Extech Instruments IR255 Bedienungsanleitung



USERGUIDE



MiniInfraRedThermometer

WithLaserPointerandHigh‐LowAlarms



ModelIR255



EXTECHINSTRUMENTS

2IR255‐en‐EU_V1.49/14

Introduction

CongratulationsonyourpurchaseoftheIR255IRThermometer.Thisthermometermakesnon‐

contact(infrared)temperaturemeasurementsatthetouchofabutton.Thebuilt‐inlaserpointer

increasestargetaccuracywhilethebacklitLCDandhandypush‐buttonscombineforconvenient,

ergonomicoperation.Thisdeviceisshippedfullytestedandcalibratedand,withproperuse,will

provideyearsofreliableservice.Pleasevisitourwebsite(www.extech.com)tocheckforthe

latestversionofthisUserGuide,ProductUpdates,andCustomerSupport.

Features

Measuresnon‐contactsurfacetemperatureupto400°C(752°F)

12:1DistancetoSpotRatio(FieldofView)

Single‐pointlasertargeting

AutomaticDataHoldwhentriggerisreleased

DisplayBacklight

Maximum‐Minimumtemperaturefunction

Selectabletemperatureunits(°C/°F)

Dynamicbatterystatusindication

Adjustableemissivity

AudibleandvisiblealarmindicationforHighandLowTemperatureAlarm

Safety

InternationalSafetySymbols

Thissymbol,adjacenttoanothersymbolorterminal,indicatestheusermustrefertothemanualfor

furtherinformation

Warnings

oDonotdirectlyorindirectlypointthelaserattheeyesofapersonorananimal

oInspectfordamageorforanyshortageofpartsoraccessoriesbeforeuse

oReplacethebatteryimmediatelyafterthebatteryindicatorflashes

oDonotusethethermometernearexplosivegases,steam,ordust

oNotethatanobjectwithhighreflectivitywillnormallycausethemeasuredtemperaturevaluetoread

muchlowerthantheactualtemperature

oUsethedeviceonlyasdescribedinthisUserGuide

Cautions

Toavoidthermometerdamage,pleaseavoidthefollowinghazards:

oEMFfromweldingequipmentorelectro‐inductionheaters

oStaticelectricity

oThermalshockcausedbylargeorabruptenvironmentaltemperaturechanges;wait30minutesto

allowthethermometertostabilizetonewenvironmentalconditions

oDonotusethisdeviceinexcessivelyhightemperatureenvironments



EXTECHINSTRUMENTS

3IR255‐en‐EU_V1.49/14

Description



MeterDescription

1. LCDDisplay

2. SETButton

3. MAX‐MIN/DownArrowButton

4. Laserpointerlens

5. IRThermometerlens

6. Backlight‐LaserPointer/UpArrowButton

7. MeasurementScanTrigger

8. BatteryCompartment

DisplayDescription

Emissivityvalueindication

Laserpointeractiveicon



Scanmode(activewhilethetriggerispulled;displayed

temperaturetracksthetemperatureofthescannedsurfaces)

Holdmode(displayedtemperaturefreezeswithtriggerrelease)

Maximum/Minimumtemperatureicons

Batterycapacityindicator(flasheswhenbatteryvoltageiscritical)

DisplayBacklighticon

Temperatureunits(°F/°C)

TemperatureAlarmiconsandaudiblealarmdisableicon

EXTECHINSTRUMENTS

4IR255‐en‐EU_V1.49/14

Operation

MeterPower

Themeterispoweredbyone9Vbattery.Withafreshbatteryinstalled,themeterswitchesON

whenthetriggerispulled.Thebatteryislocatedinthemeterhandle;pullthebattery

compartmentlidawayfromthebodyofthemetertoopen.RefertotheMaintenancesection

formoreBatteryInstallationinstructions.Thebatteryiconprovidesbatterystatusindication.

Replacethe9Vbatteryassoonasthebatterystatusiconflashes.

SurfaceTemperatureMeasurements

1. HoldthemeterbyitsHandleGripandpointittowardthesurfacetobemeasured.Readthe

FieldofViewsectionbelowfordistancetotarget(spot)ratioinformation.

2. PullandholdtheTriggertoturnthemeteronandbegintestinginScanmode.Thedisplay

willlightifthe9Vbatteryisgood.Replacethebatteryifthedisplaydoesnotlight.

3. WhilecontinuingtopulltheTrigger:

a. PushthebuttontoswitchthelaserpointerON.WhenthelaserisON,thelaser

icon willappearontheLCD.Aimtheredlaserbeamapproximatelyahalfinchbelow

thepointoftest(pressingtheLaserbuttonagainturnsthelaseroff).

b. Selectthetemperatureunits(oC/oF)intheSettingsMode(seelatersection).

c. PushthebuttontoswitchONtheLCDbacklightingfunction.

4. ReleasetheTrigger;thereadingwillholdforapproximately9seconds,afterwhichthemeter

willautomaticallyshutoff.

5. Themeterdefaultstotheprogrammedconditionsinusewhenthemeterwaslastswitched

OFF.Forexample,ifthelaserissettoONandthetemperatureunitsaresettooFatthetime

theunitisswitchedOFF,theunitwillswitchONandusethesamesettings.

Over‐rangeIndicators(OLand‐OL)

Ifthetemperaturemeasurementexceeds400°C(752°F),thethermometerwilldisplayOLin

placeofatemperaturereading.Ifthetemperaturemeasurementisbelow‐20°C(‐4°F),the

thermometerwilldisplay‐OLinplaceofatemperaturereading.

MAX‐MINMode

PresstheMAX‐MINbuttontoviewthemaximumtemperaturereading(MAX),pressagainto

viewthelowestreading(MIN).PressagaintoswitchtheMAX‐MINmodeoff.

DisplayBacklight

Pressthebacklightbutton toswitchthebacklightON.Thebacklightwillswitch

OFFautomaticallyafterseveralsecondstoconservebatterypower.



EXTECHINSTRUMENTS

5IR255‐en‐EU_V1.49/14

SettingMode

PresstheSETbuttontoaccesstheSettingMode.Usetheupanddownbuttonstonavigatethe

SettingModemenuandtomakechanges.Theavailableparametersarelistedbelow:

Emissivitysetting

°C/°Ftemperatureunitsselection

TemperatureAlarmAudibleBeeperEnable/Disable

HighTemperatureAlarmLimitsetting

LowTemperatureAlarmLimitsetting

Thecorrespondingparametericonwillflashwhenselected.ToexittheSettingMode,press

andholdtheSETbuttonfortwoseconds.

EmissivitySetting

Theiconwillflashwhenselected.Usetheupanddownbuttonstoincreaseordecreasethe

emissivity(in0.01steps).Theemissivityrangeis0.10to1.00.Holddowntheupordown

buttontorapidlyincreaseordecreasetheemissivityvalue.PresstheSETbuttontoconfirm

andtosteptothenextoption.

SelectingtheTemperatureUnitofMeasure(°C/°F)

Usetheupanddownbuttonstoselect°Cor°F.PresstheSETbuttontoconfirmandtostepto

thenextoption.

Enable/DisableAudibleTemperatureAlarm

Thisparameterisusedtoenable/disabletheaudibletemperaturealarm.The iconwillflash

inthismode.

Usetheupanddownbuttonstotogglethesetting.Whentheaudiblealarmisdisabled,the

displaywillshow‘HIGHLOW’.Whentheaudiblealarmisenabled,thedisplaywillshow

.Whentheaudiblealarmisenabled,thebeeperisallowedtosoundwhenever

themeasuredtemperaturegoesbeyondthehighorlowtemperaturelimitvalues.Pressthe

SETbuttontoconfirmandtosteptothenextoption.

HIGHTemperatureAlarmLimitSetting

UsetheupanddownbuttonstoincreaseordecreasetheHighAlarmTemperatureLimit(in

0.1steps).HoldingdowntheupordownbuttonwillrapidlyincreaseordecreasetheHIGH

limitvalue.AbeepwillsoundiftheHIGHtemperaturevaluereachestheLOWtemperature

valuewhileprogramming.PresstheSETbuttontoconfirmandtosteptothenextoption.

LOWTemperatureAlarmLimitSetting

UsetheupandownbuttonstoincreaseordecreasetheLowAlarmTemperatureLimit(in0.1

steps).HoldingdowntheupordownbuttonwillrapidlyincreaseordecreasetheLOWlimit

value.AbeepwillsoundiftheLOWtemperaturevaluereachestheHIGHtemperaturevalue

whileprogramming.PresstheSETbuttontoconfirmandtosteptothenextoption.

EXTECHINSTRUMENTS

6IR255‐en‐EU_V1.49/14

LocatingHotorColdSpots

Todetectahotorcoldspot,aimthethermometerataregionbeyondthetargetandthenscan

theentireregioninaslow,up/downmotion.



DistancetoSpotRatio(FieldofView)

Themeter’sfieldofviewis12:1(distancetospotratio).Forexample,ifthemeteris600mm

fromthetarget(spot),thediameterofthetargetmustbeatleast50mm.Otherdistancesare

shownbelowinthefieldofviewdiagram.

Notethatmeasurementsshouldnormallybemadecloserthan1200mmfromthetarget.The

metercanmeasurefromfurtherdistancesbutthemeasurementmaybeaffectedbyexternal

sourcesoflight.Inaddition,thespotsizemaybesolargethatitencompassessurfaceareasnot

intendedtobemeasured.



Itisnecessarytoensurethatthesizeofthetargetislargerthanthespotsize.Thesmallerthe

target,thecloserthedistanceshouldbe.Seetheaccompanyingdiagram.



Emissivity

Emissivityrepresentstheenergyreflectivityofamaterial.Mostorganicmaterialsandpainted

oroxidizedsurfaceshaveanemissivityofapproximately0.95.Ifpossible,maskingtapeorflat

blackpaintshouldbeappliedtocoverthemeasuredsurface.

Waitaperiodoftimetoallowthetapeorpainttoreachthermalequilibriumwiththesurface

ofthecoveredobject.Measurethetemperatureofthesurfacecoveredwithtapeorpaintonly

afterequilibriumhasbeenachieved.

EXTECHINSTRUMENTS

7IR255‐en‐EU_V1.49/14

MeasurementNotes

1. Theobjectundertestshouldbelargerthanthespot(target)sizecalculatedbythefieldof

viewdiagram.

2. Ifthesurfaceoftheobjectundertestiscoveredwithfrost,oil,grime,etc.,cleanbefore

takingmeasurements.

3. Ifanobject'ssurfaceishighlyreflectiveapplymaskingtapeorflatblackpainttothesurface

beforemeasuring.

4. Themetermaynotmakeaccuratemeasurementsthroughtransparentsurfacessuchas

glass.

5. Steam,dust,smoke,etc.canobscuremeasurements.

6. Themetercompensatesfordeviationsinambienttemperature.Itcan,however,takeupto

30minutesforthemetertoadjusttoextremelywideambienttemperaturechanges.

7. Tofindahotspot,aimthemeteroutsidetheareaofinterestthenscanacross(inanupand

downmotion)untilthehotspotislocated.

Maintenance

Cleaning

Tocleanthelensesusecompressedairtocleardustandotherparticles,thencarefullyclean

withawetcottonswab.Thecottonswabshouldbemoistenedwithcleanwater.

Tocleanthemeterhousing,wipewithadamp,softcloth.Donotusesolventsorabrasives.Do

notimmersetheIR255inwaterorotherliquid.

Troubleshooting

SymptomProblemAction

OLdisplayTargettemperatureexceedsrangeSelectatargetwithinrange

‐OLdisplayTargettemperatureunder‐rangeSelectatargetwithinrange

BatteryiconflashesLowBatterypowerReplaceBattery

BlankdisplayscreenLowbatterypowerCheckand/orreplacebattery

NoLaserpointerLowbatteryorenvironmental

temperaturehigherthan40°C(104°F)

Replacethebatteryormovethe

IR255toanareawithalower

ambienttemperature

EXTECHINSTRUMENTS

8IR255‐en‐EU_V1.49/14

ReplacingBatteries

Whenthebatteryiconflashes,orwhenthemeterdoesn’tswitchON,replacethebatteries.

Thebatterycompartmentislocatedinthehandlegrip.Thebatterycompartmentlidislocated

justbelowthetrigger.Prythecompartmentlidofftoreachthecompartment.

Replacethe9Vbatteryfollowingcorrectpolarityandthenclosethebatterycompartmentlid.

Batterysafetynotes:

oRemovethebatteryifthedeviceistobestoredforlongerthan60days

oNeverdisposeofbatteriesinafire.Batteriesmayexplodeorleak

oNevermixbatterytypes.Alwaysinstallnewbatteriesofthesametype



Neverdisposeofusedbatteriesorrechargeablebatteriesinhouseholdwaste.

Asconsumers,usersarelegallyrequiredtotakeusedbatteriestoappropriate

collectionsites,theretailstorewherethebatterieswerepurchased,orwherever

batteriesaresold.

Disposal:Donotdisposeofthisinstrumentinhouseholdwaste.Theuseris

obligatedtotakeend‐of‐lifedevicestoadesignatedcollectionpointforthe

disposalofelectricalandelectronicequipment.



EXTECHINSTRUMENTS

9IR255‐en‐EU_V1.49/14

Specifications

InfraredThermometerSpecifications

Range/Resolution‐20to400oC(‐4to752oF)

Accuracy±2°C(3.6°F)or2%ofreading(whicheverisgreater)

Note:Accuracyisspecifiedforthefollowingambient

temperaturerange:21to25°C(70to77°F)

EmissivityAdjustablefrom0.10to1.00

FieldofViewD/S=Approx.12:1ratio(D=distance,S=spot)

LaserpowerLessthan1mW

Spectralresponse630to670nm(wavelength)

GeneralSpecifications

Display 1999count,backlitLCDdisplaywithfunctionindicators

Displayrate250msapprox.

OperatingTemperature 0°Cto40°C(32°Fto104°F)

OperatingHumidityMax.75%RH

PowerSupply9Vbattery

AutomaticPowerOffMetershutsoffautomaticallyafter9seconds

Weight 140g(4.0oz.)

Dimensions165x85x40mm(6.5x3.3x1.6”)



Allrightsreservedincludingtherightofreproductioninwholeorinpartinanyform

www.extech.com

Inhaltsverzeichnis

Andere Extech Instruments Thermometer Handbücher

Extech Instruments

Extech Instruments 42540 Bedienungsanleitung

Extech Instruments

Extech Instruments 42525A Bedienungsanleitung

Extech Instruments

Extech Instruments SDL200-NIST Bedienungsanleitung

Extech Instruments

Extech Instruments IRT600 Bedienungsanleitung

Extech Instruments

Extech Instruments 42535 Bedienungsanleitung

Extech Instruments

Extech Instruments 42545-NIST Bedienungsanleitung

Extech Instruments

Extech Instruments 445715-NIST Bedienungsanleitung

Extech Instruments

Extech Instruments EA15 Bedienungsanleitung

Extech Instruments

Extech Instruments 42515 Bedienungsanleitung

Extech Instruments

Extech Instruments RH200W-T Bedienungsanleitung

Extech Instruments

Extech Instruments 42530 Bedienungsanleitung

Extech Instruments

Extech Instruments RH490 Bedienungsanleitung

Extech Instruments

Extech Instruments 421501 Bedienungsanleitung

Extech Instruments

Extech Instruments IR100 Bedienungsanleitung

Extech Instruments

Extech Instruments RH200W Bedienungsanleitung

Extech Instruments

Extech Instruments IR250 Bedienungsanleitung

Extech Instruments

Extech Instruments 42570 Bedienungsanleitung

Extech Instruments

Extech Instruments RH250W Bedienungsanleitung

Extech Instruments

Extech Instruments TM20 Bedienungsanleitung

Extech Instruments

Extech Instruments EA10-NIST Bedienungsanleitung

Extech Instruments

Extech Instruments TM40 Bedienungsanleitung

Extech Instruments

Extech Instruments 42545 Bedienungsanleitung

Extech Instruments

Extech Instruments 42545 Bedienungsanleitung

Extech Instruments

Extech Instruments 421502 Bedienungsanleitung

Beliebte Thermometer Handbücher anderer Marken

Delton

Delton 981A Bedienungsanleitung

Baker

Baker MM2P Bedienungsanleitung

Tarmo

Tarmo 320281 Bedienungsanleitung

Citizen

Citizen CTD 504 Bedienungsanleitung

TFA

TFA 14.1500 Bedienungsanleitung

Vive

Vive DMD1010 Bedienungsanleitung

Gotemp

Gotemp THB4002 Bedienungsanleitung

GREISINGER

GREISINGER G 1202 Bedienungsanleitung

Amprobe

Amprobe TMD-53W Bedienungsanleitung

Trotec

Trotec BP10 Bedienungsanleitung

Radiance instruments

Radiance instruments RT616 Series Bedienungsanleitung

Eurolec

Eurolec IR151 Bedienungsanleitung

Scaneo

Scaneo TS42B Bedienungsanleitung

Sper scientific

Sper scientific 800043 Bedienungsanleitung

Microlife

Microlife NC 200 Bedienungsanleitung

Motorola

Motorola MBP69SN Konfigurationshandbuch

The MeatStick

The MeatStick The MeatStick Bedienungsanleitung

Hama

Hama TH35-A Bedienungsanleitung