JL Audio Stealthbox SB-GM-CAM6G/12TW3 Bedienungsanleitung

INSTALLATION GUIDE

for the

SB-GM-CAM6G/12TW3

SKU# 94633

2016 & Up Chevrolet Camaro Coupe

Thank you for choosing a JL Audio Stealthbox® for your automotive sound system.

With proper installation, your new vehicle-specific enclosed subwoofer system

will deliver years of listening pleasure.

We strongly recommend that you have your new Stealthbox® installed by your

authorized JL Audio dealer. The installation professionals employed by your

dealer have the necessary tools and experience to disassemble and reassemble

your vehicle properly. If you prefer to perform your own installation, please read

this installation guide completely before beginning the process.

If you choose to perform the installation yourself, it is absolutely

vital that the Stealthbox®be properly mounted to the vehicle

according to these instructions. Failure to mount the enclosure

properly presents two problems:

1) The sub-bass performance will suffer due to the movement of the

enclosure caused by the force exerted by the woofer(s).

2) A loose enclosure presents a serious safety hazard in the event of a

collision or sudden deceleration.

INSTALLATION

DIFFICULTY:

ESTIMATED TIME:

1 HOUR

Enclosure Type: Sealed

Driver Type: 12TW3-D4

Nominal Impedance: 2 ohms

Continuous Power Handling: 400 watts (RMS method)

Continued on Next Page

OUT

SB-GM-CAM6G/12TW3 INSTR_SKU# 011465

INCLUDED HARDWARE

Continued on Next Page

Page 2 • JL Audio, Inc., 2016

SB-GM-CAM6G/12TW3 INSTR_SKU# 011465

BOM ID Qty SKU Description

1 2 151079 3/8 - 16 x 1” Hex Head Bolt

2 2 151081 3/8” Lock Washer

3 1 151140 3/8 - 16 U-Nut

4 5 151126 3/8” Fender Washer

5 1 153777 Rear Bracket

6 3 151123 3/8 - 16 Hex Nut

7 1 153640 3/8 - 16 x 2-1/2” Set Screw

8 2 153775 5/16 - 18 x 1” Carriage Bolt

9 2 153776 3/4” OD x 5/16” ID x 1/4” Aluminum Spacer

10 2 151021 1/4” Flat Washer

11 2 150929 5/16” Lock Washer

12 2 153601 5/16 - 18 Hex Nut

13 1 153778 Top Bracket

14 2 151137 1/4 - 20 x 1” Hex Head Bolt

15 2 151098 1/4” Lock Washer

16 2 153598 5/16” Standard Washer

- 1 151984 Trimming Template (not shown)

POWER RECOMMENDATION

JL Audio recommends high quality ampliers such as the JL Audio XD300/1v2. The diagram below shows the recommended crossover settings for the XD300/1v2. For a detailed description of the

amplier settings, consult the owner’s manual for the amplier. If another amplier is being used, please reference this illustration and use similar settings on that amplier.

Rem. |Oset | Signal

Input Voltage

Low | High

Turn-On Mode

Monoblock Subwoofer Amplifier

CONNECTIONS

Using quality power, signal, and speaker wire is essential in ensuring the performance of your Stealthbox®. JL Audio recommends using a 4 AWG power kit such as the XD-PCS4-1B for your

Stealthbox® amplier. Other kits are available should you be using more than one amplier. Signal wire such as the JL Audio Premium Audio Interconnect Cables should be used to provide signal for

both channels of the amplier. JL Audio recommends using 12AWG speaker wire for subwoofers such as our XC-BCS12-25.

Continued on Next Page

Page 3 • JL Audio, Inc., 2016

SB-GM-CAM6G/12TW3 INSTR_SKU# 011465

Page 4 • JL Audio, Inc., 2016 Continued on Next Page

STEP 8

Locate the two indicated holes in the factory

brace on the driver’s side.

STEP 7

Remove the driver’s side trunk liner panel from

the vehicle.

STEP 6

Remove the front clip from the driver’s side

trunk liner panel.

STEP 5

Fold down the rear seat, remove the two clips

from the center trunk liner panel, and remove

the panel from the vehicle.

STEP 4

Remove the lower clip from the driver’s side

trunk liner panel.

STEP 3

Remove the upper clip from driver’s side trunk

liner panel.

STEP 2

Remove the trunk floor panel from the vehicle.

Unscrew the four clips from the rear sill panel,

and remove the panel from the vehicle.

STEP 1

Empty the trunk of the vehicle.

SB-GM-CAM6G/12TW3 INSTR_SKU# 011465

Page 5 • JL Audio, Inc., 2016 Continued on Next Page

STEP 16

Pictured is the driver’s side trunk liner panel

with a thin, pale outline of the Trimming

Template. Carefully cut the panel on the line.

Note the wire harness located in the area

behind the panel to avoid damaging while

cutting.

STEP 15

Position the Trimming Template to the driver’s

side trunk liner panel as shown. The base of

the Trimming Template should rest on the

lower floor section of the panel, and the right

side of the Trimming Template should be

aligned with the vertical indentation.

Use a grease pencil or similar to outline the

Trimming Template onto the panel.

STEP 14

Slide a 3/4” OD x 3/8” ID, 1/4” Aluminum Spacer

over each of the 5/16 - 18 x 1” Carriage Bolts,

followed by the wide flange of the Top Bracket,

as shown.

Secure the Top Bracket with a pair of 1/4” Flat

Washers, 5/6” Lock Washers, and 5/16 - 18 Hex

Nuts as shown, and hand tighten.

STEP 13

The Top Bracket is not symmetrical, with one

mounting flange wider than the other. The

Top Bracket should be installed with the wider

mounting flange positioned at the top.

STEP 12

Reach through the large hole in the driver’s

side of the rear deck, and drop a 5/16 - 18 x 1”

Carriage Bolt down through each of the holes

indicated in the previous step.

STE P 11

Locate the two indicated holes in the rear deck

on the driver’s side.

STEP 10

Thread a 3/8 - 16 x 2-1/2” Set Screw into the

3/8 - 16 U-Nut leaving approximately 1-1/4”

protruding inward.

STEP 9

Slide a 3/8” Lock Washer and a 3/8” Fender

Washer over a 3/8 - 16 x 1” Hex Head Bolt.

Thread the assembly through one of the holes

indicated in the previous step from the back of

the brace, through a hole in the Rear Bracket.

Secure with a 3/8” Fender Washer and a 3/8 - 16

Hex Nut from the front. Repeat the process for

the second hole, and fully tighten.

Slide a 3/8 - 16 U-Nut over the center hole as

shown.

SB-GM-CAM6G/12TW3 INSTR_SKU# 011465

This side up

2.21”

1.59”

Page 6 • JL Audio, Inc., 2016

MID/HIGH FREQUENCY DRIVER FITMENT

A variety of JL Audio coaxial and component systems will t in the factory speaker locations of you vehicle.

Front Speaker Size / Location: 6”x9” - Front Doors

Fits JL Audio Models: TR690-TXi & C2-690tx

Rear Speaker Size / Location: 6-1/2”- Rear Side Panel

Fits JL Audio Models: TR650-CXi, TR650-CSi, C2-650x, C2-650,

C3-650, C5-650x, C5-650, & ZR650-CSi

(954) 443-1100

www.jlaudio.com

JLA-SKU# 011465 • ver. 10.27.2016 • 10369 NORTH COMMERCE PARKWAY • MIRAMAR, FLORIDA • 33025 • USA

CONGRATULATIONS!

You have completed the installation for this model! Enjoy your new Stealthbox®!

SB-GM-CAM6G/12TW3 INSTR_SKU# 011465

STEP 19

Slide a 1/4” Lock Washer and a 5/16” Standard

Washer over each of the 1/4 - 20 x 1” Hex Head

Bolts. Thread the assemblies through the

lower holes in the Top Bracket, into the

threaded inserts in the top of the enclosure,

and hand tighten.

STEP 18

Remove the woofer from the Stealthbox®.

Connect speaker cable to the terminal cup on

the side of the enclosure. Slide the enclosure

into position under the Top Bracket, allowing

the 3/8 - 16 x 2-1/2” Set Screw installed in Step

10 to pass through the hole in the Stealthbox®.

Thread a 3/8” Fender Washer and a 3/8 - 16 Hex

Nut over the 3/8 - 16 x 2-1/2” Set Screw, and

hand tighten.

STEP 17

Reinstall the driver’s side trunk liner panel.

Reinstall the clips removed in Steps 4-6.

STEP 20

Fully tighten the hardware from Step 18 first,

then fully tighten the hardware installed in

Steps 19 and 14.

Reinstall the subwoofer. Route the speaker

cable as necessary.

All specifications are subject to change without notice. “JL Audio®” and the JL Audio logo, and “Stealthbox” and the Stealthbox logo are registered trademarks of JL Audio, Inc. “Ahead of the

Curve”, its respective logo, and“How we play” are trademarks of JL Audio, Inc.

Andere JL Audio Subwoofer Handbücher

JL Audio

JL Audio Stealthbox SB-GM-TRKEXT/10W1v2/BK Bedienungsanleitung

JL Audio

JL Audio 10W6V2-D4 Bedienungsanleitung

JL Audio

JL Audio 12W3v3-2 Bedienungsanleitung

JL Audio

JL Audio Stealthbox SB-D-5GRAMCCF/12TW3 Bedienungsanleitung

JL Audio

JL Audio Stealthbox SB-J-JK2DR/10W1v3 Bedienungsanleitung

JL Audio

JL Audio Fathom f112 Bedienungsanleitung

JL Audio

JL Audio 15W3v2-D2 Bedienungsanleitung

JL Audio

JL Audio 12W1v2-4 Bedienungsanleitung

JL Audio

JL Audio Stealthbox SB-H-CIVCPE/12W3v2 Bedienungsanleitung

JL Audio

JL Audio Stealthbox SB-N-PTHFNDR2/10W3v3 Bedienungsanleitung

JL Audio

JL Audio Stealthbox SB-SMRT-4-2/8W3v3 Bedienungsanleitung

JL Audio

JL Audio Stealthbox SB-F-TRKCTR3/10W3 Bedienungsanleitung

JL Audio

JL Audio Stealthbox SB-N-350/10W3v2 Bedienungsanleitung

JL Audio

JL Audio Stealthbox SB-S-LWAG/10W6v2/DG Bedienungsanleitung

JL Audio

JL Audio 13TW5-3 Bedienungsanleitung

JL Audio

JL Audio Stealthbox SB-N-ARMAD/10W6v2 Bedienungsanleitung

JL Audio

JL Audio 8W7 Bedienungsanleitung

JL Audio

JL Audio e110 Bedienungsanleitung

JL Audio

JL Audio 10W7AE Bedienungsanleitung

JL Audio

JL Audio SB-N-ALT/10W3v3 Bedienungsanleitung

JL Audio

JL Audio 10TW3-D8 Bedienungsanleitung

JL Audio

JL Audio 10W3v2 Bedienungsanleitung

JL Audio

JL Audio Fathom f110 Bedienungsanleitung

JL Audio

JL Audio Gotham g213 Bedienungsanleitung

Beliebte Subwoofer Handbücher anderer Marken

Sony

Sony XS-AW8 Bedienungsanleitung

Sony

Sony XS-L836 Bedienungsanleitung

B&C Speakers

B&C Speakers 15 HPL 76W Bedienungsanleitung

Velodyne

Velodyne DD-18+ Bedienungsanleitung

Sonance

Sonance Cinema Series SUB 10-150 Bedienungsanleitung

Hifonics

Hifonics HW-12 Kurzanleitung

Magnat Audio

Magnat Audio ADR 130 BP Bedienungsanleitung

Blitz

Blitz BZP106 Bedienungsanleitung

Technics

Technics SB-AS500 Bedienungsanleitung

Lyngdorf

Lyngdorf BW-2 Bedienungsanleitung

Lyngdorf

Lyngdorf BW-3 Bedienungsanleitung

Pyle Pro

Pyle Pro PYLE PRO PDW15125 Bedienungsanleitung

REL Acoustics

REL Acoustics Q Series Bedienungsanleitung

L-Acoustics

L-Acoustics KIVA SB15M Kurzanleitung

Pioneer

Pioneer Elite S-W1EX Bedienungsanleitung

B&C Speakers

B&C Speakers Woofer 12 HPL 76 Bedienungsanleitung

KEF

KEF KUBE 200 Bedienungsanleitung

Yamaha

Yamaha SW500 Bedienungsanleitung