Eton VIPER 50M Bedienungsanleitung

E-TON

VIPER

OWNER’S MANUAL

Viper 50M, Viper 70, Viper 90

and Viper 90R

Page 1

Important Notices

READ and UNDERSTAND this owner’s manual

Both the operator and the adult supervisor should completely read and understand this

owner’s manual before operating this vehicle. This owner’s manual will instruct you in the safe

operation of the vehicle.

NO Passengers

This vehicle was designed for operation ONLY by the operator, (Driver). The load limit

and seat configuration is designed for the operator ONLY. It is not safe to carry passengers on

the vehicle.

ADULT Supervision and Instruction are REQUIRED.

This vehicle MUST NOT be operated by a youth without Adult supervision and

instructions. Unattended operation without adult supervision could result in injuries. E-TON

recommends that both the operator and the adult supervisor attend an ATV safety instruction

course.

ALWAYS Wear Protective Clothing

While operating this vehicle, the driver must always wear protective clothing. Protective

helmet with face shield, elbow and knee pads, long leg pants, gloves and hard soled boots

should always be worn when operating this vehicle.

OFF ROAD Use ONLY

This vehicle is designed and manufactured for off-road use only. Operation on public

streets, roads or highways is illegal and very dangerous.

OBEY all State and local laws and regulations

Each state and local governing agency has laws and regulations for ATV operations. It

is the owner’s responsibility to know, understand and obey these laws and regulations.

SPEED RESTRICTION Devices

This vehicle is equipped with electronic speed limiting devices. Any attempt to change,

over-ride or bypass these devices may cause dangerous operating conditions.

Age Recommendations by model size

ATV Model Size ETON Models Minimum Age Weight Capacity

Under 70cc RXL-40Ee

RXL-50M

RXL-70 6 years and older 70 Lbs

70 - 90cc RXL-90

RXL-90R 12 years and older 250 Lbs

over 90cc CXL-150 16 years and older 250 Lbs

150 cc CXL-150 16 years and older 300 Lbs

Page 2

Table of Contents

Safety notes 4

Vehicle identification number location 8

Controls, switches and feature locations 8

Control feature operations

Engine stop switch 9

Manual Choke Lever 9

Throttle lever 9

Front & Rear Brakes 10

Parking brake 10

Safety Tether Switch 10

Remote Stop / Start Switch 10

Fuel System

Fuel tank 11

Fuel valve 11

Inline Fuel Filter 12

Engine Oil

Oil Tank 12

Oil Indicator light 12

Tires & Wheels

Tire inspection 13

Tire pressure 13

Spark Plug 13

Spark Arrester Screen 13

Air Filter 14

Braking Systems

Front Brake Inspection 14

Front Brake Adjustment 15

Rear Brake Inspection 15

Filling the Brake Fluid Reservoir 16

Purging Brake Line 16

Drive Chain 17

Throttle Lever 17

Electrical Battery 18

C.V.T. Air Filter (Transmission) 18

Transmission Gear Selector Control 19

ATV Break-In Procedure 19

Changing Transmission Oil 18

Pre-Operation Inspection 20

Starting procedure 20

Driving 21

Turning 21

Parking 21

Page 3

Specifications

Viper 50M 22

Viper 70 24

Viper 90 & 90R 26

Maintenance Schedule 28

Maintenance Record Chart 28

Wiring Diagram Viper 50M 29

Wiring Diagram Viper 70 30

Wiring Diagram Viper 90 31

Wiring Diagram Viper 90R 32

Manufacture’s Warranty 33

Owner’s Notes 35

Page 4

Safety Notes

1. Both the adult supervisor and youth operator must fully understand everything in this manual

before operating this vehicle.

2. This vehicle was designed for the operator only. NO PASSENGERS should be allowed on

this vehicle.

3. This vehicle is designed for operation on level, obstacle free off-road areas.

4. Riding this vehicle on public roads or highways is illegal. If it becomes necessary to cross a

public road or highway, the vehicle should be pushed across using extreme caution.

5. This vehicle MUST NOT be operated without adult supervision and instruction.

6. DO NOT operate this vehicle while under the influence of drugs, alcohol or other medication

that impairs judgment or coordination. Doing so can result in serious injury or even death.

7. Maintain a safe distance between your vehicle

and other vehicles with whom you are riding.

8. READ the owner’s manual carefully before

riding.

9. ALWAYS wear a helmet, face shield, elbow &

knee pads, hard-soled boots, gloves, and protective

clothing while operating this vehicle.

Page 5

10. NEVER ride this vehicle unless it has

been properly maintained and adjusted.

Always perform a pre-ride inspection of your

vehicle. Look for wires, bolts and other

fasteners that may have come loose on

previous rides. Inspect the drive chain,

throttle and brakes for proper adjustment and

operation. Check the engine oil level in the oil

tank. Check fuel level and inspect for fuel

leaks. (Remember, you can ride further in 1

hour than you can walk back in 1 day!)

11. WARM UP your body with some exercises

before riding. This helps to make you alert and

prevent cramping and other discomfort.

12. LEARN TO RIDE this vehicle properly and

safely. Have an experienced rider teach you the

safe operation of your vehicle. E-TON

recommends you take an ATV riding course

before you first ride your vehicle.

Page 6

13. NEVER REFUEL this vehicle when hot. Ask

your adult supervisor to refuel your vehicle.

Gasoline is extremely flammable and will ignite if

spilled on a hot engine or muffler. Never smoke

or expose the fuel to an open flame or spark

while refueling your vehicle. Always refuel your

vehicle in a safe place free of any ignition source.

14. NEVER run the vehicle in an enclosed area. The

exhaust gases from the engine contain CARBON

MONOXIDE which can be fatal if breathed in high

concentrations for an extended time.

15. HOT! The engine and exhaust system on

your vehicle become very hot during normal

operation. Touching these hot surfaces can

cause severe burns. Always assume that your

unit’s engine and exhaust system are HOT

unless you know that they are not.

Page 7

Additional safety tips:

•Participate in an approved ATV safety education training program

•Always provide responsible adult supervision for ATV operators younger than 18 years of age

•Don't let youngsters ride full-sized ATV's

•Follow all safety recommendations of the ATV manufacturer

•Operate ATVs only during daylight

•Wear a helmet with face protection at all times

•Operate only four-wheeled ATVs

•Provide a drug and alcohol free environment

•Always use the buddy system

•Avoid riding in areas where contact with automobiles might be possible

•Drive ATVs on surfaces as recommended by the manufacturer

•Travel at speeds conducive to conditions and operator abilities

•Check on the conditions of the trails you will be traveling

•Know and understand local and state laws governing the use of ATVs

•Permit only one operator per ATV

•Insist on a "perfect fit" between the ATV and the physical, mental, and emotional maturity of the operator

•Use antenna flags and wear bright clothing to increase conspicuity.

•Use maps and compass if you are riding in an unfamiliar area.

•Make a mental note of landmarks; you may need them if you are stranded.

•If you are lost at night, do not move around. You will waste valuable fuel that you can use to ride safety in

the daylight.

•Carry a first-aid pack with you.

•Carry some snacks and a water supply with you.

•Carry equipment to handle medical and mechanical emergencies.

•Your vehicle field repair kit should include the following items;

othe manufacturer's tool kit

owire, tape, elastic cords,

opossibly locking pliers

oand a tow rope.

•Pre-Ride Inspection - Inspecting the condition of your ATV before each ride is very important to minimize

the chance of injury and maximize the enjoyment of your ride. It also helps ensures long term

performance of your ATV. Follow the owner’s manual guide to inspection and maintenance of your ATV.

A well maintained ATV will give you years of enjoyment.

•Watch out for thin ice which may be camouflaged by snow.

•Remember, you can ride further in one hour than you can walk in an entire day.

Age Recommendations by model size

ATV Model Size ETON Models Minimum Age Weight Capacity

Under 70cc RXL-40E

RXL-50M

RXL-70 6 years and older 70 Lbs

70 - 90cc RXL-90

RXL-90R 12 years and older 250 Lbs

over 90cc CXL-150 16 years and older 250 Lbs

150 cc CXL-150 16 years and older 300 Lbs

Page 8

Vehicle Identification Numbers

Your VIN RFZ______________ Eng. No._______________

Controls, Switches & Feature Locations

Locations of controls and features

1. Fuel Tank filler and vent tube

2. Front brake lever (Parking Brake Lock)

3. Throttle lever

4. Rear brake lever

5. Engine stop switch

6. Head lamp switch

7. Horn button

8. Engine starter button

9. Manual Choke Lever

Vehicle Identification Number (VIN)

is located at the front of the unit under

the front fender on a plate mounted

between the main frame rails.

Engine serial number

is located on the left-hand side of the

engine on the crankcase housing.

Page 9

Engine Stop Switch

The stop

switch is a red colored rocker switch located

on the left-hand handle bar.

To start and run the engine, this switch must

be placed in the on, “O”, position.

The vehicle is also equipped with a safety

brake switch which will prevent the engine

from starting until the parking brake is

engaged.

To stop your engine, place the switch to the

stop, “X”, position.

In the stop, “X”, position the ignition system is

grounded preventing the spark plug from

firing.

This switch can also be used as a safety or

emergency stop switch.

Manual choke lever (9)

All Viper models are equipped with a

manually operated carburetor choke system.

This choke is operated by the lever at the

bottom of the left hand control switch.

When first starting the engine,(cold start),

place the lever in the full left position, (Choke

closed or on) As the engine warms return the

lever to the full right position. (Choke open or

off).

Throttle lever

The throttle lever is located on the right-hand

handle bar below the grip. To operate the throttle

lever, place your right thumb on the lever and

press forward to increase your speed. To

decrease your speed, reduce your pressure on

the lever and the spring tension will

automatically reduce your speed.

The travel of the throttle lever is controlled by the

throttle stop bolt.

As your operator gains more experience, you

can increase the throttle travel to allow for

additional speed to be obtained.

To increase the throttle’s travel, thus increasing

the maximum speed, turn the throttle stop bolt

counter clockwise. To decrease the throttle’s

travel, thus decreasing the maximum speed, turn

the throttle stop bolt clockwise.

The throttle cable should be adjusted so there is

2mm, (1/8”) free travel at the lever before the

throttle starts to open.

Control Features

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Eton Geländefahrzeug Handbücher

Eton

Eton 2006 Viper 70 Bedienungsanleitung

Eton

Eton DXL90 Bedienungsanleitung

Eton

Eton Viper 40E (RXL-40E) Bedienungsanleitung

Eton

Eton CXL-150 Bedienungsanleitung

Eton

Eton CXL-150 - SERVICE Bedienungsanleitung

Eton

Eton Vector 250R Bedienungsanleitung

Eton

Eton ATV8F - SERVICE Bedienungsanleitung

Eton

Eton VIPER 50 ST - SERVICE Bedienungsanleitung

Eton

Eton Yukon II Bedienungsanleitung

Eton

Eton IXL 40 Bedienungsanleitung

Eton

Eton Viper 70 Bedienungsanleitung

Eton

Eton Viper 90R Bedienungsanleitung

Eton

Eton ATV8E - SERVICE Bedienungsanleitung

Eton

Eton Viper Jr. (RXL-40) Bedienungsanleitung

Eton

Eton DXL90 Bedienungsanleitung

Eton

Eton ROVER Bedienungsanleitung

Eton

Eton Viper 150 Bedienungsanleitung

Eton

Eton ATV RXL 50 Bedienungsanleitung

Eton

Eton EXL-50 - SERVICE Bedienungsanleitung

Eton

Eton Vector 250R Bedienungsanleitung

Eton

Eton VECTOR ST 250 Bedienungsanleitung

Eton

Eton ATV3F-150 - SERVICE Bedienungsanleitung

Eton

Eton Lightning-AXL50 Bedienungsanleitung

Eton

Eton ATV6A 90 Bedienungsanleitung

Beliebte Geländefahrzeug Handbücher anderer Marken

Polaris

Polaris RANGER XP 1000 EPS 2018 Bedienungsanleitung

Yamaha

Yamaha Tri Moto 125 Bedienungsanleitung

Yamaha

Yamaha YFM350X Warrior Bedienungsanleitung

APRILIA

APRILIA QUASAR 100 Bedienungsanleitung

Polaris

Polaris RZR 900 Bedienungsanleitung

Suzuki

Suzuki LT-A700X Bedienungsanleitung

Ski-Doo

Ski-Doo SCANDIC WT Handbuch

Suzuki

Suzuki LT-Z400 Bedienungsanleitung

Arctic Cat

Arctic Cat 120 sno pro Bedienungsanleitung

Yamaha

Yamaha RS90PB Bedienungsanleitung

Yamaha

Yamaha FX Nytro FX10X Bedienungsanleitung

Dinli

Dinli DL702 Bedienungsanleitung

Yamaha

Yamaha SXV70ML Bedienungsanleitung

Baja motorsports

Baja motorsports ATV 90 Handbuch

Polaris

Polaris Sportsman 550 XP EPS Bedienungsanleitung

Arctic Cat

Arctic Cat ALTERRA 450 Bedienungsanleitung

Polaris

Polaris Sportsman 9922233 Bedienungsanleitung

Yamaha

Yamaha YFM45FAT Handbuch