicle by driving it first in

areas with low traffic and/or private areas.

The use of medicins, alcohol and drugs or psychotro-

pic substances notably increases the risk of acciden-

ts.

Be sure that you are in good psychophysical condi-

tions and fit for driving and pay particular attention to

physical weariness and drowsiness.

Fig. 1

Fig. 2

Most road accidents are caused by the driver»s lack

of experience.

NEVER lend the vehicle to beginners and, in any ca-

se, make sure that the driver has all the requirements

for driving.

Rigorously observe all road signs and national and

local road regulations.

Avoid abrupt movements that can be dangerous

for yourself and other people (for example: rearing

up on the back wheel, speeding, etc.), and give

due consideration to the road surface, visibility

and other driving conditions.

Fig. 3

Fig. 4

Avoid obstacles that could damage the vehicle or

make you lose control.

Avoid riding in the slipstream created by preceding

vehicles in order to increase your speed.

Always drive with both hands on the han-

dlebars and both feet on the footrests (or

on the rider’s footboards), in the correct

driving posture.

Avoid standing up or stretching your lim-

bs while driving.

Fig. 5

Fig. 6

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere APRILIA Motorrad Handbücher

APRILIA

APRILIA SCARABEO 150 Bedienungsanleitung

APRILIA

APRILIA CLASSIC 125 - 03-1997 Bedienungsanleitung

APRILIA

APRILIA TUONO V4 R a-PRC ABS Leitfaden

APRILIA

APRILIA RST MILLE FUTURA - 2001 Bedienungsanleitung

APRILIA

APRILIA RST mille FUTURA Bedienungsanleitung

APRILIA

APRILIA RSV mille TUONO Bedienungsanleitung

APRILIA

APRILIA SPORTCITY CUBE 250 I.E Bedienungsanleitung

APRILIA

APRILIA SCARABEO 100 4T - 06-2001 PART7 Bedienungsanleitung

APRILIA

APRILIA RSV 1000 R FACTORY Gebrauchsanweisung

APRILIA

APRILIA Tuono V4 1100 Factory 2021 Bedienungsanleitung

APRILIA

APRILIA SR MAX 300 i.e. Bedienungsanleitung

APRILIA

APRILIA RS 50 Stücklistenhandbuch

APRILIA

APRILIA Pegaso 650 Benutzerhandbuch

APRILIA

APRILIA SR 50 - BROCHURE 2009 Bedienungsanleitung

APRILIA

APRILIA AMICO 50 - 11-1997 Bedienungsanleitung

APRILIA

APRILIA SCARABEO 50 4T - 2006 Bedienungsanleitung

APRILIA

APRILIA PEGASO 650 STRADA TRAIL 2005 Stücklistenhandbuch

APRILIA

APRILIA SCARABEO 50 2T - 2005 Bedienungsanleitung

APRILIA

APRILIA RALLY 50 - 2000 Bedienungsanleitung

APRILIA

APRILIA MANA 850 ABS Bedienungsanleitung

APRILIA

APRILIA TUONO R FACTORY 2007 Leitfaden

APRILIA

APRILIA SCARABEO 200 IE - 2010 Bedienungsanleitung

APRILIA

APRILIA SR 50 - USE AND MAINTENANCE BOOK Leitfaden

APRILIA

APRILIA RS 125 Technisches Handbuch

Beliebte Motorrad Handbücher anderer Marken

OHVALE

OHVALE GP-0 Stücklistenhandbuch

Yamaha

Yamaha Star XV19CTSZ 2009 Bedienungsanleitung

KTM

KTM 350 XCF-W USA Bedienungsanleitung

HYOSUNG

HYOSUNG ST7 Bedienungsanleitung

Husqvarna

Husqvarna FC 250 2016 Bedienungsanleitung

Ducati

Ducati SCRAMBLER 800 Gebrauchsanweisung

Yamaha

Yamaha 2006 YZF-R1V Bedienungsanleitung

KTM

KTM Freeride E-XC 2021 Bedienungsanleitung

Fantic

Fantic Enduro 125 Bedienungsanleitung

Ducati

Ducati Supersport 750 desmodue Bedienungsanleitung

MV Agusta

MV Agusta 2008 F4 312RR 1078 Gebrauchsanweisung

Yamaha

Yamaha XVS650A Bedienungsanleitung

Yamaha

Yamaha YZF-R6T(C) Handbuch

Ducati

Ducati 748 monoposto strada Bedienungsanleitung

ATK

ATK 1988 250 Bedienungsanleitung

Excelsior-HENDERSON

Excelsior-HENDERSON 1999 HCX Bedienungsanleitung

Triumph

Triumph Thunderbird Bedienungsanleitung

Yamaha

Yamaha 2006 FJR1300A Bedienungsanleitung