Elkay EFRC8CDC-A Installationshandbuch

97162C (Rev. H - 10/02)PAGE 1

EFRC8C-A EFRC8CDC-A EFRC12C-A EFRC12CDC-A LJNE8C-A LJNE12C

IMPORTANT

Installation/Care/Use Manual

Fully Recessed Refrigerated

Fountain with FLEXI-GUARD®

ALL SERVICE TO BE PERFORMED BY AN AUTHORIZED SERVICE PERSON

To assure you install this model easily and correctly, PLEASE READ THESE SIMPLE

INSTRUCTIONS BEFORE STARTING THE INSTALLATION. CHECK YOUR INSTALLATION

FOR COMPLIANCE WITH PLUMBING, ELECTRICAL AND OTHER APPLICABLE CODES.

After installation, leave these instructions inside the fountain for future reference.

IMPORTANT! INSTALLER PLEASE NOTE.

THE GROUNDING OF ELECTRICAL EQUIPMENT SUCHAS TELEPHONE, COMPUTERS, ETC. TOWATER

LINES IS A COMMON PROCEDURE. THIS GROUNDING MAY BE IN THE BUILDING OR MAY OCCURAWAY

FROM THE BUILDING. THIS GROUNDING CAN CAUSE ELECTRICAL FEEDBACK INTO A FOUNTAIN,

CREATING AN ELECTROLYSIS WHICH CAUSES A METALLIC TASTE OR AN INCREASE IN THE METAL

CONTENT OF THE WATER. THIS CONDITION ISAVOIDABLE BY USING THE PROPER MATERIALS AS

INDICATED. ANY DRAIN FITTINGS PROVIDED BY THE INSTALLER SHOULD BE MADE OF PLASTIC TO

ELECTRICALLY ISOLATE THE FOUNTAIN FROM THE BUILDING PLUMBING SYSTEM.

SEE FIG. 7

SEE FIG. 8

SEE FIG. 9

SEE FIG. 11

20, 21

19, 22

23 24

EFRC8C, EFRC12C EFRC8CDC, EFRC12CDC

Installer

97162C (Rev. H - 10/02) PAGE 2

EFRC8C-A EFRC8CDC-A EFRC12C-A EFRC12CDC-A LJNE8C-A LJNE12C

FIG. 1

FINISHED FLOOR LINE

EFRC8C/EFRC12C ROUGH-IN

LEGEND:

A = RECOMMENDED WATER SUPPLY LOCATION 3/8 O.D. UNPLATED COPPER TUBE CONNECT

STUB 1-1/2 (38mm) OUT FROM WALL, SHUT OFF BY OTHERS (BOTH SIDES).

B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/4 O.D. DRAIN (BOTH SIDES).

C = ELECTRICAL SUPPLY LOCATION (BOTH SIDES).

NOTES:

1. THERE ARE HOLES AND KNOCKOUTS PROVIDED ON EACH SIDE OF THE MOUNTING BOX THAT

ARE INTENDED TO BE USED TO MOUNT THE BOX. USE SIX SCREWS OR BOLTS (NOT PROVIDED).

97162C (Rev. H - 10/02)PAGE 3

EFRC8C-A EFRC8CDC-A EFRC12C-A EFRC12CDC-A LJNE8C-A LJNE12C

FIG. 2

FINISHED FLOOR LINE

EFRC8CDC/EFRC12CDC ROUGH-IN

LEGEND:

A = RECOMMENDED WATER SUPPLY LOCATION 3/8 O.D. UNPLATED COPPER TUBE CONNECT

STUB 1-1/2 (38mm) OUT FROM WALL, SHUT OFF BY OTHERS (LEFT SIDE ONLY).

B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/4 O.D. DRAIN (LEFT SIDE ONLY).

C = ELECTRICAL SUPPLY LOCATION (BOTH SIDES).

*WATERAND DRAIN CONNECTIONS MUST BE MADE FROM LEFT SIDE ONLY.

NOTES:

1. THERE ARE HOLES AND KNOCKOUTS PROVIDED ON EACH SIDE OF THE MOUNTING BOX THAT

ARE INTENDED TO BE USED TO MOUNT THE BOX. USE SIX SCREWS OR BOLTS (NOT PROVIDED).

97162C (Rev. H - 10/02) PAGE 4

EFRC8C-A EFRC8CDC-A EFRC12C-A EFRC12CDC-A LJNE8C-A LJNE12C

INSTALLATION INSTRUCTIONS

1. Remove shipping brace from mounting box and discard.

2. Fasten mounting box into wall cutout using screws or bolts (provided by others) through the holes or knock

outs provided on each side of the mounting box. (See Fig. 1 or 2)

3. Install fountain body to mounting box using #10 x .63 (16mm) PHSM screws and large clips provided.

4. Place refrigeration package into mounting box and connect water lines. (See Page 5 for details)

5. Water inlet is 3/8" O.D. and waste tube is 1-1/4" O.D. Contractor is to supply waste trap and service stop

valve in accordance with local codes.

6. Connecting lines to be unplated copper and thoroughly flushed to remove all foreign matter before connecting

to refrigeration package. The furnished strainer (Item 18) should be added to the supply line.

7. Connect the refrigeration package to the supply line service stop valve. Connect supplied fountain (internal

plumbing) tubes as shown in figures 3, 4, 5, or 6. Remove any burrs from water tubes before inserting into

fittings. (See Figs. 13 and 14) DO NOT SOLDER TUBES INSERTED INTO THE STRAINER AS DAMAGE

TO THE O-RINGS MAY RESULT.

8. Electrical: Insure power supply is identical in voltage, hertz, and phase to that specified on the refrigeration

package serial plate. Never wire compressor directly to the power supply.

9. Turn water supply on and check thoroughly for leaks.

10. Release air from tank by depressing push button; a steady stream of water assures all air is removed.

11. Re-check for leaks.

12. Stream height is factory set at 35 PSI. If supply pressure varies greatly from this, turn adjustment screw on

regulator (Item 14). Clockwise adjustment will raise the stream height and counter-clockwise adjustment

will lower stream height. For best adjustment, stream should hit basin approximately 6-1/2" from the bubbler.

13. Rotate fan blade on refrigeration package to insure proper clearance and free fan action.

14. Connect power supply.

15. Install grill using #8 x 1.00" (25mm) PH screws and small clips provided.

TROUBLE SHOOTING AND MAINTENANCE

1. Orifice Assy: Mineral deposits on orifice can cause water flow to spurt or not regulate. Mineral deposits

may be removed from orifice with a small round file not over 1/8 diameter or a small diameter wire.

CAUTION: Do not file or cut orifice materials.

2. Actuation of Quick Connect Water Fittings: Cooler is provided with lead-free connectors which utilize

an o-ring water seal. To remove tubing from the fitting, relieve water pressure, push in on the gray collar

while pulling on the tubing (See Fig. 13). To insert tubing, push tube straight into the fitting until it reaches

a positive stop, approximatley 3/4".

97162C (Rev. H - 10/02)PAGE 5

EFRC8C-A EFRC8CDC-A EFRC12C-A EFRC12CDC-A LJNE8C-A LJNE12C

FIG. 3 FIG. 4

FIG. 5 FIG. 6

17 16

EFRC8C EFRC8C W/GLASS FILLER

EFRC12C EFRC12C W/GLASS FILLER

44 44

97162C (Rev. H - 10/02) PAGE 6

EFRC8C-A EFRC8CDC-A EFRC12C-A EFRC12CDC-A LJNE8C-A LJNE12C

10 11

FIG. 8FIG. 7

FIG. 9

NOTE: WHEN INSTALLING REPLACEMENT BUBBLER

AND PEDESTAL, TIGHEN NUT (ITEM 15) ONLY TO

HOLD PARTS SNUG IN POSITION. DO NOT OVER

TIGHTEN.

BASIN

97162C (Rev. H - 10/02)PAGE 7

EFRC8C-A EFRC8CDC-A EFRC12C-A EFRC12CDC-A LJNE8C-A LJNE12C

DISPENSER/

DISPOSAL

26 29

15 26 27

FIG. 12

FIG. 11

FIG. 10

97162C (Rev. H - 10/02) PAGE 8

EFRC8C-A EFRC8CDC-A EFRC12C-A EFRC12CDC-A LJNE8C-A LJNE12C

FOR PARTS, CONTACT YOUR LOCAL DISTRIBUTOR OR CALL 1.800.323.0620

ELKAY MANUFACTURING COMPANY  2222 CAMDEN COURT  OAK BROOK, IL 60523  630.574.8484

PRINTED IN U.S.A.

PARTS LIST

ITEM NO. PARTNO. DESCRIPTION

15005C

20397C

40301C

40480C

40561C

40038C

40048C

40089C

40169C

40619C

50074C

50986C

56073C

40322C

56011C

55997C

61313C

75580C

70682C

70683C

55996C

110669443890

74070030

74070032

70567C

55001084

EFRCDF

55000881

EG23

31525028

40493C

40299C

40562C

50258C

50967C

61099C

70151C

70234C

22940C

51294C

51299C

70792C

70818C

70822C

70823C

62084C

62088C

56092C

Retaining Nut

Tailpipe - EFRC8, EFRC8F

Tailpipe - EFRC8CD

Precooler - EFRC12, EFRC12F

Precooler - EFRC12CD

Strainer

Button

Nut - Cover

Hex Nut

Ferrule

Gasket

Regulator Holder

Bubbler Assy

Orifice Assy

Housing Assy

Pedestal

Regulator

Locknut - 3/8-18

Tee - 1/4

Union - 1/4

Strainer

Screw - #10 x .63 PHSM

Screw - #8 x 1.00 PH

Speed Nut - #8

Clip - Speed

Fountain

Fountain - GF

Dispenser/Disposal

Grill

O-ring

Glass Filler

Drain - 1/2

Glass Filler

Washer

Flow Regulator Assy

Connector Assy

Washer

Hose Clamp

Bracket - Filter Mounting

Filter Head Assy

Filter Assy

Screw - #8-18 x .75 PH

Elbow - 3/8 (10mm)

Fitting - Superseal 1/4 ((8mm)

Fitting - Superseal 3/8 (10mm)

Tube Assy - GF

Poly Tubing 48(Cut to Length)

FIG. 13

FIG. 14

NOTE: REMOVE ANY BURRS FROM WATER TUBES

BEFORE INSERTING INTO FITTINGS.

NOTE: WATER FLOW

DIRECTION

BUILDING WATER

INLET

SERVICE STOP

(NOT FURNISHED)

1/4" O.D. TUBE

WATER INLET

TO COOLER

3/8" O.D. UNPLATED

COPPER TUBE CONNECT

COLD WATER SUPPLY

Dieses Handbuch passt für folgende Modelle

Andere Elkay Freiluftbrunnen Handbücher

Elkay

Elkay Hydroboost HTHBHAC8BLSSWF25N Installationshandbuch

Elkay

Elkay SWIRLFLO ENOBM28RAK Installationshandbuch

Elkay

Elkay FLEXI-GUARD SOFT SIDES ezH2O EDFP217WS F... Gebrauchsanweisung

Elkay

Elkay WGA5 1C Series Installationshandbuch

Elkay

Elkay SWIRLFLO FLEXI-GUARD ERPB8C 2C Series Installationshandbuch

Elkay

Elkay Swirlflo EDFPBW114FP Bedienungsanleitung

Elkay

Elkay 4590 Series Bedienungsanleitung

Elkay

Elkay LK4410BFFR FTN A Series Bedienungsanleitung

Elkay

Elkay Soft Sides EDFP210FP B Series Installationshandbuch

Elkay

Elkay 4430FR Bedienungsanleitung

Elkay

Elkay 4420BF1UFR Bedienungsanleitung

Elkay

Elkay EFRC8C-A Installationshandbuch

Elkay

Elkay EDFP19C*A Installationshandbuch

Elkay

Elkay Soft Sides ERO8C-C Installationshandbuch

Elkay

Elkay 4400DBFR Bedienungsanleitung

Elkay

Elkay EDFAC11PBC Installationshandbuch

Elkay

Elkay SwirlFlo ERPA8C Installationshandbuch

Elkay

Elkay Soft Sides ECDFPW314C Gebrauchsanweisung

Elkay

Elkay SOFT SIDES EDFPBM117WS Installationshandbuch

Elkay

Elkay EFRP8C Installationshandbuch

Elkay

Elkay 4405BFFR Bedienungsanleitung

Elkay

Elkay EHFRA72K Installationshandbuch

Elkay

Elkay EZH2O VRCGN8WS 1C Series Leitfaden

Elkay

Elkay LVRCTL8 1D Series Installationshandbuch

Beliebte Freiluftbrunnen Handbücher anderer Marken

Sunnydaze Decor

Sunnydaze Decor XSS-578 Bedienungsanleitung

Campania International

Campania International Bibendum FT-400 Bedienungsanleitung

S.R.Smith

S.R.Smith Color Light Stream 2CLSLBK Bedienungsanleitung

Hozelock Cyprio

Hozelock Cyprio Cascade 1500 Bedienungsanleitung

Campania International

Campania International Juliet Fountain Bedienungsanleitung

YARDART

YARDART FT-155 Bedienungsanleitung

Alpine

Alpine WIN732 Bedienungsanleitung

Campania

Campania Valencia Bedienungsanleitung

Campania International

Campania International FT-320 Bedienungsanleitung

GardenWize

GardenWize SWGSL230 Bedienungsanleitung

Kelkay

Kelkay Easy Fountain Rustic Windmill Bedienungsanleitung

Alpine

Alpine WIN258 Bedienungsanleitung

Bond

Bond Signature Series Bedienungsanleitung

Kenroy Home

Kenroy Home 51112COPBL Installationsanleitung

EasyPro

EasyPro Tranquil Décor HBB39 Bedienungsanleitung

Angelo Decor

Angelo Decor Castillo Bedienungsanleitung

Campania International

Campania International Girona FT-102A Bedienungsanleitung

Campania International

Campania International FT-271 Bedienungsanleitung