Extech Instruments IRT25 Bedienungsanleitung



UserManual



MiniInfraRedThermometer

WithLaserPointerandHigh‐LowAlarms



ModelIRT25

AdditionalUserManualTranslationsavailableatwww.extech.com

EXTECHINSTRUMENTS

2IRT25‐en‐GB_V1.02/17

Introduction

CongratulationsonyourpurchaseoftheIRT25IRThermometer.Thisthermometermakesnon‐

contact(infrared)temperaturemeasurementsatthetouchofabutton.Thebuilt‐inlaserpointer

increasestargetaccuracywhilethebacklitLCDandhandypushbuttonscombineforconvenient,

ergonomicoperation.Thisdeviceisshippedfullytestedandcalibratedand,withproperuse,will

provideyearsofreliableservice.Pleasevisitourwebsite(www.extech.com)tocheckforthe

latestversionofthisUserGuide,ProductUpdates,andCustomerSupport.

Features

Measuresnon‐contactsurfacetemperatureupto371°C(400°F)

12:1DistancetoSpotRatio(FieldofView)

Single‐pointlasertargeting

AutomaticDataHoldwhentriggerisreleased

DisplayBacklight

Maximum‐Minimumtemperaturefunction

Selectabletemperatureunits(°F/°C)

Dynamicbatterystatusindication

Adjustableemissivity

AudibleandvisiblealarmindicationforHighandLowTemperatureAlarm

Safety

InternationalSafetySymbols

Thissymbol,adjacenttoanothersymbolorterminal,indicatestheusermustrefertothemanualfor

furtherinformation

Warnings

oDonotdirectlyorindirectlypointthelaserattheeyesofapersonorananimal

oInspectfordamageorforanyshortageofpartsoraccessoriesbeforeuse

oReplacethebatteriesimmediatelyafterthebatteryindicatorflashes

oDonotusethethermometernearexplosivegases,steam,ordust

oNotethatanobjectwithhighreflectivitywillnormallycausethe

measuredtemperaturevaluetoreadmuchlowerthantheactual

temperature

oUsethedeviceonlyasdescribedinthisUserGuide

Cautions

Toavoidthermometerdamage,pleaseavoidthefollowinghazards:

oEMFfromweldingequipmentorelectro‐inductionheaters

oStaticelectricity

oThermalshockcausedbylargeorabruptenvironmentaltemperaturechanges;wait30minutesto

allowthethermometertostabilizetonewenvironmentalconditions

oDonotusethisdeviceinexcessivelyhightemperatureenvironments



<1mW Output at 650nm

EXTECHINSTRUMENTS

3IRT25‐en‐GB_V1.02/17

Description



MeterDescription

1. LCDDisplay

2. MAX‐MIN/DownButton

3. Backlight‐LaserPointer/UpButton

4. Laserpointerlens

5. IRThermometerlens

6. SETButton

7. MeasurementScanTrigger

8. BatteryCompartment

DisplayDescription

Emissivityvalueindication

Laserpointeractiveicon



Scanmode(activewhilethetriggerispulled;displayed

temperaturetracksthetemperatureofthescannedsurfaces)

Holdmode(displayedtemperaturefreezeswithtriggerrelease)

Maximum/Minimumtemperatureicons

Batterycapacityindicator(flasheswhenbatteryvoltageiscritical)

DisplayBacklighticon

Temperatureunits(°F/°C)

TemperatureAlarmiconsandaudiblealarmdisableicon

EXTECHINSTRUMENTS

4IRT25‐en‐GB_V1.02/17

Operation

MeterPower

Themeterispoweredbytwo1.5VAAbatteries.Withfreshbatteriesinstalled,themeter

switchesONwhenthetriggerispulled.Thebatteriesarelocatedinthemeterhandle;pullthe

batterycompartmentlidawayfromthebodyofthemetertoopen.RefertotheMaintenance

sectionformoreBatteryInstallationinstructions.Thebatteryiconprovidesbatterystatus

indication.Replacethebatteriesassoonasthebatterystatusiconflashes.

SurfaceTemperatureMeasurements

1. HoldthemeterbyitsHandleGripandpointittowardthesurfacetobemeasured.Readthe

FieldofViewsectionbelowfordistancetotarget(spot)ratioinformation.

2. PullandholdtheTriggertoturnthemeteronandbegintestinginScanmode.Thedisplay

willlightifthetwo1.5Vbatteriesaregood.Replacethebatteriesifthedisplaydoesnotlight.

3. ReleasetheTrigger;thereadingwillholdforapproximately9seconds,afterwhichthemeter

willautomaticallyshutoff.

4. Themeterdefaultstotheprogrammedconditionsinusewhenthemeterwaslastswitched

OFF.Forexample,ifthelaserissettoONandthetemperatureunitsaresettooFatthetime

theunitisswitchedOFF,theunitwillswitchONandusethesamesettings.

Laser–ON/OFF

Pull the trigger and release.

PushandHOLDthe buttonforabout3secondstoswitchthelaserpointerONorOFF.

TheLasericonwillflashwhenthestatehaschanged.WhenthelaserisON,thelasericon will

appearontheLCD.Aimtheredlaserbeamapproximatelyahalfinchbelowthepointoftest

(pressingtheLaserbuttonagainturnsthelaseroff).

MAX‐MINMode

Pressthetriggerandrelease.

PresstheMAX‐MINbuttontoviewthemaximumtemperaturereading(MAX),pressagainto

viewthelowestreading(MIN).PressandholdtheMAX‐MINbuttontoswitchtheMAX‐MIN

modeoff.

DisplayBacklight

Pressthetriggerandrelease.

Pressthebacklightbutton momentarilytoswitchthebacklightONorOFF.

Over‐rangeIndicators(OLand‐OL)

Ifthetemperaturemeasurementexceeds779°F(415°C),thethermometerwilldisplayOLin

placeofatemperaturereading.Ifthetemperaturemeasurementisbelow‐25°C(‐13°F),the

thermometerwilldisplay‐OLinplaceofatemperaturereading.



EXTECHINSTRUMENTS

5IRT25‐en‐GB_V1.02/17

SettingMode

ReleasethetriggerandpresstheSETbuttontoaccesstheSettingMode.UsetheSETbuttonto

navigatethroughtheSettingModefieldsanduse(UP)andtheMAX‐MIN(DOWN)

buttonstomakechanges.Theavailableparametersarelistedbelow:

Emissivitysetting

°C/°Ftemperatureunitsselection

TemperatureAlarmAudibleBeeperEnable/Disable

HighTemperatureAlarmLimitsetting

LowTemperatureAlarmLimitsetting

Thecorrespondingparametericonwillflashwhenselected.ToexittheSettingMode,press

andholdtheSETbuttonfortwoseconds.

EmissivitySetting

The iconwillflashwhenselected.UsetheupandMAX‐MINdownbuttonsto

increaseordecreasetheemissivity(in0.01steps).Theemissivityrangeis0.10to1.00.Hold

theupordownbuttontorapidlyincreaseordecreasetheemissivityvalue.PresstheSET

buttontoconfirmandtosteptothenextoption.

SelectingtheTemperatureUnitofMeasure(°C/°F)

Usethe upandMAX‐MINdownbuttonstoselect°Cor°F.PresstheSETbuttonto

confirmandtosteptothenextoption.

Enable/DisableAudibleTemperatureAlarm

Thisparameterisusedtoenable/disabletheaudibletemperaturealarm.Theiconwillflash

inthismode.

UsetheupandMAX‐MINdownbuttonstotogglethesetting.Whentheaudible

alarmisdisabled,thedisplaywillshow‘HIGHLOW’.Whentheaudiblealarmisenabled,the

displaywillshow.Whentheaudiblealarmisenabled,thebeeperisallowedto

soundwheneverthemeasuredtemperaturegoesbeyondthehighorlowtemperaturelimit

values.PresstheSETbuttontoconfirmandtosteptothenextoption.

HIGHTemperatureAlarmLimitSetting

UsetheupandMAX‐MINdownbuttonstoincreaseordecreasetheHighAlarm

TemperatureLimit(in0.1stepsfor°Cor0.2stepsfor°F).Holdingtheupordownbuttonwill

rapidlyincreaseordecreasetheHIGHlimitvalue.AbeepwillsoundiftheHIGHtemperature

valuereachestheLOWtemperaturevaluewhileprogramming.PresstheSETbuttonto

confirmandtosteptothenextoption.

LOWTemperatureAlarmLimitSetting

UsetheupandMAX‐MINdownbuttonstoincreaseordecreasetheLowAlarm

TemperatureLimit(in0.1stepsfor°Cor0.2stepsfor°F).Holdingdowntheupordown

buttonwillrapidlyincreaseordecreasetheLOWlimitvalue.AbeepwillsoundiftheLOW

temperaturevaluereachestheHIGHtemperaturevaluewhileprogramming.PresstheSET

buttontoconfirmandtosteptothenextoption.

EXTECHINSTRUMENTS

6IRT25‐en‐GB_V1.02/17

LocatingHotorColdSpots

Todetectahotorcoldspot,aimthethermometerataregionbeyondthetargetandthenscan

theentireregioninaslow,up/downmotion.



DistancetoSpotRatio(FieldofView)

Themeter’sfieldofviewis12:1(distancetospotratio).Forexample,ifthemeteris24inches

fromthetarget(spot),thediameterofthetargetmustbeatleast2inches.Otherdistancesare

shownbelowinthefieldofviewdiagram.

Notethatmeasurementsshouldnormallybemadecloserthan2feetfromthetarget.Themeter

canmeasurefromfurtherdistancesbutthemeasurementmaybeaffectedbyexternalsources

oflight.Inaddition,thespotsizemaybesolargethatitencompassessurfaceareasnotintended

tobemeasured.



Itisnecessarytoensurethatthesizeofthetargetislargerthanthespotsize.Thesmallerthe

target,thecloserthedistanceshouldbe.Seetheaccompanyingdiagram.



Emissivity

Emissivityrepresentstheenergyreflectivityofamaterial.Mostorganicmaterialsandpainted

oroxidizedsurfaceshaveanemissivityofapproximately0.95.Ifpossible,maskingtapeorflat

blackpaintshouldbeappliedtocoverthemeasuredsurface.

Waitaperiodoftimetoallowthetapeorpainttoreachthermalequilibriumwiththesurface

ofthecoveredobject.Measurethetemperatureofthesurfacecoveredwithtapeorpaintonly

afterequilibriumhasbeenachieved.

EXTECHINSTRUMENTS

7IRT25‐en‐GB_V1.02/17

MeasurementNotes

1. Theobjectundertestshouldbelargerthanthespot(target)sizecalculatedbythefieldof

viewdiagram.

2. Ifthesurfaceoftheobjectundertestiscoveredwithfrost,oil,grime,etc.,cleanbefore

takingmeasurements.

3. Ifanobject'ssurfaceishighlyreflectiveapplymaskingtapeorflatblackpainttothesurface

beforemeasuring.

4. Themetermaynotmakeaccuratemeasurementsthroughtransparentsurfacessuchas

glass.

5. Steam,dust,smoke,etc.canobscuremeasurements.

6. Themetercompensatesfordeviationsinambienttemperature.Itcan,however,takeupto

30minutesforthemetertoadjusttoextremelywideambienttemperaturechanges.

7. Tofindahotspot,aimthemeteroutsidetheareaofinterestthenscanacross(inanupand

downmotion)untilthehotspotislocated.

Maintenance

Cleaning

Tocleanthelensesusecompressedairtocleardustandotherparticles,thencarefullyclean

withawetcottonswab.Thecottonswabshouldbemoistenedwithcleanwater.

Tocleanthemeterhousing,wipewithadamp,softcloth.Donotusesolventsorabrasives.Do

notimmersetheIRT25inwaterorotherliquid.

Troubleshooting

SymptomProblemAction

OLdisplayTargettemperatureexceedsrangeSelectatargetwithinrange

‐OLdisplayTargettemperatureunder‐rangeSelectatargetwithinrange

BatteryiconflashesLowBatterypowerReplaceBatteries

BlankdisplayscreenLowbatterypowerCheckand/orreplacebatteries

NoLaserpointerLowbatteryorenvironmental

temperaturehigherthan40°C(104°F)

Replacethebatteries ormovethe

IRT25toanareawithalower

ambienttemperature

EXTECHINSTRUMENTS

8IRT25‐en‐GB_V1.02/17

ReplacingBatteries

Whenthebatteryiconflashes,orwhenthemeterdoesn’tswitchON,replacethebatteries.

Thebatterycompartmentislocatedinthehandlegrip.Thebatterycompartmentlidislocated

justbelowthetrigger.Prythecompartmentlidofftoreachthecompartment.

Replacethe1.5VAAbatteriesfollowingcorrectpolarityandthenclosethebatterycompartment

lid.

BatterySafetyNotes:Pleasedisposeofbatteriesresponsibly;neverdisposeofbatteriesinafire,

batteriesmayexplodeorleak.Ifthemeterisnottobeusedfor60daysormore,removethe

batteryandstoreseparately.Donotmixbatterytypesorfreshnesslevels;pleaseusebatteries

ofthesametypeandofthesamefreshnesslevel.



Neverdisposeofusedbatteriesorrechargeablebatteriesinhouseholdwaste.

Asconsumers,usersarelegallyrequiredtotakeusedbatteriestoappropriatecollection

sites,theretailstorewherethebatterieswerepurchased,orwhereverbatteriesaresold.



Disposal:Donotdisposeofthisinstrumentinhouseholdwaste.Theuserisobligatedtotake

end‐of‐lifedevicestoadesignatedcollectionpointforthedisposalofelectricalandelectronic

equipment.



EXTECHINSTRUMENTS

9IRT25‐en‐GB_V1.02/17

Specifications

InfraredThermometerSpecifications

Range/Resolution‐20.0to371.0oC(‐4.0to700.0oF)

Accuracy‐20~0oC(‐4~32oF):±5°C(9°F)

0~371oC(32~700oF)±2°C(3.6°F)or2%ofreading(whicheverisgreater)

Note:Accuracyisspecifiedforthefollowingambienttemperaturerange:

21to25°C(70to77°F)

EmissivityAdjustablefrom0.10to1.00

FieldofView12:1DistancetoSpotratio

LaserpowerLessthan1mW,630to670nm(wavelength)

Spectralresponse8to14µm(wavelength)

GeneralSpecifications

Display BacklitLCDdisplaywithfunctionindicators

Displayrate500msapprox.

OperatingTemperature 0°Cto40°C(32°Fto104°F)

OperatingHumidityMax.75%RH

PowerSupplyTwo1.5VAAAlkalinebatteries

AutomaticPowerOffMetershutsoffautomaticallyafter9seconds

Weight 226g(8.0oz.)

Dimensions172x97x46mm(6.8x3.8x1.8”)

Allrightsreservedincludingtherightofreproductioninwholeorinpartinanyform

ISO‐9001Certified

www.extech.com



Inhaltsverzeichnis

Andere Extech Instruments Thermometer Handbücher

Extech Instruments

Extech Instruments 421504 Bedienungsanleitung

Extech Instruments

Extech Instruments 421508 Bedienungsanleitung

Extech Instruments

Extech Instruments 403265 Bedienungsanleitung

Extech Instruments

Extech Instruments EzSmart RHT3 Bedienungsanleitung

Extech Instruments

Extech Instruments IR267 Bedienungsanleitung

Extech Instruments

Extech Instruments 42555 Bedienungsanleitung

Extech Instruments

Extech Instruments 42540A Bedienungsanleitung

Extech Instruments

Extech Instruments 445580 Bedienungsanleitung

Extech Instruments

Extech Instruments RH250W Bedienungsanleitung

Extech Instruments

Extech Instruments 445715-NIST Bedienungsanleitung

Extech Instruments

Extech Instruments 42535 Bedienungsanleitung

Extech Instruments

Extech Instruments EasyView EA11A Bedienungsanleitung

Extech Instruments

Extech Instruments TM55 Bedienungsanleitung

Extech Instruments

Extech Instruments RHT510-NIST Bedienungsanleitung

Extech Instruments

Extech Instruments 445703 Bedienungsanleitung

Extech Instruments

Extech Instruments 42510A Bedienungsanleitung

Extech Instruments

Extech Instruments 421501 Bedienungsanleitung

Extech Instruments

Extech Instruments TM20 Bedienungsanleitung

Extech Instruments

Extech Instruments RH35 Bedienungsanleitung

Extech Instruments

Extech Instruments 42570 Bedienungsanleitung

Extech Instruments

Extech Instruments IR400 Bedienungsanleitung

Extech Instruments

Extech Instruments MD13628 Bedienungsanleitung

Extech Instruments

Extech Instruments 445580 Bedienungsanleitung

Extech Instruments

Extech Instruments VIR50-NISTL Bedienungsanleitung

Beliebte Thermometer Handbücher anderer Marken

Delton

Delton 981A Bedienungsanleitung

Baker

Baker MM2P Bedienungsanleitung

Tarmo

Tarmo 320281 Bedienungsanleitung

Citizen

Citizen CTD 504 Bedienungsanleitung

TFA

TFA 14.1500 Bedienungsanleitung

Vive

Vive DMD1010 Bedienungsanleitung

Gotemp

Gotemp THB4002 Bedienungsanleitung

GREISINGER

GREISINGER G 1202 Bedienungsanleitung

Amprobe

Amprobe TMD-53W Bedienungsanleitung

Trotec

Trotec BP10 Bedienungsanleitung

Radiance instruments

Radiance instruments RT616 Series Bedienungsanleitung

Eurolec

Eurolec IR151 Bedienungsanleitung

Scaneo

Scaneo TS42B Bedienungsanleitung

Sper scientific

Sper scientific 800043 Bedienungsanleitung

Microlife

Microlife NC 200 Bedienungsanleitung

Motorola

Motorola MBP69SN Konfigurationshandbuch

The MeatStick

The MeatStick The MeatStick Bedienungsanleitung

Hama

Hama TH35-A Bedienungsanleitung