Minuteman X17 Bedienungsanleitung
User Manual
X17 ECO CFS Carpet Extractor
115V/230V with High Pressure
Minuteman®, Minuteman International, Inc.
A Member of the Hako Group #988751UM Rev. * 04/15
2 © 2015 Minuteman International, Inc.
X17 ECO CFS Carpet Extractor #988751UM Rev. * 04/15
This manual is furnished with each new Minuteman X17 ECO CFS. This provides the necessary operating and
preventive maintenance instructions. Operators must read and understand this manual before operating or servicing
this machine.
This machine was designed to give you excellent performance and efciency. For best results and minimal cost,
please follow the general guidelines below:
· Operate the machine with reasonable care.
· Follow the manufacturer’s suggested maintenance instructions as provided in this booklet.
· Use original Minuteman supplied parts.
Technical Specications
3
© 2015 Minuteman International, Inc.
X17 ECO CFS Carpet Extractor #988751UM Rev. * 04/15
Technical Specications
Model No. X17115Z / X17115HPZ X17230Z/X17230HPZ
Current Max. 12.5 Amps 7 Amps
Voltage 115V 230V
Vacuum motor power 1250W 1250W
Brush motor power 100W 100W
Pump motor power 50PSI / HP(100PSI) 50PSI / HP(100PSI)
Working width 17 in.; 43 cm 17 in., 43cm
Gross Weight 116 lb.; 52.6 kg 116 lb.; 52.6 kg
Solution tank 10 Gallons; 37.8 LITERS 10 Gallon; 37.8 LITERS
Recovery tank 7 Gallons; 26.5 LITERS 7 Gallon; 26.5 LITERS
Power Cord Length 50 ft.; 15.24m 50 ft.; 15.24m
Suction (sealed) 100in. of water 100in. of water
*Vibration < 8.2 ft/s2; <2,5 m/s2
Noise emission
The sound pressure level measured under maximum conditions 83 dB (A)
of use (LwA) according to DIN EN 60335-2-68
The sound pressure level measured (at the ear of the driver) under 72 dB (A)
normal conditions of use (LpA) according to DIN EN 60335-2-68
Measurement inaccuracy (KpA) 1,8 dB (A)
*The frequency weighted acceleration measured according to DIN EN ISO 5349 which have an effect upon the upper
limbs (hand-arm-system) amounts under normal working conditions.
Model: X17ECOCFS(ChemicalFreeSolution)withHP(HighPressure)
4 © 2015 Minuteman International, Inc.
X17 ECO CFS Carpet Extractor #988751UM Rev. * 04/15
Table Of Contents
Technical Specications ............................................................................................................................................................ 2
Table Of Contents ....................................................................................................................................................................... 4
Safety Instructions ..................................................................................................................................................................... 5
Unpacking Instructions .............................................................................................................................................................. 6
Handle Assembly .......................................................................................................................................................................................7
Assembly..................................................................................................................................................................................... 7
Machine Overview .................................................................................................................................................................... 10
X17 CFS Front ...........................................................................................................................................................................................10
Vacuum Connection .................................................................................................................................................................................10
X17 CFS Back & Bottom ..........................................................................................................................................................................11
Handle/ Control Panel ..............................................................................................................................................................................12
Circuit Breakers........................................................................................................................................................................................13
CFS Control Box .......................................................................................................................................................................................13
Solution Tank In-line Filter ......................................................................................................................................................................14
Vacuum Intake Filter ................................................................................................................................................................................14
Solution Tank Drain Hose ........................................................................................................................................................................15
Solution Level Indicator ...........................................................................................................................................................................15
Brush Removal .........................................................................................................................................................................................16
Brush Pressure Gauge ............................................................................................................................................................................17
Brush Pressure Adjustment Knob ..........................................................................................................................................................17
Removable Recovery Tank ......................................................................................................................................................................18
Handle Adjustment ...................................................................................................................................................................................19
Cord Relief ................................................................................................................................................................................................19
Accessories ..............................................................................................................................................................................................20
Maintenance .............................................................................................................................................................................. 21
Operating Instructions ............................................................................................................................................................. 24
Troubleshooting ....................................................................................................................................................................... 26
Warranty .................................................................................................................................................................................... 28
5
© 2015 Minuteman International, Inc.
X17 ECO CFS Carpet Extractor #988751UM Rev. * 04/15
SAVE THESE INSTRUCTIONS
Safety Instructions
FOR COMMERCIAL USE ONLY
IMPORTANT SAFETY INSTRUCTIONS
READ ALL INSTRUCTIONS BEFORE USING
When using an electrical appliance, basic precautions should always be followed, including the following:
WARNING - To reduce the risk of re, electric shock, or injury:
• Do not leave appliance when plugged in. Unplug from outlet when not in use and before servicing.
WARNING - To reduce the risk of electrical shock, do not expose to rain. Store indoors.
• Never allow children or untrained adults to operate this equipment.
• Keep the area of operation clear of all persons, particularly small children,
and pets. Keep bystanders at least 25 feet away from the area of operation.
• Use only as described in this manual. Use only manufacturer’s
recommended attachments.
• Do not use with damaged cord or plug. If appliance is not working as it
should, has been dropped, damaged, left outdoors, or dropped into water,
return it to a service center.
• Do not pull or carry by cord, use cord as a handle, close a door on cord,
or pull cord around sharp edges or corners.
• Do not run appliance over cord.
• Keep cord away from heated surfaces.
• Do not unplug by pulling on cord. To unplug, grasp the plug, not the cord.
• Do not handle plug or appliance with wet hands.
• Do not put any object into openings. Do not use with any opening blocked;
keep free of dust, lint, hair, and anything that may reduce air ow.
• Keep hair, loose clothing, ngers, and all parts of body away from openings
and moving parts.
• Do not pick up anything that is burning or smoking, such as cigarettes,
matches, or hot ashes.
• Turn off all controls before unplugging.
• Use extra care when cleaning on stairs.
• Do not use to pick up ammable or combustible liquids such as gasoline
or use in areas where they may be present.
• Connect to a properly grounded outlet only. See grounding instructions.
• If foam/liquid comes out of exhaust openings turn switch off immediately.
• Use only chemicals recommended by dealer/manufacturer.
• These machines must be used only with the power supply cord provided
from the manufacturer:
– X17115Z / X17115HPZ: Power Cord #748613
– X17230Z / X17230HPZ: Power Cord #748613CE
6 © 2015 Minuteman International, Inc.
X17 ECO CFS Carpet Extractor #988751UM Rev. * 04/15
INSPECTION
Carefully unpack and inspect your machine for shipping damage.
Each unit is tested and thoroughly inspected before shipment, and
any damage is the responsibility of the delivery carrier who should be
notied immediately.
ELECTRICAL
Model Numbers X17115Z / X17115HPZ are designed to operate on
a standard 15 amp. 115 volt, 60 hz, AC circuit. Voltages below 105
volts AC or above 125 volts AC could cause serious damage to the
motor.
Model Numbers X17230Z / X17230HPZ are designed to operate on
a standard 10 amp. 230 volt, 50 hz, AC circuit. Voltages below 210
volts AC or above 250 volts AC could cause serious damage to the
motor.
WARNING
Electric motors can cause explosions when operated near explosive
materials or vapors. Do not operate this machine near ammable
materials such as solvents, thinners, fuels, grain dust, etc.
GROUNDING INSTRUCTIONS
This oor-nishing machine shall be grounded while in use to protect
the operator from electric shock. The machine is provided with a
three-conductor cord and a three-contact grounding type attachment
plug to t the proper grounding type receptacle. The green (or green
and yellow) conductor in the cord is the grounding wire. Never
connect this wire to other than the grounding pin of the attachment
plug.
DANGER
Improper connection of the equipment-grounding conductor can result in a risk
of electric shock. Check with a qualied electrician or service person if you are
in doubt as to whether the outlet is properly grounded. Do not modify the plug
provided with the appliance — if it will not t the outlet, have a proper outlet
installed by a qualied electrician.
Model Numbers X17115Z / X17115HPZ are for use on a nominal 115-volt
circuit and has a grounding plug that looks like the plug illustrated in Figure 1.
Model Numbers X17230Z / X17230HPZ are for use on a nominal 230-volt
circuit and has a grounding plug that looks like the plug illustrated in Figure 2.
Make sure that the appliance is connected to an outlet having the same
conguration as the plug. No adapter should be used with this appliance.
Unpacking Instructions
Figure 1 Figure 2
7
© 2015 Minuteman International, Inc.
X17 ECO CFS Carpet Extractor #988751UM Rev. * 04/15
A
C
B
E
D F
Handle Assembly
The X17 CFS Handle Assembly (D) is not assembled
on the machine when shipped. Follow the instruction
on the next page to connect the handle assembly to the
machine.
A HANDLE ADJUSTMENT KNOB
B SHOULDER BOLT
C COVER
D HANDLE ASSEMBLY
E SCREW
F CORD RELIEF
Assembly
8 © 2015 Minuteman International, Inc.
X17 ECO CFS Carpet Extractor #988751UM Rev. * 04/15
2. Use philips screwdriver to unscrew 4 screws
and remove cover.
3. Insert handle assembly in between bushings. Insert
the shoulder bolt through the bushing and screw
into the handle assembly using supplied wrench.
4. Align the teeth on the bushing and handle
assembly before tightening the adjustment knob.
1. Unpack machine.
Assembly
9
© 2015 Minuteman International, Inc.
X17 ECO CFS Carpet Extractor #988751UM Rev. * 04/15
Assembly
6. Attach the wire harness to the machine.
7. The wire harness must be aligned with the
patterns on the connector to t.
8. Screw the cover back with the 4 screws.
5. Spin the adjustment knobclockwise to tighten.
10 © 2015 Minuteman International, Inc.
X17 ECO CFS Carpet Extractor #988751UM Rev. * 04/15
P
M
Q
N
Machine Overview
L
L
KR
A
G
B
G
C
E
D
F
H
J
Vacuum Connection
K. VACUUM MOTOR INTAKE COVER
L. VACUUM CONNECTION TUBE
M. RECOVERY INLET
N. RECOVERY TANK HANDLE
P. VACUUM FLOAT SHUT-OFF
Q. RECOVERY WINDOW EXTENSION HOSE
R. VACUUM MOTOR GASKET
X17 CFS Front
A. HANDLE
B. RECOVERY DOME LID
C. RECOVERY TANK
D. SOLUTION TANK
E. SOLUTION TANK FILL PORT
F. FAUCET FILL HOSE
G. RECOVERY WINDOW
H. BRUSH MOTOR BELT COVER
J. VAC SHOE
Inhaltsverzeichnis
Andere Minuteman Bodenreinigungsmaschine Handbücher
Minuteman
Minuteman E 17e Bedienungsanleitung
Minuteman
Minuteman MC20004CE Leitfaden
Minuteman
Minuteman TRS17-220 Stücklistenhandbuch
Minuteman
Minuteman M220028K13H Stücklistenhandbuch
Minuteman
Minuteman FR17115-11 Leitfaden
Minuteman
Minuteman FR20115-DC Bedienungsanleitung
Minuteman
Minuteman E Ride 26 SPORT Bedienungsanleitung
Minuteman
Minuteman M220021H13 Bedienungsanleitung
Minuteman
Minuteman R100H Bedienungsanleitung
Minuteman
Minuteman X Ride 28 Bedienungsanleitung
Minuteman
Minuteman Ambassador C46000-00 Leitfaden
Minuteman
Minuteman M2400 Leitfaden
Minuteman
Minuteman X17 ECO CFS Bedienungsanleitung
Minuteman
Minuteman X17 ECO CFS Bedienungsanleitung
Minuteman
Minuteman 807756 Bedienungsanleitung
Minuteman
Minuteman EX12 Stücklistenhandbuch
Minuteman
Minuteman ROS 17 ORB 115V Bedienungsanleitung
Minuteman
Minuteman EX12 Stücklistenhandbuch
Minuteman
Minuteman FR1722060-11SA Leitfaden
Minuteman
Minuteman Lumina 20 Traction Drive Stücklistenhandbuch
Beliebte Bodenreinigungsmaschine Handbücher anderer Marken
Nilfisk-Advance
Nilfisk-Advance Advance SC370 17B Bedienungsanleitung
Numatic
Numatic ET 4045 Bedienungsanleitung
HAWK ENTERPRISES
HAWK ENTERPRISES HP1513-180BRUTE Bedienungsanleitung
Mytee
Mytee 8070 Mytee-Lite Bedienungsanleitung
Kärcher
Kärcher B 140 R Bedienungsanleitung
Triple S
Triple S Ace 26T1 Bedienungsanleitung
