JL Audio C2-400x Bedienungsanleitung

OWNER’S MANUAL

Thank you for choosing a JL Audio Evolution™ C2 Coaxial Speaker System

for your automotive sound system.

These Evolution™ Speakers have been designed and manufactured to

exacting standards in order to ensure years of musical enjoyment in your

vehicle. For maximum performance, we highly recommend that you have

your new speakers installed by an authorized JL Audio dealer. Your

authorized dealer has the training, expertise and installation equipment

to ensure optimum performance from this product. Should you

decide to install the speakers yourself, please take the time

to read this manual thoroughly so as to familiarize yourself

with its installation requirements and setup procedures.

If you have any questions regarding the instructions in this

manual or any aspect of your amplifier’s operation, please contact your

authorized JL Audio dealer for assistance. If you need further assistance,

please call the JL Audio Technical Support Department

at (954) 443-1100 during business hours.

4.00-inch (100 mm) Coaxial Loudspeakers

2 | JL Audio - C2-400x Owner’s Manual

Due to ongoing product development, all specifications are subject to change without notice.

Woofer Physical Dimensions

Frame Outer Diameter (A) 4.02 in. / 102.0 mm

Grille Tray Outer Diameter (B) 5.20 in. / 132.2 mm

Magnet Outer Diameter (C) 2.36 in. / 60.0 mm w/o cover

Frontal Tweeter Protrusion (D) 0.56 in. / 14.3 mm

Frontal Grille Protrusion (E) 0.66 in / 16.7 mm

Mounting Hole Diameter (F) 3.81 in. / 96.8 mm

Mounting Depth (G) 1.81 in. / 46.0 mm w/o cover

2 | JL Audio - C2-400x Owner’s Manual

C2-400x SPECIFICATIONS:

Woofer: Injection-molded, Mica-filled, Polypropylene Cone,

Butyl Rubber Surround, 1 in. Voice Coil on Kapton® Former,

Flat, Symmetrical Roll Spider, Ferrite Magnet

Tweeter: 0.75 in. (19 mm) Silk Dome, Ferrofluid Cooling /

Damping, Neodymium Magnet

Crossover: Natural Roll-Off Low-Pass, 1st Order High-Pass

Filter with Electrolytic Capacitor

Continuous Power Handling: 35 Watts

Recommended Amp Power: 10-50 Watts per channel (RMS)

Efficiency: 84.5 dB @ 1W/1m | 90.5 dB @ 1W/0.5m

Sensitivity: 87.5 dB @ 2.83V/1m

Nominal Impedance: 4 ohm

Frequency Response: 71 Hz - 22 KHz ± 3 dB

Included Components and Parts:

• Two C2-400x 4.0-inch (100mm) Coaxial loudspeakers

• Two Grille Assemblies

• Eight #8 x 1-inch (25mm) sheet metal screws

• Eight Mounting Clips

• Two 4x6-inch (100 x 150 mm) Adaptor Plates

• Two 5.2 mm female crimpable connectors

• Two 2.8 mm female crimpable connectors

• Four #8 x 0.315-inch (8 mm) sheet metal screws

• Two self-adhesive JL Audio logo name badges

GETTING STARTED

•Turnofftheaudiosystem.Itisalso

advisabletodisconnectthenegative(–)

terminalofyourvehicle’sbatterywhenever

performinginstallationwork.

•Beforecutting,drillingorinsertinganyscrew,

checkclearancesonbothsidesoftheplanned

mountingsurface.Alsocheckforanypotential

obstacles,suchaswindowtracksandmotors,

wiringharnesses,etc.Checkbothsidesofthe

vehicle,manyvehiclesarenotsymmetrical!

•Alwayswearprotectiveeyewear.

SPEAKER PLACEMENT CONSIDERATIONS

Inmostcases,yourspeakerswillbeplacedinto

factoryspeakerlocations.Ifyouhavesomespeaker

mountingflexibility,keepthefollowinginmind:

Lowermountinglocations,suchasthelowerfront

cornerofadoororakick-panelprovidethegreatest

pathlengthdistancesforthesoundemittedbythe

speakers.Forthisreason,theyaregenerallymore

desirablethanhighermountinglocations.Higher

mountinglocationswillusuallyresultinextreme

near-sidesoundstagebiaswhichcompromisesthe

stereolisteningexperience.

4 | JL Audio - C2-400x Owner’s Manual

Itisabsolutelyvitalthatthespeakerframe

fitsintothemountingholecleanly.Thismustbe

checkedpriortotighteningthescrews.Donot

forcetheframeintoaholethatistoosmall.Do

nottightenthespeakerontoanunevensurface.

Thiswilldamageyourspeakers.Thespeaker

shouldalsofitsothatairdoesnotleakaround

themountingflange.Airleakswillcauseasevere

degradationinsoundquality.Sealanyairleaks

withanautomotive-gradesealantmaterial.

InstallasshowninDiagramA(page5).Usethe

suppliedmountingclipsunlessthefactoryholes

alreadyfeaturethreadedinserts.Hand-tightenthe

screwsevenlytoavoidbendingthespeakerframe!

Custom Location:Runspeakerwiretothe

desiredmountinglocation.Ifyouarerunning

wiresintoadoor,useexistingfactorywiringboots

wheneverpossible.Ifyouaredrillingnewholes,file

theiredgesandinstallrubbergrommetsintoeach

hole.Then,coverthewireswithaprotectivePVC

sleeveandrunthemthroughthedoorjamb.Make

surethatthewireswillcleardoorhingesandother

structuresinthedoor.Ifyouareunsureaboutany

partofthisprocess,pleasecontactyourJLAUDIO

dealerforinstallationhelp.

WARNING



Double check the clearance for both speakers

before proceeding. Many cars are different from

one side to the other!

Selectanevensurface.Tighteningaspeakeronto

anunevensurfacecandamageit.Usethesupplied

templatetomarkthedesiredmountinglocation.Mark

thecenterandtheoutlineofthemountingholeas

wellasthemountingscrewpositions.Beforedrilling

orcuttingonyourinteriorpanels,useautilityknife

tocutanyfabric,vinylorleatherfromholelocations.

Thesematerialscaneasilybesnaggedbyadrillor

asaw,causingdamagetothepanelandpossible

bodilyinjury.Drillfour1/8-inch(3mm)holesforthe

speaker’smountingscrewsatthepositionsyouhave

marked.Alsodrillapilotholeinthecenterofthe

speakermountingholeatthistime.

SPEAKER INSTALLATION

Thespeakershouldbeinstalledinoneofthe

followingwaysdependingonlocation:

Factory Location:Ifyouwillbeusingthefactory

speakerwires,itmaybenecessarytochangethe

terminations.Thismaybeaccomplishedbyusingan

adaptorplugorsimplybycuttingthefactoryconnector

offandusingthesuppliedcrimpconnectorsto

terminatethespeakerwires.Thelargeconnectorisfor

thepositiveterminalandthesmallconnectorisforthe

negativeterminalofeachC2-400x.

Youmayalsochoosetorunnewspeakerwires...

Runspeakerwiretothedesiredmounting

locations.Ifyouarerunningwiresintoadoor,use

existingfactorywiringbootswheneverpossible.If

youaredrillingnewholes,filetheiredgesandinstall

rubbergrommetsintoeachhole.Wiresshouldthen

becoveredwithaprotective,flexiblePVCsleeveand

thenrunthroughthedoorjamb.Makesurethatthe

wireswillcleardoorhingesandotherstructuresin

thedoor.Ifyouareunsureaboutanypartofthis

process,pleasecontactyourJLAudiodealerfor

installationhelp.

WARNING



Double check the clearance for both speakers

before proceeding. Many cars are different from

one side to the other!

Yournewspeakershavebeendesignedtoinstall,

withoutmodifications,intomostvehiclesthataccept

a4.0-inch(100mm)speakeror4x6-inchoval

speaker(adaptorplatesaresuppliedforthelatter).

Mostfactory4.0-inchspeakersusefourmounting

screwswhichwilllineupwiththemountingholes

onyourC2-400xspeakers.Insomevehicles,only

twomountingholesareusedandthereisinsufficient

clearanceforthetwoextramountingtabs.Ifthis

isthecase,bendtheredundanttabsbackandforth

untiltheybreakoff(allfourtabsontheC2-400xare

perforatedforthispurpose).Afterbreakingoffthe

unwantedtabs,pleasehandlethespeakercarefully,

asthebrokenedgesmaybesharp.

4 | JL Audio - C2-400x Owner’s Manual

Then,usingasabersaw,makethecircularcutoutfor

thespeaker.Fileanyroughedges.Insertthemounting

clipswiththeflatsidetowardsthespeakerasshownin

DiagramB(below).

Itisabsolutelyvitalthatthespeakerframefitsinto

themountingholecleanly.Thismustbecheckedprior

totighteningthescrews.Donotforcetheframeintoa

holethatistoosmall.Donottightenthespeakeronto

anunevensurface.Thiswilldamageyourspeakers.

Thespeakershouldalsofitsothatairdoesnotleak

aroundthemountingflange.Airleakswillcausea

severedegradationinsoundquality.Sealanyairleaks

withanautomotive-gradesealantmaterial.

Diagram A:

Factory Location Woofer Installation

WARNING

Hand-tighten the screws evenly in a criss-cross

pattern to avoid bending the speaker frame or

stripping the mounting clips.

Connectthespeakerwires,observingcorrect

polarity,andinstallthespeakerandgrilleassembly

asshowninDiagramB(below).Hand-tightenthe

screwsevenlytoavoidbendingthespeakerframe!

TheincludedJLAudiologonamebadgesshould

beaffixedtothecircularindentedareainthelower

partofeachgrilleassembly.Ifthegrilleassemblyis

notused,theJLAudiologobadgescanbeaffixed

elsewhereascreativeadditionstoyourinstallation.

Diagram B:

Custom Location Woofer Installation

6 | JL Audio - C2-400x Owner’s Manual

NOTES

6 | JL Audio - C2-400x Owner’s Manual

NOTES

LIMITED WARRANTY  AUTOMOTIVE SPEAKER SYSTEMS USA

JLAUDIOwarrantsthesespeakers(andcrossovernetworks,whereapplicable)tobefreeofdefectsin

materialsandworkmanshipforaperiodofone (1) year.

Thiswarrantyisnottransferableandappliesonlytotheoriginalpurchaserfromanauthorized

JLAUDIOdealer.Shouldservicebenecessaryunderthiswarrantyforanyreasonduetomanufacturing

defectormalfunction,JLAUDIOwill(atitsdiscretion),repairorreplacethedefectiveproductwithnewor

remanufacturedproductatnocharge.Damagecausedbythefollowingisnotcoveredunderwarranty:accident,

misuse,abuse,productmodificationorneglect,failuretofollowinstallationinstructions,unauthorizedrepair

attempts,misrepresentationsbytheseller.Thiswarrantydoesnotcoverincidentalorconsequentialdamages

anddoesnotcoverthecostofremovingorreinstallingtheunit(s).Cosmeticdamageduetoaccidentornormal

wearandtearisnotcoveredunderwarranty.

Anyapplicableimpliedwarrantiesarelimitedindurationtotheperiodoftheexpresswarrantyasprovided

hereinbeginningwiththedateoftheoriginalpurchaseatretail,andnowarranties,whetherexpressorimplied,

shallapplytothisproductthereafter.Somestatesdonotallowlimitationsonimpliedwarranties,therefore

theseexclusionsmaynotapplytoyou.Thiswarrantygivesyouspecificlegalrights,andyoumayalsohaveother

rightswhichvaryfromstatetostate.



If you need service on your JL AUDIO product:

AllwarrantyreturnsshouldbesenttoJLAUDIOfreightprepaidthroughanauthorizedJLAUDIO

dealerandmustbeaccompaniedbyproofofpurchase(acopyoftheoriginalsalesreceipt.)Direct

returnsfromconsumersornon-authorizeddealerswillberefusedunlessspecificallyauthorizedby

JLAUDIOwithavalidreturnauthorizationnumber.Warrantyexpirationonproductsreturned

withoutproofofpurchasewillbedeterminedfromthemanufacturingdatecode.Coveragemaybe

invalidatedasthisdateisprevioustopurchasedate.Returnonlydefectivecomponents.Ifonespeaker

failsinasystem,returnonlythatspeakercomponent,nottheentiresystem.Non-defectiveitems

receivedwillbereturnedfreight-collect.Customerisresponsibleforshippingchargesandinsurance

insendingtheproducttoJLAUDIO.Freightdamageonreturnsisnotcoveredunderwarranty.

For Service Information in the U.S.A. please call

JL Audio Customer Service: (954) 443-1100

9:00 AM – 5:30 PM (Eastern Time Zone)

JL Audio, Inc

10369 North Commerce Pkwy.

Miramar, FL 33025

International Warranties:

Products purchased outside the United States of America are covered only

by that country’s distributor and not by JL Audio, Inc.

C2-400x-06112008

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere JL Audio Autolautsprecher Handbücher

JL Audio

JL Audio C5-570X Bedienungsanleitung

JL Audio

JL Audio SB-F-Edg Bedienungsanleitung

JL Audio

JL Audio TR650-CSi Bedienungsanleitung

JL Audio

JL Audio Stealthbox SB-POL-RZG2SPKR/MX650 Bedienungsanleitung

JL Audio

JL Audio Stealthbox SB-GM-AVAL/12W3v3 Bedienungsanleitung

JL Audio

JL Audio C2-570x Bedienungsanleitung

JL Audio

JL Audio C2-650x Bedienungsanleitung

JL Audio

JL Audio C5-525x-02082008 Bedienungsanleitung

JL Audio

JL Audio VR525-CSi Bedienungsanleitung

JL Audio

JL Audio Evolution C5-570x Bedienungsanleitung

JL Audio

JL Audio C2-690tx Bedienungsanleitung

JL Audio

JL Audio C2-350x Bedienungsanleitung

JL Audio

JL Audio XR570-CSi Bedienungsanleitung

JL Audio

JL Audio VR650-CSi Bedienungsanleitung

JL Audio

JL Audio C2-525x Bedienungsanleitung

JL Audio

JL Audio M770-CCS Bedienungsanleitung

JL Audio

JL Audio C2-600x Bedienungsanleitung

JL Audio

JL Audio Stealthbox SB-F-EDG2G/10TW1 Bedienungsanleitung

JL Audio

JL Audio C3-100ct Bedienungsanleitung

JL Audio

JL Audio Evolution C5-650 Bedienungsanleitung

JL Audio

JL Audio stealthbox SB-J-WRUD/10TW1 Bedienungsanleitung

JL Audio

JL Audio SB-F-SUPRCNSL/10W3v2 Bedienungsanleitung

JL Audio

JL Audio 94607 Bedienungsanleitung

JL Audio

JL Audio XR570-CXi Bedienungsanleitung

Beliebte Autolautsprecher Handbücher anderer Marken

Blaupunkt

Blaupunkt GTt 300 Technisches Datenblatt

Boston Acoustics

Boston Acoustics SX55 Bedienungsanleitung

Kenwood

Kenwood KFC-W212 Bedienungsanleitung

VR3

VR3 Elite VRS653 Bedienungsanleitung

Premier

Premier TS-W3001D4 Bedienungsanleitung

Infinity

Infinity 6530cx Bedienungsanleitung

Focal

Focal K2 Power 165 KRX3 Bedienungsanleitung

Precision Power

Precision Power PPI4.2 Bedienungsanleitung

Mopar

Mopar 2011-UP Bedienungsanleitung

Jensen

Jensen XS Series Bedienungsanleitung

Blaupunkt

Blaupunkt GTx Series Bedienungsanleitung

AudioBahn

AudioBahn AT60 Bedienungsanleitung

Focal

Focal BombA 27 V1 Bedienungsanleitung

Blueant

Blueant S1 Bedienungsanleitung

Naxa

Naxa NCS-768 Bedienungsanleitung

Focal

Focal Polyglass 130 VRS Bedienungsanleitung

Boston Mobile Audio

Boston Mobile Audio SR80 Bedienungsanleitung

Blaupunkt

Blaupunkt GTx 352 DE Bedienungsanleitung