Bradford White 238-46392-00G Montageanleitung

238-46392-00G REV 10/13

STAINLESS STEEL

INDIRECT-FIRED

WATER HEATER

A Spanish language version of these instructions is available by contacting the manufacturer

listed on the rating plate.

La version Espanola de estas instruccions se puede obtener al escribirle a la fábrica cuyo

nombre aparece in la placa de especificaciones.

INSTALLATION/OPERATING MANUAL

WITH PARTS LISTING AND TROUBLESHOOTING GUIDE

For your family’s comfort, safety, and convenience, we

recommend this water heater be installed and serviced by a

plumbing professional.

WARNING

To avoid damage or injury, there

must be no materials stored

against the indirect water heater

and proper care must be taken to

avoid unnecessary contact

(especially by children) with the

indirect water heater.

Do not store or use

gasoline or other

flammable liquids in

the vicinity of this

water heater or any

other appliance.

CONGRATULATIONS!

You have just purchased one of the finest water heaters

on the market today!

This installation, operation, and instruction manual will

explain in detail the installation and maintenance of your

new Indirect Water Heater. We strongly recommend that

you contact a plumbing professional for the installation of

this water heater.

We require that you carefully read this manual, as well as

the enclosed warranty, and refer to it if questions arise.

If you have any specific questions concerning your

warranty, please consult the plumbing professional from

whom your water heater was purchased. For your

records we recommend that you write the model, serial

number and installation date of your water heater in the

back of this manual.

This manual should be kept with the water heater.

We’re committed to providing you with the finest water

heater made.

SECTION I

IMPORTANT INFORMATION

-READ CAREFULLY-

CAUTION

The maximum boiler water supply temperature to the indirect

heat exchanger must not exceed 240°F (115°C).

Improper water quality will reduce the expected life of the water

heater. Hard water, sediment, high or low PH and high levels of

chlorides in the domestic water should be avoided. Be sure that

PH value falls between 6 and 8 and dissolved chlorides are less

than 100 ppm. A filter must be used where sediment is greater

than 5 microns in size that is present in the water. A water

softening system is recommended for areas with hard water. In

areas where water quality is unknown, a qualified water

treatment expert should be consulted.

NOTICE: Damage to tanks caused by improper water quality is not

covered under warranty.

NOTICE

Insulation blankets are not required for this water heater. This

water heater meets or exceeds the ASHRAE/IES 90.1b standards

with respect to insulation and standby loss requirements.

TABLE OF CONTENTS

I- IMPORTANT INFORMATION…………….….. 3

II- SPECIFICATIONS………………………………. 8

III- GENERAL INFORMATION……………………. 12

IV- PRE-INSTALLATION…………………………… 15

V- WATER CONNECTIONS……………………….. 19

VI- ELECTRICAL CONNECTIONS……………….. 24

VII- OPERATING INSTRUCTIONS………………… 26

VIII- MAINTENANCE…………………………………. 30

IX- TROUBLESHOOTING GUIDE………………… 32

X- PARTS LIST……………………………………… 34

Important Information continued-

The equipment must be installed in accordance with those

installation regulations required in the area where the installation is

to be made. These regulations must be carefully followed in all

cases. Authorities having jurisdiction must be consulted before

installations are made.

All wiring on water heaters installed in the USA must be in

accordance with the National Electrical Code (latest edition) and/or

local regulations; or in Canada, installed in accordance with the

Canadian Electrical Code (latest edition) and/or local regulations.

The following terms are used throughout this manual to bring

attention to the presence of hazards of various risk levels, or to

important information concerning product life.

DANGER

Indicates an imminently

hazardous situation, which,

if not avoided, will result in

death, serious injury, or

substantial property

damage.

WARNING

Indicates a potentially

hazardous situation, which,

if not avoided, could result

in death, serious injury, or

substantial property

damage.

CAUTION

Indicates a potentially

hazardous situation, which,

if not avoided, may result

in moderate, or minor

injury or property damage.

NOTICE

Indicates special

instructions on installation,

operation or maintenance,

which are important but

not related to personal

injury hazards.

Important Information continued-

DANGER

DO NOT store or use gasoline or other flammable,

combustible, or corrosive vapors and/or liquids in the vicinity

of this or any other appliance.

IF YOU SMELL GAS:

DO NOT try to light any appliance.

DO NOT touch any electric switch; do not use any

telephone in your building.

Immediately call your gas supplier from a telephone in

another building. Follow the gas supplier’s instructions.

If you cannot reach your gas supplier, call the fire

department.

DO NOT OPERATE THE APPLIANCE UNTIL THE

LEAKAGE IS CORRECTED!

Liquefied petroleum gas/propane gas is heavier than air and

will remain at floor level if there is a leak. Basements, crawl

spaces, closets, and areas below ground level will serve as

pockets for accumulation of leaking gas.

This water heater is supplied with an adjustable thermostat

to control water temperature. Hot water temperatures

required for automatic dishwasher and laundry use can

cause scald burns resulting in serious personal injury and/or

death. The temperature at which injury occurs varies with

the person’s age and the time of exposure. The slower

response time of disabled persons increases the hazards to

them. NEVER allow small children to use a hot water tap or

to draw their own bath water. NEVER leave a child or

disabled person unattended in a bathtub or shower.

To comply with NSF requirements this water heater is to be:

a) Sealed to the floor with sealant, in a smooth and easily

cleanable way, or

b) Installed with an optional leg kit that includes legs

and/or extensions that provide a minimum clearance of

6” beneath the water heater.

Important Information continued-

WARNING

Installation is not complete unless a properly sized/capacity

temperature and pressure relief valve is installed into the top of

the water heater. See the General Information section of this

manual for details.

This water heater contains very hot water under high pressure.

Do not unscrew any pipe fittings or attempt to disconnect any

components of this water heater without positively assuring the

water is cool and has no pressure. Always wear protective

clothing and equipment when installing, starting up, or

servicing this water heater to prevent scald injuries. Do not

rely on pressure and temperature gauges to determine the

temperature and pressure of the water heater. This water

heater contains components that become very hot. Do not

touch any components unless they are cool.

Improper installation, adjustments, alteration, service or

maintenance can cause property damage, personal injury or

loss of life. Failure to follow all instructions in the proper order

can cause personal injury or death. Read and understand all

instructions, including all those contained in component

manufacturer’s manuals, which are provided with the

appliance before installing, starting-up, operating, maintaining,

or servicing this appliance. Keep this manual and literature in

legible condition and posted near the appliance for reference by

owner and service technician.

This water heater requires regular maintenance and service to

operate safely. Follow the instructions contained in this

manual.

Installation, maintenance, and service must be performed only

by an experienced, skilled, and knowledgeable installer or

service agency.

Important Information continued-

WARNING

It is the responsibility of the installing contractor to see that all

controls are correctly installed and are operating properly

when the installation is complete.

DO NOT operate the water heater with jumpered or absent

controls or safety devices.

DO NOT tamper with or alter the water heater and/or controls.

DO NOT operate the water heater if any external part has been

under water. Immediately call a qualified service technician to

inspect the appliance and to replace any part of the control

system that was under water.

This water heater is suitable for installation on combustible

flooring. DO NOT install this water heater on carpeting.

DO NOT operate this water heater without first being certain it

is filled with water.

Flammable items, pressurized containers, or any other potential

fire hazardous articles must never be placed on or adjacent to

the heater. Containers of flammable gases should not be stored

or used in the same room with this water heater.

SECTION II

SPECIFICATIONS

Figure 1 – Heater Layout (40, 52, 75 single exchanger models)

Table 1: Water Heater Dimension (Inches)

MODEL A B C D E F G

40-Gal. 24 5 9-1/2 19 24-5/8 35-1/4 35-1/2

52-Gal. 24 5 9-1/2 19 28-3/8 45-5/8 45-7/8

75-Gal. 24 5 9-1/2 19 28-1/4 63-7/8 64-1/8

Specifications continued-

Figure 2 – Tank Layout (120 gallon model)

Specifications continued-

Table 2: Water Heater Capacities

MODEL

Tank Cap.

(Gal)

Coil Cap.

(Gal)

Dry Weight

(Lbs)

Wet Weight

(Lbs)

40-Gal. 40 1.2 90 415

52-Gal. 52 1.6 100 525

75-Gal. 75 1.6 125 745

120-Gal. 119 4.6 270 1257

Table 3: AHRI Certified Water Heater Ratings

MODEL

First

Hour

Rating

(Gal/Hr)

Continuous

Draw

Rating

(Gal/Hr)

Standby

Heat

Loss

Rating

(°F/Hr)

Minimum

Output of

Heat Source

(BTU/Hr)

Minimum

Heat

Source

Flow Rate

(Gal/Min)

40-Gal. 158 133 0.9 87,500 8.0

52-Gal. 200 165 0.7 113,000 8.0

75-Gal. 225 165 0.5 113,000 8.0

120-Gal. 360 280 0.6 195,000 11.0

NOTE: These certified ratings were obtained with a heat source

output and flow rate as specified in Table 3 and a 180°F boiler water

supply temperature. Other results will be obtained under different

conditions.

Table 4: Water Heater Performance

MODEL

Maximum First

Hour Rating

(Gal/Hr) @

140 °F 115 °F

Continuous

Draw Rating

(Gal/Min) @

140 °F 115 °F

Approximate

Boiler Output

Needed For

Ratings

(BTU/hr)

40-Gal. 209 279 3.0 4.2 136,000

52-Gal. 276 369 4.0 5.5 180,000

75-Gal. 293 385 4.0 5.5 180,000

120-Gal. 517 683 7.2 10.0 325,000

NOTE: Based on 200°F boiler water temperature and 50°F potable

water inlet temperature.

Inhaltsverzeichnis

Andere Bradford White Boiler Handbücher

Bradford White

Bradford White EVERHOT IGI-180R Series Beilage

Bradford White

Bradford White RG1PV40S Bedienungsanleitung

Bradford White

Bradford White BRUTE DELUXE BMT2H Leitfaden

Bradford White

Bradford White ECO-DEFENDER U130T*FRN Bedienungsanleitung

Bradford White

Bradford White MITW40L Series Anwendungshandbuch

Bradford White

Bradford White SW-2-40R-L Bedienungsanleitung

Bradford White

Bradford White E32-120R Bedienungsanleitung

Bradford White

Bradford White ERE240 Bedienungsanleitung

Bradford White

Bradford White 203-B Bedienungsanleitung

Bradford White

Bradford White 50T65 Anwendungshandbuch

Bradford White

Bradford White GAS-FIRED WATER HEATER Bedienungsanleitung

Bradford White

Bradford White EFR-1-60T1206EN Montageanleitung

Bradford White

Bradford White RG250T6N Bedienungsanleitung

Bradford White

Bradford White RG275H6X-506 Bedienungsanleitung

Bradford White

Bradford White EFC-5500-4-S-10 Bedienungsanleitung

Bradford White

Bradford White BNTH Bedienungsanleitung

Bradford White

Bradford White LE110U3 Bedienungsanleitung

Bradford White

Bradford White Brute MagnaTech BMGV1600 Bedienungsanleitung

Bradford White

Bradford White M2XR75S Series Bedienungsanleitung

Bradford White

Bradford White Copper Brute II Bedienungsanleitung

Bradford White

Bradford White mi5036en10 Bedienungsanleitung

Bradford White

Bradford White M-I-5036FBN Bedienungsanleitung

Bradford White

Bradford White D-38T-155 Bedienungsanleitung

Bradford White

Bradford White Combi2 "CDW2" Series Anwendungshandbuch

Beliebte Boiler Handbücher anderer Marken

Kenmore

Kenmore 153.582400 Bedienungsanleitung

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Bedienungsanleitung

clage

clage E-Mini Series Bedienungsanleitung

Toyotomi

Toyotomi Oil Miser OM-180 Bedienungsanleitung

Eccotemp

Eccotemp 40-H Bedienungsanleitung

Dimplex

Dimplex ECSd125-580 Leitfaden

Dux

Dux 32FCR6N Bedienungsanleitung

Noritz

Noritz N-132M Gebrauchsanweisung

TESY

TESY GCV7/4S 10047 Technisches Datenblatt

A.O. Smith

A.O. Smith Gphe 50 Bedienungsanleitung

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Fehlerbehebungshandbuch

Koryo

Koryo KWHZF15Y Bedienungsanleitung

Pentair

Pentair PSC-14-4-02 Bedienungsanleitung

GE 40M06AAG Montageanleitung

Thermor

Thermor AEROMAX SPLIT 2 Bedienungsanleitung

American Hometec

American Hometec AHQ-B03X Bedienungsanleitung

PVI

PVI MAXIM Bedienungsanleitung

Sunerg Solar Energy

Sunerg Solar Energy Calor Top 200D Betriebsanleitung