Geotech 1.66 Reclaimer Bedienungsanleitung
Rev 06/10/12 Part# 26600222
Geotech
1.66 Reclaimer
Installation and Operation Manual
1
TABLE OF CONTENTS
CHAPTER 1: SYSTEM DESCRIPTION......................................................................................3
FUNCTION AND THEORY .................................................................................................3
CHAPTER 2: SYSTEM INSTALLATION .....................................................................................4
CHAPTER 3: SYSTEM OPERATION..........................................................................................5
CHAPTER 4: SYSTEM MAINTENANCE ....................................................................................7
CHAPTER 5: SYSTEM TROUBLESHOOTING ..........................................................................9
CHAPTER 6: SYSTEM SPECIFICATIONS...............................................................................10
CHAPTER 7: REPLACEMENT PARTS LIST............................................................................12
THE WARRANTY .......................................................................................................................14
EQUIPMENT RETURN POLICY................................................................................................14
EQUIPMENT DECONTAMINATION..........................................................................................14
DOCUMENTATION CONVENTIONS
This manual uses the ollowing conventions to present in ormation:
An exclamation point icon in icates a WARNING of a situation or con ition that
coul lea to personal injury or eath. You shoul not procee until you rea
an thoroughly un erstan the WARNING message.
WARNING
A raise han icon in icates CAUTION information that relates to a situation or
con ition that coul lea to equipment malfunction or amage. You shoul not
procee until you rea an thoroughly un erstan the CAUTION message.
CAUTION
A note icon in icates NOTE information. Notes provi e a itional or supplemen-
tary information about an activity or concept.
NOTE
2
Chapter 1: System Description
Function and Theory
The Geotech Reclaimer can be configure as a Top fill, Bottom fill, or Top an Bottom fill fixe
intake, positive air isplacement pump. The Geotech Reclaimer is esigne for total flui s,
hy rocarbon, leachate, an con ensate recovery. The Geotech Reclaimer is esigne to with-
stan most aggressive own well environments inclu ing highly corrosive flui s without fear of
material break own or failure.
The Geotech Reclaimer will recover flui s from epths up to 500' (152 m).
Refer to the operation section of this manual.
Flow rates of up to 3 GPM (11.4 LPM) are possible.
Refer to the specifications section of this manual.
The Geotech 1.66" Reclaimer will operate in wells 2" (5cm) insi e iameter or larger vertical wells.
3
4
Chapter 2: System Installation
Attach pro uct ischarge an air supply hoses to the proper barbe fittings on the pump.
Refer to Figures 1 an 2 below for fitting configurations.
If pump configuration was not assemble as a complete system,
please use the following steps:
Attach air supply hose to Geotech pneumatic controller air supply fitting.
Ensure all hoses are installe properly an securely to the fittings.
Attach the safety cable to the support loop using proper crimps or cable clamps.
The Reclaimer can now be lowere into the recovery well. For optimum efficiency, the
Reclaimer must be positione in the well with the intake a equately submerge .
Figure 1
1.66" Reclaimer Bottom Fill
Figure 2
1.66" Reclaimer Top Fill
Discharge
Discharge
Air
Air Fluid
Intake
5
Chapter 3: System Operation
Compressed air is utilized in this system. For pressure requirements use .5
psi per oot (.03 bar per 30.5 cm) o li t plus ten. Example: 30' (9 m) o head
would need a minimum o 25 psi (1.7 bar). Consult the controller manual or
air pressure requirements needed.
TOP FILL
The Top Fill Reclaimer is place in a recovery well with the top inlet submerge below static
groun water. Combine with the Geotech Pneumatic Controller, the Reclaimer cyclically fills
an empties.
Well recharge rate and time sequence settings on the Geotech Pneumatic
Controller will a ect the maintainable luid level.
BOTTOM FILL
The Bottom Fill Reclaimer is place in a recovery well with the bottom intake submerge below
static groun water. Combine with Geotech’s Pneumatic Controller, the Reclaimer cyclically
fills an empties.
Well recharge rate and time sequence settings on the Geotech Pneumatic
Controller will a ect the maintainable luid level, see Figure 3.
Controller
To Compressor
Product/Liquid
Discharge Air Supply
Cone of
Depression
Figure 3
1.66" Reclaimer
6
Chapter 4: System Maintenance
The Geotech Reclaimer has been esigne to be virtually maintenance free. In the event
clogging occurs in the pump or trappe particulate in the check ball seats, isassemble the
Reclaimer pump an rinse with soapy or clean water to islo ge any matter. The Reclaimer
is constructe of 300 series stainless steel an PTFE to provi e many years of continue serv-
ice with minimal maintenance. See Figure 4.
7
8
Figure 4
Top Fill Bottom Fill
9
Chapter 5: System Troubleshooting
Problem: Pump does not discharge luid to the sur ace.
Solutions:
1. Check controller to ensure it is functioning properly. Consult controller manual.
2. Ensure that the air pressure is a equate enough to overcome the total ynamic hea
pressure the pump is working against. (Consult the controller manual for air pressure
requirements nee e .)
3. Inlet screen is clogge – Remove pump from well, isassemble, clean screen
4. Inlet pipe plug is clogge – Remove pump from well, isassemble, clear, clean plug
5. Air exhaust vent hose is clogge – Remove pump from well, isassemble, clear vent hose
6. Hoses are kinke or cut – Replace amage hoses
Andere Handbücher für 1.66 Reclaimer
2
Inhaltsverzeichnis
Andere Geotech Messgerät Handbücher
Geotech
Geotech GTW Bedienungsanleitung
Geotech
Geotech Biogas 300 Bedienungsanleitung
Geotech
Geotech G100 Bedienungsanleitung
Geotech
Geotech ET WLM Bedienungsanleitung
Geotech
Geotech Keck Interface Probe Bedienungsanleitung
Geotech
Geotech EcoSense EC300M Bedienungsanleitung
Geotech
Geotech GEM5000 Bedienungsanleitung
Geotech
Geotech BIOGAS 3000 Bedienungsanleitung
Geotech
Geotech 5000 Series Benutzerhandbuch
Geotech
Geotech Seametrics EX11 Series Bedienungsanleitung
Geotech
Geotech EcoSense pH100A Bedienungsanleitung
Geotech
Geotech GA2000 Bedienungsanleitung
Geotech
Geotech Shallow Well Probe Scavenger Bedienungsanleitung
Geotech
Geotech G110 Bedienungsanleitung
Geotech
Geotech ETL WLM+T Bedienungsanleitung
Geotech
Geotech SandShaker Bedienungsanleitung
Geotech
Geotech EcoSense ODO200M Bedienungsanleitung
Geotech
Geotech GEM5000 Bedienungsanleitung
Geotech
Geotech GA5000 Bedienungsanleitung
Geotech
Geotech SCPT-GS2 Bedienungsanleitung
