Monogram ZIP360NH Bedienungsanleitung

Design Guide with

Installation

Instructions

monogram.com

31-49082-1

224D3560P003

04-15 GE

36”Built-In French Door,

Bottom-Freezer Refrigerators

Safety Information

BEFORE YOU BEGIN

Read these instructions completely and carefully.

• IMPORTANT– Save these instructions for

local inspector’s use. Observe all governing codes

and ordinances.

• Note to Installer – Be sure to leave these

instructions with the Consumer.

• Note to Consumer – Keep these instructions with

your Owner’s Manual for future reference.

If you received a damaged refrigerator, you should

immediately contact your dealer or builder.

Skill Level – Installation of this refrigerator requires

basic mechanical, carpentry and plumbing skills.

Proper installation is the responsibility of the installer.

Product failure due to improper installation is not

covered under the GE Appliance Warranty.

See the Owner’s Manual for warranty information.

WARNING Electrical Shock Hazard.

Plug into a grounded 3-prong outlet.

Do not remove the ground prong.

Do not use an adapter.

Immediately replace electric cords that become frayed

or damaged.

Do not use an extension cord with this appliance.

Failure to follow these instructions can result in death,

fire, or electrical shock.

Follow the instructions in the section Grounding the

Refrigerator.

This is the safety alert symbol. This symbol alerts you to potential hazards that can kill or hurt you and others.

All safety messages will follow the safety alert symbol and the word “DANGER”, “WARNING”, or “CAUTION”. These

words are defined as:

DANGER Indicates a hazardous situation which, if not avoided, will result in death or serious injury.

WARNING Indicates a hazardous situation which, if not avoided, could result in death or serious injury.

CAUTION Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.

For Monogram local service in your area, call 1.800.444.1845.

For Monogram service in Canada, call 1.800.561.3344 For Monogram Parts and Accessories, call 1.800.626.2002.

www.monogram.com

WARNING Tip Over Hazard.

These refrigerators are top heavy, especially with any doors open, and must be secured to prevent tipping

forward which could result in death or serious injury. Read and follow the entire installation instructions for

securing the refrigerator with the anti-tip system.

WARNING Explosion Hazard.

Keep flammable materials and vapors, such as gasoline, away from refrigerator. Failure to do so can result in

fire, explosion, or death.

WARNING To reduce the risk associated with choking, do not allow children under 3 years of age to have

access to small parts during the installation of this product.

CAUTION Lifting Hazard

This refrigerator is very heavy. To reduce the risk of person injury during maneuvering and installing this

refrigerator, 3 people are required for proper installation.

CAUTION Keep fingers out of the “pinch point” areas; clearances between the doors and between the doors and cabinet

are necessarily small. Be careful closing doors when children are in the area.

AVERTISSEMENT Risque de basculement

Ces réfrigérateurs présentent une partie supérieure lourde, en particulier avec une porte ouverte; ils doivent donc

être fixés pour prévenir le basculement vers l’avant et le risque concomitant de blessure grave ou fatale. Lisez et

suivez les instructions d’installation complètes pour l’installation du système anti-basculement.

AVERTISSEMENT Risque d’explosion.

Conservez les matériaux et vapeurs inflammables tels que l’essence à l’écart de votre réfrigérateur. Le non-

respect de cette instruction peut entraîner un risque d’incendie, d’explosion ou de décès.

AVERTISSEMENT Pour réduire le risque d’étouffement pendant l’installation de ce produit, ne pas laisser les

petites pièces à la portée des enfants âgés de moins de 3 ans.

ATTENTION Risque associé à la manutention d’une charge lourde

Ce réfrigérateur est très lourd. Pour réduire le risque de blessure lors de la manutention de ce réfrigérateur, trois

(3) personnes sont nécessaires pour procéder à l’installation appropriée du modèle 36 pouces, quatre (4) pour

l’installation des modèles 42 ou 48 pouces.

ATTENTION Éloignez les doigts des parties du congélateur où l’on peut facilement se pincer : les espaces entre

les portes, et entre les portes et les placards sont toujours étroits. Soyez prudent lorsque vous fermez les portes en

présence d’enfants.

Consignes de Sécurité

AVERTISSEMENT Risque de choc électrique.

Branchez l’appareil dans une prise triple avec terre.

Ne retirez pas la broche de terre.

N’utilisez pas d’adaptateur.

Le non-respect de ces instructions peut entraîner des

risques d’incendies, des chocs électriques ou la mort.

Remplacer immédiatement tout cordon électrique

effiloché ou endommagé.

N’utilisez pas de rallonge avec cet appareil.

Le non-respect de ces instructions peut entraîner des

risques d’incendies, des chocs électriques ou la mort.

Suivez les instructions de la section Mise à la terre du

réfrigérateur.

Ce symbole représente une alerte de sécurité. Ce symbole vous avise de dangers possibles pouvant causer la mort, des

blessures ou autres. Tous les messages de sécurité seront précédés du symbole d’alerte de sécurité ainsi que des mots «

DANGER », « AVERTISSEMENT » ou « MISE EN GARDE ». Ces messages sont les suivants :

Signale une situation qui présente un danger imminent et qui, si elle n’est pas évitée, entraînera des bles

sures graves, voire la mort.

Signale une situation qui présente un danger imminent et qui, si elle n’est pas évitée, peut entraîner des

blessures graves, voire la mort. .

Signale une situation qui présente un danger imminent et qui, si elle n’est pas évitée, peut entraîner des

blessures mineures ou graves.

AVERTISSEMENT

DANGER

ATTENTION

Contents

Safety 2, 3

Instructions for Standard Installation 5-21

Design Guide

The Installation Space 6

Dimensions and Clearances 6

Custom Handle Design Guide 7

Customization Basics 7

Refrigerator Location 7

Optional Accessory Kits 7

3/4” Overlay Panel Dimensions 8

1/4” Framed Panel Dimensions 9

Side Panels 9

130° Door Swing 10

90° Door Swing 11

Installation Instructions

Tools, Hardware, Materials, Flooring 12

Refrigerator Location 12

Grounding the Unit 12

Step 1. Remove Packaging 13

Step 2. Install Water Line 13

Step 2A. Water Line with Reverse Osmosis System 14

Step 3. Install Side Panels 14

Step 4. Anti-Tip Procedures 14-15

Step 5. Level Refrigerator 16

Step 6, Secure Unit to Wall 16

Step 7. Alternate Anti-Tip Procedure 17

Step 8. Adjust Door Swing 17

Step 9, Install Grille Panel 18

Step 10, Install 1/4” Framed Panels 18

Step 10A, Install Overlay Panels 19

Step 11. Connect Water Supply 20

Step 12. Connect Power 20

Step 13. Start Icemaker 20

Step 14. Install Toekick 21

Inspect Final Installation 21

Instructions for Flush Installation 22-38

Design Guide

The Installation Space 23

Dimensions and Clearances 23

Custom Handle Design Guide 23

1/2” Overlay Panel Dimensions 24

3/4” Decorative Panel Dimensions 25

Customization Basics 25

Refrigerator Location 25

3/4” Raised Fresh Food Door Panel Routing 26

3/4” Raised Freezer Drawer Panel Routing 27

3/4” Raised Grille Panel Routing 28

Optional Accessory Kits 28

Side Panels 29

Side Cleats 29

Installation Instructions

Tools, Hardware, Materials, Flooring 30

Grounding the Refrigerator 30

Step 1. Remove Packaging 31

Step 2. Install Water Line 31

Step 2A. Water Line with Reverse Osmosis System 32

Step 3. Install Side Panels 32

Step 4. Install Case Trim 32

Step 5. Anti-Tip Procedure 32-34

Step 6. Level Refrigerator 34

Step 7. Secure Unit to Wall 34

Step 8. Alternate Anti-Tip Procedure 35

Step 9. Adjust Door Swing 35

Step 10. Install Grille Panel 36

Step 11. Install Assembled Panels 36

Step 12. Connect Water Supply 37

Step 13. Connect Power 37

Step 14. Start Icemaker 37

Step 15. Install Toekick 38

Inspect Final Installation 38

Instructions for Stainless Steel Installation 39-46

Design Guide

The Installation Space 40

Dimensions and Clearances 40

Customization Basics 41

Side Panels 41

Refrigerator Location 41

130° Door Swing 42

90° Door Swing 43

Installation Instructions

Tools, Hardware, Materials, Flooring 44

Grounding the Refrigerator 44

Step 1. Remove Packaging 45

Step 2. Install Water Line 45

Step 2A. Water Line with Reverse Osmosis System 46

Step 3. Install Side Panels 46

Step 4. Anti-Tip Procedure 46-47

Step 5. Level Refrigerator 48

Step 6, Secure Unit to Wall 48

Step 7. Alternate Anti-Tip Procedure 49

Step 8. Adjust Door Swing 49

Step 9. Connect Water Supply 50

Step 10. Connect Power 50

Step 11. Start Icemaker 50

Step 12. Install Toekick 51

Inspect Final Installation 51

Instructions for Standard Installation

Design Guide - Standard Installation

36" Frame to

Frame Width

*84" From

Floor to

Top Frame

35"

Case Width

*83 1/2"

Rear

25-3/8"

Case Depth

Depth Including

Handles: 27-1/2"

THE INSTALLATION SPACE

Water And Electrical Locations

Electrical and water supply must be located as shown.

The cutout depth must be 24

”

The refrigerator will project forward, slightly beyond

adjacent cabinetry, depending on your installation.

Allow minimum 1/8” air gap between case back & wall.

Cutout depth beneath a soffit:

When installed beneath a soffit, the soffit cannot exceed

the 24”installation depth shown. The top case trim

overlaps the bottom of the soffit.

Additional Specifications

• A 115 volt 60Hz., 15 or 20 amp power supply is required.

An individual properly grounded branch circuit or circuit

breaker is recommended. Install

a properly grounded 3-prong electrical receptacle

recessed into the back wall. Electrical must be located

on rear wall as shown.

NOTE: GFI (ground fault interrupter) is not recommended.

• Water line can enter the opening through the floor

or back wall. Route GE SmartConnect™kit or 1/4”O.D.

copper tubing between the cold water line and the

water connection location. The tubing should be

long enough to extend to the front of the refrigerator.

Installation of an easily accessible shut-off valve in the

water line is required.

DIMENSIONS AND CLEARANCES

* Shipping height. The

refrigerator can be

adjusted to fit into a

cutout that is 83-1/2”

min. to 84-1/2”max.

height. Note that the top

case trim at the front is

1/2”higher and will

overlap upper cabinetry

or soffit. Use leveling

legs and wheels for a

maximum 1”height

adjustment.

Product Clearances

These refrigerators are equipped with a 3-position door

stop. The factory set 115° door swing can be adjusted to

90° if clearance to adjacent cabinets or walls is restricted.

23-7/8"

Behind

Frame

90°90° 18-3/16”

4” Min. Distance

to Adjacent Wall

from Cutout

Wall View

Electrical

Area

84-1/2" max

Finished

Opening

75" From

Floor to

Bottom

of Electrical Area

10"

24" Cutout Depth

35-1/2"

Finished Width

2-5/16"

10"

3-1/2" 3-1/2"

3-1/2"

Water Supply

12-1/8"

Min. to

Wall

12-1/8"

Min. to

Wall

130°

The finished

cutout width

must be

35-1/2”.

Allow 12-1/8”minimum clearance for a full 130° door

swing.

For a 90° door swing, allow 4”min. clearance to

adjacent wall from cutout. If the 90° doorstop position

is used, pan access is maintained, but pan removal is

restricted.

See illustrations pages 10 and 11 to determine door

swing interaction with adjacent cabinets or countertops.

Min. to

Wall

Min. to

Wall

115°

CUSTOMIZATION BASICS:

Framed Or Overlay Panels, Custom

Handles and Accessory Kits

These refrigerators are designed to be customized with

decorative panels. Field installed custom door and grille

panels are required.

Side Panels

Side panels must be used whenever the sides of the

refrigerator will be exposed.

Optional Accessory Kits

• ZKHFD2H: Monogram Tubular Stainless Steel handles

designed to fit 3/4”overlay panels.

Design Guide - Standard Installation

REFRIGERATOR LOCATION

• Do not install the refrigerator where the temperature

will go below 60°F (16°C). It will not run often enough

to maintain proper temperatures.

• Do not install the refrigerator where temperatures will

go above 100°F (37°C). It will not perform properly.

• Do not install the refrigerator in a location exposed to

water (rain, etc.) or direct sunlight.

• Install it on a floor strong enough to support it fully

loaded.

CUSTOM HANDLE DESIGN GUIDE

Custom handles must be used for flush installation. For

custom handle installation, counterbore holes in rear of

decorative panels must ensure 1/2” material thickness

remains for handle support.

NOTE: The counterbore must not exceed 1” in diameter.

Minimum distance on Fresh Food Doors from handle side

edge to handle center should be 1-1/4” on each door as

shown.

Minimum distance on Freezer Door from top edge to

handle center on the freezer drawer should be 1-1/4” as

shown.

7/8"

1-1/10"

3/4"

Countersink screw

into panel as shown.

1-1/4”

3/4”OVERLAY PANEL DIMENSIONS

For a more custom appearance, overlay panels may be installed

on trimmed models. The overlay panel must be secured to a

1/4”thick backer panel which slides into the trim. A spacer

panel 0.10”thick must be placed between the overlay and

backer panel.

Assemble the panels with glue and screws.

• Center the spacer panel on the backer panel, left to right and

top to bottom. Secure the panels with glue.

• Refer to the following chart for locating the backer panel to

the overlay panel. Secure the overlay panel to the backer

panel with glue and screws. Screws must be countersunk into

the backer panel.

Spacer Panel

Backer Panel

Overlay Panel

NOTE: Left-to-right offset is not always equal to

top-to-bottom offset.

IMPORTANT NOTE: Maximum

total weight for the assembled

panels:

• Fresh food door panels – 30 lbs.

• Freezer drawer panel – 28 lbs.

• Grille Panel – 11 lbs.

Design Guide - Standard Installation

Panel Locations

.25" + .10" + .75" = 1.10" Total Panel Thickness

Fresh Food Freezer Grille

1/4” Backer Panel 46-1/16” x 16-1/2” 33-7/8” x 21-7/8” 33-7/8” x 8-7/8”

.10” Spacer Panel 44-11/16” x 15” 32-1/2” x 20-1/2” 32-1/2” x 7-5/8”

3/4” Overlay Panel 46-5/16” x 16-5/8” 34-1/8” x 22" 34-1/8” x 9”

ABCD

Door Panels 1/8” 0 1/8” 1/8”

Drawer Panel 1/8” 1/8” 1/16” 1/16”

Grille Panel 1/8” 1/8” 1/16” 1/16”

Panel Dimensions

Hinge

Side

Hinge

Side

Handle

Side

Fresh

Food

Back

Backer with

Overlay Panel

Assembly

Fresh

Food

Back

A B

Grille Back

A B

Freezer Back

1/4”FRAMED PANEL DIMENSIONS

If you choose to install framed panels, they must be cut

to the dimensions shown. The panels will slide into the

frame on the door, drawer and grille.

If the custom panel is less than 1/4”thick and if it fits

loosely in the door frame, it can be backed up with a

piece of filler material or foam tape to improve the fit.

1/4"

Panel

Door

5/16"

Trim

Reveal

Design Guide - Standard Installation

*84"

2-9/16"

24"

*3" to 4"

3/16"

1-7/8"

SIDE PANELS

Side panels must be used whenever the sides of the

refrigerator will be exposed. The 1/4”side panels will

slip into the side case trim. Secure the panels to the

refrigerator with stick-on hook and loop fastener strips.

Order the side panels from the cabinet manufacturer.

• Cut a notch in the top front corner as shown to allow

clearance for corner keys in the front side trim.

* Depending on

installation height.

NOTE: Maximum total panel weight:

• Fresh food door panels – 30 lbs.

• Freezer drawer panel – 28 lbs.

• Grille Panel – 11 lbs.

Panel Dimensions

1/4” Framed Panel 46-1/16” x 16-1/2” 33-7/8” x 21-7/8” 33-7/8” x 8-7/8”

1/4" 1/2" 3/4" 1" 1-1/4"

3/4" Overlay

Panel

(Nominal Size)

Stainless Steel

1/4"

1/2"

3/4"

1-1/4"

1-1/2"

1-3/4"

2-1/4"

2-1/2"

2-3/4"

1/4"

1/2"

3/4"

Door

23-7/8" From

Rear of

Refrigerator

Case

Trim

Top View

130° DOOR SWING

Scale 1:1

Frameless Cabinets: The case trim

overlaps cabinets at the top and sides.

Therefore, frameless cabinets

may require filler strips to prevent

interference with cabinet door swing.

The opening must allow for filler strips.

Design Guide - Standard Installation

Andere Handbücher für ZIP360NH

Inhaltsverzeichnis

Andere Monogram Kühlschrank Handbücher

Monogram

Monogram ZIS36NY Bedienungsanleitung

Monogram

Monogram ZDOD240 Bedienungsanleitung

Monogram

Monogram ZIPP360NHSS Bedienungsanleitung

Monogram

Monogram ZFGP21HXASS Bedienungsanleitung

Monogram

Monogram ZFGB21HXCSS Bedienungsanleitung

Monogram

Monogram ZlS360N Bedienungsanleitung

Monogram

Monogram ZIS480NRF Bedienungsanleitung

Monogram

Monogram ZIDI240 Bedienungsanleitung

Monogram

Monogram ZIR301NBRII Bedienungsanleitung

Monogram

Monogram ZIDI240 Bedienungsanleitung

Monogram

Monogram Monogram ZIRS360NX Handbuch

Monogram

Monogram ZIFX240HX Bedienungsanleitung

Monogram

Monogram ENERGY STAR ZWE23ESHSS Bedienungsanleitung

Monogram

Monogram ZDOD240 Bedienungsanleitung

Monogram

Monogram Monogram ZISB480DR Benutzerhandbuch

Monogram

Monogram Monogram ZFSB25DSS Bedienungsanleitung

Monogram

Monogram Monogram ZISW36DRC Bedienungsanleitung

Monogram

Monogram ZIF181 Bedienungsanleitung

Monogram

Monogram ZIFS360NHRH Bedienungsanleitung

Monogram

Monogram ZIK30GNHII Bedienungsanleitung

Monogram

Monogram ZIFI240 Bedienungsanleitung

Monogram

Monogram Monogram ZISB360DR Bedienungsanleitung

Monogram

Monogram ZIFI240 Bedienungsanleitung

Monogram

Monogram ZIFI240HII Bedienungsanleitung

Beliebte Kühlschrank Handbücher anderer Marken

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Bedienungsanleitung

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Bedienungsanleitung

Sharp

Sharp SJ-BA31IEXW2-EU Bedienungsanleitung

CORBERO

CORBERO CC2300MCW Bedienungsanleitung

KitchenAid

KitchenAid 2205264 Bedienungsanleitung

Stengel

Stengel KU 1101 A++ Bedienungsanleitung

NEFF

NEFF KI181 Series Bedienungsanleitung

Hoshizaki

Hoshizaki Reach-In Bedienungsanleitung

Amana

Amana ASD2524VES00 Bedienungsanleitung

BOMANN

BOMANN KGC 213 Bedienungsanleitung

Danby

Danby DAR044A1SLDD Montageanleitung

Samsung

Samsung RF323TE Bedienungsanleitung

Beko

Beko CSA31022 Bedienungsanleitung

IKEA

IKEA FROSTIG C 185 E Bedienungsanleitung

Electrolux

Electrolux ER 6821 D Bedienungsanleitung

True

True TS-28 Bedienungsanleitung

Frigidaire

Frigidaire FSC23R5DW9 Bedienungsanleitung

Beko

Beko LSP4579W Bedienungsanleitung