Char-Griller 3001 Bedienungsanleitung
OWNER’S MANUAL
LP Gas Grill
DANGER:
DO NOT use gas grill for indoor cooking or heating.
TOXIC fumes can accumulate and cause
asphyxiation. Do not use in or on boats or recreational
vehicles.
PROP 65 WARNING:
Chemicals known to the state of California to cause
cancer, birth defects or other reproductive harm are
created by the combustion of propane.
SAVE THESE INSTRUCTIONS FOR FUTURE
REFERENCE. IF YOU ARE ASSEMBLING THIS
UNIT FOR SOMEONE ELSE, GIVE THIS MANUAL
TO HIM OR HER TO SAVE FOR FUTURE
REFERENCE.
FOR CUSTOMER SERVICE, CALL 912-638-4724
A propane gas cylinder is required for operation.
This gas grill is not intended for commercial use.
Grillin’ Pro™ 3001
!
WARNING
For Outdoor Use Only (outside any enclosure)
™ & © Char-Griller / A&J Mfg.
Model #3001
Features:
•Porcelain Coated Cast Iron Grates
•Stainless Steel Thermometers
•Nickel Plated Warming Racks
•40,800 BTU’s
•645 Inches of Cooking Area
•Side Burner, 12,000 BTU, Cast Brass
•Stainless Steel Tube Burners
•Electronic Ignition System
•Porcelain Coated Flame Shields
•6” Wheels
•Dual Stacks for Even Heating
•Stay Cool™ Hood Handle
MH45677
WARNING:
Improper installation, adjustment, alteration, service or
maintenance could cause injury or property damage
Read the installation, operation and maintenance
instructions thoroughly before assembling or servicing
this equipment.
Failure to follow these instructions could result in fire
or explosion that could cause property damage,
personal injury or death.
DANGER
If you smell gas:
Shut off gas to the appliance.
Extinguish any open flame.
Open Lid.
If odor continues, keep away from the appliance
and immediately call your gas supplier or your fire
department.
WARNING
1. Do not store or use gasoline or other flammable
liquids or vapors in the vicinity of this or any
other appliance.
2. An LP cylinder not connected for use shall not
be stored in the vicinity of this or any other
appliance.
page 2
™ & © Char-Griller / A&J Mfg.
!
!
Table of Contents
Important Safety Information.………………………..page 4 - 5
Illustrated Parts List……………………………..…..page 6 – 7
Tools Required, Assembly Tips and Hardware List..…..page 8
Assembly Instructions……………………………....page 9 – 15
Operating Grill
Connecting Gas Cylinder……………………….page 16
Checking for Leaks……………………………...page 16
Lighting Grill…...…………………………………page 17
Cleaning and Care………………………………page 18
Gas Grill Troubleshooting……………………………page 19 - 20
Grill Preparation………………………………………page 21
Recipes……………………………………………..….page 22
Accessories…………………………………………….page 23 - 24
page 3
™ & © Char-Griller / A&J Mfg.
page 4
Grillin’ Pro model # 3000 Owner’s Manual
WARNING
FOR YOUR SAFETY
1. DO NOT store or use gasoline or any other flammable vapors and liquids within 25 feet (8m) of
this or any other appliance.
2. When cooking with oil/grease, do not allow the oil/grease to exceed 350°F (177°C). Do not
store of use extra cooking oil in the vicinity of this or any other appliance.
3. An LP Cylinder not connected for use should be stored a minimum of 10 feet (3m) away from
this or any other appliance. Never fill the cylinder beyond 80 percent full. If the above
information not followed exactly, a fire causing death or serious injury may occur.
4. If you smell gas:
- Shut Off gas to the grill.
- Extinguish any open flame.
- Open Lid.
- If odor continues, immediately call your gas supplier or fire department.
For Your Safety
Stop! Call us first! Do Not return product to store. This grill has been made to high quality
standards. If you have any questions not addressed in this manual or if you need parts please
call our customer service department at 1-912-638-4724 (USA), Monday-Friday 9am-5pm
(EST).
NOTE: The use and installation of this product must conform to local codes. In absence of local
codes, use the National Fuel Gas Code, ANSI Z223.1/NFPA54.
IMPORTANT NOTICE: read all instructions prior to assembly and use.
Read and understand all warnings and precautions prior to operating your grill.
CAUTION
1. This grill is for use with propane gas only (propane gas cylinder not included).
2. Never attempt to attach this grill to the self-contained propane system of a camper trailer, motor
home or house.
3. Never use charcoal or lighter fluid with the gas grill.
4. Do not use gasoline, kerosene or alcohol for lighting. The LP-gas supply cylinder must be
constructed and marked in accordance with the specifications for propane gas cylinders of the
U.S. Department of Transportation (DOT) CFR 49. This grill is not intended to be used in or
installed on recreation vehicles and/or boats.
5. Do not attempt to move the grill while it is lit.
6. Do not use the grill unless it is completely assembled and all parts are securely fastened and
tightened.
7. Keep all combustible items and surfaces at least 36 inches (91.4cm) away from grill at all times.
8. DO NOT use this grill or any gas product near unprotected combustible constructions.
™ & © Char-Griller / A&J Mfg.
page 5
9. Do not use in an explosive atmosphere. Keep grill area clear and free from combustible
materials, gasoline and other flammable vapors and liquids.
10. Do not touch metal parts of grill until it has completely cooled (about 45 minutes) to avoid burns,
unless you are wearing protective gear (BBQ mittens, pot holders, etc.)
11. Do not alter this grill in any manner.
12. Clean and inspect the hose before each use. If there is evidence of abrasion, wear, cuts, or
leaks, the hose must be replaced prior to operating the appliance. The replacement hose
assembly will be that which is specified by the manufacturer.
13. Move gas hoses as far away as possible from hot surfaces and dripping hot grease.
14. Never keep a filled container in a hot car or car trunk. Heat will cause the gas pressure to
increase, which may open the relief valve and allow gas to escape.
15. Keep the grill’s valve compartment, burners and circulating air passages clean. Inspect the grill
before each use.
WARNING
1. This grill is for outside use only, and should not be used in a building, garage or any other
enclosed area.
2. The use of alcohol, prescription or non-prescription drugs may impair the operator’s ability to
properly assemble or safely operate the grill.
3. Always open grill lid slowly and carefully as heat and steam trapped within the grill can burn you
severely.
4. Always place your grill on a hard, level surface far away from combustibles. An asphalt or
blacktop surface may not be acceptable for this purpose.
5. Do not leave a lit grill unattended. Keep children and pets away from the grill at all times.
6. Do not place this grill on any type of tabletop surface.
7. Do not use the grill in high winds.
DANGER
Liquid propane (LP) gas is flammable and hazardous if handled improperly. Know its characteristics
before using any propane product.
• Propane Characteristics: Flammable, explosive under pressure, heavier than air and settles in
pools and low areas.
• In its natural state, propane has no odor. For your safety, an odorant has been added.
• Contact with propane can cause freeze burns to skin.
• This grill is shipped from the factory for propane gas use only.
• Never use a propane cylinder with a damaged body, valve, collar or footing.
• Dented or rusted propane cylinders may be hazardous and should be checked by your propane
gas supplier.
™ & © Char-Griller / A&J Mfg.
page 6
12. LEG CROSS BAR....2PCS
11. SHORT LEG………….2PCS10. LONG LEG………..…2PCS
9. FLAME SHIELD…..3PCS8. BASE………………..…1PC7A. BURNER (with short wire)….2PC
6.WARMING.RACK…..1 PC5. HOOD HANDLE……..1 SET4. THERMOMETER……1 PC
3. CHIMNEY……..2PCS2. GRILL BODY……...1PC1. HOOD……………....1PC
ILLUSTRATED PARTS LIST:
™ & © Char-Griller / A&J Mfg.
7B. BURNER (with longer wire)…1PC
page 7
24. POT STAND……1 PC23. SIDE SHELF…………1 PC22. CATCH PAN……..…..1PC
21. GREASE TRAY..……1PC20. UTENSIL HOOK….3PCS
19. SIDE BURNER / CONTROL
PANEL / HOSE VALVE…1SET
18. FRONT PANEL……..1PC
17. AXEL………………..….1PC
16. LEG BRACE……….2PCS
15. WHEEL…………......2PCS
14. AXEL CAP…………....2PCS13.COOKING GRATE….3PCS
™ & © Char-Griller / A&J Mfg.
page 8
HAIR COTTER PIN….2 PCS
¼” LOCK WASHER…32 PCS
HINGE PINS………..2 PCS
¼-20 HEX NUT……..8 PCS
¼” FLAT WASHER…4 PCS
SCREW……………….3 PCS
¼-20x1/2” BOLT….... 38 PCS
¼-20x 1 ½” BOLT……4 PCS
Assembly: Requires 2 people. Get another person to help.
Tools Needed: Pliers, Phillips Head Screwdriver and a 7/16” Nut Driver.
NOTE: Do Not tighten any bolts unless instructed to do so. Tightening too soon may prohibit
parts from fitting together. All Hex Nuts should be on the inside of the grill unless stated
otherwise. Unpack all contents in a well cleared and padded area.
Estimated Assembly Time: 45 minutes
STOP! Do Not Return to Store. If you are missing parts or need assistance please email us at
info@chargriller.com or call 912-638-4724. Do not attempt assembly if you are missing parts.
HARDWARE:
™ & © Char-Griller / A&J Mfg.
page 9
Step 1
Attach the LONG LEGS and SHORT LEGS to the base, opposite the tank well/hole with two (2)
lock washers ½” Bolts as shown below.
Assembly Instructions
Step 2
Insert the LEGS into the LEG CROSS BARS as shown below.
Step 3
Insert the AXEL through the SHORT LEGS and through the BASE. Slide WHEELS onto
AXEL and hammer AXEL CAPS onto each end of the AXEL to secure WHEELS.
™ & © Char-Griller / A&J Mfg.
Lock Washer
Long Legs
Long Legs
page 10
Step 4
Install the two (2) LEG BRACES to the LEGS using eight (8) LOCK WASHERS and eight (8) ½”
BOLTS as shown. Remember to NOT tighten the bolts until the grill is completely assembled.
Step 5
Attach the FRONT PANEL to the inside of the front LEGS using four (4) LOCK WASHERS and
½” BOLTS as shown below.
Step 6
Attach the GRILL BODY to the LEGS using four (4) LOCK WASHERS, four (4) ½” BOLTS and four (4)
FLAT WASHERS as shown. Make sure to insert the bolt first through the lock washer then the flat
washer then through the grill body as shown. You may need to loosen other bolts and move the GRILL
BODY slightly to get the holes in the GRILL BODY to line up with the holes in the LEGS.
™ & © Char-Griller / A&J Mfg.
Lock Washer
LEG BRACE
Lock Washer
Flat Washer
Lock Washer
Bolt
Andere Handbücher für 3001
1
Dieses Handbuch passt für folgende Modelle
1
Inhaltsverzeichnis
Andere Char-Griller Grill Handbücher
Char-Griller
Char-Griller Outlaw MAVERICK 1016 Bedienungsanleitung
Char-Griller
Char-Griller Competition Pro 8125 Bedienungsanleitung
Char-Griller
Char-Griller Patio Pro 1515 Bedienungsanleitung
Char-Griller
Char-Griller Side Fire Box #2424 Bedienungsanleitung
Char-Griller
Char-Griller 2121 Bedienungsanleitung
Char-Griller
Char-Griller E2137 Bedienungsanleitung
Char-Griller
Char-Griller Akorn JR. Kamado 06614 Bedienungsanleitung
Char-Griller
Char-Griller AKORN Kamado Kooker E56720 Bedienungsanleitung
Char-Griller
Char-Griller 789792021218 Bedienungsanleitung
Char-Griller
Char-Griller Super Pro #2121 Bedienungsanleitung
Char-Griller
Char-Griller Flatiron 8128 Bedienungsanleitung
Char-Griller
Char-Griller 789792090207 Bedienungsanleitung
Char-Griller
Char-Griller 2123 Bedienungsanleitung
Char-Griller
Char-Griller 2197 Bedienungsanleitung
Char-Griller
Char-Griller 5650 Bedienungsanleitung
Char-Griller
Char-Griller Akorn 6520 Bedienungsanleitung
Char-Griller
Char-Griller Akorn Jr. 6714 Bedienungsanleitung
Char-Griller
Char-Griller Super Pro 2121 Bedienungsanleitung
Char-Griller
Char-Griller 5050 Bedienungsanleitung
Char-Griller
Char-Griller DUAL THREAT E5037 Bedienungsanleitung
