Kohler K-5665 Montageanleitung

Installation and Care Guide

Kitchen Sinks

Français, page ″Français-1″

Español, página ″Español-1″

K-5665, K-5827, K-6351, K-6487, K-6489 K-6349, K-6427

1218029-2-C

Tools and Materials

Important Information

CAUTION: Risk of personal injury. Cast iron sinks are

heavy. Get help when lifting or moving.

IMPORTANT! Refer to the ″Roughing-In and Preparation″section

for cabinet dimensional requirements.

IMPORTANT! The cabinet must be installed and secured, and must

be plumb and level.

IMPORTANT! Long screws may damage adjacent cabinets. Ensure

the screws are long enough to secure the support framing, but short

enough not to extend through the walls of adjacent cabinets.

Due to the nature of under-mount installations, Kohler Co.

recommends that under-mount sink installations be performed by

trained and experienced installers.

Use proper fasteners and techniques to ensure the frame will

support a minimum of 300 lbs (136 kg). Locate the fasteners for

easy access in the event the sink needs to be removed.

For K-5665 Only: This sink is intended for installation into a 24″

apron sink base cabinet.

For K-5827 Only: This sink is intended for installation into a 33″

apron sink base cabinet.

For K-6349, K-6351, K-6427 and K-6489: This sink is intended for

installation into a 36″apron sink base cabinet.

For K-6487 Only: This sink is intended for installation into a 30″

apron sink base cabinet.

Observe all local plumbing and building codes.

Painter's

Tape

Plus:

• Suitable support framing material

[1/2" (13 mm)] max thickness

• Screws

Silicone

Sealant

Construction

Adhesive

1218029-2-C 2 Kohler Co.

1. Roughing-In and Preparation

IMPORTANT! Before installing this sink, verify the distance from

the top of the cabinet to the top of the doors (A) is greater than the

apron height.

TIP: Apply painter’s tape to the cabinet to mark cuts and protect the

cabinet surfaces when cutting.

Position the template on the front of the cabinet, ﬂush with the

top and centered left to right; secure with tape.

Trace the template and remove.

Cut the cabinet along the traced line.

A =

Apron

8-13/16"

(224 mm)

Top of Cabinet to Top of Doors

Trace the template onto

the cabinet and cut along

the traced line.

Kohler Co. 3 1218029-2-C

2. Install Support Framing

NOTICE: For proper countertop installation, the top of the sink

must not extend above the top of the cabinet.

Cut two lengths of support framing to extend horizontally along

the inside walls on each side of the cabinet.

Measure and mark the support mounting locations; ensure the

sink rim will sit at or slightly below the top of the cabinet.

Position and level the supports.

TIP: Use clamps to hold the supports in position.

Secure the supports with construction adhesive and screws (not

provided).

Optional Vertical Supports

Cut four lengths of support framing to extend from the bottom of

the horizontal supports to the ﬂoor of the cabinet.

Secure the vertical supports with construction adhesive and

screws (not provided).

5/8"

(16 mm)

Optional Vertical

Supports

1218029-2-C 4 Kohler Co.

3. Install the Sink

Lower the sink onto the supports; verify the sink is supported by

the frame.

Push the sink in to ensure the apron is ﬂush to the front of the

cabinet.

Verify the sink is level; make any adjustments and shim as

needed.

Kohler Co. 5 1218029-2-C

4. Install the Countertop

Apply a bead of silicone sealant around the side and back of the

sink.

Install the countertop.

Apply a thin bead of silicone sealant where the sink meets the

countertop and cabinet.

Immediately wipe away any excess sealant.

5. Complete the Installation

Install the faucet and the strainers, according to the installation

instructions.

Connect the trap to the strainers.

Care and Cleaning

For best results, keep the following in mind when caring for your

KOHLER product:

1218029-2-C 6 Kohler Co.

Care and Cleaning (cont.)

•Always test your cleaning solution on an inconspicuous area

before applying to the entire surface.

•Wipe surfaces clean and rinse completely with water immediately

after applying cleaner. Rinse and dry any overspray that lands on

nearby surfaces.

•Do not allow cleaners to soak on surfaces.

•Use a soft, dampened sponge or cloth. Never use an abrasive

material such as a brush or scouring pad to clean surfaces.

•Be careful not to leave staining materials in contact with the

surface for extended periods of time.

•The ideal cleaning technique is to rinse thoroughly and blot dry

any water from the surface after each use.

For detailed cleaning information and products to consider, visit

www.kohler.com/clean. To order Care & Cleaning information, call

1-800-456-4537.

Warranty

KOHLER

Enameled Cast Iron Kitchen Sink Lifetime Limited

Warranty

Kohler Co. warrants the enameled cast iron component of kitchen,

entertainment, or utility sinks manufactured after April 29, 2008, to be

free of defects in material and workmanship during normal residential

use for as long as the original consumer purchaser owns his or her

home. Kohler Co. further warrants that the enameled cast iron

component of the product will not chip, crack or burn for as long as

the original consumer purchaser owns his or her home. Gloss

reduction, scratching, staining and alkaline etching of the ﬁnish over

time due to use, cleaning practices or water or atmospheric conditions,

are not manufacturing defects but are indicative of normal wear and

tear. This warranty applies only to KOHLER Cast Iron kitchen,

entertainment and utility sinks installed in the United States of

America, Canada or Mexico (″North America″).

If a defect is found in normal residential use, Kohler Co. will, at its

election, replace the defective cast iron component, or make other

appropriate adjustment. Damage caused by misuse or abuse is not

covered by this warranty. Improper care and cleaning will void the

warranty. Proof of purchase (original sales receipt) must be provided to

Kohler Co. with all warranty claims. Kohler Co. is not responsible for

removal, installation, labor charges, or other incidental or consequential

Kohler Co. 7 1218029-2-C

Warranty (cont.)

costs. In no event shall the liability of Kohler Co. exceed the purchase

price of the kitchen, entertainment or utility sink.

If the cast iron kitchen, entertainment or utility sink is used

commercially or is installed outside of North America, Kohler Co.

warrants that for one (1) year from the date the product is installed the

cast iron product will be free from defects in material and

workmanship, and will not chip, crack or burn. All other terms of this

warranty apply except for duration. All other components other than

the enameled cast iron component carry Kohler Co.’s one-year limited

warranty unless otherwise speciﬁed.

If you believe that you have a warranty claim, contact your Dealer,

Plumbing Contractor, Home Center or E-tailer, or by writing Kohler

Co., Attn.: Customer Care Center, 444 Highland Drive, Kohler, WI

53044, USA. Please be sure to provide all pertinent information

regarding your claim, including a complete description of the problem,

the product, model number, color, ﬁnish, and the date the product was

purchased and from whom the product was purchased. Also include

your original invoice. For other information, or to obtain the name and

address of the service and repair facility nearest you, call

1-800-4KOHLER (1-800-456-4537) from within the USA and Canada,

and 001-877-680-1310 from within Mexico or visit www.kohler.com

within the USA, www.ca.kohler.com from within Canada, or

www.mx.kohler.com in Mexico.

KOHLER CO. AND/OR SELLER ARE PROVIDING THIS

WARRANTY IN LIEU OF ALL OTHER WARRANTIES, EXPRESSED

OR IMPLIED, INCLUDING BUT NOT LIMITED TO THE IMPLIED

WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A

PARTICULAR PURPOSE. KOHLER CO. AND/OR SELLER

DISCLAIMS ANY LIABILITY FOR SPECIAL, INCIDENTAL OR

CONSEQUENTIAL DAMAGES. Some states/provinces do not allow

limitations on the duration of an implied warranty or the exclusion

or limitation of such damages, so these limitations and exclusions

may not apply to you. This warranty gives the consumer speciﬁc

legal rights. You may also have other rights that vary from

state/province to state/province. This warranty is extended to the

original consumer purchaser only, and excludes product damage due

to installation error, or product abuse or product misuse, whether

attributable to the consumer, a contractor, service company or other

third party.

This is Kohler Co.’s exclusive written warranty.

1218029-2-C 8 Kohler Co.

Guide d’installation et d’entretien

Éviers de cuisine

Outils et matériaux

Informations importantes

ATTENTION: Risque de blessures. Les éviers en fonte sont

lourds. Se faire aider pour les soulever ou les déplacer.

IMPORTANT! Se reporter à la section ″Raccordement et

préparation″pour les conditions requises pour les dimensions du

meuble.

IMPORTANT! Le meuble doit être installé et ﬁxé en place, et il doit

être d’aplomb et de niveau.

IMPORTANT! Les vis longues peuvent endommager les meubles

adjacents. S’assurer que les vis sont suffisamment longues pour ﬁxer

le cadrage de support, mais suffisamment courtes pour ne pas

traverser les parois des meubles adjacent.

Vu la nature particulière des installations à encaster par le

dessous, Kohler Co. recommande que les installations à encastrer

par le dessous soient effectuées par des installateurs formés et

expérimentés.

Utiliser la visserie et les techniques qui conviennent pour

s’assurer que le cadre puisse soutenir un minimum de 300 lb (136

kg). Placer la visserie à des endroits accessibles au cas où l’évier

doit être déposé.

Ruban de

peintre

Plus:

• Matériau de cadrage de

support approprié [épaisseur

maximum 1/2" (13 mm)]

• Vis

Mastic à la

silicone

Adhésif de

construction

Kohler Co. Français-1 1218029-2-C

Informations importantes (cont.)

Pour les modèles K-5665 seulement: Cet évier est conçu pour

une installation dans un meuble bas pour évier à tablier de 24″.

Pour les modèles K-5827 seulement: Cet évier est conçu pour

une installation dans un meuble bas pour évier à tablier de 33″.

Pour les modèles K-6349, K-6351, K-6427 et K-6489: Cet évier est

conçu pour une installation dans un meuble bas pour évier à

tablier de 36″.

Pour les modèles K-6487 seulement: Cet évier est conçu pour

une installation dans un meuble bas pour évier à tablier de 30″.

Respecter tous les codes de plomberie et de bâtiment locaux.

1218029-2-C Français-2 Kohler Co.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Sprachen:

Andere Kohler Sanitärprodukte Handbücher

Kohler

Kohler Aleo 77751X-4CD Bedienungsanleitung

Kohler

Kohler 10879T-4 Bedienungsanleitung

Kohler

Kohler Memoris 10435T Bedienungsanleitung

Kohler

Kohler K-6350 Montageanleitung

Kohler

Kohler Mira Agile S Eco Bedienungsanleitung

Kohler

Kohler K-10268 Bedienungsanleitung

Kohler

Kohler SAN RAPHAEL PRESSURE LITE K-3394 Bedienungsanleitung

Kohler

Kohler K-15261 Montageanleitung

Kohler

Kohler K-13925 Bedienungsanleitung

Kohler

Kohler Elate 13963X-4 Bedienungsanleitung

Kohler

Kohler K-8297TW-HC-0 Montageanleitung

Kohler

Kohler K-6811 Montageanleitung

Kohler

Kohler K-1122-LA Kurzanleitung

Kohler

Kohler CFI230G Bedienungsanleitung

Kohler

Kohler GP30420 Handbuch

Kohler

Kohler K-T125 Bedienungsanleitung

Kohler

Kohler Carillon K-7806-95 Bedienungsanleitung

Kohler

Kohler STANCE Bedienungsanleitung

Kohler

Kohler K-T12014 Montageanleitung

Kohler

Kohler K-18829 Bedienungsanleitung

Kohler

Kohler K-7223 Montageanleitung

Kohler

Kohler 10415T-B Bedienungsanleitung

Kohler

Kohler Quiet-Close C3-455 Bedienungsanleitung

Kohler

Kohler K-5024-T Bedienungsanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema

Crosswater

Crosswater Heir 18-31 Bedienungsanleitung

Sanela

Sanela SLVN 07 Bedienungsanleitung

Glacier bay

Glacier bay DORIND HD67478W-6001 Montageanleitung

Sterling Plumbing

Sterling Plumbing C741 Bedienungsanleitung