Elkay EFRP12CDC_2 Installationshandbuch

97722C (Rev. C - 10/02)PAGE 1

EFRP12C_2 EFRP12CDC_2

IMPORTANT

Installation/Care/Use Manual

Fully Recessed Refrigerated

Fountain with FLEXI-GUARD®

ALL SERVICE TO BE PERFORMED BY AN AUTHORIZED SERVICE PERSON

To assure you install this model easily and correctly, PLEASE READ THESE SIMPLE

INSTRUCTIONS BEFORE STARTING THE INSTALLATION. CHECK YOUR INSTALLATION

FOR COMPLIANCE WITH PLUMBING, ELECTRICAL AND OTHER APPLICABLE CODES.

After installation, leave these instructions inside the fountain for future reference.

IMPORTANT! INSTALLER PLEASE NOTE.

THE GROUNDING OF ELECTRICAL EQUIPMENT SUCH AS TELEPHONE, COMPUTERS, ETC. TOWATER

LINES IS A COMMON PROCEDURE. THIS GROUNDING MAY BE IN THE BUILDING OR MAY OCCUR AWAY

FROM THE BUILDING. THIS GROUNDING CAN CAUSE ELECTRICAL FEEDBACK INTOA FOUNTAIN,

CREATING AN ELECTROLYSIS WHICH CAUSES A METALLIC TASTE OR AN INCREASE IN THE METAL

CONTENT OF THE WATER. THIS CONDITION ISAVOIDABLE BY USING THE PROPER MATERIALS AS

INDICATED.ANY DRAIN FITTINGS PROVIDED BY THE INSTALLER SHOULD BE MADE OF PLASTIC TO

ELECTRICALLY ISOLATE THE FOUNTAIN FROM THE BUILDING PLUMBING SYSTEM.

SEE FIG. 5

SEE FIG. 6

SEE FIG. 7

SEE FIG. 8

20, 21

19, 22

23 24

EFRP12C EFRP12CDC

Installer

97722C (Rev. C - 10/02) PAGE 2

EFRP12C_2 EFRP12CDC_2

FIG. 1

FINISHED FLOOR

EFRP12C ROUGH-IN

LEGEND:

A = RECOMMENDED WATER SUPPLY LOCATION 3/8 O.D. UNPLATED COPPER TUBE CONNECT

STUB 1-1/2 (38mm) OUT FROM WALL, SHUT OFF BY OTHERS (BOTH SIDES).

B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/4 O.D. DRAIN (BOTH SIDES).

C = ELECTRICAL SUPPLY LOCATION (BOTH SIDES).

NOTES:

1. THERE ARE HOLES AND KNOCKOUTS PROVIDED ON EACH SIDE OF THE MOUNTING BOX THAT

ARE INTENDED TO BE USED TO MOUNT THE BOX. USE SIX SCREWS OR BOLTS (NOT PROVIDED).

97722C (Rev. C - 10/02)PAGE 3

EFRP12C_2 EFRP12CDC_2

FIG. 2

FINISHED FLOOR

EFRP12CDC ROUGH-IN

LEGEND:

A = RECOMMENDED WATER SUPPLY LOCATION 3/8 O.D. UNPLATED COPPER TUBE CONNECT

STUB 1-1/2 (38mm) OUT FROM WALL, SHUT OFF BY OTHERS (LEFT SIDE ONLY).

B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/4 O.D. DRAIN (LEFT SIDE ONLY).

C = ELECTRICAL SUPPLY LOCATION (BOTH SIDES).

*WATER AND DRAIN CONNECTIONS MUST BE MADE FROM LEFT SIDE ONLY.

NOTES:

1. THERE ARE HOLES AND KNOCKOUTS PROVIDED ON EACH SIDE OF THE MOUNTING BOX THAT

ARE INTENDED TO BE USED TO MOUNT THE BOX. USE SIX SCREWS OR BOLTS (NOT PROVIDED).

97722C (Rev. C - 10/02) PAGE 4

EFRP12C_2 EFRP12CDC_2

INSTALLATION INSTRUCTIONS

1. Remove shipping brace from mounting box and discard.

2. Fasten mounting box into wall cutout using screws or bolts (provided by others) through the holes or knock

outs provided on each side of the mounting box. (See Fig. 1 or 2)

3. Install fountain body to mounting box using #10 x .63 (16mm) PHSM screws and large clips provided.

4. Place refrigeration package into mounting box and connect water lines. (See Page 5 for details)

5. Water inlet is 3/8" O.D. and waste tube is 1-1/4" O.D. Contractor is to supply waste trap and service stop

valve in accordance with local codes.

6. Connecting lines to be unplated copper and thoroughly flushed to remove all foreign matter before connecting

to refrigeration package. The furnished strainer (Item 18) should be added to the supply line. Discard addi

tional strainer.

7. Connect the refrigeration package to the supply line service stop valve. Connect supplied fountain (internal

plumbing) tubes as shown in figures 3, or 4. Remove any burrs from water tubes before inserting into

fittings. (See Fig. 8) DO NOT SOLDER TUBES INSERTED INTO THE STRAINER AS DAMAGE

TO THE O-RINGS MAY RESULT.

8. Electrical: Insure power supply is identical in voltage, hertz, and phase to that specified on the refrigeration

package serial plate. Never wire compressor directly to the power supply.

9. Turn water supply on and check thoroughly for leaks.

10. Release air from tank by depressing push button; a steady stream of water assures all air is removed.

11. Re-check for leaks.

12. Stream height is factory set at 35 PSI. If supply pressure varies greatly from this, turn adjustment screw on

regulator (Item 14). Clockwise adjustment will raise the stream height and counter-clockwise adjustment

will lower stream height. For best adjustment, stream should hit basin approximately 6-1/2" from the bubbler.

13. Rotate fan blade on refrigeration package to insure proper clearance and free fan action.

14. Connect power supply.

15. Install grill using #8 x 1.00" (25mm) PH screws and small clips provided.

TROUBLE SHOOTING AND MAINTENANCE

1. Orifice Assy: Mineral deposits on orifice can cause water flow to spurt or not regulate. Mineral deposits

may be removed from orifice with a small round file not over 1/8 diameter or a small diameter wire.

CAUTION: Do not file or cut orifice materials.

2. Actuation of Quick Connect Water Fittings: Cooler is provided with lead-free connectors which utilize

an o-ring water seal. To remove tubing from the fitting, relieve water pressure, push in on the gray collar

while pulling on the tubing (See Fig. 9). To insert tubing, push tube straight into the fitting until it reaches

a positive stop, approximatley 3/4".

97722C (Rev. C - 10/02)PAGE 5

EFRP12C_2 EFRP12CDC_2

FIG. 3

FIG. 4

16 18

EFRP12C

EFRP12C W/GLASS FILLER

97722C (Rev. C - 10/02) PAGE 6

EFRP12C_2 EFRP12CDC_2

FIG. 5

FIG. 6

NOTE: WHEN INSTALLING REPLACEMENT BUBBLER

AND PEDESTAL, TIGHEN NUT (ITEM 15) ONLY TO

HOLD PARTS SNUG IN POSITION. DO NOT OVER

TIGHTEN.

BASIN

36 37

97722C (Rev. C - 10/02)PAGE 7

EFRP12C_2 EFRP12CDC_2

DISPENSER/

DISPOSAL

26 29

FIG. 7

FIG. 8

DISPENSER/

DISPOSAL

97722C (Rev. C - 10/02) PAGE 8

EFRP12C_2 EFRP12CDC_2

ELKAY MANUFACTURING COMPANY  2222 CAMDEN COURT  OAK BROOK, IL 60523 

PRINTED IN U.S.A.

PARTS LIST

ITEM NO. PARTNO. DESCRIPTION

15005C

40480C

40561C

40038C

21708C

40206000

40045C

40619C

50074C

50986C

56073C

40322C

56011C

55997C

61314C

75580C

70682C

70683C

55996C

110669443890

74070030

74070032

70567C

55001086

55000881

55001080

31525028

56092C

40299C

40562C

50258C

50967C

61099C

70151C

70234C

22911C

70002C

75555C

70018C

22912C

21705C

70378C

50198C

62088C

70278C

70920C

Retaining Nut

Precooler - EFRP122C

Precooler - EFRP122CDC

Strainer

Assy-Push Bar Buffed

Retainer

Hex Nut

Ferrule

Gasket

Regulator Holder

Bubbler Assy

Orifice Assy

Housing Assy

Pedestal

Regulator

Locknut - 3/8-18

Tee - 1/4

Union - 1/4

Strainer

Screw - #10 x .63 PHSM

Screw - #8 x 1.00 PH

Speed Nut - #8

Clip - Speed

Fountain

Dispenser/Disposal

Grill

O-ring

Poly Tubing (Cut to Length)

Drain - 1/2

Glass Filler

Washer

Flow Regulator Assy

Connector Assy

Washer

Hose Clamp

Lever-Push Bracket

Screw - #10 x .50 HHSM

Clip - .125 Stud Lock

Nut - 1/4-20 Hex

Bracket - Push Bar Mtg.

Clip - Push Rod

Rod - Push

Bushing - Snap .125 ID

Tube Assy - GF

Rod - Support

Rod - Pivot

FIG. 9 FIG. 10

NOTE: REMOVE ANY BURRS FROM WATER

TUBES BEFORE INSERTING INTO FITTINGS.

NOTE: WATER FLOW

DIRECTION

BUILDING WATER

INLET

SERVICE STOP

(NOT FURNISHED)

1/4" O.D. TUBE

WATER INLET

TO COOLER

3/8" O.D. UNPLATED

COPPER TUBE CONNECT

COLD WATER SUPPLY

www.DrinkingFountainDoctor.com 800-518-5388

Dieses Handbuch passt für folgende Modelle

Andere Elkay Freiluftbrunnen Handbücher

Elkay

Elkay EZS8WS 1F Series Gebrauchsanweisung

Elkay

Elkay SWIRLFLO Series Installationshandbuch

Elkay

Elkay Space-ette FD700-10 1J-MDN Series Installationshandbuch

Elkay

Elkay VRCTL 8 1D Series Installationshandbuch

Elkay

Elkay SOFT SIDES EDFPBM117WS Installationshandbuch

Elkay

Elkay 4400 Series Bedienungsanleitung

Elkay

Elkay 4590 Series Bedienungsanleitung

Elkay

Elkay 4460YHHB Series Bedienungsanleitung

Elkay

Elkay SWIRLFLO Series Installationshandbuch

Elkay

Elkay OFA25 2FJO Series Installationshandbuch

Elkay

Elkay FLEXI-GUARD EIOA4 1E Series Installationshandbuch

Elkay

Elkay 4420BF1LDB Series Bedienungsanleitung

Elkay

Elkay Fountains with Flexi-Guard EDF210C Gebrauchsanweisung

Elkay

Elkay Soft Sides ERO8C-C Installationshandbuch

Elkay

Elkay EHFRA72K Installationshandbuch

Elkay

Elkay 4400BFEVGWR Installationshandbuch

Elkay

Elkay LMABFD Installationshandbuch

Elkay

Elkay HEW1 1K Series Bedienungsanleitung

Elkay

Elkay Soft Sides Series Installationshandbuch

Elkay

Elkay 4420FR FTN A Series Bedienungsanleitung

Elkay

Elkay 4590 Series Bedienungsanleitung

Elkay

Elkay WGA5 1C Series Installationshandbuch

Elkay

Elkay OFA25 1D Series Installationshandbuch

Elkay

Elkay EDF214WC Installationshandbuch

Beliebte Freiluftbrunnen Handbücher anderer Marken

Sunnydaze Decor

Sunnydaze Decor XSS-578 Bedienungsanleitung

Campania International

Campania International Bibendum FT-400 Bedienungsanleitung

S.R.Smith

S.R.Smith Color Light Stream 2CLSLBK Bedienungsanleitung

Hozelock Cyprio

Hozelock Cyprio Cascade 1500 Bedienungsanleitung

Campania International

Campania International Juliet Fountain Bedienungsanleitung

YARDART

YARDART FT-155 Bedienungsanleitung

Alpine

Alpine WIN732 Bedienungsanleitung

Campania

Campania Valencia Bedienungsanleitung

Campania International

Campania International FT-320 Bedienungsanleitung

GardenWize

GardenWize SWGSL230 Bedienungsanleitung

Kelkay

Kelkay Easy Fountain Rustic Windmill Bedienungsanleitung

Alpine

Alpine WIN258 Bedienungsanleitung

Bond

Bond Signature Series Bedienungsanleitung

Kenroy Home

Kenroy Home 51112COPBL Installationsanleitung

EasyPro

EasyPro Tranquil Décor HBB39 Bedienungsanleitung

Angelo Decor

Angelo Decor Castillo Bedienungsanleitung

Campania International

Campania International Girona FT-102A Bedienungsanleitung

Campania International

Campania International FT-271 Bedienungsanleitung