Heat & Glo EXCLAIM-36 Bedienungsanleitung

1Heat&Glo•Exclaim36/42•4013-266InstallersManual•RevG•10/07/13

Installationandserviceofthisreplaceshouldbe

performedbyqualiedpersonnel.Hearth&Home

TechnologiesrecommendsNFIcertiedprofes-

sionals,ortechnicianssupervisedbyan

NFIcertiedprofessional.

WOODBURNING FIREPLACE

Fire Risk.

WARNING

Forusewithsolidwoodfuelonly.

Otherfuelsmayoverreandgenerate

poisonousgases(i.e.carbonmonoxide).

Model(s):

Installation Manual

Installation and Fireplace Setup

WARNING

HOT SURFACES!

Glassandothersurfacesarehotduring

operationANDcooldown.

Hot glass will cause burns.

• DO NOTtouchglassuntilitiscooled

• NEVERallowchildrentotouchglass

• Keepchildrenaway

• CAREFULLY SUPERVISE children in same room as

replace.

• Alertchildrenandadultstohazardsofhightemperatures.

Hightemperaturesmayigniteclothingorotherammable

materials.

• Keep clothing, furniture, draperies and other ammable

materialsaway.

INSTALLER: Leave this manual with party responsible for use and operation.

OWNER: Retain this manual for future reference.

EXCLAIM-36

EXCLAIM-42

NOTICE: DO NOT discard this manual!

• DO NOTstoreorusegasolineorotheram-

mablevaporsandliquidsinthevicinityofthis

oranyotherappliance.

• DO NOToverre.Overring will void your

warranty.

• Complywithallminimumclearancestocom-

bustiblesasspecied.Failuretocomplymay

causehousere.

WARNING: If the information in these

instructionsisnotfollowedexactly,are

or explosion may result causing property

damage, personal injury, or death.

2Heat & Glo • Exclaim 36/42 • 4013-266 Installers Manual • Rev G • 10/07/13

Safety Alert Key:

• DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury.

• WARNING!Indicatesahazardoussituationwhich,ifnotavoidedcouldresultindeathorseriousinjury.

• CAUTION! Indicatesahazardoussituationwhich,ifnotavoided,couldresultinminorormoderateinjury.

• NOTICE:Indicatespracticeswhichmaycausedamagetothereplaceortoproperty.

Table of Contents

1 ProductSpecic&ImportantSafetyInformation

A.FireplaceCertication 4

B.Non-CombustibleMaterials 4

C.CombustibleMaterials 4

2 Getting Started

A.TypicalFireplaceSystem 5

B.DesignandInstallationConsiderations 6

1.SelectingFireplaceLocations 6

2.LocatingFireplace&Chimney 7

C.ToolsandSuppliesNeeded 8

D.InspectFireplaceandComponents 8

E.FireplaceSystemRequirements 8

3 Framing and Clearances

A.FireplaceDimensions 9

B.Clearances 10

MinimumClearancestoCombustibles 10

C.ConstructtheChase 11

D.UnpacktheFireplace(Exclaim-36only) 12

E.UnpacktheFireplace(Exclaim-42only) 12

F. FrametheFireplace 13

G.SecureandLeveltheFireplace 14

H.ProtectiveMetalHearthStrips 14

I. OutsideAirKit 15

4 Chimney and Termination Requirements

A.ChimneyRequirements 16

B.Offsets/Returns 17

C.TerminationRequirements 18

5 Chimney Installation

A.TypicalChimneySystem 19

B.AssembleChimneySections 20

C.InstallChimneyAirKit 20

D.SecureOffset/Return 21

E.InstallCeilingFirestops 21

F. InstallAtticInsulationShield 22

G.RoofPenetration 23

H.InstallChase/ChaseTop 23

I. TerminationCapRequirements 24

J. InstallTerminationCap 24

6 Shrouds

A.RadiationShield 26

B.FieldConstructedShrouds 26

1.OpenTopShroud 26

2.MailboxStyleShroud 27

3.RoofedStyleShroud 27

7 Finishing

A.FinishingMaterial 28

B.HearthExtension,BuildingandFinishing 29

1.FireplaceInstalledFlushontheFloor

 andHearthExtensionRaisedtoBottom

 ofFireboxOpening 30

2.RaisedHearthExtensionandRaisedFireplace 31

3.FireplaceOpeningandHearthExtensionFlush

 withtheFloor 32

C.Non-CombustibleSealantMaterial 32

D.Sidewalls/Surrounds 33

E.MantelandWallProjections 34

8 Fireplace Setup

A.GasLog/LighterProvision 35

B.WoodBurningInserts 35

C.InstalltheRefractory(Exclaim-42only) 36

9 Reference Materials

A.ChimneyComponents 37

B.OptionalComponents 40

►

Heat & Glo • Exclaim 36/42 • 4013-266 Installers Manual • Rev G • 10/07/13

Customer:

Lot/Address

Model (circle one): EXCLAIM-36

EXCLAIM-42

YES IF NO, WHY?

Protectivehearthstripsinstalledpermanualrequirements.(Pg.14)

Outsideairkitinstalled.(Pg.15)

Atticinsulationshieldinstalled.

Shroudisinstalledproperlyperinstructions.

WARNING! Risk of Fire or Explosion! Failure to install fireplace acording to these instructions can lead to a fire or

explosion.

Verifiedthatthechaseisinsulatedandsealed.(Pg.11)

Verifiedclearancestocombustibles.(Pg.10)

Fireplaceisleveledandsecured.(Pg.14)

Hearthextensionsize/heightdecided.(Pg.29)

Chimneyconfigurationcomplieswithdiagrams.

Chimneyinstalled,lockedandsecuredinplacewithproperclearance.

Chimneyairkitinstalled.

Firestopsinstalled.

ATTENTION INSTALLER:

Follow this Standard Work Checklist

Thisstandardworkchecklististobeusedbytheinstallerinconjuctionwith,notinsteadof,theinstructionscontainedinthisinstallation

manual.

Date Installed:

Location of Fireplace:

Installer:

Dealer/Distributor Phone #

Serial #:

Roofflashinginstalled.

Terminationinstalled.

Fireplace Install

ChimneySection4&5(Pg.16)

Shrouds Section 6 (Pg. 26)

Fi i hi

S ti 7 (P 28)

Hearthextensioninstalledpermanualrequirements.

Commentscommunicatedtopartyresponsible

4013-268•RevB•3-13-13

__________________________by______________________on_________

(Builder/Gen.Contractor)(Installer)(Date)

Comments:Furtherdescriptionoftheissues,whoisresponsible(Installer/Builder/OtherTrades,etc.)andcorrectiveactionneeded:

Manualbagandallofitscontentsareremovedfromthefireplaceandgiventotheparty

responsibleforuseandoperation.

•Thatthischecklistremainvisibleatalltimesonthefireplaceuntiltheinstallationiscomplete.

•Photographingtheinstallationandcopyingthischecklistforyourfile.

Combustiblematerialsnotinstalledinnon-combustibleareas.

Hearth&HomeTechnologiesrecommendsthefollowing:

Finishing Section 7 (Pg. 28)

Fireplace Setup Section 8 (Pg. 35)

Verifiedallclearancesmeetinstallationmanualrequirements.

Mantelsandwallprojectionscomplywithinstallationmanualrequirements.

Allpackagingandprotectivematerialsremoved.

Optionaldoorsproperlyinstalled.

Moldedbrickpanelsinstalledcorrectly.

Grateisproperlyinstalled.

Firescreeninstalledproperly.

4Heat & Glo • Exclaim 36/42 • 4013-266 Installers Manual • Rev G • 10/07/13

WARNING! Risk of Fire! Hearth & Home Technologies

disclaims any responsibility for, and the warranty and

agency listing will be voided by the following actions.

DO NOT:

• installoroperatedamagedreplace

• modifyreplace

• install other than as instructed by Hearth & Home

Technologies

• operate the fireplace without fully assembling all

components

• overre

• installunventedgaslogset

• installanycomponentnotapprovedbyHearth&Home

Technologies

• installpartsorcomponentsnotListedorapproved

Improper installation, adjustment, alteration, service or

maintenance can cause injury or property damage. For

assistance or additional information, consult a qualied

installer, service agency or your dealer.

B. Non-Combustible Materials

• Materialswhich willnot igniteand burn,composed of

anycombinationofthefollowing:

- Steel - Iron

- Brick - Tile

- Concrete - Slate

- Glass - Plasters

• MaterialsreportedaspassingASTM E 136, Standard

Test Method for Behavior of Metals, in a Vertical Tube

Furnace at 750° C

C. Combustible Materials

• Materialsmadeoforsurfacedwithanyofthefollowing

materials:

- Wood - Compressedpaper

- Plantbers - Plastic

- Plywood/OSB - Sheetrock(drywall)

• Anymaterialthatcanigniteandburn;ameproofedor

not,plasteredorun-plastered

1 ProductSpecic&ImportantSafetyInformation

A.FireplaceCertication

ThisreplacemaybeinstalledinsleepingroomsEX-

CEPTinmanufacturedhomes.Ifinstalledwithagaslog

set,provisionsfortheNationalFuelGasCodemustbe

met.

Thisreplacehasbeentestedandlistedforusewiththe

optionalcomponentsspeciedinthismanual.Theseop-

tionalcomponentsmaybepurchasedseparatelyandin-

stalledatalaterdate.Installationofanoutsideairkitwill

requiresignicantreconstructionandisbestifinstalledat

thetimeofreplaceinstallation.

Heat&GloisaregisteredtrademarkofHearth&Home

TechnologiesInc.

Thisreplacesystemhasbeentestedandlistedinaccor-

dancewithUL127andULC-S610standardsbyUnder-

writersLaboratoriesInc.forinstallationandoperationin

theUnitedStatesandCanada.

Heat & Glo • Exclaim 36/42 • 4013-266 Installers Manual • Rev G • 10/07/13

2 Getting Started

A. Typical Fireplace System

Figure 2.1 Typical Fireplace System

)

))

)

Non-combustible

roof flashing maintains

minimum clearance

around chimney

Additional lateral

support for chimney

above roof (or enclosed

in chase) if needed

Ceiling firestop

on floor of attic

Support straps

on rafter support

chimney

Termination cap

Chimney penetrates roof

preferably without affecting

roof rafters

Offset & Return (with hanger straps)

Framing headed off

in ceiling joists

Enclosed space above

and around fireplace

Mantel and surround

Decorative facing

and trim

Hearth extension

Factory-built fireplace

Protective metal

hearth strip(s)

Outside

combustion air

Combustible framing/header

on top of V-shaped standoffs

Chimney system

Attic insulation shield

must be used here to keep

insulation away from chimney

if attic is insulated

Storm Collar

Chimney Air Kit

Required in

Canada. Outlet

must be no

less than 4 ft.

(1.22 m) off

ground level.

6Heat & Glo • Exclaim 36/42 • 4013-266 Installers Manual • Rev G • 10/07/13

In an exterior

chase or projecting

into a garage

Across a

corner

As a room

divider

Along a wall

B A

48 in.

(1219 mm)

min.

Note: EXCL36 - 1 in. (25 mm)

EXCL42 - 1 1/2 in. (38 mm)

minimum distance from

sides & back of fireplace to

combustible materials.

I60 & I80 - 1/2 in. (13 mm)

minimum at nailing flanges.

1/2 in. (13 mm)

all configurations

*8 in. (203 mm) extra space

included for outside air

connection. If outside air duct

has no bend, this dimension

may be reduced as long as

minimum clearances are met.

A B C D E F G H

inches 45 1/2 53 1/2 85 42 1/2 19 3/8 60 1/8 28

mm 1156 1359 2159 1080 492 1527 711

inches

59 1/2 92 3/4 46 3/8 21 1/2 65 5/8 28 1/2

mm 1308 1511 2356 1178 546 1667 724

Model

Exclaim-36

Exclaim-42

24 in. (610 mm)

Minimum from FP opening to an

perpendicular wall.

51 1/2

Figure 2.2 Fireplace Locations

NOTICE:

• Illustrationsandphotosreecttypicalinstallationsand

are FORDESIGNPURPOSESONLY.

• Illustrations/diagramsarenotdrawntoscale.

• Actualinstallation/appearancemayvaryduetoindividual

design preference.

• Hearth&HomeTechnologiesreservestherighttoalter

its products.

NOTICE: In addition to these framing dimensions, also

reference the following section:

• Clearances (Section 3).

NOTICE:

Exclaim-36-Aminimum1in.airclearanceatthe

backandsidesofthereplaceassemblymustbe

maintained.

Exclaim-42-Aminimum11/2in.airclearanceat

thebackandsidesofthereplaceassemblymust

be maintained

Chimneysectionsatanylevelrequirea2in.mini-

mum air space clearance between the framing

and chimney sections.

B. Design and Installation Considerations

NOTICE: Check building codes prior to installation.

• InstallationMUSTcomplywithlocal,regional,stateand

nationalcodesandregulations.

• Consultinsurancecarrier,localbuildinginspector,re

ofcialsorauthoritieshavingjurisdictionoverrestrictions,

installationinspectionandpermits.

• Before installing,determinethefollowing:

- Wherethereplaceistobeinstalled.

- Theventsystemcongurationtobeused.

- Gassupplypiping.

- Electricalwiring.

- Framingandnishingdetails.

- Whetheroptionalaccessories-devicessuchasa

fan,wallswitchorremotecontrol-aredesired.

1. Selecting Fireplace Locations

Thisreplacemaybeusedasaroomdivider,installed

alongawall,acrossacornerorusedinanexteriorchase.

SeeFigure2.2.

Locatingthereplaceinabasementshouldbeavoided.

Locatingnearfrequentlyopeneddoors,centralheat

outletsorreturns,orotherlocationsofconsiderableair

movementcanaffecttheperformance.

Considerationshouldbegiventothesefactorsbefore

decidingonalocation.

Heat & Glo • Exclaim 36/42 • 4013-266 Installers Manual • Rev G • 10/07/13

2. LocatingFireplace&Chimney

Locationofthereplaceandchimneywillaffectperfor-

mance.

• Installwithinthewarmairspaceenclosedbythebuilding

envelope.Thishelpstoproducemoredraft,especially

duringlightinganddie-downofthere.

• Installing the fireplace in a basement is not

recommenbded.

• Penetratethehighestpart oftheroof.Thisminimizes

theeffectsofwindloading.

• Locate termination cap away from trees, adjacent

structures,unevenrooflinesandotherobstructions.

• Minimizetheuseofchimneyoffsets.

• Considerthereplacelocationrelativetooorandceiling

andatticjoists.

Marginal Location:

• Below peak

Location NOT recommended:

• Not the highest point of the roof

• Wind loading possible

Multi-level Roofs

Windward

Leeward

Recommended Location:

• Above peak

Recommended:

• Insulated exterior chase

in cooler climates

Recommended Location:

• Above peak

• Inside heated space

Location NOT recommended:

• Too close to tree

• Below adjacent structure

• Lower roof line

• Avoid outside wall

Marginal Location:

• Wind loading possible

Figure 2.3 Recommended Chimney Locations

• Takeintoconsiderationtheterminationrequirementsin

Sections4and5.

• Installtheoutsideairkitwiththeintakefacingprevailing

windsduringtheheatingseason.

• Ensure adequate outdoor air for all combustion

appliancesandexhaustequipment.

• Ensurefurnaceandairconditioningreturnventsarenot

locatedintheimmediatevicinityofthereplace.

• Avoidinstallingthereplaceneardoors,walkwaysor

smallisolatedspaces.

• Recessedlightingshouldbea“sealedcan”design.

• Attichatchesweatherstrippedorsealed.

• Atticmountedductworkandairhandlerjointsandseams

tapedorsealed.

8Heat & Glo • Exclaim 36/42 • 4013-266 Installers Manual • Rev G • 10/07/13

C. Tools and Supplies Needed

Beforebeginningtheinstallationbesurethefollowing

toolsandbuildingsuppliesareavailable:

Reciprocatingsaw Framingmaterial

Pliers Non-combustiblesealant

Hammer Gloves

Phillipsscrewdriver Framingsquare

Flatbladescrewdriver Electricdrillandbits

Plumbline Safetyglasses

Level Tapemeasure

1/2-3/4in.length,#6or#8self-drillingscrews

Misc.screwsandnails

D. Inspect Fireplace and Components

WARNING! Risk of Fire and/or Explosion! Damaged

parts could impair safe operation. DO NOT install dam-

aged,incompleteorsubstitutecomponents.Keepre-

place dry.

• Inspectreplacefordamage.

• Vent system components and doors are shipped in

separatepackages.

• Reporttoyourdealeranypartsdamagedinshipment.

• Read all the instructions before starting the

installation. Follow these instructions carefully

during the installation to ensure maximum safety

andbenet.

E. Fireplace System Requirements

TheHeat&Gloreplacesystemrequirementsconsistof

thefollowing:

• Fireplace

- Refractory(includedwithreplace)

- Firescreen(includedwithreplace)

- HearthExtension

• OutsideAirSystem

- AirInletHood(includedwithreplace)

- Flex(required,soldseparately)

• ChimneySystem

- Chimneyairkit(requiredinCanada,soldseparately)

- AtticInsulationShield(includedwithreplace)

- Chimneyterminationcap(required,soldseparately)

- SLA10adapter(requiredinCanada,soldseparately)

• Non-combustiblenishmaterial

Heat & Glo • Exclaim 36/42 • 4013-266 Installers Manual • Rev G • 10/07/13

3 Framing and Clearances

A. Fireplace Dimensions

Gas

Knockout

8-5/8 in.

(219 mm)

9-5/8 in.

(244 mm)

9-1/2 in.

(241 mm)

Outside Air

9-1/4 in.

(235 mm)

Gas Knockout

18-1/2 in.

(470 mm)

8-5/8 in.

(219 mm)

49-5/8 in.

(1260 mm) 28-1/2 in.

(724 mm)

55-1/2 in.

(1410 mm)

(effective height)

49-1/8 in.

(1248 mm)

59-1/4 in.

(1505 mm)

7-5/8 in.

(194 mm) 36 in.

(914 mm)

28-5/8 in.

(727 mm)

14-3/8 in.

(365 mm)

44-1/2 in.

(1130 mm)

27-1/2 in.

(699 mm)

9-1/2 in.

(241 mm)

Figure 3.1 Fireplace Dimensions

28-1/2 in.

(724 mm)

55-1/2 in.

(1410 mm)

(Efective Height

49-1/8 in.

(1248 mm)

49-5/8 in.

(1260 mm)

59-1/4 in.

(1505 mm)

7-5/8 in.

(194 mm) 42 in.

(1067 mm)

Gas

Knockout

18-1/2 in.

(470 mm)

8-5/8 in.

(219 mm)

Gas

Knockout

8-5/8 in.

(219 mm)

9-5/8 in.

(244 mm)

9-1/2 in.

(241 mm)

9-1/4 in.

(235 mm)

Outside

Air

34-1/2 in.

(876 mm)

9-1/2 in.

(241 mm)

27-1/2 in.

(699 mm)

50-1/2 in.

(1283 mm)

Exclaim-42

Exclaim-36

10 Heat & Glo • Exclaim 36/42 • 4013-266 Installers Manual • Rev G • 10/07/13

B. Clearances

WARNING! Risk of Fire!

You must comply with all minimum air space clearances

tocombustiblesasspeciedinFigure3.2.DO NOT pack

required air spaces with insulation or other materials.

Framing or nishing material used on the front of, or in

frontof,thereplacecloserthantheminimumslistedmust

be constucted entirely of non-combustible materials (i.e.,

steel studs, concrete board, etc.). Failure to comply may

causere.

Figure 3.2 Clearances to Combustible Materials

Minimum Clearances to Combustibles

WITHIN ENCLOSURE AREA

Fireplacetobackwall(Exclaim-36) 1in.(25mm)

Fireplacetobackwall(Exclaim-42) 11/2in.(38mm)

Fireplacetosidewall(Exclaim-36) 1in.(25mm)

Fireplacetosidewall(Exclaim-42) 11/2in.(38mm)

Topstandoffstoheader 0in.(0mm)

Dooropeningtosidewall 24in.(610mm)

MANTEL

Mantelminimumheight 481/8in.(1222mm)

Maximummanteldepth 12in.(305mm)

(insulation)

0 in. to level

of standoffs

Attic

Insulation

Shield

(ceiling)

(roof)

(attic)

(ceiling)

Ceiling Firestop

Offset/Return (secured

with hanger straps)

Storm Collar

Roof Flashing

Clearance to back &

sides of appliance

Exclaim-36 - 1 in. (25 mm)

Exclaim-42 - 1 1/2 in. (38 mm)

(except at nailing flanges

where it is 1/2 in. [13 mm])

Must have 2 in. (51 mm)

minimum clearance

to header

0 in.

to floor

2 in. (51 mm) min.

Shaded areas

represent

2 in. (51 mm) min.

air space clearance

required around pipe

Combustible Object

48 in.

1219 mm

Adapter attached here (not shown)

Note: Chimneyairkitand 11-10

in./279-254 mm adapter are

not shown, but are required in

Canada.

Andere Handbücher für EXCLAIM-36

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Heat & Glo Kamin im Innenbereich Handbücher

Heat & Glo

Heat & Glo CFX-CRESCENT Bedienungsanleitung

Heat & Glo

Heat & Glo 6000GBV-IPI Bedienungsanleitung

Heat & Glo

Heat & Glo SL-550TR-E Bedienungsanleitung

Heat & Glo

Heat & Glo GATEWAY Bedienungsanleitung

Heat & Glo

Heat & Glo EM-415 Bedienungsanleitung

Heat & Glo

Heat & Glo Grand-XTS Bedienungsanleitung

Heat & Glo

Heat & Glo 6000CL-IPI-S Bedienungsanleitung

Heat & Glo

Heat & Glo ST-42TVFL-IPI Bedienungsanleitung

Heat & Glo

Heat & Glo EXCLAIM-50 Bedienungsanleitung

Heat & Glo

Heat & Glo SL-7BV Bedienungsanleitung

Heat & Glo

Heat & Glo SL-550BE Bedienungsanleitung

Heat & Glo

Heat & Glo ST-550TM-IPI Bedienungsanleitung

Heat & Glo

Heat & Glo 550TRSI-AUF Bedienungsanleitung

Heat & Glo

Heat & Glo ST-HVBI-AUB Bedienungsanleitung

Heat & Glo

Heat & Glo 8000TRD Montageanleitung

Heat & Glo

Heat & Glo 6000CL-IFT-S Bedienungsanleitung

Heat & Glo

Heat & Glo Options Bedienungsanleitung

Heat & Glo

Heat & Glo STELLAR 3-SS-20-G Bedienungsanleitung

Heat & Glo

Heat & Glo BAY-40 Bedienungsanleitung

Heat & Glo

Heat & Glo ST-38GTV Montageanleitung

Heat & Glo

Heat & Glo SL-5 Bedienungsanleitung

Heat & Glo

Heat & Glo REVO-V12 Bedienungsanleitung

Heat & Glo

Heat & Glo RED40-N-AU Bedienungsanleitung

Heat & Glo

Heat & Glo 550TRSI-AUF Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch