INSTALLATION & OPERATION MANUAL 14-0299 REV 4 (11/22)
PAGE 8 OF 32
Marine Steam-It Electric Counter Pressure Cooker
Operation
PLEASE READ CAREFULLY THE FOLLOWING INFORMATION AND THE OPERATING INSTRUCTIONS ON THE
FOLLOWING PAGES.
NOTICE
Market Forge will not be responsible for damage resulting from the use of hard or corrosive water, from failure to drain
the unit daily, or from inadequate cleaning procedures.
CAUTION
The model SB-ST-E Steam-It pressure cooker cylinder is constructed of a corrosion resistant alclad aluminum
water. If the water supply is known to be hard or corrosive, a source of treated water should be used. Corrosion
may also occur if water is not drained daily. Do not use distilled water.
The model SB-ST-E Marine Electric Steam-It pressure cooker (15 PSI operation) consists of one (1) cooking compartment
a cooking cycle will automatically be performed with the act of setting the timer to the length of cooking time desired.
The automatic sequence of operation is:
STEP 1
close and direct electricity to the heating elements: The cooking cycle light, which remains in circuit while the heating
elements are on.
STEP 2 As steam is produced within the cooking cylinder, trapped air escapes through the steam trap. The
steam trap is induced to close thermostatically when live steam fully replaces the trapped air passing through it.
Freeventing will automatically cease and cooking cylinder will become steam-tight. A build-up of cooking cylinder
steam pressure will occur.
STEP 3 When the steam pressure build-up reaches 10 PSI, the timer control switch will activate the timer to start its
timing cycle.
STEP 4
to the heating elements. Thus, by controlling the contactor to open and close intermittently, the element control
STEP 5
completed to the buzzer allowing it to sound while the circuit t to the pilot light is broken. The steam exhaust valve
will open and the cooking chamber is automatically exhausted of steam. The buzzer will continue to sound until the
the door, allow a second or two for the vapor to clear and remove the foods.
