Proluxe Progrill TW1520 Bedienungsanleitung

formerly DOUGHPRO. New Name. Same Quality. Superior Service.

proluxe.com

Operations Manual

Model: TW1520/TW2025

Tortilla Warming Flat Grills

Operation Instructions

Step 1

Carefully unpack and clean grill plates with

mild soap then sponge clean with cold water.

WARNING

 ALLOW 2” MINIMUM CLEARANCE between

adjacent equipment and/or wall areas.

 DO NOT touch hot surfaces.

Step 3

Plug into proper 3 prong wall outlet. If other appliances

are connected to the same circuit make sure the total

load does not exceed maximum ampacity of the circuit.

Step 4: Warm-up

Energize by turning on the temperature control knob to your desired temperature. (0o-425oF).

 Allow at least 15-20 minutes to pre-heat grill.

 When the pilot light is lit, the temperature has NOT been reached.

 When the pilot light is off, the desired temperature has been reached.

Website: www.doughpro.com E-Mail: [email protected]

PROPROCESS CORPORATION

P.O. Box 869 7328 Madison St. Paramount, CA 90723

(562) 531-0305 (800) 624-6717 Fax (562) 869-7715

FOR SERVICE CALL: (800) 624-6717

Step 2

Place in location where it will be used allowing

for clearances per the dimensions indicated.

3/8” OD (10mm)

protective guard

DIMENSIONS:

TW1520

A-22 3/8” (568mm)

B - 20” (508mm)

C - 17 3/8” (441mm)

D - 15” (381mm)

TW2025

A-27 3/8” (695mm)

B - 25” (635mm)

C - 22 3/8” (568mm)

D - 20” (508mm)

Includes 60” NEMA 5-15P approved cord and plug.

TW2025

208v/60hz

2800w/13.4 amps

TW1520

120v/60hz

1700w/14.17amps

Electrical Data

CLEANING

Use only cleaners which are safe for ALUMINUM.DO NOT use caustic cleaners,

ice or cold water to clean the grill. Turn grill down or OFF during idle periods to

prevent carbon buildup.

1. Turn power off and unplug, allow grill to cool.

2. Remove particles by using a spatula with rounded corners.

3. Wipe down all surfaces using a warm damp cloth and mild detergent.

CARBON CLEANING

When carbon buildup occurs, use a carbon removal agent which is safe for

aluminum, follow the instructions provided with the product. When this process is

complete, you must re-season your grill.

INITIAL START UP

Before using the unit for the first time, wipe down the exterior and platen area

with a damp cloth.

Heat for approximately 30 minutes. The warmer may emit a small amount of

smoke as the cooking surface reaches its operating temperature. This is normal,

as the smoke is caused by oils associated with the manufacturing process and

will stop when the burn off is complete. Brush off any debris from the warming

surface.

SEASONING THE TORTILLA GRILL HEATING SURFACE

FIRST TIME SEASONING

Follow your company/corporate guidelines for seasoning cooking surfaces or

perform the following:

1. Bring the grill to 300°F (148°C) and leave it on while performing the next three

steps.

2. Brush the cooking surfaces with a release agent. If using an aerosol agent,

first apply into a cup and then brush onto cooking surface.

3. Let sit for 20 minutes.

4. Wipe the cooking surface clean, using a warm damp cloth.

*Warning*

DO NOT SUBMERGE IN WATER OR ALLOW WATER TO SPILL INTO THE

ELECTRICAL HOUSING. AS THIS WILL VOID WARRANTY AND DAMAGE

THE UNIT.

*Caution - To reduce the risk of fire, the appliance is to be installed in non-combustible surroundings

only, with no combustible material within 18 inches of the sides, front, or rear of the appliance or within

40 inches above the appliance. The appliance is to be mounted on floors of noncombustible

construction with noncombustible flooring and surface finish and with no combustible material against

the underside, or on noncombustible slabs or arches have no combustible material against the

underside. Such construction shall in all cases extend not less than 12 inches beyond the equipment on

all sides.

14 4X

18X

12 4X

TW2025E

EXPTW2025E NC 102318

CUSTOMER MANUAL

PARTS LIST FOR TW1520 TORTILLA WARMER

TW1520A TW1520B

120 ~ AC 240 ~ AC

1 HEATED PLATEN WITH WIRING ASSY 110843074 110843075 1

3 SCREW, PAN HEAD PHILLIPS 6-32 X 1/4 SP63214 SP63214 1

4 SCREW, SET 3/8-16 X 1.0 SST38161 SST38161 4

5 SCREW, SET3/8-16 X 1/2 SST381612 SST381612 1

6 SPACER, LEG 11082249 11082249 4

7 BOTTOM SHROUD 11082335 11082335 1

8 INSULATION, FIBERGLASS MPSP254 MPSP254 1

9 BOLT, HEX 1/4-20 X 2-3/4 BH1420234 BH1420234 2

10 HEAT GUARD ASSEMBLY 11082310 11082310 1

11 APPLIANCE LEG 4” AE601653 AE601653 4

12 STRAIN RELIEF 3231 3231 1

13 POWER CORD 11080374 11080374 1

14 HOUSING 11082322 11082322 1

15 SCREW, PAN HEAD PHILLIPS 8-32 X 3/8 SST SP83238S SP83238S 4

16 LIGHT PILOT 250~AC (GREEN) 110966018G 110966018G 1

17 THERMOSTAT CONTROLLER ASSEMBLY 570° 11051452 11051452 1

18 SCREW, PAN HEAD PHILLIPS 8-32 X 5/8 SST SP83258S SP83258S 3

19 WASHER, SAE #8 WSAE8 WSAE8 4

20 WASHER, #8 INTERNAL TOOTH LOCK WLIT8 WLIT8 2

21 NUT, HEX 8-32 NH832 NH832 4

22 WASHER, SAE #6 WSAE6 WSAE6 1

23 MANUAL TW1520 MTW1520 MTW1520 1

24 NUT, CONDUIT 1/2" NC12 NC12 1

25 TERMINAL BLOCK #2, DOUBLE 6012 6012 1

26 MARKER STRIP #2 MS6012 MS6012 1

REF #

DESCRIPTION

QTY.

PLTW1520 R7 1426 052413.DOC

PARTS LIST FOR TW2025B TORTILLA WARMER

TW2025B

240 ~ AC

1 HEAT PLATEN 20 X 25 11082231240 1

3 SCREW, PAN HEAD PHILLIPS 6-32 X 1/4 SP63214 1

4 SET SCREW SET CUP POINT 3/8-16 x 1.0 SST38161 4

5 WASHER, SAE #6 WSAE6 1

6 SPACER, LEG 11082249 4

7 BOTTOM SHROUD 11082235 1

8 INSULATION MPSP254 2

9 SCREW, BUTTOM HD ¼-20 x 1/2 SB142012 2

10 HEAT GUARD ASSEMBLY 11082210 1

11 APPLIANCE LEG 4” AE601653 4

12 STRAIN RELIEF 3231 1

13 POWER CORD 1101009176 1

14 HOUSING 11082322 1

15 SCREW, PAN HEAD PHILLIPS 8-32 X 3/8 SST SP83238S 4

16 LIGHT PILOT 250~AC (GREEN) 110966018G 1

17 THERMOSTAT CONTROLLER ASSEMBLY 570° 11051452 1

18 SCREW, PAN HEAD PHILLIPS 8-32 X 5/8 SST SP83258S 3

19 WASHER, SAE #8 WSAE8 4

20 WASHER, #8 INTERNAL TOOTH LOCK WLIT8 2

21 NUT, HEX 8-32 NH832 4

22 MANUAL TW2025 MTW2025 1

23 NUT, CONDUIT 1/2" NC12 1

24 TERMINAL BLOCK #3, DOUBLE 6013 1

25 MARKER STRIP #3, DOUBLE MS6013 1

REF #

DESCRIPTION

QTY

PLTW2025 R7 20558 052413.DOC

PARTSLISTFORMODELTW2025E

ITEM

NO. DESCRIPTION PART NUMBER QTY.

1 SHROUD, TW2025E 110108641 1

2 INSULATION, FIBERGLASS 15 X 20 MPSP254 2

3 SCREW, PAN HEAD PHILLIPS 10-24 X 1/4 STAINLESS STEEL SP102414S 18

4 BURN GUARD ASSEMBLY, TW2025E 110108610 1

5 LEG, APPLIANCE 4" AE601653 4

6 HOUSING, TW1520/TW2025/TW2540 11082322 1

7 MARKER STRIP #3, DOUBLE MS6013 1

8 TERMINAL BLOCK #3, DOUBLE 6013 1

9 NUT, HEX 8-32 NH832 4

10 SCREW, PAN HEAD PHILLIPS 8-32 X 5/8 STAINLESS STEEL SP83258S 2

11 SCREW, PAN HEAD PHILLIPS 8-32 X 3/4 STAINLESS STEEL SP83234S 1

12 WASHER, SAE #8 WSAE8 4

13 WASHER, INTERNAL TOOTH LOCK #8 WLIT8 2

14 SCREW, PAN HEAD PHILLIPS 8-32 X 3/8 STAINLESS STEEL SP83238S 4

15 THERMOSTAT CONTROLLER 11051452 1

16 LIGHT PILOT, 250~AC 110966018 1

17 HOLDER, SENSOR 110108881 1

18 SCREW, PHILLIPS PAN HEAD 6-32 X 1/4 SP63214 1

19 WASHER, SAE #6 WSAE6 1

20 BUTTON, PLUG 7/8" PB78 1

21 HEYCO STRAIN RELIEF 3231 1

22 NUT, CONDUIT 1/2" NC12 1

23 POWER CORD 1101009176 1

24 MANUAL TW2025 MTW2025 1

A1 PLATEN WIRING ONL

110108625K 1

PLTW2025ENC102318CUSTOMERMANUAL

TW1520 WIRE DIAGRAM

VAC: 120 / 230

AMPS: 14.17 / NA

WATTS: 1700 / NA

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Proluxe Grill Handbücher

Proluxe

Proluxe TACO BELL PROGRILL SL1577TBCEC Bedienungsanleitung

Proluxe

Proluxe CSD1515PE Bedienungsanleitung

Proluxe

Proluxe SL1577 Bedienungsanleitung

Proluxe

Proluxe Edge Plus Bedienungsanleitung

Proluxe

Proluxe TACO BELL PROGRILL SL1577TB Bedienungsanleitung

Proluxe

Proluxe Progrill CS1500 Bedienungsanleitung

Proluxe

Proluxe Progrill SL1577PHN Bedienungsanleitung

Proluxe

Proluxe Progrill SL1577W Bedienungsanleitung

Proluxe

Proluxe TW2540 Bedienungsanleitung

Proluxe

Proluxe ProGrill Taco Bell SL1266TB Bedienungsanleitung

Proluxe

Proluxe CSD1212 Bedienungsanleitung

Proluxe

Proluxe Vantage SL SL1577 Bedienungsanleitung

Proluxe

Proluxe TACO BELL PROGRILL SL1577Y Bedienungsanleitung

Proluxe

Proluxe CS157TBA Bedienungsanleitung

Proluxe

Proluxe Tortillapro Pancheros DP2000BPP Bedienungsanleitung

Proluxe

Proluxe CSD1212 Bedienungsanleitung

Proluxe

Proluxe Progrill CS157PHNA Bedienungsanleitung

Proluxe

Proluxe Vantage SL Compact SL1266 Bedienungsanleitung

Proluxe

Proluxe Vantage CS CSD1515PEE Bedienungsanleitung

Proluxe

Proluxe CSD1515 Bedienungsanleitung

Proluxe

Proluxe DEL TACO SL1266DTA Bedienungsanleitung

Proluxe

Proluxe SL1577PHC Bedienungsanleitung

Proluxe

Proluxe Vantage SL Bedienungsanleitung

Proluxe

Proluxe SL1577HDA Bedienungsanleitung

Beliebte Grill Handbücher anderer Marken

Orbegozo

Orbegozo GR 2300 Bedienungsanleitung

bora

bora PT11 Bedienungsanleitung

Klarstein

Klarstein 10031664 Bedienungsanleitung

Garland

Garland MWE3W Bedienungsanleitung

Char-Broil

Char-Broil 463722714 Bedienungsanleitung

Nexgrill

Nexgrill 720-0830HK Bedienungsanleitung

Kenmore

Kenmore 415.16123800 Bedienungsanleitung

Camp Chef

Camp Chef PG24CLAU Bedienungsanleitung

Tucker Barbecues

Tucker Barbecues GTR Series Montageanleitung

Monogram

Monogram ZGG540NCP1SS Bedienungsanleitung

Equipex

Equipex Sodir Savoy Bedienungsanleitung

Gaggenau

Gaggenau VR 414 610 Bedienungsanleitung

Miele

Miele KM 408-1 Bedienungsanleitung

George Foreman

George Foreman GGR50B Bedienungsanleitung

AOG

AOG T series Bedienungsanleitung

Gorenje

Gorenje TG2000CB Bedienungsanleitung

Weber

Weber Genesis Silver-B Permamount NG 051701 Bedienungsanleitung

Glen

Glen SA 3037 Bedienungsanleitung