Desa C26TO Gebrauchsanweisung

If any wood pieces are missing or damaged, contact the

dealer where you purchased this mantel for replacement. If

hardware is missing or damaged, contact DESAHeating, LLC

at 1-866-672-6040 for referral information. You can also visit

DESA Heating, LLC’s web site at www.desatech.com.

       









IMPORTANT: If you are staining an unnished mantel (C26TU

only), remove any sawdust, dirt or oils. This will prevent blem-

ishes from appearing under the stain. Stain mantel before

assembling according to manufacturer’s instructions. Apply

sanding sealer.

IMPORTANT: If you are painting an unnished mantel (C26TU

only), assemble mantel before painting. Follow directions

listed on paint for wood products. Apply base coat and top

coat following directions listed on product.

Note: Gather all mantel pieces together before assembling

mantel.

     /4   

     

are used for this purpose.

C26TU and C26TO

Corner Mantel and Base

ASSEMBLY AND INSTALLATION INSTRUCTIONS

IMPORTANT:





-



This mantel kit contains the following:

• Mantel pieces - unassembled and numbered as follows:

#1 Base

#2 Right Side Assembly

#3 Left Side Assembly

#4 Header

#5 Top

#6 Top Triangle

#7 Top Left Support

#8 Top Right Support

#9 Top Center Support

#10 Base Support

#11 Vertical Support

Right Top Trim Strip

Left Top Trim Strip

• Hardware Package

22 - 1 1/4" Wood Screws 114325-01

8 - 1" Finishing Nails 114295-04

4 - 2" Wood Screws 122447-01

* Extra hardware may be included

Tools required:

• Power Screwdriver with #2 Phillips Bit

• Hammer

• Nail Set

www.desatech.com

123672-01A

2www.desatech.com

Header #4

Header

Assembly

Block

Figure 1 - Installing Base Support

Figure 2 - Installing Header

Base #1

11/4" Screws

Base Support #10

11/4"

Screws

Left Leg

Assembly #3

Right Leg

Assembly #2

Figure 3 - Installing Mantel Base

11/4"

Screws



IMPORTANT:





Use the following illustrations to assemble mantel. Use only

screws provided.

IMPORTANT: Align mantel left to right on base before installing.

Corner of mantel legs must be ush with back of mantel base

before installation. Use a tape measure to insure accuracy.

Right Leg

Assembly

Left Leg

Assembly #3

Base #1

Header into

Groove on

Legs

www.desatech.com

123672-01A 3

Fireplace Installation

1. Fireplace should be fully assembled. See Assembling

Fireplace in replace owner’s manual.

2. Mantel must be installed ush with two walls. Remove

baseboard along walls where mantel is to be installed.

Baseboard will prevent proper installation of mantel and

base.

3. Place mantel base close to installation location. See re-

place owner’s manual for installation clearances. Leave

enough room to insert replace from back of mantel.

4. If installing gas replace, install gas line. See Connecting

to Gas Supply in replace owner’s manual. Remember to

leave access to gas shutoff valve somewhere on mantel

base or where it is accessible to user. Check for leaks. See

Checking Gas Connections in replace owner’s manual.

5. Position replace inside mantel through back opening

(see Figure 5). Carefully position gas lines if applicable.

IMPORTANT: Use caution when positioning replace on

base. Base may scratch easily. Make sure replace is in

proper position within mantel opening before continuing

with installation.

6.      Lower bottom louver

door. Use two screws provided in replace hardware kit

and attach replace to wooden base. Close louver door.

 Before installing logs

or burner assembly (see owner’s manual) remove screws

securing oor to assembly. Lift oor for access to bot-

tom of replace. Use two screws provided in replace

hardware kit and attach replace base to wooden base.

Reinstall oor with screws removed previously.

Figure 5 - Installing Gas Fireplace

Mantel Top

Assembly

Blocks

Assembly

Blocks

11/4"

Screws

Mantel

Legs Flush

with Mantel

Base

Figure 4 - Installing Mantel Top

Corner

of Mantel

Legs Must

be Flush

with Edge

of Mantel

Top

IMPORTANT: Use 2" screws only on top center support. Using

2" screws in any other location will damage mantel.

IMPORTANT: Align mantel top left to right before installing.

Back corner of mantel leg must be ush with edge of mantel

top before installation.

IMPORTANT: If installing a gas replace, vertical support

will be installed to mantel assembly after gas replace has

been installed. If installing electric replace, rst install verti-

cal support and install replace from front of mantel. Do not

put any weight on mantel top until vertical support has been

installed.



This mantel can be used with DESA Heating, LLC electric

replaces. Electric replaces install from the front of mantel.

To install electric replace see replace instruction manual.



Install vertical support (see Figure 6).

Figure 7 - Installing Mantel Trim

Finishing Nails

Trim Strips

123672-01

Rev. A

07/08

Figure 6 - Installing Vertical Support

Vertical

Support

#11

1 1/4" Screws

Base Support #10

Top

Center

Support



1. Carefully push mantel and base into position in corner

and ush against both walls. Check operation of replace

before proceeding.

2. Place right trim strip on right side of top and left trim on left

side of top. Align both pieces so any gaps between mantel

and wall are covered as well as possible and front of trim

strips are ush with side of top. With one person holding

trim strips in place, nail each strip to mantle using nishing

nails included in hardware kit and nail set.

123672 01

NOT A UPC

DESA Heating, LLC

2701 Industrial Drive

Bowling Green, KY 42101

www.desatech.com

1-866-672-6040

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Desa Kaminzubehör Handbücher

Desa

Desa PC-BVBN Bedienungsanleitung

Desa

Desa HFL200 SERIES Bedienungsanleitung

Desa

Desa Wall Mantel and Base W32LT Gebrauchsanweisung

Desa

Desa PC-BDV37N Bedienungsanleitung

Desa

Desa GA6050 Bedienungsanleitung

Desa

Desa W32GO Gebrauchsanweisung

Desa

Desa W32AOSA Gebrauchsanweisung

Desa

Desa Wall Mantel and Base W26LT Gebrauchsanweisung

Desa

Desa Wall Mantel and Base W26ME Gebrauchsanweisung

Desa

Desa Wall Mantel with Base and Trim WD26CP Gebrauchsanweisung

Desa

Desa Comfort Glow GA3750 Bedienungsanleitung

Desa

Desa C36TO Gebrauchsanweisung

Desa

Desa GA6050 Bedienungsanleitung

Desa

Desa BK3 Bedienungsanleitung

Desa

Desa PCBM-325 Bedienungsanleitung

Desa

Desa Wall Mantel and Base W32MF Gebrauchsanweisung

Desa

Desa W32CO Gebrauchsanweisung

Desa

Desa W23FT Gebrauchsanweisung

Desa

Desa Mantel and Base W32RO Gebrauchsanweisung

Desa

Desa W32TO Gebrauchsanweisung

Desa

Desa Proflame 584 Bedienungsanleitung

Desa

Desa Mantel and Base W26RO Gebrauchsanweisung

Desa

Desa C32CO Gebrauchsanweisung

Desa

Desa HFL300 SERIES Bedienungsanleitung

Beliebte Kaminzubehör Handbücher anderer Marken

Valor

Valor L2 1700K Bedienungsanleitung

Exodraft

Exodraft Xzense Bedienungsanleitung

Whalen

Whalen Ruso MNFP62BF23-6 Bedienungsanleitung

Lopi

Lopi Hearthview 864 Bedienungsanleitung

Woodstock Soapstone

Woodstock Soapstone Fireview 201 Bedienungsanleitung

EdilKamin

EdilKamin SERBATOIO 250 Kurzanleitung

Bronpi

Bronpi KIT-1 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22150051 Bedienungsanleitung

Travis Industries

Travis Industries 33 DVI Bedienungsanleitung

Superior

Superior ASD3628-TI Bedienungsanleitung

pleasant hearth

pleasant hearth OFP28WG Bedienungsanleitung

IHP

IHP Astria Series Bedienungsanleitung

Firegear

Firegear FG-H-2110SS Bedienungsanleitung

Nibe

Nibe Contura C i31 Bedienungsanleitung

kozy heat

kozy heat KZK-052 Bedienungsanleitung

SimpliFire

SimpliFire SF-WM36 Bedienungsanleitung

Bluegrass Living

Bluegrass Living BC18NR Kurzanleitung

pleasant hearth

pleasant hearth IRIS SCROLL Bedienungsanleitung