Elkay SWIRLFLO Series Installationshandbuch

Page 1

EDFPB117C,EDFPBM117C,EDFPB117RAC,EDFPBM117RAC,EDFPBV117C,

EDFPBMV117C,EDFPBV117RAC,EBFPBMV117RAC

97922C (Rev. G - 6/08)

SWIRLFLO fountains with FLEXI-GUARD

INSTALLATION, CARE & USE MANUAL

TM TM

CAUTION

Reviewtheseinstructionsbeforebeginninginstallation.Be sure that installation

conformstoallplumbing,electricaland other applicable codes.

!WARNING

When installation is complete, ensure these instructions are left in the plastic bag

providedinside theinstalled unit forfuture reference.

!WARNING

Serviceto beperformedby authorizedservice personnel only.

INSTALLER

NOTE: It is commonpracticetogroundelectrical hardware such as telephones, computers and other devices

toavailable water lines.This can, however, cause electrical feedbackinthe plumbing circuit, which

results in an “electrolysis” effect occurring in the fountain. This may result in water which has a metallic

taste to it or has a noticeable increase in the metallic content of the water.

Wheninspecting plumbing circuit, remember the line may be grounded some distance from the

installation, and may occur outside the building or area in which the unit is being installed.

This condition can be avoided (in most cases) by using recommended materials during installation.Any

drainfittings provided by the installer should bemade of plastic which will electronically isolate the

fountainfrom the remainder ofthe building’s plumbing circuits.

EDFPBM(V)117C EDFPBM(V)117RAC

distributed by RESTROOM DIRECT 704 . 937.2673 www.RestroomDirect.com

EDFPB117C,EDFPBM117C,EDFPB117RAC,EDFPBM117RAC,EDFPBV117C,

EDFPBMV117C,EDFPBV117RAC, EBFPBMV117RAC

Page 2

97922C (Rev. G - 6/08)

LEGEND

A = Water Inlet Location Left Or Right Side. 3/8” O.D. Unplated Copper Tube Connect.

B = Fountain Waste Location Left Or Right Side. Waste Is Shown in Wall But May Be Behind

Wall. 1-1/4” O.D. Drain (Trap Not Furnished)

C = Opening For Optional AP-99 Access Panel

Note: Reinforce The Wall In The Shaded Areas.

Figure 2 - Rough-in Assembly EDFPBM(V)117C

Figure 1 - Rough-in EDFPBM(V)117C

Optional

distributed by RESTROOM DIRECT 704 . 937.2673 www.RestroomDirect.com

Page 3

EDFPB117C,EDFPBM117C,EDFPB117RAC,EDFPBM117RAC,EDFPBV117C,

EDFPBMV117C,EDFPBV117RAC, EBFPBMV117RAC

97922C (Rev. G - 6/08)

LEGEND

A = Water Inlet Location Left Or Right Side. 3/8” O.D. Unplated Copper Tube Connect.

B = Fountain Waste Location Left Or Right Side. Waste Is Shown in Wall But May Be Behind

Wall. 1-1/4” O.D. Drain (Trap Not Furnished)

C = Opening For Optional AP-99 Access Panel

Note: Reinforce The Wall In The Shaded Areas.

Figure 3 -Rough-in EDFPBM(V)117RAC

Figure 4 -Rough-in Assembly EDFPBM(V)117RAC

Optional

distributed by RESTROOM DIRECT 704 . 937.2673 www.RestroomDirect.com

EDFPB117C,EDFPBM117C,EDFPB117RAC,EDFPBM117RAC,EDFPBV117C,

EDFPBMV117C,EDFPBV117RAC, EBFPBMV117RAC

Page 4

97922C (Rev. G - 6/08)

43 1/2"

1105mm

36 1/2"

927mm

37"

940mm

28 3/4"

730mm

29 1/4"

743mm

6 5/8"

168mm 18 3/4"

476mm

1 1/4"

32mm 1 1/4"

32mm

3 1/4"

82mm

16"

406mm

32"

813mm

HANGER BRACKET

BACK PANEL MPW200

MTG. PLT.

FINISHED FLOOR

27"

686mm

ADA

REQUIREMENT

5/8"

16mm

18 3/8"

467mm

21 15/16"

557mm

2 7/8"

73mm 14"

356mm

4 3/4"

121mm 14"

356mm

38 1/2"

978mm

33 15/16"

862mm

41 11/16"

1059mm

1 5/8"

41mm

1 5/8"

41mm

FINISHED FLOOR

FINISHED WALL

Figure 5 -Rough-in EDFPB(V)117C

Figure 6 -Rough-in Assembly EDFPB(V)117C

LEGEND

A = Water Inlet Location Left Or Right Side. 3/8” O.D. Unplated Copper Tube Connect.

B = Fountain Waste Location Left Or Right Side. Waste Is Shown in Wall But May Be Behind

Wall. 1-1/4” O.D. Drain (Trap Not Furnished)

C = 3/8” (10mm) DIA. Slots For Mounting Hanger Bracket To Wall

MPW200MTG.PLT.

REF. SEPARATE

INSTALLATION

INSTRUCTIONS

FOR DETAILS

distributed by RESTROOM DIRECT 704 . 937.2673 www.RestroomDirect.com

Page 5

EDFPB117C,EDFPBM117C,EDFPB117RAC,EDFPBM117RAC,EDFPBV117C,

EDFPBMV117C,EDFPBV117RAC, EBFPBMV117RAC

97922C (Rev. G - 6/08)

5/8"

16mm

18 3/8"

467mm

27"

686mm

ADA

REQUIREMENT

33 15/16"

862mm

1 5/8"

41mm

41 11/16"

1059mm

1 5/8"

41mm

FINISHED FLOOR

FINISHED WALL

21 15/16"

557mm

2 7/8"

73mm 14"

356mm

4 3/4"

121mm 14"

356mm

38 1/2"

978mm

Figure 7 -Rough-in EDFPB(V)117RAC

Figure 8 -Rough-in Assembly EDFPB(V)117RAC

36 1/2"

927mm

37"

940mm

28 3/4"

730mm

29 1/4"

743mm

3 1/4"

82mm

16"

406mm

32"

813mm

1 1/4"

32mm 1 1/4"

32mm

6 5/8"

168mm 18 3/4"

476mm

HANGER BRACKET

BACK PANEL

MPW200

MTG. PLT.

FINISHED FLOOR

43 1/2"

1105mm

LEGEND

A = Water Inlet Location Left Or Right Side. 3/8” O.D. Unplated Copper Tube Connect.

B = Fountain Waste Location Left Or Right Side. Waste Is Shown in Wall But May Be Behind

Wall. 1-1/4” O.D. Drain (Trap Not Furnished)

C = 3/8” (10mm) DIA. Slots For Mounting Hanger Bracket To Wall

MPW200MTG.PLT.

REF. SEPARATE

INSTALLATION

INSTRUCTIONS

FOR DETAILS

distributed by RESTROOM DIRECT 704 . 937.2673 www.RestroomDirect.com

EDFPB117C,EDFPBM117C,EDFPB117RAC,EDFPBM117RAC,EDFPBV117C,

EDFPBMV117C,EDFPBV117RAC, EBFPBMV117RAC

Page 6

97922C (Rev. G - 6/08)

Figure 9 -Panel Installation

Figure 10 - Fountain Installation

Figure 11 - AP-99 Panel (Optional)

Installation Instructions:

1. Fountains using the MPW Mounting Plate refer to Figures

5 or 7 for hanger bracket location and rough-in dimensions.

NOTE: Review separate installation instructions for details of the

MPW Mounting Plate.

Fountains using the Wall Plate Assy. refer to Fig’s. 1 or 3

for rough-in dimensions.

2. Shown dimensions pertain to installation location (framing must

support up to 300 lbs. weight). These dimensions are required for

compliance with ANSI Standard A117.0.

3. Install rough-in plumbing as shown in Fig’s. 1, 3, 5, or 7. Run

supply water inlet line through the back panel. Install a service

stop (not provided). Turn on supply water and flush thoroughly.

4. Installing back panel.

Ftn. w/MPW Mounting Plate: Refer to Fig. 16 for placement

of braces onto back panel. Place the upper edge of the panel

above the hanger bracket. Slide the panel down until it engages

the hanger bracket. Be sure back panel is firmly engaged before

releasing it.

Ftn. w/Wall Plate Assy.: Place the upper edge of the panel

above mounting plate on the wall. Slide the panel down until it

engages the mounting plate. Be sure back panel is firmly engaged

before releasing it. (See Figure 9)

5. Install fountain. Remove screw (Item 28) from cover

plate and slide cover plate (Item 14) toward basin. (See Figure 10)

Ftn. w/MPW Mounting Plate: Mount the fountain to the back

panel and wall using (4) 5/16” x 6” long threaded rods, washers,

and nuts (provided). Tighten securely.

Ftn. w/Wall Plate Assy.: Mount the fountain to the back panel

and wall plate assy. with (4) 5/16” x 1” (25mm) long screws

(Item 30 - provided). Tighten securely.

6. Determine required length of waste line and cut to

appropriate length. 1-1/4” O.D. waste tube furnished.

1-1/4” slip trap, waste elbow and extension not provided.

7. Make water supply connections from service stop to the

3/8” O.D. unplated copper tube coming out of the strainer. Turn on

water supply and check for leaks (See Figure 17). Newly installed

water supply line should be insulated after leak check is

completed.

CAUTION: DO NOT SOLDER tubes inserted

into the strainer as damage to the

o-rings may result.

8. These products are designed to operate on 20-105 PSIG supply

line pressure. If the inlet pressure is above 105 PSIG, a pressure

regulator must be installed in the supply line. Any damage caused

by reason of connecting these products to supply line pressures

lower than 20 PSIG or higher than 105 PSIG is not covered by

warranty.

9. Check stream height from bubbler. Stream height is factory set at

35 PSI. If supply pressure varies greatly from this, remove push

button (Item 17 - Figure 14) and adjust the screw on the regulator

(Item 19 - Figure 14). To remove push button, remove setscrew

from bottom of sleeve (Item 15). Insert a small punch in screw

hole and push up while grasping the push button and pull forward

removing the push button. Clockwise adjustment will raise stream

height and counterclockwise movement will lower stream height.

For best adjustment stream should hit basin approximately 6-1/2”

from the bubbler. Reassemble the push button by pushing in on

button until the push button catches in the sleeve. Reinstall the

setscrew (Item 31) in the sleeve (Item 15).

distributed by RESTROOM DIRECT 704 . 937.2673 www.RestroomDirect.com

Page 7

EDFPB117C,EDFPBM117C,EDFPB117RAC,EDFPBM117RAC,EDFPBV117C,

EDFPBMV117C,EDFPBV117RAC, EBFPBMV117RAC

97922C (Rev. G - 6/08)

BUBBLERDETAIL

VANDALRESISTANT

BUBBLERDETAIL

NOTE:

When installing replacement bubbler and pedestal, tighten

nut (Item 7) only to hold parts snug in position. Do Not

Overtighten.

Figure 12 - Bubbler Details

BASIN

2, 3, 4

BASIN

distributed by RESTROOM DIRECT 704 . 937.2673 www.RestroomDirect.com

EDFPB117C,EDFPBM117C,EDFPB117RAC,EDFPBM117RAC,EDFPBV117C,

EDFPBMV117C,EDFPBV117RAC, EBFPBMV117RAC

Page 8

97922C (Rev. G - 6/08)

Figure 13 - Fountain Body

Figure 14 - Push Button

17 18

See Fig. 12

distributed by RESTROOM DIRECT 704 . 937.2673 www.RestroomDirect.com

Page 9

EDFPB117C,EDFPBM117C,EDFPB117RAC,EDFPBM117RAC,EDFPBV117C,

EDFPBMV117C,EDFPBV117RAC, EBFPBMV117RAC

97922C (Rev. G - 6/08)

Figure17 – Water SupplyConnections

NOTE: WATER FLOW

DIRECTION SERVICE STOP

(NOT FURNISHED)

BUILDING WATER INLET

3/8" O.D. UNPLATED

COPPER TUBE CONNECT

COLD WATER SUPPLY

1/4" O.D. TUBE

WATER INLET

TO COOLER

TROUBLESHOOTING& MAINTENANCE

Orifice Assembly: Mineraldeposits on orifice

can cause water flow to spurt or not regulate. Mineral

depositsmay be removed from theorificeby poking

with a small round file not over 1/8” diameter, or using a

smalldiameter wire.

!CAUTION

DO NOT file or cut orifice

material.

Stream Regulator: If orifice is clean, regulate

flow as in Step 8 of the installation instructions. If

replacement is necessary, see parts list for correct

regulatorpartnumber.

Actuation of Quick Connect Water

Fittings: Cooleris provided with lead-freeconnec-

torswhich utilize an o-ring water seal.Toremove

tubingfromthefitting,relievewaterpressure, push in

on the gray collar while pulling on the tubing. (See

Figure 15) To insert tubing, push tube straight into

fittinguntil it reachesa positive stop (approximately3/4”).

Figure 15 – Quick Connect Fittings

PARTSLIST

ITEMNO. PARTNO. DESCRIPTION

56073C

40319C

50171C

50314C

56011C

55997C

75580C

98118C

100322740560

15009C

28474C

28473C

45767C

28343C

45781C

45847C

45848C

50986C

61313C

15005C

56163C

45769C

45768C

56092C

28392C

28393C

AP99

111008343890

70432C

38417001

75560C

75632C

70817C

55996C

75671C

28844C

28845C

27090C

Bubbler Assy

Fitting - Orifice

O-Ring

Orifice - Flow Straightener

Housing Assembly

Pedestal

Bubbler Locknut

Bubbler Assembly VR

Gasket - Black .68 x 1.03 VR

Nipple - Bubbler VR

Basin - Swirlflow

Lower Shell

Fountain Body

CoverPlate

Sleeve

Pin - Push Button

Push Button

Holder - Regulator

Regulator

RetainingNut

Gasket - Drain

Assy - Drain/Tailpipe

Drain - Plug 1-1/2”

Poly Tubing (Cut To Length)

Back Panel RHADA

Back Panel LHADA

AP-99 Panel (Optional)

Screw - #10-24 x .62 HHMS

Screw - #8-32 x .38 THSM

Screw - #8-18 x .37 HHSM

Screw - 5/16-18 x 1.00 HHMS

Setscrew - #10-32 x .31

Fttng - Elbow 1/4 x 1/4

Strainer

Spring - Push Button

Back Panel Assy RH ADA

Back Panel Assy LH ADA

Hanger Bracket

FOR PARTS, CONTACT YOUR LOCAL DISTRIBUTOR OR CALL 1.800.323.0620

ELKAY MANUFACTURING COMPANY · 2222 CAMDEN COURT · OAK BROOK, IL 60523 · 630.574.8484

PRINTED IN U.S.A.

Installing Back Panel: When installing back panel

assy. (Item 35) with MPW (Mounting Plate), attach

channel braces as shown above. Remove the

protective backing from the tape installed on the

braces. Line up the corresponding holes in the

braces and back panel and press firmly in place.

Figure 16 – Back Panel Assembly

distributed by RESTROOM DIRECT 704 . 937.2673 www.RestroomDirect.com

Andere Handbücher für SWIRLFLO Series

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Elkay Freiluftbrunnen Handbücher

Elkay

Elkay Swirlflo EDFPB114FP Bedienungsanleitung

Elkay

Elkay Soft Sides EDFP217FP B Series Bedienungsanleitung

Elkay

Elkay Swirlflo EDFPB117FP Installationshandbuch

Elkay

Elkay 4400DBFR Bedienungsanleitung

Elkay

Elkay Slimline EHWM14C A Series Bedienungsanleitung

Elkay

Elkay VRCTL8 2C Series Installationshandbuch

Elkay

Elkay EHW214FP Series Installationshandbuch

Elkay

Elkay SwirlFlo ERPA8C Installationshandbuch

Elkay

Elkay HTHBHVR8-NF-25N Installationshandbuch

Elkay

Elkay 4400BFEVGWR Installationshandbuch

Elkay

Elkay SWIRLFLO Series Gebrauchsanweisung

Elkay

Elkay 4405BFFR Bedienungsanleitung

Elkay

Elkay EDFPVR217RC Installationshandbuch

Elkay

Elkay LVRCTL8 1D Series Installationshandbuch

Elkay

Elkay Hydroboost HTHBHAC8BLSSWF25N Installationshandbuch

Elkay

Elkay FLEXI-GUARD EIOA4 1E Series Installationshandbuch

Elkay

Elkay SWIRLFLO FLEXI-GUARD ERPB8C 2C Series Installationshandbuch

Elkay

Elkay SOFT SIDES EDFP217WS F Series Gebrauchsanweisung

Elkay

Elkay Soft Sides FLEXI-GUARD ERO2-8C 2C Installationshandbuch

Elkay

Elkay EZH2O VRCGN8WS 1C Series Leitfaden

Elkay

Elkay Swirlflo Freeze Resistant Fountain... Gebrauchsanweisung

Elkay

Elkay EHWM214C*A Installationshandbuch

Elkay

Elkay LK4410FR FTN A Series Bedienungsanleitung

Elkay

Elkay Swirlflo EDFPB114FPC Installationshandbuch

Beliebte Freiluftbrunnen Handbücher anderer Marken

Sunnydaze Decor

Sunnydaze Decor XSS-578 Bedienungsanleitung

Campania International

Campania International Bibendum FT-400 Bedienungsanleitung

S.R.Smith

S.R.Smith Color Light Stream 2CLSLBK Bedienungsanleitung

Hozelock Cyprio

Hozelock Cyprio Cascade 1500 Bedienungsanleitung

Campania International

Campania International Juliet Fountain Bedienungsanleitung

YARDART

YARDART FT-155 Bedienungsanleitung

Alpine

Alpine WIN732 Bedienungsanleitung

Campania

Campania Valencia Bedienungsanleitung

Campania International

Campania International FT-320 Bedienungsanleitung

GardenWize

GardenWize SWGSL230 Bedienungsanleitung

Kelkay

Kelkay Easy Fountain Rustic Windmill Bedienungsanleitung

Alpine

Alpine WIN258 Bedienungsanleitung

Bond

Bond Signature Series Bedienungsanleitung

Kenroy Home

Kenroy Home 51112COPBL Installationsanleitung

EasyPro

EasyPro Tranquil Décor HBB39 Bedienungsanleitung

Angelo Decor

Angelo Decor Castillo Bedienungsanleitung

Campania International

Campania International Girona FT-102A Bedienungsanleitung

Campania International

Campania International FT-271 Bedienungsanleitung