Kohler Archer K-2449 Bedienungsanleitung

Installation

Guide

Vanity

Mproduct numbers are for Mexico (i.e. K-12345M)

Los números de productos seguidos de

Mcorresponden a México (Ej.

K-12345M)

Français, page “Français-1”

Español, página “Español-1”

K–2449

1061207-2-A

Thank You For Choosing Kohler Company

We appreciate your commitment to Kohler quality. Please take a few

minutes to review this manual before you start installation. If you

encounter any installation or performance problems, please don’t

hesitate to contact us. Our phone numbers and website are listed on

the back cover. Thanks again for choosing Kohler Company.

Tools and Materials

Before You Begin

Observe all local building codes.

Prior to installation, unpack the new product and inspect it for

damage. Return the product to its protective carton until you are

ready to install it.

Make sure the ﬁnished wall is straight and plumb, and the ﬂoor

is ﬂat and perpendicular to the ﬁnished wall.

This vanity is designed to allow most base moldings to pass

behind the vanity. Remove any moldings that may inhibit the

vanity from being ﬂush against the ﬁnished wall.

Remove the drawer from the vanity before beginning the vanity

installation. Doing so will ease the installation process. Refer to

the section contained in this guide for proper removal.

Install the water supply and drain lines according to the

roughing-in information. The water supply nipples must extend

3” (7.6 cm) beyond the ﬁnished wall material.

Kohler Co. reserves the right to make revisions in the design of

products without notice, as speciﬁed in the Price Book.

Pencil Tape Measure Siliconized

Acrylic Caulk

Safety Glasses Drill Level

Assorted

Screwdrivers

• Wood Screws

• Framing Nails

• 3/4" Plywood

Plus:

1061207-2-A 2 Kohler Co.

1. Wall Preparation

NOTE: When notching the studs, the 3/4″plywood should be no

bigger than 9″(22.9 cm) in height to maintain structural integrity.

Measure and mark 33″(83.8 cm) up from the ﬂoor. This will be

the height from the top of the 3/4″plywood backing material to

the ﬂoor.

Notch the studs so the front of the 3/4″plywood will be ﬂush

with the edge of the studs.

IMPORTANT! The backing should be at least 30″(76.2 cm) long and

be aligned with the vanity.

Secure the 3/4″plywood backing material to the studs with

framing nails.

Install the water supply and drain lines according to the

roughing-in information provided with your lavatory. The water

supply nipples must extend at least 3″(7.6 cm) beyond the

ﬁnished wall material.

NOTE: Plumbing will be exposed and visible once the vanity

installation is complete. Chrome plumbing ﬁttings are

recommended.

Complete the ﬁnished wall. Ensure the ﬁnished wall is straight

and plumb, and the ﬂoor is ﬂat and perpendicular to the ﬁnished

wall.

3/4" Plywood

33"

(83.8 cm)

9" (22.9 cm)

30" (76.2 cm) Min

Kohler Co. 3 1061207-2-A

Wall Preparation (cont.)

IMPORTANT! Before installing molding to the ﬁnished wall, check

to ensure that it will not interfere with the vanity.

1061207-2-A 4 Kohler Co.

2. Install the Legs

Remove the drawer from the lower vanity section.

Position the two leg assemblies on each side of the drawer

assembly with the pins facing each other.

Slide one set of pins into the back rail (ﬂat). Repeat with the other

side.

Slide one set of pins into the front rail (curved). Repeat with the

other side.

Firmly push the front and back rail down.

Carefully slide the drawer assembly up until the bolt holes in the

drawer and legs are aligned.

Slide a lock washer and washer onto each bolt.

Thread the bolts into the legs.

Firmly tighten the bolts using the supplied hex wrench.

Insert the bolt through the front of the drawer from inside the

drawer and thread the knob onto the bolt.

Tighten securely.

Knob

Bolt

Leg Bolt

Washer

Lock Washer

Kohler Co. 5 1061207-2-A

3. Install the Vanity

Position the vanity against the ﬁnished wall.

Verify the vanity is level. If it is not level, tip the vanity to allow

access to the appropriate leveler(s) and turn the leveler(s)

counterclockwise to raise the vanity, or clockwise to lower it.

Mark two pilot holes an equal distance from the centerpoint of

the mounting rail.

Drill two pilot holes through mounting rail at the marked

locations.

Tighten a wood screw through each of the two drilled holes until

the vanity is ﬂush and secure against the ﬁnished wall.

Leveler

Mounting Rail

Wood Screw

Vanity

Finished Wall

1061207-2-A 6 Kohler Co.

4. Install the Lavatory

Install the faucet to the lavatory following the faucet

manufacturer’s instructions.

Properly seat the lavatory on top of the vanity. The back of the

lavatory must be ﬂush against the ﬁnished wall.

Push down on each corner of the lavatory to make sure it does

not rock from side to side on the vanity.

NOTE: If adjustment is needed, remove the lavatory and set it aside.

Use a screwdriver to turn the levelers on the vanity. Seat the

lavatory on the vanity. Repeat this procedure, if necessary.

Remove the lavatory from the vanity and set it aside.

CAUTION: Risk of product damage. Siliconized acrylic caulk must

be used to secure the lavatory to the vanity. Do not use 100%

silicone sealant, which will damage the ﬁnish of the vanity.

Apply a 1/8″(3 mm) thick bead of siliconized acrylic caulk

around the top edge of the vanity.

Carefully position the lavatory on top of the vanity.

Apply a small bead of siliconized acrylic caulk to the top edge

where the lavatory contacts the wall. Allow the caulk to dry

before proceeding. Refer to the manufacturer’s instructions for

recommended drying time.

Connect the drain and supplies.

Leveler

Apply sealant.

Kohler Co. 7 1061207-2-A

5. Remove/Install the Drawer/Basket

To remove the top drawer:

Slide the release latches, located on the bottom of each rail,

backwards.

Carefully pull on the drawer until the rails are fully extended.

Remove the drawer.

To reinstall the top drawer:

Reach under the rails and slide the release latches backward.

Position the rollers on the drawer under the front end of the rails

and lift up until the rollers are in the rails.

Push the drawer in until it is fully closed. If it only goes a short

distance and stops, the release latch must be moved farther back.

Partially open the drawer and slide the release latch forward. Test

the drawer to make sure the release latch stops it before it can

disengage from the rails.

To remove the bottom drawer:

Slide the drawer out on the rails until fully extended.

Pull the right side release latch down, and push the left side

release latch toward you. Pull the drawer toward you until the

rails separate.

To reinstall the bottom drawer:

Rail

Lock

Release Latch

Basket Slide

1061207-2-A 8 Kohler Co.

Remove/Install the Drawer/Basket (cont.)

Fully extend the rails.

Slide the drawer rail into the vanity rail.

Slide the drawer to the closed position.

Open and close the drawer several times to verify smooth

operation.

Kohler Co. 9 1061207-2-A

Guide d’installation

Meuble

Outils et matériels

Merci d’avoir choisi la compagnie Kohler

Nous apprécions votre engagement envers la qualité Kohler. Veuillez

prendre s’il vous plaît quelques minutes pour lire ce manuel avant de

commencer l’installation. Ne pas hésiter à nous contacter en cas de

problème d’installation ou de performance. Nos numéros de téléphone

et notre adresse du site internet sont au verso. Merci encore d’avoir

choisi la compagnie Kohler.

Avant de commencer

Respecter tous les codes de construction locaux.

Avant l’installation, déballer le nouveau produit et l’examiner

pour en déceler tout dommage. Remettre le produit dans son

emballage de protection jusqu’à être prêt à l’installer.

S’assurer que le mur ﬁni soit droit et d’aplomb, que le sol soit

plat et perpendiculaire au mur ﬁni.

Ce meuble est conçu pour permettre à la plupart des moulures de

base de passer derrière le meuble. Retirer tout moulage risquant

de prévenir le meuble d’être nivelé contre le mur ﬁni.

Crayon à papier Mètre ruban Mastic acrylique

siliconé

Lunettes

de protection

Perceuse Niveau à bulle

Tournevis

assortis

• Vis à bois

• Clous de cadrage

• Contreplaqué de 3/4"

Plus:

Kohler Co. Français-1 1061207-2-A

Andere Handbücher für Archer K-2449

Inhaltsverzeichnis

Sprachen:

Andere Kohler Inneneinrichtung Handbücher

Kohler

Kohler K-2967 Montageanleitung

Kohler

Kohler Natura 15457T Bedienungsanleitung

Kohler

Kohler CL Series Bedienungsanleitung

Kohler

Kohler K-45775T Bedienungsanleitung

Kohler

Kohler Purist K-3080 Bedienungsanleitung

Kohler

Kohler AMERISSIC K-99073T Bedienungsanleitung

Kohler

Kohler FAMILY CARE K-31500T Bedienungsanleitung

Kohler

Kohler K-CB-CLW2030DAW Bedienungsanleitung

Kohler

Kohler K-72441T Bedienungsanleitung

Kohler

Kohler BANCROFT Service-Handbuch

Kohler

Kohler K-2431 Montageanleitung

Kohler

Kohler K-6334 Montageanleitung

Kohler

Kohler K-2527 Montageanleitung

Kohler

Kohler Fountainhead K-2441 Bedienungsanleitung

Kohler

Kohler DEVONSHIRE Series Bedienungsanleitung

Kohler

Kohler MAXISPACE 2.0 K-24374T Bedienungsanleitung

Kohler

Kohler K-1082 Montageanleitung

Kohler

Kohler Memoirs 485T Bedienungsanleitung

Kohler

Kohler 97631-G9 Montageanleitung

Kohler

Kohler Top Art K-14041 Bedienungsanleitung

Kohler

Kohler VEIL K-21800T-X Bedienungsanleitung

Kohler

Kohler K-2412 Montageanleitung

Kohler

Kohler NEW IPSWICH K-13987T-A Bedienungsanleitung

Kohler

Kohler K-6138 Bedienungsanleitung

Beliebte Inneneinrichtung Handbücher anderer Marken

Homelegance

Homelegance California 1662PEK-1CK Bedienungsanleitung

Osmond Ergonomics

Osmond Ergonomics FLO Bedienungsanleitung

OVE

OVE ELOISE 42 Bedienungsanleitung

overstock

overstock MF286255 Bedienungsanleitung

Sonoma

Sonoma 160-801 Bedienungsanleitung

BOLERO

BOLERO Wicker Side Chair CF158 Installationsanleitung

Coaster

Coaster 4799N Bedienungsanleitung

Stor-It-All

Stor-It-All WS39MP Programmierhandbuch

Lexicon

Lexicon 194840161868 Bedienungsanleitung

Next AMELIA NEW 462947 Bedienungsanleitung

impekk

impekk Manual II Bedienungsanleitung

Elements

Elements Ember Nightstand CEB700NSE Bedienungsanleitung

JWA

JWA CARY 68429 Bedienungsanleitung

VIPACK

VIPACK AMORI AMKB9014 Bedienungsanleitung

Rowico

Rowico SANNA Bedienungsanleitung

Southern Enterprises

Southern Enterprises CK556000TX Bedienungsanleitung

hygena

hygena 314/5041 Bedienungsanleitung

VINNOVA

VINNOVA Kinsley 536060S Bedienungsanleitung