Hussmann SPECIALITY VR3/HV Series Bedienungsanleitung

/SPECIALTY

USER MANUAL

092019

MERCHANDISER

VR3/HV

DELI/BAKERY SERVICE

VR3 - VR3-D/B-4-R

- VR3-D/B-6-R

- VR3-D/B-8-R

- VR3-D/B-12-R

- VR3HV-D/B-4-R

- VR3HV-D/B-6-R

- VR3HV-D/B-8-R

- VR3HV-D/B-12-R Remote

General Information 3

Case Sections 4

Installation 6

Receiving Case 6

Lifting and Transport 7

 DrainConguration 7

Skid Removal 8

Lifting Points 8

Dollie Placement 8

Hardware Removal 8

Level Case 9

 LegAdjustment    9

Joint Trim Packlist 10

Setting and Joining 11

 ArmAdjustment 14

 GlassAdjustment 15

Body Panels Install 16

Refrigeration 17

Refrigerant Piping 17

Line Sizing 17

Oil Traps 17

Refrigerant Spec Sheet 19

Electrical 20

Merchandiser Electrical Data 20

Electrical Connections 20

Field Wiring 20

 IdenticationofWiring 20

Remove Rear Raceway 21

 ElectricalConduit(ElectricalBox) 21

Electrical Wiring Diagram 22

Table of Contents

User Information 30

Start Up 30

Load Limits 30

Basic Operation 30

Maintenance 31

Case Cleaning 31

 ExteriorSurfaces 31

 InteriorSurfaces 31

Troubleshooting 3

Case Descripon:

Description: Refrigerated Service Deli Merchandiser

ShippingDamage:Allequipmentshouldbethoroughlyexaminedforshippingdamagebeforeand

duringunloading.Thisequipmenthasbeencarefullyinspectedatourfactoryandthecarrierhas

assumedresponsibilityforsafearrival.Ifdamaged,eitherapparentorconcealed,claimmustbe

madetothecarrierImmediately.

ApparentLossorDamage:Ifthereisanobviouslossordamage,itmustbenotedonthefreightbill

orexpressreceiptandsignedbythecarrier’sagent;otherwise,carriermayrefuseclaim.Thecarrier

willsupplynecessaryclaimforms.

ConcealedLossorDamage:Whenlossordamageisnotapparentuntilafterallequipmentis

uncrated,aclaimforconcealeddamageismade.Makerequestinwritingtocarrierforinspection

within15days,andretainallpackaging.Thecarrierwillsupplyinspectionreportandrequiredclaim

forms.

Shortages:Checkyourshipmentforanypossibleshortagesofmaterial(SeePartsListpage9).If

ashortageshouldexistandisfoundtobetheresponsibilityofHussmannChino,notifyHussmann

Chino.Ifsuchashortageinvolvesthecarrier,notifythecarrierimmediately,andrequestan

inspection.HussmannChinowillacknowledgeshortageswithintendaysfromreceiptofequipment.

HussmannChinoProductControl:Theserialnumberandshippingdateofallequipmenthavebeen

recordedinHussmann’slesforwarrantyandreplacementpartpurposes.Allcorrespondence

pertainingtowarrantyorpartsorderingmustincludetheserialnumberofeachpieceofequipment

involved,inordertoprovidethecustomerwiththecorrectparts.

Location/StoreConditions:TheVR3HVrefrigeratedmerchandiserhasbeendesignedforuseonlyin

airconditionedstoreswheretemperatureandhumidityaremaintainedatorbelow75°FDrybulband

55%relativehumidity.DONOTallowairconditioning,electricfans,ovens,opendoorsorwindows

(etc.)tocreateaircurrentsaroundthemerchandiser,asthiswillimpairitscorrectoperation.

This equipment is to be installed

to comply with the applicable

NEC, Federal, State , and Local

Plumbing and Construction

Code having jurisdiction.

AT TENTION

INSTALLER

/CHINO

ApublicationofHUSSMANN®Chino

13770RamonaAvenue•Chino,California91710

(909)628-8942FAX

(909)590-4910

(800)592-2060

Keep this booklet with the case at all times for future reference.

General Information

VR3-D Vertical Glass

Standard Service Dome, Multi Deck Self Service

391/4 (997)

10 (254)

283/4 (730)

233/8 (594)

23 (584)

(356)

133/8

(340)

(152)

(1346)

337/8

(860)

117/8

(302)

optional

refrigerated or

dry storage

181/4

(464)

31/2

(89)

37/8

(98)

153/8

(391)

5/8 (1184)

VR3-D+4 Vertical Glass

Standard Service Dome, Multi Deck Self Service +4 Height

optional

refrigerated or

dry storage

391/4 (997)

10 (254)

233/8 (594)

(584)

171/2

(445) 12 (305)

16 (406)

(152)

(1448)

117/8

(302)

37/8

(98)

181/4

(464)

465/8 (1184)

375/8

(956)

153/8

(391)

31/2

(89)

283/4 (730)

Elec

drop

front close-off

Lower

Drain

Refrig

Upper

Drain

case leg

rear close-off

(152)

35/8 (92)

15(381)

93/4

(248) 91/8

(232)

103/8

(264)

VR3-D, VR3-B

7(178)4'

Length “A”

41(1041)6'

53(1346)8'

“B”

65(1651)

32(813)

44(1118)

56(1422)

77(1956)12'

End Panels

1/8 (29)

case front

(533)

“A”

“B”

465/8

(1184)

VR3-D+2 Vertical Glass

Standard Service Dome, Multi Deck Self Service +2 Height

optional

refrigerated or

dry storage

391/4 (997)

10 (254)

233/8 (594)

(584)

14 (356)

151/2

(394)

(152)

(1397)

117/8

(302)

31/2

(89)

357/8

(911)

37/8

(98)

153/8

(391)

465/8 (1184)

283/4 (730)

181/4

(464)

CaseSectionsVR3-D/B

VR3HV-D

Vertical Glass

High Volume Service Dome, Multi Deck Self Service

optional

refrigerated or

dry storage

505/8 (1286)

431/8 (1095)

12 (305)

14 (356)

23 (584)

(356)

3/4 (705)

(279)

227/8

(581)

5/8

(524)

(1397)

333/4

(857)

117/8

(302)

261/4 (667)

35/8

(92)

37/8

(98)

VR3HV-D -2 Vertical Glass

High Volume Service Dome,

Multi Deck Self Service -2" height

optional

refrigerated or

dry storage

505/8 (1286)

431/8 (1095)

12 (305)

14 (356)

23 (584)

3/4 (705)

(228)

227/8

(581)

(1346)

313/4

(806)

117/8

(302)

37/8

(98)

5/8

(524)

261/4 (667)

35/8

(92)

VR3HV-D +2 Vertical Glass

High Volume Service Dome, Multi Deck Self Service +2" height

optional

refrigerated or

dry storage

5/8

(524)

261/4 (667)

35/8

(92) 505/8 (1286)

431/8 (1095)

12 (305)

14 (356)

23 (584)

(356)

3/4 (705)

(330)

227/8

(581)

(1448)

353/4

(908)

117/8

(302)

37/8

(98)

(152)

Elec Refrig

Drain,

lower

Drain,

upper

back close-off

case legs front close-off

End

Panel 11/8

(29)

End

Panel

11/8

(29)

(381)

131/2

(343) 9

(229)

(533)

103/4

(273)

505/8

(1286)

37/8

(98)

35/8

(92)

7(178)4'

Length “A”

53(1346)8'

“B”

65(1651)

32(813)

56(1422)

77(1956)

12'

“A”

“B”

(1219)

(2438)

144

(3658)

VR3HV-D, VR3HV-B

CaseSectionsVR3HV-D/B

Unloading

NOTICE

Do NOT remove Foam Blocks from shelves

and glass until the merchandisers are

positioned for installation. Shelves or

merchandising glass may be damaged.

Loose

Items

Warning

Labels

Foam Blocks

in place

Boards

fastened

Case is to arrive at store as was shipped form fac-

tory.Seereferenceaboveforpropershipmentrefer-

encing.(Notactualcase)

Receiving Case

UponreceivingyournewHussmannCaseallequip-

mentshouldbethoroughlyexaminedforshipping

damagebeforeandduringunloading.Thisequipment

hasbeencarefullyinspectedatourfactory.Anyclaim

forlossordamagemustbemadetothecarrier.The

carrier will provide any necessary inspection reports

orclaimform.

Ifthereisobviouslossordamage,itmustbenoted

onthefreightbillorexpressreceiptandsignedbythe

carrier’sagent;otherwisecarriermayrefuseclaim.

VR3HV Lifting and Transport

Instructions

1.TheVR3HV-Dcanbeliftedbyaforkliftattypical

liftingpoints.

2.Ensurelowerbodypanelsareremovedbefore

liftingwithaforklift.Seriousdamagewilloccurif

thebodypanelsarenotremoved.(Shippedloose

fromfactory)

3.Makesurethatforkspacingandwidthwillnot

damagedrainorcomeincontactwithpiping,or

electrical lines

4.Besurethattheforksarelongenoughtosup-

portbeyondthecenterofthecasebutnotdam-

agenearcomponents.Checkforproperbalance

beforemoving.Aminimumforklengthof36”is

recommendedfor68”widecases

Installation(cont’d)

5.TheVR3HV-Dmerchandisercanberaisedatone

endunderneaththedeckwithaforkliftorJ-Barif

forklift is not accesible to allow the placement of

rollersordollies.

6.Evenlysupporttheentirebasestructureonrollers

ordolliesbeforeattemptingtomove.EachBase

Legmusthaveitsowndollietoproperlysupport

thecase.

WARNING

Improper placement of forks may damage

drainage piping. Use a spotter when placing

forks. Make sure that piping will not be dam-

aged. Use J-Bars or Jacks if forks cannot be

used safely

LiftingPointsaretypicalanddependentuponsizeof

caseandrefrigerationapplication,drainagecongu-

rationswillcallforaltercationsinLiftingZones.

Belowarethefollowingdrainagecongurationsand

liftingshouldbealteredtotheexpectedmodel.

Service Drain

Bottom Drain

4’ Case

8’ Case

12’ Case

VR3HV-D Drain Location

Skid Removal

Important: Seeliftinginstructionstoproperlyliftcase

whenbeingplacedondolliesorpermanentlocation.

(Seepage6forLiftingInstructions.)

Lifting Points

Leaveallhardwareandttingsinplaceuntilcaseis

locatedatornearitspreferredlocation.Usingforklift

orJ-Barliftthecasefromthe2x4boardsandplacing

dolliesunderneatheachbaseleg,proceedtomov-

ing the case to its designated location if not done so

already.

Dollie Placement

TheIllustrationbelowdemonstratesperfectplace-

ment of a dollie per 1 side for both base legs of the

merchandiser.

IF APPLICABLE

(NOT ALL CASES

CARRY LEG BRACES)

Installation(cont’d)

Movethextureascloseaspossibletoitsperma-

nent location and then remove all packaging and

preparetoremoveoffSkid.Removeallseparately

packedaccessoriessuchaskits,andpanels.Check

fordamagebeforediscardingpackaging.

Hardware Removal

Remove screws as well as fastened plates bolted to

each2x4boardateachbaseleg.

Removefastenedplatesonlyupperbracelegsareto

remainfastenedontocase.

Fastened plate

OncethefastenedplatesareremovedaJ-Barcan

beusedtoliftateachendofthelegbracestore-

movethebelow2x4boards.

Installation(cont’d)

Level Case

Positionthecaseatthehighestpoint.Setalong

magnetizedlevel(4ft[1220mm]ormore)on

eitherunderneaththedeckorontopofthecase.

Ensuretolevelcasefromfronttobackandside

toside.

Level

(4 ft[1220mm])

Leg Adjustment

Adjustthelegsateachcornerofthecaseto

leveloutanydiscrepanciesinordertooptimize

caseperformanceandproperdrainage. Note:Toavoidremovingconcreteooring,begin

lineuplevellingfromthehighestpointofthe

storeoor.

Awrenchorpliersmaybeusedtoadjusteach

baseleg.

• Turningthebaseofeachlegclockwisewill

lowertheheightofthecase.

• Turningthebaseofeachlegcounter-

clockwisewillraisetheheightofthecase.

Level

(4 ft[1220mm])

Joint Trim Packlist

CHK ITEM PART # QTY GRAPHIC

□

FRONT BODY PANEL TRIM 2H20345(STAINLESS)

2H20345 (EXT COLOR) 1A

□

TOE KICK TRIM TBD (EXT COLOR)

TBD (STAINLESS) 1B

□

SELF SERVICE BULKHEAD CAP 2H20347 (STAINLESS) 1 C

□

SERVICE BULKHEAD CAP 2H20348 (STAINLESS) 1 D

□

REAR ARM TRIM 2H20346 (STAINLESS) 1 E

□

REAR TOE KICK TRIM 2H22014 (STAINLESS) 1 F

□UPPER FRONT BODY PANEL TRIM 2H20344 (EXT COLOR)

2H20344 (STAINLESS)

□REAR UPPER RACEWAY TRIM 2H20350(STAINLESS) 1 H

□REAR LOWER RACEWAY TRIM 2H20351(STAINLESS) 1 I

□

WASHER , 3/8"

300-03-1320

□

BOLT, 3/8 - 16 X 8

300-03-0902

□

GASKET SEAL TAPE

225-01-0628

16 FT L

□

SEALANT, BUTYL, TUBE

100-01-0121

□

ALIGNMENT PIN

0376408

□

SPLINE H CHAN POLY 4 1/2

200-02-3022

□

JOINING NYLON WASHER

2H04205800

□

BOLT, 3/8 - 16 X 1.5

300-03-0850

□

NUT,3/8-16

300-03-1370

2H21696 (EXT COLOR)

2H21696 (STAINLESS)

□

SEALANT, SILICONE, TUBE

100-01-0051 (CLEAR)

100-01-0063 (SILVER)

100-01-0065 (BLACK)

□

SCREW, SELF TAP #8 X 1/2

300-03-0037

12 -

□

VHB DOUBLE-SIDED TAPE

175-01-0562

16 FT -

□

COUPLING, 2" PVC

225-01-0090

1TRIM JOINT FRONT PLEX 6IN

□S

REV E 01/21/2016

VR3HV/VR3/ JOINT CHECKSHEET INSPECTOR _________________

SALES ORDER # _____________

EXT COLOR _________________

INT FINISH __SS__/__BLACK___

A JK*

JK*

JQR*

JQRP*

JQR*

*SEE INSTALLATION GUIDE

INDICATES CASE BOLTING/ALIGNMENT POINT

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Hussmann Kaufmann Handbücher

Hussmann

Hussmann ASCS Bedienungsanleitung

Hussmann

Hussmann FWG Bedienungsanleitung

Hussmann

Hussmann RHR-HEX Bedienungsanleitung

Hussmann

Hussmann P1X50-EP Bedienungsanleitung

Hussmann

Hussmann IMPACT ED1 Bedienungsanleitung

Hussmann

Hussmann VR3-M-EP Original Betriebsanleitung

Hussmann

Hussmann Q3-BC Bedienungsanleitung

Hussmann

Hussmann Specialty Products CR3M-F Bedienungsanleitung

Hussmann

Hussmann IMPACT D5NGE Bedienungsanleitung

Hussmann

Hussmann CID Betriebsanleitung

Hussmann

Hussmann LNG Bedienungsanleitung

Hussmann

Hussmann IMPACT RL Bedienungsanleitung

Hussmann

Hussmann GGSM Kurzanleitung

Hussmann

Hussmann Impact M1E Bedienungsanleitung

Hussmann

Hussmann IMPACT RL Bedienungsanleitung

Hussmann

Hussmann IMPACT Excel B4X-E Bedienungsanleitung

Hussmann

Hussmann EVM Kurzanleitung

Hussmann

Hussmann Impact Excel C6X-E Bedienungsanleitung

Hussmann

Hussmann IMPACT RLNIE Bedienungsanleitung

Hussmann

Hussmann LIE Bedienungsanleitung

Hussmann

Hussmann Impact PWWSP49 Bedienungsanleitung

Hussmann

Hussmann M4EP Bedienungsanleitung

Hussmann

Hussmann Impact Excel M5X Bedienungsanleitung

Hussmann

Hussmann impact Excel C5X-LEP Bedienungsanleitung

Beliebte Kaufmann Handbücher anderer Marken

FRIGOGLASS

FRIGOGLASS Flex 20 HC Bedienungsanleitung

EPTA

EPTA COSTAN RHINO MULTI Bedienungsanleitung

CASCO

CASCO Nano Cube Bedienungsanleitung

True

True GDIM-26 Bedienungsanleitung

Structural Concepts

Structural Concepts Oasis Mobile Series Montageanleitung

Haussmann

Haussmann RL Bedienungsanleitung

Howard McCray

Howard McCray R-CDS32E-4 Bedienungsanleitung

EPTA

EPTA iarp Cool Emotions Delight Lite Bedienungsanleitung

VALERA

VALERA BC 85 Bedienungsanleitung

HL Display

HL Display 3eBin Bedienungsanleitung

Dixie Narco

Dixie Narco DNCB 501E Bedienungsanleitung

APW Wyott

APW Wyott Racer DMXD-30H Bedienungsanleitung

Hoshizaki

Hoshizaki KD-90C Bedienungsanleitung

Summit

Summit SCR1006 Bedienungsanleitung

Delfield

Delfield Shelleyspeed SPM-28E Bedienungsanleitung

EPTA

EPTA iarp Cool Emotions GLEE 40 Bedienungsanleitung

Kysor/Warren

Kysor/Warren GranBering KW Leitfaden

Crane

Crane BevMAX Refresh 6 Media Bedienungsanleitung