Prorack K603 Bedienungsanleitung

K603

Fitting Kit

EN Fitting Instructions for Basic Carrier

x 4 x 8 x 1 x 1

x 4 x 4 x 4 x 4

x 8 x 4

Revision No: 4C 1

Fitting Kit K603

MAX kgs (lbs)

W/P WHD

Nissan

Navara D40 Double Cab, 4dr Truck 05-+ US 75 kgs (165 lbs) 75 kgs (165 lbs)

Navara D40 Double Cab, 4dr Ute 05-+ EU 75 kgs (165 lbs) 75 kgs (165 lbs)

Navara D40 Double Cab, 4dr Ute Dec 05-+ NZ 75 kgs (165 lbs) 75 kgs (165 lbs)

Navara D40 Double Cab, 4dr Ute Nov 05-+ AU 75 kgs (165 lbs) 75 kgs (165 lbs)

Fitting Kit EN

K603

Items you will require:

●Tape measure

Pen

Cordless drill

Depth stop

Vacuum cleaner

Rust inhibitor

Small paint brush

Neutral cure silicon sealant

Rivet gun

Attention:

●Attaches with permanent mount blocks

riveted to roof. Bar can be removed.

Professional installation advised.

Fitting Kit EN

K603

First Time Installation

●Remove parts from inside the package and

check. Contact your dealer if any parts are

missing or damaged.

●This kit fits type A, B, C and D.

●These instructions show type D crossbar

fitted. They also apply to type A, B and C.

●Use keys to remove covers.

Fitting Kit EN

K603

●Remove Hex Key from right hand cover.

●Use hex screwdriver to reverse adjusting

screw 10 turns.

●Press adjusting screw and pull crossbar

legs out. Refer to the crossbar instructions

for crossbar adjustment.

●Ensure each end of the crossbar is

adjusted equally.

Fitting Kit EN

K603

●Adjust crossbar in or out to suit vehicle.

●Please check the rear of this manual for

information relating specifically to your

vehicle.

●Remove plastic clamp block by gripping bar

leg with fingers and push firmly with

thumbs until clamp block drops out behind

leg.

●Select plastic internal block (from fitting kit)

and insert into foot.

●Repeat for all legs.

Fitting Kit EN

K603

●Tighten adjusting screw to 5 Nm (3.7 ft lb).

●Fit rubber pads (supplied with fitting kit) to

foot. Pad may vary in shape to that shown.

●Make sure the pad fits into the holes

underneath the foot.

●This setup is applicable for two crossbars

only.

●Recommended crossbar placement is as

shown.

Fitting Kit EN

K603

●This setup is applicable for one crossbar

only.

●Recommended single crossbar placement

is above door pillar.

●Apply masking tape to vehicle roof in all

four positions.

●Position the permanent mount block so the

inner edge of the block is on the outer edge

of the ditch channel.

Fitting Kit EN

K603

●With the drill, lightly mark both permanent

mount hole positions while holding the

mount firmly on roof.

●CAUTION: Maximum depth 7mm.

Use 7mm drillstop over supplied 4.9mm

drill bit.

Drill two outside holes at marked positions.

●Remove masking tape.

Fitting Kit EN

K603

●Treat holes to prevent corrosion.

●Apply neutral cure silicon sealant in and

around drilled holes.

●Install rivets through permanent mount

blocks.

Inhaltsverzeichnis

Andere Prorack Autozubehör Handbücher

Prorack

Prorack K383 Bedienungsanleitung

Prorack

Prorack K596 Bedienungsanleitung

Prorack

Prorack K601 Bedienungsanleitung

Prorack

Prorack K398 Bedienungsanleitung

Prorack

Prorack K802 Bedienungsanleitung

Prorack

Prorack PR3097 Bedienungsanleitung

Prorack

Prorack PR3104 Bedienungsanleitung

Prorack

Prorack K107 Bedienungsanleitung

Prorack

Prorack K465 Bedienungsanleitung

Prorack

Prorack K1003 Bedienungsanleitung

Prorack

Prorack K042 Bedienungsanleitung

Prorack

Prorack K1104 Bedienungsanleitung

Prorack

Prorack K629 Bedienungsanleitung

Prorack

Prorack K823 Bedienungsanleitung

Prorack

Prorack K1188 Bedienungsanleitung

Prorack

Prorack K401 Bedienungsanleitung

Prorack

Prorack K869 Bedienungsanleitung

Prorack

Prorack K573 Bedienungsanleitung

Prorack

Prorack K543 Bedienungsanleitung

Prorack

Prorack K312 Bedienungsanleitung

Prorack

Prorack VOYAGER PR3207 Bedienungsanleitung

Prorack

Prorack K718 Bedienungs- und Installationshandbuch

Prorack

Prorack K947 Bedienungsanleitung

Prorack

Prorack K186 Bedienungsanleitung

Beliebte Autozubehör Handbücher anderer Marken

James Baroud

James Baroud Odyssey Bedienungsanleitung

Motorola

Motorola i50sx Bedienungsanleitung

Yakima

Yakima 9MM STANDARD BIKE MOUNT Bedienungsanleitung

Feniex

Feniex T3 Bedienungsanleitung

Renault

Renault 77 11 423 180 Bedienungsanleitung

Kia

Kia E8300-4D000 Bedienungsanleitung

Brink

Brink 756843 Bedienungsanleitung

Whispbar

Whispbar K085W Bedienungsanleitung

v.link

v.link CI-VL2-PC-HSD Bedienungsanleitung

Viking

Viking Stack-Rack Kurzanleitung zur Einrichtung

Aries

Aries 203015 Bedienungsanleitung

Choetech

Choetech AT0005 Bedienungsanleitung

ZZ2

ZZ2 ZZAIR-PRO Bedienungsanleitung

Holman

Holman 4A80L Bedienungsanleitung

Thule

Thule 2075 Bedienungsanleitung

Motorola

Motorola T325 Bedienungsanleitung

TAUBENREUTHER

TAUBENREUTHER 16-3950 Installationsanleitung

DV8

DV8 FBJL-02 Bedienungsanleitung