Prorack K549 Bedienungs- und Installationshandbuch

K549

Fitting Kit

EN Fitting Instructions for Basic Carrier

x 2 x 2 x 2 x 4

x 4 x 2

Revision No: 3C 1

Fitting Kit K549

MAX kgs (lbs)

W/P WHD

Volkswagen

Golf Mk5, 3dr Hatch 06-09 EU 60 kgs (132 lbs) 60 kgs (132 lbs)

Golf Mk6, 3dr Hatch 10-12 AU 60 kgs (132 lbs) 60 kgs (132 lbs)

Golf Rabbit Mk6, 3dr Hatch 10-12 US 60 kgs (132 lbs) 60 kgs (132 lbs)

Golf Mk6, 3dr Hatch 10-12 EU 60 kgs (132 lbs) 60 kgs (132 lbs)

Rabbit Mk5, 3dr Hatch 06-09 US 60 kgs (132 lbs) 60 kgs (132 lbs)

Fitting Kit EN

K549

First Time Installation

●Remove parts from inside the package and

check. Contact your dealer if any parts are

missing or damaged.

●This kit fits type A, B, C and D.

●These instructions show type A crossbar

fitted. They also apply to type B, C and D.

NOTE: Clamp images in these instructions may

not be representative of the clamps in this kit

Fitting Kit EN

K549

●Use keys to remove covers.

●Use hex screwdriver to reverse adjusting

screw 10 turns.

●Press adjusting screw and pull crossbar

legs out. Refer to the crossbar instructions

for crossbar adjustment.

●Ensure each end of the crossbar is

adjusted equally.

Fitting Kit EN

K549

●Remove locking screw.

●Apply protective strip as shown.

Trim if required.

●It is important to put the clamps in the

correct position on the vehicle.

●Letters refer to the part numbers stamped

on clamps.

●Clamp Part Number:

A = 450A

B = 761A

Fitting Kit EN

K549

●Attach clamp to each leg. NOTE; clamps

may have labels showing their positions on

the vehicle (For example; "Front Right").

●Refit locking screw so that it goes through

the hole in the clamp. Do not begin to

tighten the locking screw.

●Fit rubber pads (supplied with fitting kit) to

foot. Pad may vary in shape to that shown.

Fitting Kit EN

K549

●Make sure the pad fits into the holes

underneath the foot.

Fitment

●Place crossbar on vehicle. Minimum

recommended spacing between the bars is

700mm (27 1/2") (unless otherwise stated).

●Please check the rear of this manual for

information relating specifically to your

vehicle.

●Locate vehicle's fixed points.

●Adjust the legs on the crossbar so that they

are positioned equally from the ends of the

crossbar, and the clamps engage firmly on

the body work of the vehicle.

●Clamps directly to edge of roof under the

doors, pin locates in hole on vehicle on

front clamps

Fitting Kit EN

K549

●Tighten adjusting screw to 5 Nm (3.7 ft lb).

●Tighten locking screw on both legs evenly.

●Check crossbar is securely attached to the

vehicle.

Fitting Kit EN

K549

●Use keys to fit and lock covers

Energising Door Seal (Mk5 only)

●Measure doors as shown for starting

placement of door seal.

●Repeat for all doors.

●Ensure door seal positioned as shown.

Fitting Kit EN

K549

●Install door seal.

●Check placement

CAUTION: Recheck all fasteners immediately after

a load is applied to the crossbars.

Regularly check screws are tight.

Inhaltsverzeichnis

Andere Prorack Autozubehör Handbücher

Prorack

Prorack K1007 Bedienungsanleitung

Prorack

Prorack K623 Bedienungsanleitung

Prorack

Prorack K820 Bedienungsanleitung

Prorack

Prorack K387 Bedienungsanleitung

Prorack

Prorack K067 Bedienungsanleitung

Prorack

Prorack K938 Bedienungsanleitung

Prorack

Prorack K993 Bedienungs- und Installationshandbuch

Prorack

Prorack K382 Bedienungsanleitung

Prorack

Prorack K443 Bedienungsanleitung

Prorack

Prorack K143 Bedienungsanleitung

Prorack

Prorack K382 Bedienungsanleitung

Prorack

Prorack K774 Bedienungsanleitung

Prorack

Prorack K679 Bedienungsanleitung

Prorack

Prorack K776 Bedienungs- und Installationshandbuch

Prorack

Prorack K134 Bedienungsanleitung

Prorack

Prorack K677 Bedienungs- und Installationshandbuch

Prorack

Prorack K1013 Bedienungsanleitung

Prorack

Prorack K1027 Bedienungsanleitung

Prorack

Prorack K327 Bedienungsanleitung

Prorack

Prorack K444 Bedienungs- und Installationshandbuch

Prorack

Prorack K931 Bedienungsanleitung

Prorack

Prorack K346 Bedienungsanleitung

Prorack

Prorack K307 Bedienungsanleitung

Prorack

Prorack K162 Bedienungsanleitung

Beliebte Autozubehör Handbücher anderer Marken

James Baroud

James Baroud Odyssey Bedienungsanleitung

Motorola

Motorola i50sx Bedienungsanleitung

Yakima

Yakima 9MM STANDARD BIKE MOUNT Bedienungsanleitung

Feniex

Feniex T3 Bedienungsanleitung

Kia

Kia E8300-4D000 Bedienungsanleitung

Brink

Brink 756843 Bedienungsanleitung

Whispbar

Whispbar K085W Bedienungsanleitung

v.link

v.link CI-VL2-PC-HSD Bedienungsanleitung

Viking

Viking Stack-Rack Kurzanleitung zur Einrichtung

Aries

Aries 203015 Bedienungsanleitung

Choetech

Choetech AT0005 Bedienungsanleitung

ZZ2

ZZ2 ZZAIR-PRO Bedienungsanleitung

Holman

Holman 4A80L Bedienungsanleitung

Thule

Thule 2075 Bedienungsanleitung

Motorola

Motorola T325 Bedienungsanleitung

TAUBENREUTHER

TAUBENREUTHER 16-3950 Installationsanleitung

DV8

DV8 FBJL-02 Bedienungsanleitung

Curt Manufacturing

Curt Manufacturing A25 Bedienungsanleitung