Prorack K363 Bedienungsanleitung
K363
Fitting Kit
EN Fitting Instructions for Basic Carrier
x 6 x 2 x 4 x 6
x 6 x 2 x 2 x 2
Revision No: 5E 1
Fitting Kit K363
MAX kgs (lbs)
W/P WHD
Toyota
Land Cruiser Prado , 5dr SUV 03-09 EU 75 kgs (165 lbs) 75 kgs (165 lbs)
Land Cruiser Prado , 5dr SUV 03-09 CN 75 kgs (165 lbs) 75 kgs (165 lbs)
Land Cruiser Prado GX, 5dr SUV Dec 09-+ NZ 75 kgs (165 lbs) 100 kgs (220 lbs)
Land Cruiser Prado , 5dr SUV Mar 03-Nov 09 NZ 75 kgs (165 lbs) 75 kgs (165 lbs)
Land Cruiser Prado 120 Series, 5dr SUV Mar 03-Oct
09
AU 75 kgs (165 lbs) 75 kgs (165 lbs)
Land Cruiser Prado GX, 5dr SUV Nov 09-+ AU 75 kgs (165 lbs) 100 kgs (220 lbs)
Land Cruiser V8 200 Series, 5dr SUV 07-12 EU 75 kgs (165 lbs) 100 kgs (220 lbs)
Land Cruiser 200 Series, 5dr SUV 07-+ CN 75 kgs (165 lbs) 100 kgs (220 lbs)
Land Cruiser 200 Series, 5dr SUV 08-12 US 75 kgs (165 lbs) 100 kgs (220 lbs)
Land Cruiser 100 Series, 5dr SUV 98-07 EU 75 kgs (165 lbs) 75 kgs (165 lbs)
Land Cruiser 100 Series, 5dr SUV 98-07 US 75 kgs (165 lbs) 75 kgs (165 lbs)
Land Cruiser 100 Series, 5dr SUV 98-07 ZA 75 kgs (165 lbs) 75 kgs (165 lbs)
Land Cruiser 100 Series, 5dr SUV 98-07 CN 75 kgs (165 lbs) 75 kgs (165 lbs)
Land Cruiser 100 Series, 5dr SUV Apr 98-Jun 07 AU 75 kgs (165 lbs) 75 kgs (165 lbs)
Land Cruiser 100 Series, 5dr SUV Apr 98-Oct 07 NZ 75 kgs (165 lbs) 75 kgs (165 lbs)
Land Cruiser 200 Series, 5dr SUV Aug 07-12 AU 75 kgs (165 lbs) 100 kgs (220 lbs)
Land Cruiser 200 Series, 5dr SUV Nov 07-12 NZ 75 kgs (165 lbs) 100 kgs (220 lbs)
Lexus
LX470 , 5dr SUV Apr 98-Jul 07 AU 75 kgs (165 lbs) 75 kgs (165 lbs)
LX470 , 5dr SUV May 98-Oct 07 NZ 75 kgs (165 lbs) 75 kgs (165 lbs)
2
Fitting Kit EN
K363
First Time Installation
●Remove parts from inside the package and
check. Contact your dealer if any parts are
missing or damaged.
●This kit fits type A, B, C and D.
●These instructions show type A crossbar
fitted. They also apply to type B, C and D.
●Use keys to remove covers.
3
Fitting Kit EN
K363
●Use hex screwdriver to reverse adjusting
screw 10 turns.
●Press adjusting screw and pull crossbar
legs out. Refer to the crossbar instructions
for crossbar adjustment method.
●Ensure each end of the crossbar is
adjusted equally.
●Set bars to length (revert to rear of these
instructions).
●Please check the rear of this manual for
information relating specifically to your
vehicle.
4
Fitting Kit EN
K363
●Tighten adjusting screw to 5 Nm (3.7 ft lb)
hand tight.
●Remove plastic clamp block by gripping bar
leg with fingers and push firmly with
thumbs until clamp block drops out behind
leg.
●Select plastic internal block (from fitting kit)
and insert into foot.
5
Fitting Kit EN
K363
Fitment
●Open or remove fixed-point covers.
●Store items away in a safe place.
●Letters refer to the part numbers stamped
on clamps.
●Clamp Part Number:
A = 5212
B = 5214
●Hook clamps into the fixed points on the
vehicle.
6
Fitting Kit EN
K363
●Place ditch mould insert over the clamp.
●Repeat for all six positions.
●Refer to the underside of the pad for the
part number.
●Letters refer to the pad part numbers and
position.
●Pad Part Number:
A = 11-04-218
B = 11-04-222
C = 11-04-223
7
Fitting Kit EN
K363
●Place pads on roof as per diagram. Screw
thread should be vertically through square
hole in pad.
●Place crossbar foot over clamp bolt.
●Tighten the plastic knob. The side with the
nut showing should be facing up.
8
Fitting Kit EN
K363
●Ensure the plastic knob is in the position
shown when fully tightened.
●Repeat for all six positions.
●Check crossbar is securely attached to the
vehicle.
●Use keys to fit and lock covers
CAUTION: Recheck all fasteners immediately after
a load is applied to the crossbars.
Regularly check screws are tight.
9
Fitting Kit EN
K363
Maintenance
●Clean the car roof and surfaces of the
product that will be in contact with the car
roof.
●Follow the fitting instructions for fitting the
product to your vehicle. Make sure all steps
are carried out in order.
●Set crossbars a minimum distance of
700mm (27 1/2") apart where no other
distance is specified in the fitting
instructions. This is especially important
when carrying long loads.
●Check unit is securely attached whenever
you refit it to the vehicle. If the unit feels
loose, refer to the fitting instructions and
readjust.
●Some glass/panoramic roofs and radio
antennae may not be able to be used when
the product is fitted.
●Do not modify this product.
●Refer to the maximum permitted load
capacity specified in the fitting instructions.
Do not exceed the vehicle manufacturers
roof load rating if it is lower than the
maximum load capacity specified in the
fitting instructions.
●Loads should not overhang the sides of the
product and be evenly distributed with the
lowest possible centre of gravity.
●Long loads should be secured with non-
elastic straps to the front and rear of the
vehicle.
●Objects with pointed ends (e.g. ski poles)
should be carried with the pointed ends to
the rear of the vehicle.
●Remove all loose or removable objects
from the load prior to loading.
●Make sure all loads are securely fastened
with non-elastic straps. Check regularly
during longer journeys.
●A loaded roof rack system can alter the
performance of your vehicle. Be especially
aware of the effects of side winds,
changing of direction, and braking
performance. Avoid rapid acceleration and
deceleration. Drive carefully.
●Note that the total height of the vehicle
increases when upright loads are carried.
●Products should be locked during transport
if they have locks fitted.
10
Inhaltsverzeichnis
Andere Prorack Autozubehör Handbücher
Prorack
Prorack K702 Bedienungsanleitung
Prorack
Prorack K084 Bedienungsanleitung
Prorack
Prorack K136 Bedienungsanleitung
Prorack
Prorack K340 Bedienungsanleitung
Prorack
Prorack K129 Bedienungsanleitung
Prorack
Prorack K488 Bedienungsanleitung
Prorack
Prorack WHISPBAR S53 Bedienungs- und Installationshandbuch
Prorack
Prorack Whispbar S43 Bedienungsanleitung
Prorack
Prorack K569 Bedienungsanleitung
Prorack
Prorack K328 Bedienungsanleitung
Prorack
Prorack K838 Bedienungsanleitung
Prorack
Prorack K455 Bedienungsanleitung
Prorack
Prorack K584 Bedienungsanleitung
Prorack
Prorack K188 Bedienungsanleitung
Prorack
Prorack K327 Bedienungsanleitung
Prorack
Prorack K869 Bedienungsanleitung
Prorack
Prorack K857 Bedienungs- und Installationshandbuch
Prorack
Prorack K010 Bedienungsanleitung
Prorack
Prorack K346 Bedienungsanleitung
Prorack
Prorack PR3600 Bedienungsanleitung
