APRILIA QUASAR 100 - 2004 Bedienungsanleitung

use and maintenance Quasar 50 - 100 - 125 - 180

QUASAR 50-100-125-180

aprilia part# 8202427

2use and maintenance Quasar 50 - 100 - 125 - 180

First edition: April 2004

Reprint:

Produced and printed by:

DECA S.r.l.

Via Risorgimento, 23/1 - Lugo (RA) - Italy

Tel. +39 - 0545 35235

Fax +39 - 0545 32844

E-mail: deca@decaweb.it

www.decaweb.it

On behalf of:

Moto Laverda s.r.l.

via G. Galilei, 15 - 30033 Noale (VE) - Italy

Tel. +39 - 041 50 79 823

Fax +39 - 041 50 79 720

E-mail: customer@laverda.it

SAFETY WARNINGS

The symbols and warnings used

throughout this manual have the following

meanings:

Safety warning. This symbol

attached to the vehicle or in the

manual indicates a potential risk of

personal injury. Non-compliance with

the indications given in the messages

preceded by this symbol may result in

major risks for your and other people’s

safety and for the vehicle!

WARNING

Indicates a potential hazard which may

result in serious injury or even death.

CAUTION

Indicates a potential hazard which may

result in minor personal injury or

damage to the vehicle.

CAUTION The word

"CAUTION" in this manual identifies

important information or instructions.

TECHNICAL INFORMATION

The operations preceded by this

symbol must be repeated on the

opposite side of the vehicle.

Unless expressly indicated otherwise,

reassembly is a reversal of the

disassembly procedure.

The terms "right" and "left" are referred to

the rider seated on the vehicle in the

normal riding position.

WARNINGS - PRECAUTIONS -

GENERAL ADVICE

Before starting the engine, read this

manual thoroughly paying special attention

to section "SAFE RIDING".

Your and other people's safety largely

depends on your reflexes and agility, but

there are other key factors, such as your

knowledge of the vehicle's operation and

condition, as well as of the basic rules of

"SAFE RIDING".

Becoming thoroughly familiar with vehicle is

essential to mastering safe riding

techniques in traffic.

use and maintenance Quasar 50 - 100 - 125 - 180

CAUTION This manual must be

considered as an integral part of the

vehicle and must always accompany it,

also in the event the vehicle is resold.

Laverda has carried out this manual with

the maximum attention, in order to supply

the user with correct and updated

information. However, since Laverda

constantly improves the design of its

products, there may be slight

discrepancies between the characteristics

of your vehicle and those described in this

manual.

For any clarification concerning the

information contained in this manual, do

not hesitate to contact your Aprilia

Authorised Dealer.

For control and repair operations not

expressly described in this publication, for

the purchase of Aprilia genuine spare

parts, accessories and other products, as

well as for specific advice, contact

exclusively Aprilia Authorised Dealers and

Service Centres, which guarantee prompt

and accurate assistance.

Thank you for choosing Aprilia. We wish

you a nice ride.

All rights of electronic storage,

reproduction and total or partial adaptation

with any means reserved for all Countries.

CAUTION Some countries

have statutory emission and noise control

regulations in place requiring that motor

vehicles undergo periodical inspections.

Users in these countries must:

√contact an Aprilia Authorised Dealer to

have the non-homologated components

replaced with others homologated for

use in the country in question;

√have their vehicles inspected at the

required intervals.

7model 50 cu cm

model 100 cu cm

model 125 cu cm

model 180 cu cm

“HP” version

“GRIP” version

100

125

180

GRIP

use and maintenance Quasar 50 - 100 - 125 - 180

GENERAL INDEX

SAFETY WARNINGS .................................... 2

TECHNICAL INFORMATION ........................ 2

WARNINGS - PRECAUTIONS - GENERAL

ADVICE ........................................................ 2

BASIC SAFETY RULES........................................ 6

CLOTHING ............................................................ 8

ARRANGEMENT OF THE MAIN

ELEMENTS................................................. 10

ARRANGEMENT OF THE MAIN ELEMENTS

HP .............................................................. 11

ARRANGEMENT OF THE MAIN ELEMENTS

GRIP........................................................... 12

LOCATION OF INSTRUMENTS/CONTROLS 13

INDICATORS.............................................. 14

INSTRUMENTS AND INDICATORS TABLE ...... 15

MULTIFUNCTION COMPUTER .................. 16

OPERATION ....................................................... 16

SETTING THE CLOCK ....................................... 17

CHANGING THE BATTERY ............................... 17

MAIN INDEPENDENT CONTROLS ............. 18

CONTROLS ON LEFT HANDLEBAR ................. 18

IGNITION SWITCH ............................................. 18

AUXILIARY EQUIPMENT ........................... 19

GLOVE/TOOL KIT COMPARTMENT ................. 19

MAIN COMPONENTS ................................. 20

FUEL ................................................................... 20

FUEL COCK ..................................... 21

MIXER OIL RESERVOIR ................. 21

TYRES ................................................................ 22

CHECKING/CHANGING TRANSMISSION

FLUID .................................................................. 23

CHECKING ENGINE OIL LEVEL ..... 24

CHANGING ENGINE OIL ................ 25

BRAKE FLUID - RECOMMENDATIONS ............ 26

DISC BRAKES .................................................... 26

CHECKING BRAKE FLUID LEVEL..................... 26

CHECKING THE BRAKE PADS FOR WEAR..... 27

EXHAUST MUFFLER/EXHAUST SILENCER .... 28

INSTRUCTIONS FOR USE ......................... 28

PRE-RIDE CHECKS ........................................... 28

PRE-RIDE CHECKS CHART .............................. 29

STARTING .......................................................... 30

MOVING OFF AND RIDING................................ 32

RUNNING-IN ....................................................... 32

STOPPING .......................................................... 33

PARKING ............................................................ 33

SUGGESTIONS TO PREVENT THEFT.............. 33

MAINTENANCE.......................................... 34

SCHEDULED MAINTENANCE CHART.............. 35

IDENTIFICATION DATA ..................................... 37

AIR FILTER ...................................... 38

DRIVE CHAIN ..................................................... 39

CHECKING AND SERVICING THE

SUSPENSIONS................................................... 41

ADJUSTING THE THROTTLE TWISTGRIP ....... 41

ADJUSTING THE BRAKE LEVERS.................... 42

IDLING ADJUSTMENT ....................................... 42

SPARK PLUG...................................................... 43

BATTERY ............................................................ 45

CHECKING AND CLEANING THE TERMINALS 45

REMOVING THE BATTERY ............................... 45

CHECKING BATTERY FLUID LEVEL ................ 46

CHARGING THE BATTERY ............................... 46

INSTALLING THE BATTERY .............................. 47

TRANSMISSION AIR FILTER .......... 47

BULBS................................................................. 48

VERTICAL ADJUSTMENT OF THE HEADLIGHT

BEAM .................................................................. 48

CHANGING THE HEADLIGHT

BULB ................................................ 49

CHANGING THE HEADLIGHT

BULB ................................................ 50

CHANGING THE TAIL LIGHT BULB .................. 51

REPLACING THE FRONT AND REAR TURN

INDICATOR BULBS ............................................ 51

REPLACING THE NUMBER PLATE

BULB ....................................... 51

CHANGING A FUSE ........................................... 52

TRANSPORT.............................................. 52

CLEANING ................................................. 53

LONG PERIODS OF INACTIVITY....................... 54

TECHNICAL DATA..................................... 55

LUBRICANT CHART ........................................... 58

WIRING DIAGRAM ............................................. 60

KEY TO WIRING DIAGRAM ............................... 61

WIRING DIAGRAM ............................................. 62

KEY TO WIRING DIAGRAM ............................... 63

AUTHORISED DEALERS AND SERVICE

CENTRES............................................................ 64

50 100

125 180

50 100

125 180

100 125 180

guida sicura

6use and maintenance Quasar 50 - 100 - 125 - 180

BASIC SAFETY RULES

To drive the vehicle, you must satisfy

certain legal requirements (driving licence,

minimum age limit, psychophysical fitness,

insurance, vehicle licence tax, vehicle

registration, number plate, etc.).

Begin to familiarise yourself with the

vehicle by riding in low traffic areas and/or

private ground.

Certain prescribed medicines, alcohol,

drugs and psychotropic substances will

affect your riding, thereby increasing the

risk of an accident.

Be sure that you are in good

psychophysical conditions and fit for

driving and pay particular attention to

physical weariness and drowsiness.

Most road accidents are caused by

inexperienced riders.

NEVER lend your vehicle to a beginner

and make sure any person borrowing your

vehicle fills the legal requirements for

driving.

Strictly observe all posted signs and

national and local road regulations.

Avoid any sudden or risky manoeuvres

that may endanger your and other people's

safety (for example: reckless manoeuvres,

speeding, etc.), and adjust your riding style

to road surface conditions, visibility, etc.

Avoid obstacles that could damage the

vehicle or make you lose control of the

vehicle.

WARNING

Always hold the handlebars with both

hands and keep both feet on the

footpegs (or on the rider's footboards),

in the correct riding position.

Do not stand up or stretch your limbs while

riding.

use and maintenance Quasar 50 - 100 - 125 - 180

The driver should pay attention and avoid

distractions caused by people, things and

movements (never smoke, eat, drink, read,

etc.) while driving.

Use only the specified fuels and lubricants

indicated in the "LUBRICANT CHART"

(page58) and check engine oil,

transmission fluid and fuel levels at regular

intervals.

If the vehicle has been involved in an

accident, make sure that no damage has

occurred to the control levers, pipes, wires,

braking system and vital parts.

If necessary, have the vehicle inspected by

an Aprilia Authorised Dealer who should

carefully check the frame, handlebars,

suspensions, safety parts and all the

devices that you cannot check by yourself.

Remember to report any malfunction to the

technicians and/or mechanics to facilitate

their work.

Never use the vehicle when the amount of

damage it has suffered makes it unsafe to

ride.

Never change the position, inclination or

colour of: number plate, turn indicators,

lights and horns.

Any modification of the vehicle will result in

the invalidity of the warranty.

Making any modifications to the vehicle

and/or removing the original components

can adversely affect vehicle performance

and safety or make it illegal to ride.

Observe applicable law and all national

and local regulations concerning vehicle

equipment.

In particular, avoid any modifications apt to

enhance performance or alter the vehicle's

original specifications.

Never race with other vehicles.

ONLY ORIGINALS

8use and maintenance Quasar 50 - 100 - 125 - 180

CLOTHING

Always wear and fasten your helmet

correctly before moving off. Make sure

your helmet complies with applicable

regulations, is not damaged, is the right

size and keep the visor clean.

Wear protective clothing, preferably bright

and/or reflective clothing. This will ensure

you are easily seen by other road users

and reduce the risk of an accident, besides

affording improved protection in the event

of a fall.

Wear tight-fitting clothing fastened at the

wrists and ankles; make sure no strings,

belts and ties are hanging loose; make

sure no items of clothing or other objects

can distract you or become entangled with

moving parts or with the handlebars.

Do not ride with sharp or pointed objects in

your pockets as they might cause injury in

the event of a fall (this includes keys, pens,

glass vials, etc. - note that the same

applies to your passenger).

Avoid fixing bulky, heavy and/or dangerous

objects to the handlebars, mudguards and

forks - this could slow down the vehicle's

response in turns and would inevitably

affect handling.

Do not place bags that are too bulky or the

crash helmet on the vehicle sides and do

not ride with them on, because they could

hit people or obstacles, making you lose

control of the vehicle.

Do not exceed the maximum load capacity

of each luggage rack.

When the vehicle is overloaded, its stability

and its manoeuvrability can be

compromised.

use and maintenance Quasar 50 - 100 - 125 - 180

Never use the vehicle in water deeper than

10 cm.

After having used the vehicle in salt water,

it is necessary to wash it with fresh water.

Never show off without respecting the

safety features.

Never unbalance the weight of your body

so to avoid that vehicle takes unusual

positions.

The vehicle should always be ridden

following the safety rules indicated in this

manual, at any time (riding uphill, downhill,

turning, etc.) and with any surface

conditions.

10 use and maintenance Quasar 50 - 100 - 125 - 180

1 2 5

100

ARRANGEMENT OF THE MAIN ELEMENTS

KEY

1) Left rear-view mirror

2) Front shield

3) Battery

4) Main fuse carrier

5) Seat

6) Rear shock absorber

7) Left footrest

Kick start lever

8) Transmission air filter

9) Air filter

10) Left front suspension

11) Headlight

12) Instrument holder

KEY

1) Rear shield

2) Mixer oil filler plug

3) Fuel tank

4) Fuel tank filler plug

5) Right rear-view mirror

6) Warning horn

7) Right front suspension

8) Fuel cock

9) Front + rear brake pedal (100

cc only)

10) Right footrest

11) Drive chain

12) Glove/tool kit compartment

13) Tail light

100

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere APRILIA Geländefahrzeug Handbücher

APRILIA

APRILIA QUASAR 100 Bedienungsanleitung

Beliebte Geländefahrzeug Handbücher anderer Marken

Polaris

Polaris RANGER XP 1000 EPS 2018 Bedienungsanleitung

Yamaha

Yamaha Tri Moto 125 Bedienungsanleitung

Yamaha

Yamaha YFM350X Warrior Bedienungsanleitung

Polaris

Polaris RZR 900 Bedienungsanleitung

Suzuki

Suzuki LT-A700X Bedienungsanleitung

Ski-Doo

Ski-Doo SCANDIC WT Handbuch

Suzuki

Suzuki LT-Z400 Bedienungsanleitung

Arctic Cat

Arctic Cat 120 sno pro Bedienungsanleitung

Yamaha

Yamaha RS90PB Bedienungsanleitung

Dinli

Dinli DL702 Bedienungsanleitung

Yamaha

Yamaha SXV70ML Bedienungsanleitung

Baja motorsports

Baja motorsports ATV 90 Handbuch

Polaris

Polaris Sportsman 550 XP EPS Bedienungsanleitung

Arctic Cat

Arctic Cat ALTERRA 450 Bedienungsanleitung

Polaris

Polaris Sportsman 9922233 Bedienungsanleitung

Yamaha

Yamaha YFM45FAT Handbuch

Polaris

Polaris RZR XP 1000 Bedienungsanleitung

Polaris

Polaris Outlaw 500 Bedienungsanleitung