Panasonic KX-P7100 Bedienungsanleitung

rights reserved. Unauthorized copying and

distribution is a violation of law.

KX-P7100 Laser Printer

ORDER NO.KM60108623C0

KX-P7100

1 Introduction 4

1.1. Specifications 4

1.2. Indicators 9

1.3. Parts Identification 11

1.4. Component Layout and Paper Path 12

1.5. Electrical Components and Sensor Boards 13

1.6. Switches and Solenoids 14

1.7. Print Process 15

1.8. Paper Feed 17

1.9. Laser Scan Unit ( Exposure ) 18

1.10. Fuser Unit 20

1.11. Paper Ejection and Paper Switchback 21

2 Installation, Setup, and Repacking 22

2.1. Installation Requirements 22

2.2. Setup 22

2.3. Repacking 24

3 Removal and Replacement Procedures 27

3.1. Front and Rear Covers 27

3.2. Right, Left and Top Covers 29

3.3. Laser Scanning Unit ( LSU ) 30

3.4. Relay Board (B) 30

3.5. High Voltage Board and Power Supply Unit 31

3.6. Indicator Board and Toner Empty Sensor Board 33

3.7. Main Controller Board and Fuser Drive Gear 33

3.8. Fan Motor 34

3.9. Gear Support Bracket, Motor and Drive Gear Unit 35

3.10. Upper Exit Roller Holder 37

3.11. Fuser Unit 38

3.12. Pickup, Paper Feed, Registration and Transfer Rollers 42

3.13. Transfer Roller Assembly 44

3.14. Auto Duplex Unit, ADU Registration Roller and ADU Pinch

Roller 45

3.15. Registration Sensor, Paper Top Detection Sensor and

Registration & Paper Top Detection Sensor Board 47

4 Electronic Circuit Description and Diagrams 49

4.1. Block Diagram 49

4.2. Connection Diagram 50

4.3. Power Supply 51

4.4. Main Control Board 52

4.5. Timing Chart 71

5 Schematic Diagram 73

5.1. Main Control Board 73

5.2. Sensors, Indicator and Relay Boards 79

6 Explanation of Connectors 81

6.1. Main Board 81

6.2. Registration & Paper Top Sensor Board 86

6.3. Paper Exit / ADU Paper Jam Sensor Board 86

6.4. Indicator Board 86

6.5. Relay Board ( B ) 86

6.6. Toner Empty Sensor Board 87

7 Component Reference Guide 88

7.1. IC1 ( Main Control CPU ) 88

7.2. IC2 ( Inverters ) 88

7.3. IC3 ( GDI ASIC ) 89

7.4. IC5 ( DRAM ) 90

7.5. IC6 ( ASIC ) 91

7.6. IC8 ( USB Chip ) 92

7.7. IC9 ( Comparators ) 92

7.8. IC10 ( Reset IC ) 92

7.9. IC11 ( Engine Control CPU ) 93

7.10. IC12 ( EEPROM ) 93

7.11. IC14 ( Motor driver IC ) 94

7.12. IC15 ( Inverters ) 94

8 Preventative Maintenance 95

8.1. General 95

8.2. Recommended Tools 95

8.3. Recommended Cleaning 95

8.4. Maintenance Tables 95

9 Troubleshooting 98

9.1. Self-Diagnostic Indicators 98

9.2. Initial Troubleshooting Flowchart 101

9.3. No Operation 102

9.4. Print Quality 103

9.5. Paper Jam 113

9.6. Call Service 118

10 Replacement Parts List with Lubrication Guide 126

10.1. Exterior 126

10.2. Right Side Parts 128

10.3. Left Side Parts ( Power Supply Unit and High Voltage

Board ) 132

10.4. Rear and Top Side Parts 133

10.5. Bottom Side Parts 136

10.6. Mechanical Base 138

10.7. Media Tray ( Paper Cassette ) 139

10.8. Packing 140

10.9. Main Control Board 141

10.10. Registration & Paper Top Detection Sensor Board 147

10.11. Paper Exit / ADU Paper Jam Sensor Board 147

10.12. Indicator Board 147

10.13. Toner Empty Sensor Board 148

10.14. Relay Board (A) 148

10.15. Relay Board (B) 148

11 Schematic Diagram for printing with A4 size 149

11.1. Main Control Board 149

11.2. Sensors, Indicator and Relay Boards 162

CONTENTS

Page Page

KX-P7100

1 Introduction

1.1. Specifications

1.1.1. Printer

KX-P7100

1.1.2. Paper

KX-P7100

1.1.3. Interface, Options, Accessories, and Supplies

KX-P7100

1.1.4. Others

1.1.4.1. About Media

Available Media and Media Size

Available Paper Weights and Capacity

KX-P7100

Recommended Media

Transparency:

·To avoid damaging the printer, do not use ink jet transparency.

·Transparencies and adhesive material of labels should be stable at 205°C ( 400°F ), the printer’s maximum temperature.

·Re-using transparencies that have been fed through the printer once ( for example, after jams or if the transparency is ejected

without being printed ) can reduce the life of the consumables and paper path components.

·When using transparencies, if the print quality is poor, print on the other side.

Labels:

·With any label stock, the labels must completely cover the backing material.

Envelope:

It is recommended that you purchase only high quality envelopes with diagonal seams, as shown in the diagram below:

High quality envelopes have the following characteristics:

·A thin, sharply creased leading edge

·Paper weight of 90 g/m2( 24 lbs. )

·Flat, free of curls, wrinkles, nicks, etc.

Note:

Wrinkles may occur, even when using high quality envelopes.

1.1.4.2. Margins and Print Area

The image ( print area ) is printed a bit smaller than the media size. 4.2 mm ( 0.17” ) is required for top, bottom and side margins.

It may be needed to adjust the page margins in the application software to match the allowable printarea.

KX-P7100

1.2. Indicators

1.2.1. Printer Panel

1.2.2. Indicators / Button

Three indicators show the following printer’s status.

For detailed information on the printer status and recovery, see Section 9.1.

KX-P7100

Andere Handbücher für KX-P7100

Inhaltsverzeichnis

Andere Panasonic Drucker Handbücher

Panasonic

Panasonic KX-P3626 Bedienungsanleitung

Panasonic

Panasonic KX-P1090 Bedienungsanleitung

Panasonic

Panasonic Jetwriter KX-P6100 Bedienungsanleitung

Panasonic

Panasonic KXPX10M - DIGITAL VIDEO PRINTER Bedienungsanleitung

Panasonic

Panasonic JT-H340PR Series Bedienungsanleitung

Panasonic

Panasonic KX-P3696 Bedienungsanleitung

Panasonic

Panasonic KX-P1080i Bedienungsanleitung

Panasonic

Panasonic KX-P2124 Bedienungsanleitung

Panasonic

Panasonic KX-CL400 Bedienungsanleitung

Panasonic

Panasonic Network Printing DP2000/2500 Bedienungsanleitung

Panasonic

Panasonic FP-D355 Bedienungsanleitung

Panasonic

Panasonic KX-MB2061CXB Bedienungsanleitung

Panasonic

Panasonic KX-P7500 Bedienungsanleitung

Panasonic

Panasonic KX-MC6000 Series Montageanleitung

Panasonic

Panasonic SP28P Bedienungsanleitung

Panasonic

Panasonic KX P2023 - KX-P 2023 B/W Dot-matrix Printer Bedienungsanleitung

Panasonic

Panasonic KX-P1624 Bedienungsanleitung

Panasonic

Panasonic SV-AP10E Bedienungsanleitung

Panasonic

Panasonic JT-H300PR-E1 Bedienungsanleitung

Panasonic

Panasonic KX-P7310 - KX-P 7310 B/W Laser Printer Bedienungsanleitung

Panasonic

Panasonic SV-P10U Bedienungsanleitung

Panasonic

Panasonic KX-CL400 Bedienungsanleitung

Panasonic

Panasonic PV-PD2000 Bedienungsanleitung

Panasonic

Panasonic SP22P Bedienungsanleitung

Beliebte Drucker Handbücher anderer Marken

Canon

Canon i70 Series Bedienungsanleitung

Evolis

Evolis Elypso Bedienungsanleitung

Kyocera

Kyocera FS-9530DN Bedienungsanleitung

Canon

Canon LASER SHOT LBP-1210 Bedienungsanleitung

Samsung

Samsung BIXOLON SRP-350plusF Bedienungsanleitung

Canon

Canon PIXMA PRO-1 Series Bedienungsanleitung

Canon

Canon PIXMA G3560 Einrichtungshandbuch

Dell

Dell Color Laser Printer 2130cn Bedienungsanleitung

Tektronix

Tektronix Phaser 840 Bedienungsanleitung

Brother

Brother 1440 - HL B/W Laser Printer Kurzanleitung

Fuji Xerox

Fuji Xerox DocuPrint P375 dw Bedienungsanleitung

WOOSIM

WOOSIM PORTI-S30 Bedienungsanleitung

Olivetti

Olivetti PG L2140 Bedienungsanleitung

Konica Minolta

Konica Minolta bizhub 224e Bedienungsanleitung

Canon

Canon LBP113w Bedienungsanleitung

Xerox

Xerox DocuColor 5000 Bedienungsanleitung

Canon

Canon PRO-500 Series Einrichtungshandbuch

Epson

Epson ET-7750 Betriebsanleitung