MULTIQUIP WHISPERWATT DCA10SPX4 Leitfaden

PARTS AND OPERATION MANUAL

OPERATION AND PARTS MANUAL

THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.

To find the latest revision of this

publication, visit our website at:

www.mqpower.com

WHISPERWATTTM SERIES

MODEL DCA10SPX4

MODEL DCA10SPXU4

50 Hz GENERATORS

(KUBOTA D1503-M DIESEL ENGINE)

Revision #0 (08/05/09)

(DCA10SPX4 S/N 3819207~)

(DCA10SPXU4 S/N 8710001~)

PAGE 2 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)

Diesel engine exhaust and some of

DCA10SPX4/DCA10SPXU4 — PROPOSITION 65 WARNING

DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 3

DCA10SPX4/DCA10SPXU4 — NOTE PAGE

PAGE 4 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)

DCA10SPX4/DCA10SPXU4 —TABLE OF CONTENTS

Specifications are subject to

change without notice.

NOTE

MQ POWER DCA-10SPX4MQ POWER DCA-10SPX4

MQ POWER DCA-10SPX4

WHISPERWHISPER

WHISPERWW

WAA

ATTTT

TTTT

TTTMTM

TMTM

GENERATORGENERATOR

GENERATOR

California Proposition 65 Warning .................................... 2

Table Of Contents ............................................................4

Parts Ordering Procedures .............................................. 5

Specifications ................................................................... 6

Dimensions (Top, Side, Front) .......................................... 7

Safety Message Alert Symbols .................................... 8-9

Rules for Safe Operation .......................................... 10-14

Installation ................................................................ 16-17

General Information ....................................................... 18

Major Components ......................................................... 19

Generator Control Panel ................................................ 20

Output Terminal Panel Familiarization ...................... 21-23

Load Application/Maximum Amperage ...........................24

Setup ........................................................................ 25-28

Generator Start-up Procedure.................................. 29-30

Generator Shut-Down Procedure ...................................31

Maintenance (Engine) .............................................. 32-33

Maintenance (Trailer) ................................................ 34-36

Generator Wiring Diagram ..............................................37

Engine Wiring Diagram ..................................................38

Troubleshooting (Engine) ......................................... 39-40

Troubleshooting (Generator) .......................................... 41

Troubleshooting (Pre-heat Lamp Codes) .......................42

Explanation of Code in Remarks Column ......................44

Suggested Spare Parts .................................................. 45

COMPONENT DRACOMPONENT DRA

COMPONENT DRAWINGSWINGS

WINGSWINGS

WINGS

Generator Assembly ................................................. 46-47

Control Panel Assembly ........................................... 48-51

Output Receptacle Assembly ................................... 52-53

Engine and Radiator Assembly ................................ 54-57

Battery Assembly (DCA10SPX4) ............................. 58-59

Battery Assembly (DCA10SPXU4)........................... 60-61

Muffler Assembly ...................................................... 62-63

Fuel Tank Assembly ................................................. 64-65

Enclosure Assembly ................................................. 66-69

Rubber Seals Assembly ........................................... 70-71

Nameplate and Decals ............................................. 72-73

Terms and Condition of Sale — Parts ............................ 74

DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 5

DCA10SPX4/DCA10SPXU4 — PARTS ORDERING PROCEDURES

www.mqpower.com

Ordering parts has never been easier!

Choose from three easy options:

WE ACCEPT ALL MAJOR CREDIT CARDS!

When ordering parts, please supply:

❒❒

❒

Dealer Account Number

❒❒

❒

Dealer Name and Address

❒❒

❒

Shipping Address (if different than billing address)

❒❒

❒

Return Fax Number

❒❒

❒

Applicable Model Number

❒❒

❒

Specify Preferred Method of Shipment:

✓

UPS/Fed Ex

DHL

Priority One Truck

Ground

Next Day

All orders are treated as

Standard Orders

and will ship the same day if received

If you have an MQ Account, to obtain a

Username and Password, E-mail us at:

part[email protected].

To obtain an MQ Account, contact your

Order via Internet (Dealers Only):

Order parts on-line using Multiquip’s SmartEquip website!

■

View Parts Diagrams

Order Parts

Note: Discounts Are Subject To Change

Goto www.multiquip.com and click on

Order Parts to log in and

save!

Use the

internet

and qualify for a 5% Discount

Standard orders

for all orders which include

Order via Fax (Dealers Only):

All customers are welcome to order parts via Fax.

Domestic (US) Customers dial:

Fax

your order in and qualify for a 2% Discount

Standard orders

for all orders which include

Order via Phone: Domestic (US) Dealers Call:

International Customers

should contact

their local Multiquip Representatives for

Non-Dealer Customers:

Contact your local Multiquip Dealer for

parts or call 800-427-1244 for help in

Note: Discounts Are Subject To Change

Effective: January

PAGE 6 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)

DCA10SPX4/DCA10SPXU4 — SPECIFICATIONS

snoitacificepSrotareneG.1elbaT

ledoM4UXPS01ACD/4XPS01ACD

epyT suonorhcnysepytdetcetorpnepo,detalitnevfles,dleifgnivloveR

rotareneg

esahP e

sahPelgniS

tuptuOybdnatS WK8.8

tuptuOemirP WK8

egatloV 001/V002

ycneuqerF zH05

deepS mpr0051

rotcaFrewoP 0.1

)A(BdleveLdnuoS

)sretem7(.tf32@ 16

thgieWyrD.xorppA ).gk205(.sbl701,1

thgieWteW.xorppA ).gk765(.sbl052,1

snoitacificepSenignE.2elbaT

ledoM M-3051DATOBUK

epyT epytrebmahcnoitsubmoclriws,delooc-retaw,elcyC4

srednilyCfo.oN srednilyc3

ekortSxer

oB )mm4.29xmm38(.ni46.3x.ni72.3

deepSdetaR mpr0051

tnemecalpsiD )cc894,1(.ni.uc4.19

gnitratS cirtcelE

yticapa

CtnalooC )sretil7(.lag58.1

yticapaCliOebuL )sretil6.5(.lag84.1

yticapaCknaTleuF )sretil26(.lag4.61

noitpmus

noCleuF tarh/)L0.3(.lag97.0 daollluf

yrettaB 1xhA56V21

leuF leuFleseiD2#

DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 7

DCA10SPX4/DCA10SPXU4 — DIMENSIONS (TOP, SIDE AND FRONT)

Figure 1. Dimensions

SNOISNEMID.3ELBAT

retteLecnerefeR).mm(.tfnoisnemiD

A).mm055(.ni56.12

B).mm094(.ni92.91

C).mm074(.ni05.81

D).mm004,1(.ni21.55

E).mm

009(.ni34.53

F).mm056(.ni00.62

PAGE 8 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)

This Owner's Manual has been

developed to provide complete

instructions for the safe and

efficient operation of the

MQ Power

Generator.

Before using this generator,

ensure that the operating individual has read and

understands all instructions in this manual.

Safety precautions should be followed at all times when

operating this equipment. Failure to read and understand

the Safety Messages and Operating Instructions could result

in injury to yourself and others.

FOR YOUR SAFETY AND THE SAFETY OF OTHERS! HAZARD SYMBOLS

Potential hazards associated with the operation of this

equipment will be referenced with "

Hazard Symbols

" which

appear throughout this manual, and will be referenced in

conjunction with Safety "

Message Alert Symbols

NOTE

DCA10SPX4/DCA10SPXU4 — SAFETY MESSAGE ALERT SYMBOLS

SAFETY MESSAGE ALERT SYMBOLS

The three (3) Safety Messages shown below will inform you

about potential hazards that could injure you or others. The

Safety Messages specifically address the level of exposure

to the operator, and are preceded by one of three words:

DANGER, WARNING, or CAUTION.

You WILL be KILLED or SERIOUSLY injured if you

do not follow directions.

You COULD be KILLED or SERIOUSLY injured if

you do not follow directions.

You CAN be injured if you do not follow directions

Gasoline engine exhaust gases contain

poisonous carbon monoxide. This gas is

colorless and odorless, and can cause

DEATH

if inhaled. NEVER operate this

equipment in a confined area or enclosed structure that

does not provide ample free flow air.

Diesel fuel

is extremely flammable, and

its vapors can cause an explosion if

ignited. DO NOT start the engine near

spilled fuel or combustible fluids.

DO NOT fill the fuel tank while the engine

is running or hot.

DO NOT overfill tank, since spilled fuel could ignite if it

comes into contact with hot engine parts or sparks from

the ignition system. Store fuel in approved containers, in

well-ventilated areas and away from sparks and flames.

NEVER use fuel as a cleaning agent.

Engine components can generate extreme

heat.To prevent burns, DO NOT touch these

areas while the engine is running or

immediately after operations. NEVER

operate the engine with heat shields or heat

guards removed.

WARNING

DANGER

CAUTION

WARNING - LETHAL EXHAUST GASES

WARNING - BURN HAZARDS

WARNING - EXPLOSIVE FUEL

During operation of this generator, there

exists the possibility of

electrocution,

electrical shock or burn,

which can cause

severe bodily harm

or even

DEATH!

DANGER - ELECTROCUTION HAZARDS

DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 9

DCA10SPX4/DCA10SPXU4 — SAFETY MESSAGE ALERT SYMBOLS

ALWAYS place the engine ON/OFF

switch (MPEC) in the OFF/RESET

position when the generator is not in use.

ALWAYS wear approved

respiratory

protection.

ALWAYS wear approved

eye

and

hearing

protection.

Other important messages are provided throughout this

manual to help prevent damage to your generator, other

property, or the surrounding environment.

This generator, other property,

or the surrounding environment

could be damaged if you do not

follow instructions.

NOTE

NEVER tamper with the factory settings

of the engine governor or settings.

Personal injury and damage to the engine

or equipment can result if operating in

speed ranges above maximum allowable.

CAUTION - OVER-SPEED CONDITIONS

CAUTION - ACCIDENTAL STARTING

CAUTION - RESPIRATORY HAZARDS

CAUTION - SIGHT AND HEARING HAZARDS

CAUTION - EQUIPMENT DAMAGE MESSAGES

NEVER operate equipment with covers,

or guards removed. Keep

fingers

hands

hair

and clothing away from all

moving parts to prevent injury.

WARNING - ROTATING PARTS

Wet-Stacking is a common problem with diesel engines

which are operated for extended periods with light or no

load applied. When a diesel engine operates without

sufficient load (less than 40% of the rated output) it will

not operate at its optimum temperature. This will allow

unburned fuel to accumulate in the exhaust system, which

can foul the fuel injectors, engine valves and exhaust

system, including turbocharges, and reduce the operating

performance.

In order for a diesel engine to operate at peak efficiency it

must be able to provide fuel and air in the proper ratio and

at a high enough engine temperature for the engine to

completely burn all of the fuel.

Wet stacking does usually cause any permanent damage

and can be alleviated if additional load is applied to relieve

the condition. It can reduce the system performance and

increase maintenance. Applying an increasing load over

a period of time until the excess fuel is burned off and the

system capacity is reached usually can repair the condition.

This can take several hours to burn off the accumulated

unburned fuel.

CAUTION - ENGINE LOAD (WET-STACKING)

PAGE 10 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)

DCA10SPX4/DCA10SPXU4 — RULES FOR SAFE OPERATION

The following safety guidelines should always be used when

operating the

generator.

General Safety:

■

DO NOT operate or service this

equipment before reading this entire

manual.

The operator MUST BE familiar with proper safety

precautions and operations techniques before using

generator.

■

This equipment should not be operated by persons under

18 years of age.

■

NEVER operate this equipment without proper protective

clothing, shatterproof glasses, steel-toed boots and other

protective devices required by the job.

■

NEVER operate this equipment when not

feeling well due to fatigue, illness or taking

medicine.

■

NEVER operate this equipment under the influence or

drugs or alcohol.

Failure to follow instructions in this manual may lead to

serious injury

or even

DEATH

! This equipment is to be

operated by trained and qualified personnel only! This

equipment is for industrial use only.

DANGER - READ THIS MANUAL!

■

ALWAYS wear proper respiratory (mask),

hearing and eye protection equipment when

operating the generator.

Whenever necessary, replace nameplate, operation and

safety decals when they become difficult read.

Manufacturer does not assume responsibility for any

accident due to equipment modifications. Unauthorized

equipment modification will void all warranties.

NEVER use accessories or attachments, which are not

recommended by Multiquip for this equipment. Damage

to the equipment and/or injury to user may result.

The engine section of this generators requires an

adequate free flow of cooling air.

NEVER

operate the

generator in any enclosed or narrow area where free

flow of the air is restricted. If the air flow is restricted it will

cause serious damage to

the generators or engine

and may cause injury to

people. Remember the

generator's engine gives

off

DEADLY

carbon

monoxide gas.

NEVER touch the hot exhaust

manifold, muffler or cylinder. Allow

these parts to cool before

servicing engine or generators.

ALWAYS refuel in a well-ventilated area, away from sparks

and open flames.

ALWAYS use extreme caution when

working with flammable liquids. When

refueling, stop the engine and allow it

to cool. DO NOT

smoke

around or near

the machine. Fire or explosion could

result from fuel vapors, or if fuel is spilled

on a hot engine.

NEVER operate the generator in an

explosive atmosphere or near

combustible materials. An explosion or

fire could result causing severe

bodily

harm or even death.

■

NEVER disconnect any

"emergency or safety devices"

These devices are intended for operator safety. Disconnection

of these devices can cause severe injury, bodily harm or even

death! Disconnection of any of these devices will void all

warranties.

DANGEROUS

GAS FUMES

Denyo

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere MULTIQUIP Tragbarer Generator Handbücher

MULTIQUIP

MULTIQUIP Power WHISPERWATT DCA-220SSJ Leitfaden

MULTIQUIP

MULTIQUIP GA-2.9R Leitfaden

MULTIQUIP

MULTIQUIP GAC-6HZ Leitfaden

MULTIQUIP

MULTIQUIP DCA5USI Leitfaden

MULTIQUIP

MULTIQUIP GA-3.6RZ2 Bedienungsanleitung

MULTIQUIP

MULTIQUIP GAC6HRS Leitfaden

MULTIQUIP

MULTIQUIP POWER WHISPERWATT DCA-25SSAI Bedienungsanleitung

MULTIQUIP

MULTIQUIP GA-2.5H Bedienungsanleitung

MULTIQUIP

MULTIQUIP DCA125USI3CAN Leitfaden

MULTIQUIP

MULTIQUIP MQ POWER SG1400C3 Bedienungsanleitung

MULTIQUIP

MULTIQUIP DA7000SS Leitfaden

MULTIQUIP

MULTIQUIP GA6HB Bedienungsanleitung

MULTIQUIP

MULTIQUIP Power WHISPERWATT DCA-220SSK Leitfaden

MULTIQUIP

MULTIQUIP Power WHISPERWATT DCA70USI2 Leitfaden

MULTIQUIP

MULTIQUIP GDP-5HA Bedienungsanleitung

MULTIQUIP

MULTIQUIP WHISPERWATT DCA-15SPXU4 Bedienungsanleitung

MULTIQUIP

MULTIQUIP Power Ultra-Silent DCA-85USJ Leitfaden

MULTIQUIP

MULTIQUIP Power WHISPERWATT DCA-220SSJ Leitfaden

MULTIQUIP

MULTIQUIP DCA85USJ2 Leitfaden

MULTIQUIP

MULTIQUIP Whiteman KD1800/KD6 Bedienungsanleitung

MULTIQUIP

MULTIQUIP Power WHISPERWATT DCA-40SSI Bedienungsanleitung

MULTIQUIP

MULTIQUIP Power Ultra-Silent DCA-70SSIU Leitfaden

MULTIQUIP

MULTIQUIP ga2.5Hr Leitfaden

MULTIQUIP

MULTIQUIP GAC2.2H Leitfaden

Beliebte Tragbarer Generator Handbücher anderer Marken

Kohler

Kohler 20EORZ Bedienungsanleitung

Powerhorse

Powerhorse 83171 Bedienungsanleitung

HURST

HURST ML-630-SI Bedienungsanleitung

ETQ

ETQ TG4000 Bedienungsanleitung

Briggs & Stratton

Briggs & Stratton 40265 Einrichtungshandbuch

evertz

evertz 7700 Series Bedienungsanleitung

Firefly

Firefly Cygnus CYG2400/460/24 Bedienungsanleitung

Owon

Owon Waveform Generator Bedienungsanleitung

Draper

Draper PG950S Firmware-Update

SDMO

SDMO SH 4000 Bedienungsanleitung

EINHELL

EINHELL STE 5500 Bedienungsanleitung

Wanco

Wanco WI3000P Bedienungsanleitung

Full Boar

Full Boar FBT-3300 Bedienungsanleitung

Dwyer Instruments

Dwyer Instruments ASG Bedienungsanleitung

Westinghouse

Westinghouse WH1000i Series Bedienungsanleitung

Wallenstein

Wallenstein GF5000A Bedienungsanleitung

Leroy-Somer

Leroy-Somer LSA 49.1 Bedienungsanleitung

Yamakoyo

Yamakoyo SH2900DX Bedienungsanleitung