Honeywell HE120A1010 - Whole House Humidifier Bedienungsanleitung

69-1110EF-02

OWNER’S MANUAL

HE120 By-Pass

Drum Humidifier

Contents

How Your Humidifier Works .................................................................................... 2

Operating Your Humidifier ...................................................................................... 2

Maintaining Your Humidifier .................................................................................... 3

Checking Your Humidifier Operation ...................................................................... 6

Troubleshooting Your Humidifier ............................................................................. 6

HE120 BY-PASS DRUM HUMIDIFIER

69-1110EF—02 2

HOW YOUR HUMIDIFIER WORKS

Your Honeywell humidifier uses the principle that vapor (evaporated water) is created

when warm air blows over a water soaked area. As the vapor circulates, the relative

humidity rises.

Your humidity control monitors the relative humidity and activates the humidifier

accordingly. The humidifier has a water supply that disburses water evenly over a

humidifier pad. The warm dry air from the furnace passes over the humidifier pad and

picks up the moist air to circulate it through your home.

Humidified air feels warmer and more comfortable so you may be able to lower your

thermostat heating setpoint and save money on your heating fuel bills. The end result

is that your humidifier gives you a comfortable environment that is also energy

efficient.

OPERATING YOUR HUMIDIFIER

Your HE120 Honeywell humidifier is controlled by

the Humidity Control that is installed either on the

return air duct or on an interior wall in your living

area. Choose the humidity control setting using the

combination relative humidity/outdoor temperature

setting scale on your humidity control. Match the

dial setting to the outdoor temperature for

optimizing the humidity level while reducing the

moisture condensation on your windows. The table

below can also be used to adjust the humidity

control to the recommended setting.

NOTE: As the outside temperature drops, the recommended humidity control setting

is lowered to accommodate for the effects of dewpoint. These settings should

reduce the accumulation of moisture and ice on your windows and in other

areas of your home.

Some indoor activities such as cooking, showering and clothes drying can cause

excessive levels of humidity and start the accumulation of moisture on your windows.

NOTE: If this condition persists for more than a few hours, set the humidity control to

the lowest setting to turn off the humidifier. If the condition does not improve,

ventilate your home to remove the moisture.

At Outside

Temperature

Recommended

Setting

At Outside

Temperature

Recommended

Setting

-20°F (-29°C) Low +10°F (-12°C) Med

-10°F (-23°C) Low +20°F (-7°C) High

0°F (-18°C) Med Above 20° (-7°C) High

M13608

HE120 BY-PASS DRUM HUMIDIFIER

3 69-1110EF—02

MAINTAINING YOUR HUMIDIFIER

A regular maintenance program prolongs the life of your humidifier and provides a

more comfortable home. The frequency of cleaning will depend on the condition of

your water.

You can use either hard or soft water in your humidifier, but hard water mineral

deposits are more difficult to clean than soft water deposits.

Cleaning Humidifier

(Every 1 to 3 Months Depending on Water Quality)

CAUTION

Voltage Hazard.

Can cause electrical shock

and equipment damage.

Disconnect power and shut off water supply before installing or servicing.

IMPORTANT

Never oil any part of the humidifier.

Use the following steps to clean your Honeywell humidifier:

1. Disconnect the power and turn off the humidifier water supply.

2. Remove the humidifier cover by lifting the bottom of the cover upward.

3. Lift up the drum shaft from the bearing end and slide it out of the motor coupling

to remove the drum assembly. See Fig. 1.

NOTE: You will encounter some resistance when removing the drum shaft until you

hear an audible click.

4. Remove the drum from the assembly.

HE120 BY-PASS DRUM HUMIDIFIER

69-1110EF—02 4

Fig. 1. Removing Drive Assembly

5. Grasp the rubber valve seat between your thumb and forefinger and lift it upward

to remove the valve seat from the valve. The seat is located inside the humidifier

housing at the water valve opening. See Fig. 2.

Fig. 2. Float Valve Assembly

6. Raise up the float and remove the water pan.

M12252

WATER PAN

HUMIDIFIER

HOUSING

DRUM ASSEMBLY

BEARING END OF

DRUM SHAFT

COVER

WATER VALVE

OPENING

M13617

LIFT THE RUBBER VALVE SEAT UPWARD

TO REMOVE IT FROM THE VALVE

HE120 BY-PASS DRUM HUMIDIFIER

5 69-1110EF—02

7. Refer to the drawing to disassemble the drum. See Fig. 3.

Fig. 3. Drum Assembly

8. Clean all humidifier parts in a 50% solution of vinegar (or a humidifier cleaner)

and water. Soak overnight to remove stubborn deposits.

NOTE: Replace humidifier pad yearly with the new Honeywell Drum Humidifier Pad

(Part no. HC12A1015). The actual frequency depends on the quality of the

water used.

9. After the humidifier components are clean, reassemble the humidifier by

reversing the order of steps 1 through 7.

NOTE: Be sure that the drum shaft is completely seated-listen for the click.

10. Verify the humidifier operation by following the steps in the Checking Your

Humidifier Operation section.

Start of Humidification Season

Replace the humidifier pad with a new Honeywell Drum Humidifier Pad (Part no.

HC12A1015) at the beginning of the heating season. Follow the cleaning instructions

to replace the pad and check for proper operation.

End of Humidification Season

Clean the humidifier and shut it off at the end of the heating season. Follow the

cleaning instructions, steps 1 through 9, to shut down the device for the season.

OPEN

DRUM END

CLOSED DRUM END

METAL TABS

TINNERMAN

DRUM SHAFT

PAD

SQUEEZE

SLIGHTLY

TO INSTALL

M13609

HE120 BY-PASS DRUM HUMIDIFIER

69-1110EF—02 6

IMPORTANT

Be sure the humidifier power is off and the humidifier water pan is empty.

Vacation

When leaving on vacation, turn off the humidifier water supply and your humidity

control. Turn on the humidifier water supply and reset your humidity control when you

return.

CHECKING YOUR HUMIDIFIER OPERATION

After winter startup or maintenance, use the following steps to check the humidifier

operation:

1. Turn on the humidifier power and water supply.

2. Open By-Pass Damper (if installed).

3. Check the water level in the humidifier water pan; water level setting should be

1-3/8 in.

NOTE: Turn the valve adjustment screw, located on the water valve inside the

humidifier, clockwise to lower the water level and counter clockwise to raise it.

4. Turn the Humidity Control to the highest setting.

5. Check that the humidifier pad is rotating.

6. Reset the thermostat and Humidity Control to a comfortable setting.

TROUBLESHOOTING YOUR HUMIDIFIER

Problem What To Look For What To Do

Low humidity Furnace blower not

operating. •Reset circuit breaker or check for blown fuse.

•Check that the furnace power is on.

•Check all external wiring connections.

•Check the humidity control setting.

•Call a professional heating contractor.

Rapid air changes.

Drafts (cold air is dry

and is an added load

to the humidifier).

•Keep doors and windows closed.

•Close fireplace damper when not in use.

•Keep exhaust fan running time to a

minimum.

•Seal around doors and windows.

High humidity Condensation on

walls. •Turn off the humidity control and water until

condensation is completely evaporated.

Heavy condensation

on windows. •Turn humidity control down low enough to

eliminate condensation caused by moisture

from bathing, mopping, cooking, etc. If

moisture persists, more ventilation is

needed.

HE120 BY-PASS DRUM HUMIDIFIER

7 69-1110EF—02

LIMITED WARRANTY

Honeywell warrants this product to be free from defects in the workmanship or materials, under

normal use and service, for a period of one (1) year from the date of purchase by the consumer.

If, at any time during the warranty period, the product is defective or malfunctions, Honeywell

shall repair or replace it (at Honeywell’s option) within a reasonable period of time.

If the product is defective, return it, with a bill of sale or other dated proof of purchase, to the

retailer from which you purchased it.

This warranty does not cover removal or reinstallation costs. This warranty shall not apply if it is

shown by Honeywell that the defect or malfunction was caused by damage which occurred while

the product was in the possession of a consumer.

Honeywell’s sole responsibility shall be to repair or replace the product within the terms stated

above. HONEYWELL SHALL NOT BE LIABLE FOR ANY LOSS OR DAMAGE OF ANY KIND,

INCLUDING ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES RESULTING, DIRECTLY OR

INDIRECTLY, FROM ANY BREACH OF ANY WARRANTY, EXPRESS OR IMPLIED, OR ANY

OTHER FAILURE OF THIS PRODUCT. Some states do not allow the exclusion or limitation of

incidental or consequential damages, so this limitation may not apply to you.

THIS WARRANTY IS THE ONLY EXPRESS WARRANTY HONEYWELL MAKES ON THIS

PRODUCT. THE DURATION OF ANY IMPLIED WARRANTIES, INCLUDING THE

WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, IS

HEREBY LIMITED TO THE ONE YEAR DURATION OF THIS WARRANTY. Some states do not

allow limitations on how long an implied warranty lasts, so the above limitation may not apply to

you.

This warranty gives you specific legal rights, and you may have other rights which vary from state

to state.

If you have any questions concerning this warranty, please write Honeywell Customer Relations,

1985 Douglas Dr. N MN10-1461, Golden Valley, MN 55422 or call 1-800-468-1502, Monday-

Friday, 7:00 a.m. to 5:30 p.m., Central time. In Canada, write Honeywell Limited/Honeywell

Limitée, 35 Dynamic Dr., ON15, Scarborough, Ontario M1V4Z.

Automation and Control Solutions

Honeywell International Inc. Honeywell Limited-Honeywell Limitée

1985 Douglas Drive North 35 Dynamic Drive

Golden Valley, MN 55422 Toronto, Ontario M1V 4Z9

yourhome.honeywell.com

® U.S. Registered Trademark

69-1110EF—02 E.K. 05-09

GUIDE DU PROPRIÉTAIRE

69-1110EF-02

Humidificateur à dérivation

à tambour HE120

Contents

Fonctionnement de L'humidificateur ....................................................................... 10

Utilisation de L'humidificateur ................................................................................. 10

Entretien de L'humidificateur .................................................................................. 11

Vérification de L'humidificateur ............................................................................... 14

Dépannage de L'humidificateur .............................................................................. 15

HUMIDIFICATEUR À DÉRIVATION À TAMBOUR HE120

69-1110EF—02 10

FONCTIONNEMENT DE L'HUMIDIFICATEUR

L'humidificateur Honeywell fonctionne selon le principe suivant : de la vapeur (eau

évaporée) se forme lorsque l'air chaud passe sur une surface imbibée d'eau; en

circulant, la vapeur fait augmenter l'humidité relative.

Le régulateur d'humidité surveille l'humidité relative et fait fonctionner l'humidificateur

selon les besoins. L'humidificateur est muni d'un système d'alimentation qui distribue

uniformément de l'eau sur un tampon. L'air sec et chaud de l'appareil de chauffage

circule au-dessus du tampon et capte l'air humide pour le faire circuler dans la maison.

L'air humidifié semble plus chaud et il assure un meilleur confort; il est donc possible

d'abaisser le point de consigne du thermostat et, ainsi, de diminuer les coûts de

chauffage. Non seulement l'humidificateur assure plus grand confort, il permet de

réaliser des économies d'énergie.

UTILISATION DE L'HUMIDIFICATEUR

L'humidificateur Honeywell HE120 est commandé

par un régulateur d'humidité qui est installé soit sur

une gaine de retour d'air, soit sur un mur à l'intérieur

d'une pièce utilisée. Pour régler le régulateur

d'humidité, consulter l'échelle combinée de l'humidité

relative et de la température à l'extérieur apposée sur

le régulateur. Il faut tenir compte de la température à

l'extérieur pour optimiser le degré d'humidité et

réduire la condensation dans les fenêtres. Le tableau

ci-dessous peut également servir à choisir le réglage

recommandé.

REMARQUE : Lorsque la température à l'extérieur diminue, le point de consigne du

régulateur d'humidité doit être abaissé pour tenir compte des effets du

point de rosée. Ces réglages permettent de réduire l'accumulation de

condensation et de glace dans les fenêtres et ailleurs dans la maison.

Certaines activités comme la cuisson, les douches et le séchage des vêtements

peuvent produire une humidité excessive dans les fenêtres.

Température à

l'extérieur

Réglage

recommandé Température à l'extérieur

Réglage

recommandé

-29 °C (-20 °F) Bas -12 °C (+10 °F) Moyen

-23 °C (-10 °F) Bas -7 °C (+20 °F) Élevé

-18 °C (0 °F) Moyen Supérieure à -7 °C (20 °F) Élevé

M13608

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Sprachen:

Andere Honeywell Luftbefeuchter Handbücher

Honeywell

Honeywell HCM-750-TGT Bedienungsanleitung

Honeywell

Honeywell HE100A1000 Bedienungsanleitung

Honeywell

Honeywell TrueEASE HE100 Bedienungsanleitung

Honeywell

Honeywell HCM 800 - PermaFresh Cool Moisture... Bedienungsanleitung

Honeywell

Honeywell REFLECTION HUL900 Series Bedienungsanleitung

Honeywell

Honeywell HCM6011I - QuietCare Console Humidifer Bedienungsanleitung

Honeywell

Honeywell enviracaire Elite HE225A Bedienungsanleitung

Honeywell

Honeywell HM750 Bedienungsanleitung

Honeywell

Honeywell HUL535B Bedienungsanleitung

Honeywell

Honeywell MISTMATE HUL520BC Bedienungsanleitung

Honeywell

Honeywell Steam Humidifier Bedienungsanleitung

Honeywell

Honeywell HCM-890WTG Bedienungsanleitung

Honeywell

Honeywell HE420A Bedienungsanleitung

Honeywell

Honeywell TrueSTEAM Bedienungsanleitung

Honeywell

Honeywell HCM-710 Series Bedienungsanleitung

Honeywell

Honeywell Enviracaire Elite HE365A Bedienungsanleitung

Honeywell

Honeywell TrueSTEAM Series Bedienungsanleitung

Honeywell

Honeywell TrueSTEAM HM506 Bedienungsanleitung

Honeywell

Honeywell TrueEASE Bedienungsanleitung

Honeywell

Honeywell HM750A1000 Bedienungsanleitung

Honeywell

Honeywell HE120A Bedienungsanleitung

Honeywell

Honeywell HE360A - Whole House Powered Humidifier Bedienungsanleitung

Honeywell

Honeywell TrueSTEAM HM512 Gebrauchs- und Pflegehandbuch

Honeywell

Honeywell HM700A1000 Bedienungsanleitung

Beliebte Luftbefeuchter Handbücher anderer Marken

Bionaire

Bionaire CM1 Handbuch

Air-O-Swiss

Air-O-Swiss AOS 7131 Handbuch

KING

KING K 5002 Rainbow Bedienungsanleitung

Crane

Crane EE-6902 Bedienungsanleitung

Glaziar

Glaziar Ness Bedienungsanleitung

Philips

Philips DreamStation Go Abmessungen

Stadler Form

Stadler Form Hera Bedienungsanleitung

Hunter

Hunter 31206 Bedienungsanleitung

TaoTronics

TaoTronics TT-AH004 Bedienungsanleitung

adorini

adorini Cigar Heaven Bedienungsanleitung

Lanaform

Lanaform Aroma Bedienungsanleitung

Aprilaire

Aprilaire 800 Series Bedienungsanleitung

Pyle

Pyle SereneLife PHUMDIF8 Bedienungsanleitung

Trotec

Trotec B 200 Bedienungsanleitung

Pure Humidifier

Pure Humidifier EC Series Bedienungsanleitung

Crane

Crane EE-864 Bedienungsanleitung

air&me

air&me Solnan Bedienungsanleitung

weewell

weewell WHC730 Bedienungsanleitung