Edelbrock 5255 Bedienungsanleitung

Catalog #5255 Brochure #63-0470

Rev. 11/05

Page 1of 2

Edelbrock Adjustable Trailing Arms

Catalog #5255

1979-2004 Mustang

Installation Instructions

Please study these instructions carefully before installing your new Adjustble Trailing Arms. If you have any questions,

contact our Technical Hotline at: 1-800-416-8628, 7 am to 5 pm, Monday-Friday, Pacific Standard Time or

e-mail us at [email protected].

Tools and Supplies Required:

❑ Floorjack

❑Jackstands

❑Tire chocks

❑Lug wrench

❑18mm socket, combination wrench, and torque wrench

❑Blue Loctite™

❑Grease gun

REMOVAL OF STOCK TRAILING ARMS

1. Place car on level surface and place tire chocks in front of and

behind front tires (Figure 1).

2. Support rear of the car on jackstands and remove the rear

wheels.

3. Place a floor jack under the differential and lift up slightly to

remove tension from the trailing arm bolts - make sure not to lift

the car off the jackstands (Figure 2).

KEEP FLOOR JACK UNDER CAR DURING THE COMPLETE

REMOVAL AND INSTALLATION PROCEDURE.

CAUTION - DO NOT REMOVE BOTH TRAILING ARMS AT THE

SAME TIME OR THE AXLE WILL ROTATE AND THE TRAILING

ARM INSTALLATION WILL BE MUCH MORE DIFFICULT.

4. Start with either trailing arm and remove the rear bolt.

Note: Re-install the bolts in same direction as original.

5. Remove the front trailing arm bolt.

6. Remove the trailing arm.

7. Clean frame at trailing arm pivot area with a wire brush.

Fig. 1

Fig. 2

Catalog #5255 Brochure #63-0470

Rev. 11/05

Page 2of 2

DIFFERENTIAL BUSHING INSTALLATION

Note: The bushings supplied with these arms are designed to be used with the original differential bushing shells. Do

not press out bushing shells.

1. Remove rubber and the inner sleeve from outer bushing shells.

2. Clean original shells thoroughly.

3. Using special pre-lube teflon grease, lube the I.D. and flange of the O.E. bushing shell.

4. Lightly grease O.D. and I.D. of polyurethane bushing.

5. Install bushing into shell.

6. Grease O.D. of steel sleeve and install into bushing.

7. Install thrust bushing.

INSTALLATION OF EDELBROCK ADJUSTABLE TRAILING ARMS

Edelbrock Adjustable Trailing Arms are fully assembled, greased, and ready to install.

1. Install new trailing arms with the grease fittings facing down, locating the front bolt first.

2. Place one drop of blue Loctite™ on clean threads and torque the nut to 70 ft./lbs.

3. The trailing arm should then pivot smoothly.

4. Place a thin coat of supplied grease on the sides of the new axle housing bushings.

5. Pivot trailing arm into position over polyurethane bushing and thrust washer. Install rear bolt in same direction as

original.

6. Place one drop of blue Loctite™ on clean threads and torque the nut to 70 ft./lbs.

7. Although Edelbrock Trailing Arms are pre-lubed, you may want to finish your installation by lubing the front bushings

with a greasegun. Be sure to replace the dust caps on the Zerk fittings to prevent dirt and corrosion from damaging

the fitting.

Check all nut and bolt tightness after first 10 miles.

NOTES:

1. Edelbrock Adjustable Trailing arms come pre-adjusted to stock length. Pinion angle can be adjusted by loosening the

jam nuts on the arms and turning the aluminum adjuster sleeve in the center of the arm. Both arms should be

adjusted evenly. A properly installed and adjusted trailing arm will have the spherical ball straight and parallel with

the ball housing. If the ball is twisted in its housing when installed, the arm could fail during suspension articulation.

After adjustment has been made, use a drop of Loctite™ on threads at jam nuts.

2. Jam nuts should be checked periodically for tightness.

3. Tofurther enhancethe handlingand performanceof yourMustang, checkour catalogto findout moreabout Edelbrock

Suspension components such as coil springs, lower trailing arms, strut tower brace and sub-frame connectors. To

order our catalog, call 1-800-FUN-TEAM.

Please complete and mail your warranty card. Be sure to write the model number in the “Part #” space. Thank you.

Edelbrock Corporation, 2700 California St., Torrance, CA 90503

Tech Line: 1-800-416-8628

Tech Fax: (310) 972-2730

E-Mail: [email protected]

Inhaltsverzeichnis

Andere Edelbrock Automobilteil Handbücher

Edelbrock

Edelbrock 541583 Bedienungsanleitung

Edelbrock

Edelbrock Camaro 5290 Bedienungsanleitung

Edelbrock

Edelbrock 60509 Bedienungsanleitung

Edelbrock

Edelbrock Russell 641540 Bedienungsanleitung

Edelbrock

Edelbrock 5721 Bedienungsanleitung

Edelbrock

Edelbrock 6501 Bedienungsanleitung

Edelbrock

Edelbrock Chevrolet/GMC Trucks 454 SS Bedienungsanleitung

Edelbrock

Edelbrock 7107 Bedienungsanleitung

Edelbrock

Edelbrock Nitrous Refill Station 78000 Bedienungsanleitung

Edelbrock

Edelbrock 1795 Bedienungsanleitung

Edelbrock

Edelbrock 68982 Bedienungsanleitung

Edelbrock

Edelbrock Russell R09320 Bedienungsanleitung

Edelbrock

Edelbrock 4790 Bedienungsanleitung

Edelbrock

Edelbrock 1565 Bedienungsanleitung

Edelbrock

Edelbrock 15015 Bedienungsanleitung

Edelbrock

Edelbrock 5658 Bedienungsanleitung

Edelbrock

Edelbrock 70403 Bedienungsanleitung

Edelbrock

Edelbrock Victor Series 6570 Bedienungsanleitung

Edelbrock

Edelbrock 68882 Bedienungsanleitung

Edelbrock

Edelbrock 5786 Bedienungsanleitung

Edelbrock

Edelbrock 71003 Bedienungsanleitung

Edelbrock

Edelbrock 3864 Bedienungsanleitung

Edelbrock

Edelbrock 3562 Bedienungsanleitung

Edelbrock

Edelbrock 2-R Bedienungsanleitung

Beliebte Automobilteil Handbücher anderer Marken

Dakota Digital

Dakota Digital 650277 Bedienungsanleitung

bosal

bosal 037031 Bedienungsanleitung

Vintage Air

Vintage Air 571063 Bedienungsanleitung

GFB

GFB EX38 Bedienungsanleitung

bosal

bosal 028091 Bedienungsanleitung

Dodge

Dodge 8W-43 Kurzanleitung

ICI

ICI Magnum FBM10DGN Bedienungsanleitung

Volant Perfomance

Volant Perfomance 19435 Bedienungsanleitung

BENDIX

BENDIX GEN 4 GEN 5 ABS Bedienungsanleitung

Vintage Air

Vintage Air 571065 Bedienungsanleitung

Rugged Ridge

Rugged Ridge 11503.13 Bedienungsanleitung

BENDIX

BENDIX CYCLONE DURADRAIN TRAILER WATER Bedienungsanleitung

Porsche

Porsche 968 - ASSEMBLY INSPECTION PROCEDURE AND MAINTENANCE... Leitfaden

Sumitomo

Sumitomo FINE CYCLO FC-A 15 G Bedienungsanleitung

Toshiba

Toshiba 48-1250 A Bedienungsanleitung

aldes

aldes EHT2 Bedienungsanleitung

Go Rhino

Go Rhino 24371T Bedienungsanleitung

BBK

BBK 18950 Bedienungsanleitung