Dexter Laundry B-Series Bedienungsanleitung

8514-265-001 REV C PAGE 1

INDUSTRIAL DRYER

MODEL T-20X2 AND T-30X2 ON-PREMISE

B-SERIES CONTROL, ELECTRIC-HEATED

OPERATOR’S MANUAL

INSTALLATION & OPERATION INSTRUCTIONS

The dryer ust not be stored or installed where it will be exposed to water and/or weather and is

suitable for use in roo te peratures between 40F and 105F (5C and 45C.)

Post the following “For Your Safety” caution in a pro inent location:

FOR YOUR SAFETY

Do not store or use gasoline or other flamma le vapors or liquids in the vicinity of this or any

other appliance or machine.

It is important that you read this Manual and retain it for future reference. For service or

replacement parts, contact the Dexter Distri utor in your area or the manufacturer.

WARNING / Avertissement

WARNING– Risk of Fire / Avertissement: Risque d’incendie

Clothes dryer installation must e performed y a qualified installer. / L’installation de la

sécheuse doit être effectuée par un spécialiste qualifié.

Install the clothes dryer according to the manufacturer’s instructions and local codes.

Do not install a clothes dryer with flexi le plastic venting materials. If flexi le metal (foil type)

duct is installed, use duct that has een investigated and found accepta le for use with clothes

dryers. Flexi le venting materials are known to collapse, e easily crushed, and trap lint.

These conditions will o struct clothes dryer airflow and increase the risk of fire. / Ne pas

installer une sécheuse avec des matériaux de ventilation en plastique. Dans le cas où un

conduit en métal flexi le (du genre à feuille) est installé, il doit être d’un type spécifique

identifié par le fa ricant de l’appareil comme accepta le pour les sécheuses. Les matériaux de

ventilation flexi les sont réputés pour s’aplatir, se déformer facilement et collecter de la

peluche. Ces conditions vont o struer l’écoulement d’air de la sécheuse et augmenter le risque

d’incendie.

To reduce the risk of severe injury or death, follow all installation instructions. / Pour réduire le

risque de lessures graves ou mortelles, suivre toutes les instructions d’installation.

Save these instructions. / Garder les instructions.

Dexter Laundry, Inc.

2211 West Grimes Avenue

Fairfield, Iowa 52556

8514-265-001 REV C PAGE 2

TABLE OF CONTENTS

Page No.

Warnings a out use and operation 2

Dryer Specifications 3

Dryer Dimensions 6

Installation Instructions 12

Dryer Shutdown 17

Description of Dryer Control 18

Dryer Fault Codes 19

Operating Instructions 23

Programming the Dryer Control 24

Servicing and Trou leshooting 30

Preventative Maintenance Instructions 31

WARNINGS ABOUT USE AND OPERATION

DO NOT MODIFY THIS APPLIANCE. KEEP SHIELDS, GUARDS, AND COVERS IN PLACE. These

safety devices are provided to protect everyone from injury.

It is ABSOLUTELY ESSENTIAL that the dryer e grounded to a known earth (zero) ground in accordance

with local codes or, in the a sence of local codes, with the latest editions of the National Electric Code, ANSI//NFPA

70 or Standard CSA C22.1 Canadian Electrical Code Part 1. This is not only for personal safety, ut is necessary

for proper operation of the controller. Failure to do so will void the warranty of the controller.

THIS DRYER IS EQUIPPED WITH AN OVER-TEMPERATURE THERMOSTAT located a ove the

motor on the side of the exhaust duct. If the dryer ceases to operate, refer to your “Service Procedure and Parts

Data” ook for instructions.

CHECK THIS THERMOSTAT WHEN INSTALLING DRYER to assure it is not tripped. Impacts such as

rough handling in shipment, may trip the thermostat. It may e reset y inserting a wooden pencil or dowel

through the ushing in the cover.

DO NOT SPRAY AEROSOLS IN THE VICINITY OF THIS APPLIANCE while in operation.

THIS APPLIANCE SHALL NOT BE USED TO DRY OFF SOLVENTS OR DRY-CLEANING FLUIDS.

8514-265-001 REV C PAGE 3

SPECIFICATIONS

20 lb. (9.1kg) Industrial Dryer: T-20X2

DN20X2E_-(82/84/85/86/87)_B_

Ca inet Height 68 1/2” 1740 mm.

(Assumes minimum leveling leg adjustment)

Ca inet Width 27” 686 mm.

Ca inet Depth 44 5/8” 1133 mm.

Floor to Bottom of Door- Bottom Dryer 8 1/2” 216 mm.

Floor to Bottom of Door- Top Dryer 42” 1067 mm.

Door Opening 18 1/8” 460 mm.

Dry Wt. Capacity 20 x 2 l s. 9.1 x 2 kg.

Cylinder Diameter 25 1/2” 648 mm.

Cylinder Depth 24” 610 mm.

Cylinder Volume 7.0 cu. ft. 198 liters

Lint Screen Area 285 sq. in. 1839 sq. cm.

Exhaust Size 8” 203 mm.

Make-up Air 1.0 sq. ft. 929 sq. cm.

Example: 1.0 sq. ft = 1 ft. long X 1 ft. wide

Motor Size (per dryer) 1/3 H.P. .248 kW

Airflow (per dryer - 50 hz) 300 CFM 8.5 m^3/min

Electrical Specifications – Model -82

Voltage/Hz/Phase 400V/50Hz/3Phase/15kW Heat

Running Amps 30 Amps

Minimum Dual Element Time Delay Fuse 30 Amp

Wire Size 8.5 mm^2

Electrical Service 4 wire + ground

Electrical Specifications – Model -84

Voltage/Hz/Phase 208V/60Hz/3Phase/15kW Heat

Running Amps 55 Amps

Minimum Dual Element Time Delay Fuse 60 Amp

Wire Size #4

Electrical Service 4 wire + ground

Electrical Specifications – Model -85

Voltage/Hz/Phase 240V/60Hz/3Phase/15kW Heat

Running Amps 50 Amps

Minimum Dual Element Time Delay Fuse 50 Amp

Wire Size #4

Electrical Service 4 wire + ground

Electrical Specifications – Model -86

Voltage/Hz/Phase 208V/60Hz/1Phase/16kW Heat

Running Amps 100 Amps

Minimum Dual Element Time Delay Fuse 100 Amp

Wire Size #1

Electrical Service 3 wire + ground

Electrical Specifications – Model -87

Voltage/Hz/Phase 240V/60Hz/1Phase/16kW Heat

Running Amps 85 Amps

Minimum Dual Element Time Delay Fuse 90 Amp

Wire Size #2

Electrical Service 3 wire + ground

8514-265-001 REV C PAGE 4

Shipping Weight 650 l s. 295 kg.

Net Weight 615 l s. 279 kg.

Clearance Behind Machines (min.) 18” 457 mm.

8514-265-001 REV C PAGE 5

SPECIFICATIONS

30 lb. Industrial Stack Dryer: T-30X2

DN30X2E_-(71/74/77/78)EB_X

Ca inet Height 76 1/4” 1937 mm.

(Assumes minimum leveling leg adjustment)

Ca inet Width 31 1/2” 800 mm.

Ca inet Depth 49 1/2” 1257 mm.

Floor to Bottom of Door- Bottom Dryer 7 5/8” 194 mm.

Floor to Bottom of Door- Top Dryer 45 1/4” 1149 mm.

Door Opening 22 5/8” 575 mm.

Dry Wt. Capacity 30 x 2 l s. 13.6 x 2 kg.

Cylinder Diameter 30” 762 mm.

Cylinder Depth 27 1/2” 699 mm.

Cylinder Volume 11.25 cu. ft. 319 liters

Lint Screen Area 453 sq. in. 2923 sq. cm.

Exhaust Size 8” 203 mm.

Make-up Air 1.5 sq. ft. 1394 sq. cm.

Example: 1.5 sq. ft = 1 ft. long X 1.5 ft. wide

Motor Size 1/2 H.P. .373 kW

Airflow (60 hz) 600 CFM 17.0 m^3/min

Electrical Specifications – Model -71

Voltage/Hz/Phase 208V/60Hz/3Phase/24kW Heat

Running Amps 85

Minimum Dual Element Time Delay Fuse 90 Amp

Wire Size #2

Electrical Service 4 wire + ground

Electrical Specifications – Model -74

Voltage/Hz/Phase 240V/60Hz/3Phase/24kW Heat

Running Amps 75

Minimum Dual Element Time Delay Fuse 80 Amp

Wire Size #3

Electrical Service 4 wire + ground

Electrical Specifications – Model -77

Voltage/Hz/Phase 120&208V/60Hz/1Phase/20kW Heat

Running Amps 120

Minimum Dual Element Time Delay Fuse 125 Amp

Wire Size (1/0)

Electrical Service 3 wire + ground

Electrical Specifications – Model -78

Voltage/Hz/Phase 120&240V/60Hz/1Phase/20kW Heat

Running Amps 105

Minimum Dual Element Time Delay Fuse 110 Amp

Wire Size (1/0)

Electrical Service 3 wire + ground

Shipping Weight 750 l s. 340 kg.

Net Weight 699 l s. 317 kg.

Clearance Behind Machines (min.) 18” 457 mm.

8514-265-001 REV C PAGE 6

T-20X2 DRYER DIMENSIONS- FIGURE 1A

8514-265-001 REV C PAGE 7

T-20X2 DRYER DIMENSIONS- FIGURE 1B

8514-265-001 REV C PAGE 8

T-20X2 DRYER DIMENSIONS- FIGURE 1C

8514-265-001 REV C PAGE 9

T-30X2 DRYER DIMENSIONS- FIGURE 1A

8514-265-001 REV C PAGE 10

T-30X2 DRYER DIMENSIONS- FIGURE 1B

Andere Handbücher für B-Series

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Dexter Laundry Trockner Handbücher

Dexter Laundry

Dexter Laundry DN20X2 Leitfaden

Dexter Laundry

Dexter Laundry DTCH30 series Bedienungsanleitung

Dexter Laundry

Dexter Laundry STACK DRYER Bedienungsanleitung

Dexter Laundry

Dexter Laundry DDAD50KC Series Bedienungsanleitung

Dexter Laundry

Dexter Laundry T-30 Bedienungsanleitung

Dexter Laundry

Dexter Laundry T-30 Bedienungsanleitung

Dexter Laundry

Dexter Laundry DN0170 XL Bedienungsanleitung

Dexter Laundry

Dexter Laundry T-30SWD Bedienungsanleitung

Dexter Laundry

Dexter Laundry DDAD30HC-59 Series Dryers Bedienungsanleitung

Dexter Laundry

Dexter Laundry C Series Kurzanleitung

Dexter Laundry

Dexter Laundry T-30 Bedienungsanleitung

Dexter Laundry

Dexter Laundry O Series Kurzanleitung

Dexter Laundry

Dexter Laundry T-50X2 Bedienungsanleitung

Dexter Laundry

Dexter Laundry T-20 SWD Bedienungsanleitung

Dexter Laundry

Dexter Laundry DCBD 30 Series Bedienungsanleitung

Dexter Laundry

Dexter Laundry T-30 SWD Bedienungsanleitung

Dexter Laundry

Dexter Laundry T-30 Bedienungsanleitung

Dexter Laundry

Dexter Laundry DCBD30KC-64F Series Bedienungsanleitung

Dexter Laundry

Dexter Laundry T-50X2 Administratorhandbuch

Dexter Laundry

Dexter Laundry T-20SWD Montageanleitung

Dexter Laundry

Dexter Laundry T-20 SWD Bedienungsanleitung

Dexter Laundry

Dexter Laundry T-30 Bedienungsanleitung

Dexter Laundry

Dexter Laundry T-20X2 Bedienungsanleitung

Dexter Laundry

Dexter Laundry DDAD30KC Series Bedienungsanleitung

Beliebte Trockner Handbücher anderer Marken

Bosch

Bosch WTA79200GB Bedienungsanleitung

Amana

Amana W10233410A Bedienungsanleitung

Asko

Asko T760 Bedienungsanleitung

Bosch

Bosch Logixx 10 WTB76556GB Technisches Datenblatt

Electrolux

Electrolux EW2H328R2 Bedienungsanleitung

Beko

Beko DS8433RX1M Bedienungsanleitung

Dawlance

Dawlance Spinner DS 6000 C Bedienungsanleitung

Electrolux

Electrolux TP5080TW Bedienungsanleitung

AEG

AEG TR838P4OB Bedienungsanleitung

Indesit

Indesit IDV 75 Bedienungsanleitung

Infiniton

Infiniton SD-DG85C Bedienungsanleitung

BOMANN

BOMANN WT 5019 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems TMB795C Bedienungsanleitung

Asko

Asko T793C Bedienungsanleitung

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Bedienungsanleitung

Frigidaire

Frigidaire CAQE7077KW0 Betriebsanleitung

Bosch

Bosch WTX8HKM9SN Bedienungsanleitung

Sharp

Sharp KD-NHH9S7GW2-PL Bedienungsanleitung