Polaris FST IQ 2007 Bedienungsanleitung

2007 - 2008 IQ SNOWMOBILE

SERVICE MANUAL

FOREWORD

This service manual is designed primarily for use by certified Polaris Master Service Dealer technicians in a properly

equipped shop and should be kept available for reference. All references to left and right side of the vehicle are from

the operator's perspective when seated in a normal riding position.

Some procedures outlined in this manual require a sound knowledge of mechanical theory, tool use, and shop

proceduresinordertoperformtheworksafelyandcorrectly. Techniciansshouldreadthetextandbefamiliarwithservice

procedures before starting the work. Certain procedures require the use of special tools. Use only the proper tools as

specified.

Comments or suggestions about this manual may be directed to: Service Publications Dept. @ Polaris Sales Inc. 2100

Hwy 55 Medina Minnesota 55340.

2007 - 2008 IQ Snowmobile Service Manual PN 9921044

improvements in thedesign and quality of production components, some minor discrepancies may resultbetween the actual vehicle and the information presented in this

publication. Depictions and/or procedures in this publication are intended for reference use only. No liability can be accepted for omissions or inaccuracies. Any reprinting

or reuse of the depictions and/or procedures contained within, whether whole or in part, is expressly prohibited. Printed in U.S.A.

UNDERSTANDING MANUAL SAFETY LABELS AND DIRECTIONS

Throughout this manual, important information is brought to your attention by the following symbols:

SAFETY ALERT WARNING indicates a potential hazard that may result in severe injury or death to the operator,

bystander or person(s) inspecting or servicing the vehicle.

SAFETYALERTCAUTIONindicatesapotentialhazardthatmayresultinminorpersonalinjuryordamagetothevehicle.

CAUTION indicates special precautions that must be taken to avoid vehicle damage or property damage.

NOTE:

NOTE provides key information by clarifying instructions.

IMPORTANT:

IMPORTANT provides key reminders during disassembly, assembly and inspection of components.

MEASUREMENT provides a key for a determined measurement specification.

TORQUE provides a key for a required torque value.

TRADEMARKS

POLARIS ACKNOWLEDGES THE FOLLOWING PRODUCTS MENTIONED IN THIS MANUAL:

Loctite, Registered Trademark of the Loctite Corporation

Nyogel, Trademark of Wm. F. Nye Co.

Fluke, Registered Trademark of John Fluke Mfg. Co.

Mity-Vac, Registered Trademark of Neward Enterprises, Inc.

Torx, Registered Trademark of Textron

M-10, Registered Trademark of FAST Inc.

WD-40, Registered Trademark of WD-40 Company

Rapid Reaction Driven Clutch, Registered Trademark of Team Industries Inc.

VM and TM Carburetors, Registered Trademarks of Mikuni American Corporation

Fox and Fox PS-5 Registered Trademark of Fox Racing Shox, Inc.

Ryde FX and Air 2.0, Registered Trademark of Arvin Meritor, Inc.

Walker Evans Air Shock, Registered Trademark of Walker Evans Racing, Inc.

WARNING

CAUTION

= In. / mm.

= T

2007 - 2008 IQ Snowmobile

Service Manual Chapters

Model Specifications........................... ....1

General Information............................ ....2

Maintenance....................................... ....3

Fuel Systems...................................... ....4

Engine Systems.................................. ....5

Final Drive and Brake Systems.......... ....6

PVT System........................................ ....7

Suspension and Steering.................... ....8

Shocks................................................ ....9

Chassis............................................... ....10

Electrical Systems.............................. ....11

Wiring Schematics.............................. ....12

Model Specifications

1.1

CHAPTER 1

Model Specifications 1

SPECIFICATIONS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1.2

2007 600 HO IQ . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.2

2007 600 HO SWITCHBACK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.4

2007 600 HO RMK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.6

2007 600 HO IQ CFI. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.8

2007 600 HO SWITCHBACK CFI. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.10

2007 600 HO IQ LX CFI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.12

2007 600 HO IQ TOURING CFI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.14

2007 700 HO IQ DRAGON. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.16

2007 700 HO RMK DRAGON. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.18

2008 IQ SHIFT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.20

2008 600 RMK 144 / 600 RMK SHIFT 155. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.22

2008 600 DRAGON IQ . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.24

2008 600 SWITCHBACK / 600 DRAGON SWITCHBACK. . . . . . . . . . . . . . . . . . . . . . .1.26

2008 600 IQ LX. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.28

2008 600 IQ TOURING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.30

2008 600 RMK 155. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.32

2008 700 IQ / 700 DRAGON IQ . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.34

2008 700 SWITCHBACK / 700 DRAGON SWITCHBACK. . . . . . . . . . . . . . . . . . . . . . .1.36

2008 700 RMK 155 / 700 DRAGON RMK 155 / 163 . . . . . . . . . . . . . . . . . . . . . . . . . . .1.38

2008 800 DRAGON RMK 155 / 163. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.40

1.2

Model Specifications

SPECIFICATIONS

2007 600 HO IQ

Model Number: S07PP6FS (A) (B)

Engine

Engine Type Liberty Liquid-Cooled /

Case Reed Induction

Model Number S3273-6044-PF6F

Displacement / # Cylinders 599cc / 2

Bore (inches/mm) 3.04 / 77.25

Stroke (inches/mm) 2.52 / 64

Piston to Cylinder Clearance

(inches/mm) .004 - .006 / .105 - .159

Installed Ring Gap

(inches / mm) .014 - .020 / .356 - .508

Operating RPM ±200 8100

Idle RPM 1500

Engagement RPM ±200 3800

Exhaust Valve Spring Pink

Carburetor Settings

Type Mikuni TM38

Main Jet 420

Pilot Jet 50

Jet Needle/Clip position 9DGN6-57 / 2

Needle Jet P-8

Throttle Gap (Under Cutaway) (in/mm) 0.08 / 2.1

Cutaway 1.5 Notch

Valve Seat 1.5

Starter Jet 145

Pilot Air Jet .6

Fuel screw (Turns Out) 1.25

Recommended Fuel Octane (R+M/2) 91

(Non-Oxygenated)

Carburetor Jetting

Altitude

Meters (feet)

Ambient Temperature

< -25°F/<-35°C

-30°F to -10°F/-34°C to -23°C

-15°F to +5°F/-26°C to -15°C

0°F to +20°F/-18°C to -7°C

+15°F to +35°F/-9°C to +2°C

+30°F to +50°F/-1°C to +10°C

+45°F to +65°F/+7°C to +18°C

>+60°F/>+16°C

0-600

(0-2000) 440

#3 430

#3 420

#2 400

#2 390

#2 380

#2 370

#2 360

600-1200

(2000-4000) 410

#3 400

#3 390

#2 370

#2 360

#2 350

#2 340

#1 330

1200-1800

(4000-6000) 370

#3 360

#2 350

#2 340

#2 330

#2 320

#1 310

#1 300

1800-2400

(6000-8000) 340

#3 320

#2 310

#2 300

#2 280

#1 270

#1 260

2400-3000

(8000-10000) 310

#2 300

#2 290

#2 280

#1 270

#1 260

#1 250

#1 240

3000-3700

(10000-12000) 290

#2 280

#2 270

#1 250

#1 240

#1 230

#1 220

#1 210

When using non oxygenated fuel with a RON greater than 93,

decrease the main jet number in the above chart by 10 and raise the

E-clip one position. If the chart recommends clip #1,install washer

on top when using RON 93.

Clutch Settings

ALTITUDE

meters

(feet)

DRIVE CLUTCH DRIVEN CLUTCH

Shift

Weight Clutch

Spring Clutch

Spring Driven

Helix Gearing

0-600

(0-2000) 10-62

BLK / GRN

(120 / 340)

(7042083)

RED/BLK

(140 / 240)

(7043058)

64/42.36

LW ER 23:39-76

600-1200

(2000-4000) 10-60

56/42 - .36

LW ER

22:39-76

1200-1800

(4000-6000) 10-58

22:40-76

1800-2400

(6000-8000) 10-56

2400-3000

(8000-10000) 10-54

20:41-76

3000-3600

(10000-12000) 10-AL

Drive Clutch Bolt Torque: 50 lb.ft. (68Nm)

1.3

Model Specifications

General

Width (in/cm) 48 / 121.9

Length (in/cm) 115 / 292.1

Height (in/cm) 48 / 121.9

Estimated Dry Weight

(lb/kg) 475 / 215.7

Fuel (Gallons / Liters) 10.8 / 40.9

Oil (Quarts / Liters) 3.4 / 3.2

Cooling System Capacity

(Quarts / Liters) 6.3 / 6

Brake Fluid DOT 4

Drive Belt

Part Number

Width (inches / cm)

Side Angle

Circumference (inches / cm)

Center Distance (inches / cm)

3211080

1.438 / 3.65

28_

46.625 / 118.4

11.5 / 29.2

Chaincase

Center Distance (inches)

Top Gear (Stock)

Bottom Gear (Stock)

Chain (Stock)

Gear Lube

Capacity (oz / ml)

Reverse System

8.373

Polaris Synthetic

11 / 325.3

Perc

Electrical

Alternator Output

Operating Voltage

Watts @ 13.5 Vdc (Total) 13.5 - 14.5 Vdc

280

Ignition Timing 26_@3500 RPM

(TPS Un-plugged)

Spark Plug Gap in.(mm) .027 (.70)

Spark Plug Champion RN57YCC

CDI Marking 4011033

Flywheel Marking 4010677

Track

Width - Inches (cm) 15 (38)

Length - Inches (cm) 121 (307)

Lug Height - Inches (cm) 1.0 / (2.5)

1.25 (3.175) - Option

Tracktensionsagin/cm with

10 lbs/4.54kg placed 16 in/

40cm ahead of rear idler

shaft

7/8″ - 1-1/8″(2.2 - 2.9cm)

Front Suspension

Suspension Type IQ 42.5

Shocks

Ryde FX HPG w/IFP (STD.)

(Rebuidlable)

Fox Compression Adj. Remote

Resevoir HPG (OPT.)

(Rebuidable)

IFS Spring Rate

lbs/in (N/mm) 100 (17.5)

Spring Installed Length

Inches (cm) 10.55 (26.8)

Front Vertical Travel

Inches (cm) 10 (25.4)

Suspension Setup

Width

Inches (cm) 41.16 (104.54)

Camber Inches (cm) 2.25 ±0.31 (57 ±7.9)

Toe Out Inches (cm) 0 - 0.12 (0 - 0.31)

Rear Suspension

Suspension Type IQ 121

Front Track Shock (FTS)

Ryde FX HPG w/IFP (STD.)

(Rebuildable)

Fox HPG w/IFP (OPT.)

(Rebuildable)

FTS Spring Rate

lbs/in (N/mm) 130 - 270 (23 - 47)

FTS Spring Installed

Length Inches (cm) 7.97 (20.2)

Rear Track Shock (RTS)

Fox PS5 w/IFP (STD.)

(Rebuildable)

Fox Compression Adjustable

Remote Resevoir HPG (OPT.)

(Rebuildable)

Torsion Spring Diameter

Tail Angle .374

80_

Rear Travel Inches (cm) 13.9 (35.3)

1.4

Model Specifications

2007 600 HO Switchback

Model Number: S07PS6FS (A)

Engine

Engine Type Liberty Liquid-Cooled /

Case Reed Induction

Model Number S3273-6044-PF6F

Displacement / # Cylinders 599cc / 2

Bore (inches/mm) 3.04 / 77.25

Stroke (inches/mm) 2.52 / 64

Piston to Cylinder Clearance

(inches/mm) .004 - .006 / .105 - .159

Installed Ring Gap

(inches / mm) .014 - .020 / .356 - .508

Operating RPM ±200 8100

Idle RPM 1500

Engagement RPM ±200 3800

Exhaust Valve Spring Pink

Carburetor Settings

Type Mikuni TM38

Main Jet 420

Pilot Jet 50

Jet Needle/Clip position 9DGN6-57 / 2

Needle Jet P-8

Throttle Gap (Under Cutaway) (in/mm) 0.08 / 2.1

Cutaway 1.5 Notch

Valve Seat 1.5

Starter Jet 145

Pilot Air Jet .6

Fuel screw (Turns Out) 1.25

Recommended Fuel Octane (R+M/2) 91

(Non-Oxygenated)

Carburetor Jetting

Altitude

Meters (feet)

Ambient Temperature

< -25°F/<-35°C

-30°F to -10°F/-34°C to -23°C

-15°F to +5°F/-26°C to -15°C

0°F to +20°F/-18°C to -7°C

+15°F to +35°F/-9°C to +2°C

+30°F to +50°F/-1°C to +10°C

+45°F to +65°F/+7°C to +18°C

>+60°F/>+16°C

0-600

(0-2000) 440

#3 430

#3 420

#2 400

#2 390

#2 380

#2 370

#2 360

600-1200

(2000-4000) 410

#3 400

#3 390

#2 370

#2 360

#2 350

#2 340

#1 330

1200-1800

(4000-6000) 370

#3 360

#2 350

#2 340

#2 330

#2 320

#1 310

#1 300

1800-2400

(6000-8000) 340

#3 320

#2 310

#2 300

#2 280

#1 270

#1 260

2400-3000

(8000-10000) 310

#2 300

#2 290

#2 280

#1 270

#1 260

#1 250

#1 240

3000-3700

(10000-12000) 290

#2 280

#2 270

#1 250

#1 240

#1 230

#1 220

#1 210

When using non oxygenated fuel with a RON greater than 93,

decrease the main jet number in the above chart by 10 and raise the

E-clip one position. If the chart recommends clip #1,install washer

on top when using RON 93.

Clutch Settings

ALTITUDE

meters

(feet)

DRIVE CLUTCH DRIVEN CLUTCH

Shift

Weight Clutch

Spring Clutch

Spring Driven

Helix Gearing

0-600

(0-2000) 10-62

BLK / GRN

(120 / 340)

(7042083)

RED/BLK

(140 / 240)

(7043058)

64/42-.36

LW ER 22:39-76

600-1200

(2000-4000) 10-60

56/42 - .36

LW ER

1200-1800

(4000-6000) 10-58 22:40-76

1800-2400

(6000-8000) 10-56

20:41-76

2400-3000

(8000-10000) 10-54

3000-3600

(10000-12000) 10-AL

Drive Clutch Bolt Torque: 50 lb.ft. (68Nm)

1.5

Model Specifications

General

Width (in/cm) 48 / 121.9

Length (in/cm) 125 / 317.5

Height (in/cm) 48 / 121.9

Estimated Dry Weight

(lb/kg) 483 / 219.3

Fuel (Gallons / Liters) 10.8 / 40.9

Oil (Quarts / Liters) 3.4 / 3.2

Cooling System Capacity

(Quarts / Liters) 6.3 / 6

Brake Fluid DOT 4

Drive Belt

Part Number

Width (inches / cm)

Side Angle

Circumference (inches / cm)

Center Distance (inches / cm)

3211080

1.438 / 3.65

28_

46.625 / 118.4

11.5 / 29.2

Chaincase

Center Distance (inches)

Top Gear (Stock)

Bottom Gear (Stock)

Chain (Stock)

Gear Lube

Capacity (oz / ml)

Reverse System

8.373

Polaris Synthetic

11 / 325.3

Perc

Electrical

Alternator Output

Operating Voltage

Watts @ 13.5 Vdc (Total) 13.5 - 14.5 Vdc

280

Ignition Timing 26_@3500 RPM

(TPS Un-plugged)

Spark Plug Gap in.(mm) .027 (.70)

Spark Plug Champion RN57YCC

CDI Marking 4011033

Flywheel Marking 4010677

Track

Width - Inches (cm) 15 (38)

Length - Inches (cm) 144 (366)

Lug Height - Inches (cm) 1.25 (3.175) (STD.)

1.50 (3.8) (OPT.)

Track tensionsagin/cm with

10 lbs/4.54kg placed 16 in/

40cm ahead of rear idler

shaft

3/8″- 1/2″(1 - 1.3cm)

Front Suspension

Suspension Type IQ 42.5

Shocks

Fox HPG w/IFP (STD.)

(Rebuidlable)

Fox Compression Adj. Remote

Resevoir HPG (OPT.)

(Rebuidable)

IFS Spring Rate

lbs/in (N/mm) 100 (17.5)

Spring Installed Length

Inches (cm) 10.55 (26.8)

Front Vertical Travel

Inches (cm) 10 (25.4)

Ski Center Distance

Inches (cm) 42.5 (108)

Camber Inches (cm) 2.25 ±0.31 (57 ±7.9)

Toe Out Inches (cm) 0 - 0.12 (0 - 0.31)

Rear Suspension

Suspension Type IQ 144

Front Track Shock (FTS) Fox HPG w/IFP

(Rebuildable)

FTS Spring Rate

lbs/in (N/mm) 170 (30)

FTS Spring Installed

Length Inches (cm) 7.25 (18.4)

Rear Track Shock (RTS) Fox Compression Adjustable

Remote Resevoir HPG

(Rebuildable)

Torsion Springs

.359 Square / 77_(Stock)

.347 / 77_/ (Soft)

- PN 7041627 - 067

- PN 7041628 - 067

.375 / 77_/ (Firm)

- PN 7041942 - 067

- PN 7041943 - 067

Rear Travel Inches (cm) 13.9 (35.3)

1.6

Model Specifications

2007 600 HO RMK

Model Number:

144 = S07PK6FS / S07PK6FE

155 = S07PM6FS (A)

Engine

Engine Type Liberty Liquid-Cooled /

Case Reed Induction

Model Number S3273-6044-PF6F

Displacement / # Cylinders 599cc / 2

Bore (inches/mm) 3.04 / 77.25

Stroke (inches/mm) 2.52 / 64

Piston to Cylinder Clearance

(inches/mm) .004 - .006 / .105 - .159

Installed Ring Gap

(inches / mm) .014 - .020 / .356 - .508

Operating RPM ±200 8100

Idle RPM 1500

Engagement RPM ±200 3800

Exhaust Valve Spring Pink

Carburetor Settings

Type Mikuni TM38

Main Jet 280

Pilot Jet 50

Jet Needle/Clip position 9DGN6-57 / 1

Needle Jet P-8

Throttle Gap (Under Cutaway) (in/mm) 0.13 / 3.2

Cutaway 2.5

Valve Seat 1.5

Starter Jet 145

Pilot Air Jet .6

Fuel screw (Turns Out) 1

Recommended Fuel Octane (R+M/2) 91

(Non-Oxygenated)

Carburetor Jetting

Altitude

Meters (feet)

Ambient Temperature

< -25°F/<-35°C

-30°F to -10°F/-34°C to -23°C

-15°F to +5°F/-26°C to -15°C

0°F to +20°F/-18°C to -7°C

+15°F to +35°F/-9°C to +2°C

+30°F to +50°F/-1°C to +10°C

+45°F to +65°F/+7°C to +18°C

>+60°F/>+16°C

0-600

(0-2000) 440

#3 430

#3 420

#2 400

#2 390

#2 380

#2 370

#2 360

600-1200

(2000-4000) 410

#3 400

#3 390

#2 370

#2 360

#2 350

#2 340

#1 330

1200-1800

(4000-6000) 370

#3 360

#2 350

#2 340

#2 330

#2 320

#1 310

#1 300

1800-2400

(6000-8000) 340

#3 320

#2 310

#2 300

#2 280

#1 280

#1 270

#1 260

2400-3000

(8000-10000) 310

#2 300

#2 290

#2 280

#1 270

#1 260

#1 250

#1 240

3000-3700

(10000-12000) 290

#2 280

#2 270

#1 250

#1 240

** 230

** 220

** 210

** = Clip in # 1 position with washer placed on top of clip. When

usingnon-oxygenatedfuelwithaRONgreaterthan93,decreasethe

main jet number in the above chart by 10 and raise the E-clip one

position. If thechart recommends **, do nothing with the clip when

using RON 93.

Clutch Settings

ALTITUDE

meters

(feet)

DRIVE CLUTCH DRIVEN CLUTCH

Shift

Weight Clutch

Spring Clutch

Spring Driven

Helix Gearing

0-600

(0-2000) 10-62

BLK / GRN

(120 / 340)

(7042083)

RED/BLK

(140 / 240)

(7043058)

64/42-.36

LW ER

19:41-76

600-1200

(2000-4000) 10-60

56/42 - .36

LW ER

1200-1800

(4000-6000) 10-58

1800-2400

(6000-8000) 10-56

2400-3000

(8000-10000) 10-54

3000-3600

(10000-12000) 10-AL

Drive Clutch Bolt Torque: 50 lb.ft. (68Nm)

1.7

Model Specifications

General

Width (in/cm) 46.5 / 118.1

Length (in/cm) 144 = 125 / 318

155 = 130 / 330.2

Height (in/cm) 49 / 124.5

Estimated Dry Weight

(lb/kg) 144 = 472 / 214.3

155 = 478 / 217

Fuel (Gallons / Liters) 12 / 45.4

Oil (Quarts / Liters) 3.4 / 3.2

Cooling System Capacity

(Quarts / Liters) 6.3 / 6

Brake Fluid DOT 4

Drive Belt

Part Number

Width (inches / cm)

Side Angle

Circumference (inches / cm)

Center Distance (inches / cm)

3211115

1.460 / 3.7

26_

46.77 / 118.8

11.5 / 29.2

Chaincase

Center Distance (inches)

Top Gear (Stock)

Bottom Gear (Stock)

Chain (Stock)

Gear Lube

Capacity (oz / ml)

Reverse System

8.373

Polaris Synthetic

11 / 325.3

Perc

Electrical

Alternator Output

Operating Voltage

Watts @ 13.5 Vdc (Total) 13.5 - 14.5 Vdc

280

Ignition Timing 26_@3500 RPM

(TPS Un-plugged)

Spark Plug Gap in.(mm) .027 (.70)

Spark Plug Champion RN57YCC

CDI Marking 4011033

Flywheel Marking 4010677

Track

Width - Inches (cm) 15 (38)

Length - Inches (cm) 144 (325)

155 (393.7)

Lug Height - Inches (cm) 2.0(5) or 2.4(6.1)

Track tensionsagin/cm with

10 lbs/4.54kg placed 16 in/

40cm ahead of rear idler

shaft

3/8″- 1/2″(1 - 1.3cm)

Front Suspension

Suspension Type IQ RMK Adjustable

Shocks

Ryde FX Compression Adjustable

(STD.)

Walker Evans Air (OPT.)

(Rebuidable)

IFS Spring Rate

lbs/in (N/mm) 100 (17.5)

Spring Installed Length

Inches (cm) 10.35 (26.3)

WE Air Oil Volume 95cc

WE Air Nitrogen

Charge

Stock

Optional

215 psi

220 - 225 psi

Front Vertical Travel

Inches (cm) 9 (22.9)

Ski Center Distance

Inches (cm) 39(99.1) / 40(101.6) / 41(104.1)

Camber Inches (cm) 2.17 ±0.31 (55 ±7.9)

Toe Out Inches (cm) 0 - 0.12 (0 - 0.31)

Rear Suspension

Suspension Type IQ 144 / 155

Front Track Shock (FTS) Ryde FX (STD.)

Walker Evans Air (OPT.)

FTS Spring Rate

lbs/in (N/mm) 190 (33)

FTS Spring Installed

Length Inches (cm) 7.4 (18.8)

Rear Track Shock (RTS) Ryde FX (STD.)

Walker Evans Air (OPT.)

(Rebuildable)

WE Air Oil Volume 70cc

WE Air Nitrogen Charge

Stock

Optional 215 psi

210 - 220 psi

Torsion Springs

.359 Square / 77_(Stock)

.347 / 77_/ (Soft)

- PN 7041627 - 067

- PN 7041628 - 067

.375 / 77_/ (Firm)

- PN 7041942 - 067

- PN 7041943 - 067

Rear Travel Inches (cm) 144 = 14.5(36.8)

155 = 15.5(39.4)

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Polaris Geländefahrzeug Handbücher

Polaris

Polaris Sportsman 550 XP EPS Bedienungsanleitung

Polaris

Polaris 2000 INDY 700 RMK Konfigurationshandbuch

Polaris

Polaris Sportsman 9922249 Bedienungsanleitung

Polaris

Polaris MV700 Leitfaden

Polaris

Polaris 600 IQ Widetrak Bedienungsanleitung

Polaris

Polaris Sportsman XP Touring 1000 Bedienungsanleitung

Polaris

Polaris RZR 900 2017 Bedienungsanleitung

Polaris

Polaris Sportsman 800 EFI Leitfaden

Polaris

Polaris RZR RS1 2021 Leitfaden

Polaris

Polaris Sportsman 550 EFI Bedienungsanleitung

Polaris

Polaris 2000 INDY 700 XC SP Konfigurationshandbuch

Polaris

Polaris RZR XP Turbo Bedienungsanleitung

Polaris

Polaris Sportsman XP Touring 1000 Bedienungsanleitung

Polaris

Polaris Sportsman 9922551 Bedienungsanleitung

Polaris

Polaris General 2020 Bedienungsanleitung

Polaris

Polaris 120 Bedienungsanleitung

Polaris

Polaris Sportsman 9922475 Bedienungsanleitung

Polaris

Polaris 2000 INDY 500 XC SP Bedienungsanleitung

Polaris

Polaris 2016 RZR XP Turbo Bedienungsanleitung

Polaris

Polaris 2008 Leitfaden

Polaris

Polaris 2003 Scrambler 50 Bedienungsanleitung

Polaris

Polaris SNOWMOBILE 2001 Leitfaden

Polaris

Polaris PHOENIX Phoenix 200 Bedienungsanleitung

Polaris

Polaris SPORTSMAN ACE 2014 Bedienungsanleitung

Beliebte Geländefahrzeug Handbücher anderer Marken

Yamaha

Yamaha Tri Moto 125 Bedienungsanleitung

Yamaha

Yamaha YFM350X Warrior Bedienungsanleitung

APRILIA

APRILIA QUASAR 100 Bedienungsanleitung

Suzuki

Suzuki LT-A700X Bedienungsanleitung

Ski-Doo

Ski-Doo SCANDIC WT Handbuch

Suzuki

Suzuki LT-Z400 Bedienungsanleitung

Arctic Cat

Arctic Cat 120 sno pro Bedienungsanleitung

Yamaha

Yamaha RS90PB Bedienungsanleitung

Dinli

Dinli DL702 Bedienungsanleitung

Yamaha

Yamaha SXV70ML Bedienungsanleitung

Baja motorsports

Baja motorsports ATV 90 Handbuch

Arctic Cat

Arctic Cat ALTERRA 450 Bedienungsanleitung

Yamaha

Yamaha YFM45FAT Handbuch

Can-Am

Can-Am DS 70 Handbuch

Ski-Doo

Ski-Doo SKANDIC Handbuch

Yamaha

Yamaha VT500B Bedienungsanleitung

GAS GAS

GAS GAS K2 QUAD 250 - SERVICE Bedienungsanleitung

GMX

GMX GMXK150WHI Bedienungsanleitung