Kohler FAMILY CARE K-31500T Bedienungsanleitung

-1-

FAMILY CARE

INSTALLATION INSTRUCTIONS

CABINET

K-31500T/K-31501T-L/K-31501T-R/K-31503T-L/K-31503T-R

BEFORE YOU BEGINBEFORE YOU BEGIN

Please read these instructions carefully to familiarize

yourself with the required tools, materials, and installation

sequences. Follow the sections that pertain to your

particular installation. This will help you avoid costly

mistakes. In addition to proper installation, read all

operating and safety instructions.

All information in these instructions is based upon the

latest product information available at the time of

publication. Kohler China. reserves the right to make

changes in product characteristics, packaging, or

availability at any time without notice.

These instructions contain important care, cleaning, and

warranty information-

Turn off the water supply.

The plumbing installation must comply with Water Supply

Regulations/Bye-laws, Building Regulations or any

particular regulations and practices, specified by the local

water company or water undertakers. The installation

should be carried out by a plumber.

Before installation carefully inspect the new fixture for any

signs of damage.

This product complies with GB 24977-2010.

please leave instructions for the

consumer.

FAMILY CARE bathroom cabinet adopts E1 grade wood-

based panel of high quality, and with further processing,

its harmful emissions will be less than 1.5mg/L.

1.5mg/L

GB 24977-2010

ORDERING INFORMATION

This installation covers the following products in the FAMILY

CARE range:

FAMILY CARE Cabinet 600mm.........................K-31500T

FAMILY CARE Cabinet 800mm-L ..................K-31501T-L

FAMILY CARE Cabinet 800mm-R .................K-31501T-R

FAMILY CARE Cabinet 1000mm-L ................K-31503T-L

FAMILY CARE Cabinet 1000mm-R ...............K-31503T-R

600mm............................................K-31500T

800mm( ) ...........................K-31501T-L

800mm( )...........................K-31501T-R

1000mm( ) .........................K-31503T-L

1000mm( ).........................K-31503T-R

SAFETY WARNINGS

Kohler products are precision-engineered and should give

continued superior and safe performance, provided:

1. They are installed, commissioned, operated and

maintained in accordance with the recommendations given

in this Manual.

2. Periodic attention is given, as necessary, to maintain the

product in good functional order. Recommended

guidelines are given in the section.

Carefully inspect the new fixture for any signs of damage.

When installing Kohler Products, manufacturers guidelines for

power tool safety should be followed.

MAINTENANCE

CHANGSHU KOHLER LTD., SOUTHEAST ECONOMIC DEVELOPMENT ZONE,

CHANGSHU, JIANGSU PROVINCE, CHINA POST CODE 215500

215500

2018

1356924-T01-A

ROUGHING-IN

-2-

UNIT : mm

Fig.2

INSTALLATION

A. Install Washbasin Cabinet

Install the services.

Hot (H) and Cold (C) inlets must be

connected to the correct inlet pipes.

Install the drain in accordance with the

manufacturer's instructions.

We suggest using P-trap drain. Connect P-

trap pipe with washbasin drain.

Make sure a watertight seal

exisits on all washbasin drain

connections.

Provide access to the

plumbing connections for future

plumbing maintenance.

The hot and cold water supplies must be

installed with isolating valves.

Caution!

(H) (C)

Fig.1

Kohler reserves the right to change marked dimensions without prior notice.

Reference Value

540

576

776

976

438

776

976

1356924-T01-A

Fig.3

UNIT : mm

Wall Bracket Wall Bracket Wall Bracket

All installation dimensions are for reference only.

-3-

1. 3

1. Mark the position of hanged bracket according to

dimensions as illustrated, and loosen the suspension hook

of washbasin cabinet.

Avoid the cables and pipes inner set when

drilling in the wall.

Different types of bolts are required for different

decoration boards. Please apply suitable bolts and plugs.

Caution!

Note:

4. 4

2. Drill holes for fixing the bracket. Using a level, ensure that

the hanged bracket is level.

3. Use suitable plugs and bolts, and fix the hanged bracket on

the wall.

4. Hang the washbasin cabinet on the wall, and position the

suspension on the hanged bracket. See Fig.4.

Fig.4

20 20 170

170

976

195

538

570

776

576

1356924-T01-A

-4-

11.

11. Apply a washer to the screw before tighten it. Make sure

the washbasin cabinet has been fixed firmly on the wall.

See Fig.7.

5. Set the washbasin cabinet onto the wall bracket. Be sure

the cabinet adjusted level and the back board of cabinet

appressed to the wall by adjusting the screws of wall clips.

See Fig.5.

6. Mark the wall through two holes at the corresponding

positions as illustrated in Fig 6.

7. Take out the L shape metal support from the package and

install it according to its installation instructions.

8. Dismount the washbasin cabinet and put aside. Drill holes

at the marked position.

9. Insert the plugs into the wall.

Caution!

Note:

Avoid the cables and pipes inner set when

drilling in the wall.

Different types of bolts are required for different

decoration boards. Please apply suitable bolts and plugs.

6. 6

7. L

Fig.5

Fig.6

MAX1

10.

10. Set the washbasin cabinet onto the brackets. Be sure the

cabinet adjusted level and the back board of cabinet

appressed to the wall by adjusting the screws of wall clips.

See Fig.5.

Fig.7

1356924-T01-A

-5-

Fig.8

Fig.9

12.

()

13.

14. 8

12. Adjust the screw with the wrench supplied to lift the

support foot and make sure it is firmly attached to the

cabinet bottom.

The support foot is the important part that must be

installed to prevent the cabinet from descending. It must

be firmly attached to the cabinet bottom (use the wrench

until the screw is completely tightened.)

Note:

13. Place the hinge cover and plastic cover.

14. Adjust the hinge of door in 3 direction to make sure the

door level.

1. (P )

C. Connect Drainage

1. Inwall drainage (P-Trap)

Please install the drain assembly and faucet as shown.

Please set the water supply and drainage position

according to the suppliers instructions. You can put the

pipe into the U Notch.

Faucet

Supply Lines

Shut-off Valve

Drain Assembly

B. Install the Synthetic Top

Note: Please refer to the installation instructions of synthetic

top for its installation. To protect the cabinet from

dampness, please apply silicone sealant where the

synthetic top and the cabinet connect.

1356924-T01-A

-6-

USER MAINTENANCEUSER MAINTENANCE

WARNING! Risk of product damage.

6. Please do not sit, lean or step on the basin cabinet.

7. If any fixtures caused by abnormal reasons, Kohler China

can supply paid replacement for service parts caused by

abnormal reasons as shown in the Service Parts Page in

the limited duration of warranty.

Many cleansers contain abrasive and chemical substance

which is not suitable for cleaning stainless steel, enamel,

plating or plastic products. You may use mild cleansers or

soaps to clean the surfaces. Wipe any splashes of cleaner

solutions from the surface with clean soft cloth.

Maintain ventilation in the bathroom, and separate the dry

area from the damp one if conditions permit. Try to open

the door and windows of the bathroom and maintain good

ventilation.

Kohler bathroom cabinet are dealt with strict procedures

for damp-proof, whose good damp-proof function ensures

good performance even in bathroom of huge humidity. Yet

do not splash and pour water directly on the bathroom

cabinet. Make sure that the bathroom is not over damp

and wipe any splashes from surfaces immediately.

Maintenance of door board: Clean and wipe door board

regularly, and wipe the condensation vapor with dry and

soft cloth.

Ensure that electrical connections for appliances such as

head lamp is insulated wipe mirror surface with chamois

regularly to guarantee the persistent excellent performance.

2. S

2. Floor drainage (S-Trap)

Please install the drain assembly and faucet as shown.

Please set the water supply and drainage position

according to the suppliers instructions.

Fig.10

Faucet

Supply Lines

Shut-off Valve

Drain Assembly

Ripple Pipe

Outlet

1356924-T01-A

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Kohler Inneneinrichtung Handbücher

Kohler

Kohler Jacob Delafon Idol Bedienungsanleitung

Kohler

Kohler K-2527 Montageanleitung

Kohler

Kohler K-11750 Montageanleitung

Kohler

Kohler Archer K-2449 Bedienungsanleitung

Kohler

Kohler Englefield VALENCIA Vanity Series Bedienungsanleitung

Kohler

Kohler MING K-77127T Bedienungsanleitung

Kohler

Kohler Natura 15457T Bedienungsanleitung

Kohler

Kohler MAXISPACE Bedienungsanleitung

Kohler

Kohler RIVLET K-31534K-CP Bedienungsanleitung

Kohler

Kohler K-2732 Montageanleitung

Kohler

Kohler TRESHAM K-72530T-R Bedienungsanleitung

Kohler

Kohler TRESHAM VANITY K-45980 Series Montageanleitung

Kohler

Kohler PASTORIFE K-99074T Bedienungsanleitung

Kohler

Kohler K-3092 Montageanleitung

Kohler

Kohler PARADOX K-15050T Bedienungsanleitung

Kohler

Kohler Top Art K-14041 Bedienungsanleitung

Kohler

Kohler K-97269 Montageanleitung

Kohler

Kohler K-98850T Bedienungsanleitung

Kohler

Kohler 5900SP Montageanleitung

Kohler

Kohler M MODULAR Bedienungsanleitung

Kohler

Kohler Vanity K-2435 Montageanleitung

Kohler

Kohler K-3082 Montageanleitung

Kohler

Kohler URBANITY K-99916T-LK Bedienungsanleitung

Kohler

Kohler VERDERA K-26376T Bedienungsanleitung

Beliebte Inneneinrichtung Handbücher anderer Marken

Homelegance

Homelegance California 1662PEK-1CK Bedienungsanleitung

Osmond Ergonomics

Osmond Ergonomics FLO Bedienungsanleitung

OVE

OVE ELOISE 42 Bedienungsanleitung

overstock

overstock MF286255 Bedienungsanleitung

Sonoma

Sonoma 160-801 Bedienungsanleitung

BOLERO

BOLERO Wicker Side Chair CF158 Installationsanleitung

Coaster

Coaster 4799N Bedienungsanleitung

Stor-It-All

Stor-It-All WS39MP Programmierhandbuch

Lexicon

Lexicon 194840161868 Bedienungsanleitung

Next AMELIA NEW 462947 Bedienungsanleitung

impekk

impekk Manual II Bedienungsanleitung

Elements

Elements Ember Nightstand CEB700NSE Bedienungsanleitung

JWA

JWA CARY 68429 Bedienungsanleitung

VIPACK

VIPACK AMORI AMKB9014 Bedienungsanleitung

Rowico

Rowico SANNA Bedienungsanleitung

Southern Enterprises

Southern Enterprises CK556000TX Bedienungsanleitung

hygena

hygena 314/5041 Bedienungsanleitung

VINNOVA

VINNOVA Kinsley 536060S Bedienungsanleitung