Elkay Soft Sides EDFP210FP B Series Installationshandbuch

97565C (Rev. K - 1/08)

EDFP210FP*B EDFP214FP*B EDFP217FP*B

Installation/Care/Use Manual

EDFP210FPC EDFP214FPC EDFP217FPC

Soft Sides™Freeze Resistant Fountains

IMPORTANT! INSTALLER PLEASE NOTE.

THEGROUNDINGOFELECTRICALEQUIPMENTSUCHASTELEPHONE,COMPUTERS,ETC.TO

WATERLINES ISACOMMONPROCEDURE.THISGROUNDINGMAYBEINTHEBUILDINGORMAY

OCCURAWAYFROMTHE BUILDING.THISGROUNDING CAN CAUSE ELECTRICALFEEDBACK

INTOAFOUNTAIN,CREATINGAN ELECTROLYSIS WHICH CAUSESAMETALLICTASTE ORAN

INCREASEINTHEMETALCONTENTOFTHE WATER.THISCONDITIONISAVOIDABLEBYUSING

THEPROPERMATERIALSASINDICATED.ANYDRAINFITTINGSPROVIDEDBYTHE INSTALLER

SHOULDBEMADEOFPLASTICTOELECTRICALLYISOLATETHE FOUNTAINFROMTHEBUILDING

PLUMBINGSYSTEM.

IMPORTANT

ALLSERVICETO BE PERFORMEDBY AN AUTHORIZEDSERVICE PERSON

EDFP210FPC EDFP217FPC

Toassureyouinstallthismodeleasilyandcorrectly,PLEASEREADTHESESIMPLE

INSTRUCTIONSBEFORESTARTINGTHEINSTALLATION.CHECKYOURINSTALLA-

TIONFORCOMPLIANCEWITHPLUMBING,ELECTRICALANDOTHERAPPLICABLE

CODES.Afterinstallation,leavetheseinstructionsinsidethefountainforfuturereference.

ThisFreezeResistantFountainisshippedintwoseparatecartons.Thesecondcarton(s)

containstheFreezeResistantPackage(s)LKFRB1 thatareinstalledonaninterior

heatedwall.Theinteriorspacemustmaintainaminimumtemperatureof50°F(10°C).

RefertotheFreezeResistantPackagefortherough-indimensionsforinstallation.

Installer

EDFP214FPC

97565C (Rev. K - 1/08)

EDFP210FP*B EDFP214FP*B EDFP217FP*B

FIG.1

PAGE 2

LEGEND

A= MOUNTING BOLT LOCATIONS

(4) (3/8" DIA. NOT PROVIDED)

B = 7/8" DIA. (22mm) HOLE FOR

WATER SUPPLY TUBE

C = 7/8" DIA. (22mm) HOLE FOR

OPERATING CABLE

D = 1-3/4" (44mm) HOLE FOR

WASTE LINE

FINISHEDFLOOR

EDFP210FP/EDFP214FP

MOUNTING BOLT AND ACCESS HOLE LAYOUT

97565C (Rev. K - 1/08)

EDFP210FP*B EDFP214FP*B EDFP217FP*B

PAGE 3

FIG. 2

FINISHEDFLOOR

1. Wall should already be framed for the fountain using dimensions shown in Fig. 1. Shown dimensions pertain to installation location.

These dimensions are required for compliance with ANSI Standard A117.1. and ADA (Framing shown for reference only).

2. Remove bottom cover from fountain and save the screws.

3. Install the fountain using bolts and washers (not provided). Tighten securely.

4. Attach drain tube to fountain and cut to required length using the freeze resistant box as a guide.

5. Install freeze-resistant box - see box instructions.

6. Replace bottom cover.

EDFP210FP/EDFP214FP

ROUGH-IN DRAWINGS

97565C (Rev. K - 1/08)

EDFP210FP*B EDFP214FP*B EDFP217FP*B

FINISHEDFLOOR

PAGE 4

FIG.3

LEGEND

A = 3/8" DIA. (10mm) SLOTS (FOR MOUNTING

UPPER HANGER BRACKET)

B = 7/8" DIA. (22mm) HOLE FOR WATER

SUPPLY TUBE

C = 7/8" DIA. (22mm) HOLE FOR OPERATING

CABLE

D = MOUNTING BOLT LOCATIONS (8) (3/8" DIA.

NOT PROVIDED)

E = 1-3/4" (44mm) HOLE FOR WASTE LINE

EDFP217FP

MOUNTING BOLT AND ACCESS HOLE LAYOUT

97565C (Rev. K - 1/08)

EDFP210FP*B EDFP214FP*B EDFP217FP*B

1. Wall should already be framed for the fountains using dimensions shown in Fig. 3. Shown dimensions pertain to installation location.

These dimensions are required for compliance with ANSI Standard A117.1. and ADA (Framing shown for reference only).

2. Remove bottom covers from fountains and save the screws.

3. Install the fountains using bolts and washers (not provided). Tighten securely.

4. Attach drain tubes to fountains and cut to required length using the freeze resistant boxes as guides.

5. Install freeze-resistant boxes - see box instructions.

6. Replace bottom covers.

FIG.4

FINISHEDFLOOR

PAGE 5

EDFP217FP

ROUGH-IN DRAWINGS

97565C (Rev. K - 1/08)

EDFP210FP*B EDFP214FP*B EDFP217FP*B

PAGE 6

FIG. 8 FIG. 9

FIG. 5 FIG. 6

See Fig. 9

See Fig. 5 FIG. 7

CABLESHEATHADJUSTMENT

To Increase FreePlay

To Reduce FreePlay

97565C (Rev. K - 1/08)

EDFP210FP*B EDFP214FP*B EDFP217FP*B

PAGE 7

Thefreeze resistant package must be mounted on an interior wall in a heated area. The roomtemperature ofthe interior

heated area must be 50° F (10° C) or higher. The freeze resistant package may be surface or recessed mounted. If recess

mounted the surface of the cover must be flush with the interior wall surface. The package is furnished with screws for

mounting the cover to the box. If the box is recess mounted, do not fasten the top and bottom of the cover to the box. Use

the holes on the front only.

1. Assemble the operating cable to the fountain bracket. (Fountain should be mounted to exterior wall) Create a loop in

the cable and thread the free end of the cable through the wall into the freeze resistant box. The adjustment nuts should

be in the middle of threaded area on the operating cable. See Figure 9

2. Connectfree end of operating cable to the valve-operating bracket. Theend ofthe cablesmust be recessed into the

indents on the pivot brackets.

3. Remove cable free play by adjusting the jam nuts on the ends of the operating cable. See Figure 6

4. Connect water line from fountain bubbler into freeze resistant box. The connection to the box uses a quick connect

water fitting. Position the water line, in the fountain, to drain back into interior mounted box. Any water left standing, in

theexterior line, can freeze.

To insert tubing, push tube straight into fitting until it reaches a positive stop. To remove tubing from the fittings, relieve

water pressure, push in on dark gray collar while pulling out on the tubing. See Figure 11

5. Connect drain and water supply lines to the freeze resistant fountain. Refer to Figure 1 for component positions. Inline

strainer must be used on the inlet water line.

Start-up

1. Turn on building water supply and check all connections for leaks. Repair as required.

2. Stream height is factory set at 35 PSI. If stream height needs to be changed adjust the regulator in the freeze resistant

package. Clockwise adjustment raises stream height, counter clockwise adjustment will lower stream.

3. Adjustoperating cable as required. Cable systemshould havea minimal amount of freeplay to allow for propervalve

operation. If the system is too tight the valve will stay in the on position creating constant water flow. Too much free

playwill result innon-operation of thevalve with the push-buttons.

4. Note: Water from the drain back tube in the freeze resistant package, will continue to run while the valve is actuated.

5. After cable system is adjusted properly stuff flexible insulation into any openings between the outside wall and the

interiorbox.

6. Recheckall connections. If all connections are leak free replace cover(s) on the freeze resistant box(es) andfountain(s).

FIG. 10

NOTE:WATERFLOWDIRECTION

BUILDINGWATER

INLET

SERVICESTOP

(NOT FURNISHED)

1/4"O.D. TUBE

WATERINLET

3/8"O.D. UNPLATED

COPPERTUBECONNECT

COLDWATERSUPPLY

TUBE IS

SECURED

IN POSITION

SIMPLY PUSH IN

TUBE TO ATTACH PUSH IN COLLET

TO RELEASE TUBE

PUSHING TUBE IN BEFORE

PULLING IT OUT HELPS TO

RELEASE TUBE

FIG. 11

OPERATIONOFQUICKCONNECTFITTINGS

97565C (Rev. K - 1/08)

EDFP210FP*B EDFP214FP*B EDFP217FP*B

PAGE 8

FOR PARTS, CONTACT YOUR LOCAL DISTRIBUTOR OR CALL 1.800.323.0620

ELKAY MANUFACTURING COMPANY • 2222 CAMDEN COURT • OAK BROOK, IL 60523 • 630.574.8484

PARTNO.ITEMNO.

PARTSLIST

GASKET

SCREW-#10X .50PINNEDTORX

NIPPLEASSY

BRACKET-REGULATORMOUNTING

BRACKET-BASIN

BRACKET-BASINPIVOT

HEXNUT1-5/16

RETAINER

BUBBLERASSEMBLY

PUSHBUTTON

SLEEVE-PUSHBUTTONGUIDE

SNAPBUSHING

BUMPER-REG.VALVEASSY

PUSHBUTTON(EXTENSION)

PIVOTROD

FOUNTAINARM- SHORT

FOUNTAINARM-LONG

BOTTOMCOVERPLATE-SHORT

BOTTOMCOVERPLATE-LONG

BACKPANELASSY- EDFP217FPC

CAPSCREW

WASTE ARMASSY

POLYTUBING (CUTTOLENGTH)

BIT-PINNEDTORX

EDGETRIM

100322740560

75570C

15009C

28823C

27945C

27946C

40045C

40206000

98118C

45662C

45663C

50198C

51667C

55919C

70425C

28782C

28783C

55000661

55000665

27971C

75672C

72000833

56092C

75520C

56280C

DESCRIPTION

2, 17

SEE FIG. 13

SEE FIG. 14

11,19

576

FIG. 13

FIG. 12

FIG. 14

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Elkay Freiluftbrunnen Handbücher

Elkay

Elkay EDF214WC Installationshandbuch

Elkay

Elkay FLEXI-GUARD DRKR14RC Installationshandbuch

Elkay

Elkay EDFPVR217RC Installationshandbuch

Elkay

Elkay 4420BF1UFR Bedienungsanleitung

Elkay

Elkay 4400BFFR Bedienungsanleitung

Elkay

Elkay HTHBHAC8SSWF25WN Installationshandbuch

Elkay

Elkay EHWM214C*A Installationshandbuch

Elkay

Elkay 4400FR Series Bedienungsanleitung

Elkay

Elkay 4420 Series Bedienungsanleitung

Elkay

Elkay Soft Sides ECDFPW314FPC Installationshandbuch

Elkay

Elkay 4420BF1LDBFR Bedienungsanleitung

Elkay

Elkay EHFRA72K Installationshandbuch

Elkay

Elkay SWIRLFLO EZWS-EDFPBM114K Installationshandbuch

Elkay

Elkay SWIRLFLO ENOBM28RAK Installationshandbuch

Elkay

Elkay 4410BF Bedienungsanleitung

Elkay

Elkay OFA25 1D Series Installationshandbuch

Elkay

Elkay SWIRLFLO EDFPBWM114C Gebrauchsanweisung

Elkay

Elkay LZOOTL8WSS2KN Bedienungsanleitung

Elkay

Elkay 4430FR Bedienungsanleitung

Elkay

Elkay Soft Sides ERO8C Series Installationshandbuch

Elkay

Elkay SOFT SIDES EDFP217WS F Series Gebrauchsanweisung

Elkay

Elkay 4420FR FTN A Series Bedienungsanleitung

Elkay

Elkay 4400 Series Bedienungsanleitung

Elkay

Elkay SWIRLFLO Series Installationshandbuch

Beliebte Freiluftbrunnen Handbücher anderer Marken

Sunnydaze Decor

Sunnydaze Decor XSS-578 Bedienungsanleitung

Campania International

Campania International Bibendum FT-400 Bedienungsanleitung

S.R.Smith

S.R.Smith Color Light Stream 2CLSLBK Bedienungsanleitung

Hozelock Cyprio

Hozelock Cyprio Cascade 1500 Bedienungsanleitung

Campania International

Campania International Juliet Fountain Bedienungsanleitung

YARDART

YARDART FT-155 Bedienungsanleitung

Alpine

Alpine WIN732 Bedienungsanleitung

Campania

Campania Valencia Bedienungsanleitung

Campania International

Campania International FT-320 Bedienungsanleitung

GardenWize

GardenWize SWGSL230 Bedienungsanleitung

Kelkay

Kelkay Easy Fountain Rustic Windmill Bedienungsanleitung

Alpine

Alpine WIN258 Bedienungsanleitung

Bond

Bond Signature Series Bedienungsanleitung

Kenroy Home

Kenroy Home 51112COPBL Installationsanleitung

EasyPro

EasyPro Tranquil Décor HBB39 Bedienungsanleitung

Angelo Decor

Angelo Decor Castillo Bedienungsanleitung

Campania International

Campania International Girona FT-102A Bedienungsanleitung

Campania International

Campania International FT-271 Bedienungsanleitung