Pulsar G2319N Bedienungsanleitung

Inverter Gasoline

OPERATOR’S MANUAL

Model: G2319N

Warning: The Engine Exhaust from this product contains chemicals known to

the State of California to cause cancer, birth defects or other reproductive harm.

Introduction. ＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮ 3

Parts Ordering / Customer Service. Ｎ3

Safety Rules . ＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮ 4

Safety Symbols . 4

Safety Instructions . 4

Features.ＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮ 7

Control Panel Functions . ＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮ 8

ON/OFF Start Switch and Choke. 8

Indicator Lights. Ｎ8

DC Protector. Ｎ9

Engine ﾓEconomyﾔControl . Ｎ9

Parallel Outlets. Ｎ1

Fuel Cap Air Vent. 10

Ground Terminal. Ｎ10

Assembly. ＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮ 11

Connecting Generator to an Electrical System. 11

Adding Fuel. 11

Adding / Checking Oil . 12

Operation. ＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮ 13

Grounding the Generator . 13

How to Start Engine. 13

How to Stop Engine. 14

Attaching Electronic Devices. 14

Charging a 12 Volt Battery. 15

AC Parallel Operation. 16

Don’t Overload Generator. 17

Wattage Reference Guide. 17

Maintenance . ＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮ 18

Maintenance Schedule . Ｎ18

Checking＠Spark＠Plug . Ｎ19

Changing Oil . 20

How to Clean Air Filter. 21

How to Clean Fuel Filter . 22

Troubleshooting . ＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮ 24

Specifictions.ＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮ 25

Warranty .ＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮＮ 26

TABLE OF CONTENTS

8USB Outlet

Checking Muffler and Spark Arrestor Ｎ21

Transport & Storage

INTRODUCTION

Thank you for purchasing this superior quality portable generator from PULSAR PRODUCTS INC. When operating and

maintaining this product as instructed in this manual, your generator will give you many years of reliable service.

AC Output

Rated AC Voltage

Rated Frequency

AC Current

5V DC 1.5A

Rated Output 1800W

Maximum Output 2300W

Engine

Displacement 80cc

Engine Type Single cylinder, 4 Stroke, OHV, Air Cooled

Engine Oil Type SAE 10W30

Engine Oil Capacity 350ml / 11.8oz

Fuel Tank Capacity 4.5L / 1.18Gal

camping equipment, lighting, or serve as a back up power source during power outages.

Date of Purchase:

Model Number:

Serial Number

The emissions control system for this generator is compliant with all standards set by the Environmental Protection Agency.

Record the following information below for service or warranty assistance.

120V

60Hz

15A

This generator is an engine-driven, portable generator.It is designed to supply electrical power to operate tools, appliances,

USB Outlet

PULSAR PRODUCTS.I

5721 E. SANTA ANA AVE.

ONTARIO. 91761

How to contact us:

You can contact us by Telephone: 1.866.591.8921, Email: [email protected], or write to us at:

DC Output Cigarette Outlet 12V DC 8A

Indicates a potentially hazardous

situation which could result in

serious injury or death if not avoided.

Toxic Fumes Risk of explosion

Risk of electric shock Hot surface

WARNING!

CAUTION!

Indicates a potentially hazardous

situation which could result in

damage to equipment or property.

the user must understand and follow all manual instructions and use common sense.

Safety Symbols

Read and understand this manual in its entirety before operating this generator. Improper use of

this generator could result in serious injury or death.

WARNING!

Safety Instructions

•Using a generator indoors WILL KILL YOU IN MINUTES!

•Carbon monoxide gas is a poisonous, odorless gas that can cause headache, confusion, fatigue, nausea, fainting,

sickness, seizures, or death. If you start to experience any of these symptoms, IMMEDIATELY get fresh air and seek

medical attention.

•

•Install a battery operated carbon monoxide alarm near bedrooms.

•

•When working in areas where vapors could be inhaled, use a respirator mask according to all of its instructions.

WARNING! monoxide gas from dissipating.

SAFETY RULES

•Always wash hands after handling generator.

WARNING! Engine exhaust contains chemicals that lead to cancer and cause birth defects.

SAFETY RULES

•Do not wear loose clothing or gloves.

•Remove jewelry or anything else that could be caught in moving parts.

•Tie back or wear protective head covering to contain long hair.

WARNING! Starter and other moving parts can catch on clothing, jewelry, and hair.

•

death.

•

on the unit before starting the engine.

•Never smoke while operating or fueling this unit.

•

•Generator should have at least 5 feet of clearance from buildings or other equipment during operation.

•

•When adding or draining fuel, unit should be turned off for at least 2 minutes to cool before removing fuel cap. If unit

has been running then the fuel cap is under pressure, remove slowly.

•To keep fuel from spilling, secure unit so it cannot tip while operating or transporting.

•When transporting unit, disconnect the spark plug wire and make sure the fuel tank is empty with the 3 in 1 switch is

turned to the off position.

WARNING!

Never exceed generators wattage / amperage capacity. This could damage the generator

and / or connected electrical devices.

WARNING!

•ｨ･｣ｫ＠ｯｰ･ｲ｡ｴｩｮｧ＠ｶｯｬｴ｡ｧ･＠｡ｮ､＠ｦｲ･ｱｵ･ｮ｣ｹ＠ｲ･ｱｵｩｲ･ｭ･ｮｴｳ＠ｯｦ＠｡ｬｬ＠･ｬ･｣ｴｲｩ｣｡ｬ＠､･ｶｩ｣･ｳ＠ｰｲｩｯｲ＠ｴｯ＠ｰｬｵｧｧｩｮｧ＠ｴｨ･ｭ＠ｩｮｴｯ＠ｴｨ･＠ｧ･ｮ･ｲ｡ｴｯｲＮ

•To avoid recoil, pull starter cord slowly until resistance is felt, then pull rapidly.

WARNING! Pull cord recoils rapidly and pulls arm towards engine faster than you can let go which

could result in injury.

•ｩｮｧ＠｡ｮｹ＠･ｬ･｣ｴｲｯｮｩ｣＠､･ｶｩ｣･ｳＮ

ﾁｄｩｳ｣ｯｮｮ･｣ｴ＠｡ｬｬ＠･ｬ･｣ｴｲｯｮｩ｣＠､･ｶｩ｣･ｳ＠｢･ｦｯｲ･＠ｳｴｯｰｰｩｮｧ＠ｴｨ･＠･ｮｧｩｮ･Ｎ

WARNING! Never start or stop engine with electrical devices plugged in to the receptacles. Failure to

do so could damage the generator and / or connected electrical devices.

•

•Allow hot components to cool before touching.

WARNING! Avoid contacting hot areas of this unit.

•Improper treatment of generator can damage the unit and shorten its life.

•

service center.

•

WARNING!

•Do not bypass any safety device. Moving parts are covered with guards. Make sure all protective covers are in place.

•Never transport or make adjustments to this unit while it is running.

•Never insert objects through cooling slots.

WARNING!

Never operate this unit if there are any broken or missing parts and only use PULSAR PRO-

DUCTS INC. replacement parts specifically designed for this unit.

Only use this unit as it is intended or serious injury or death could result.

SAFETY RULES

•Increasing governing speed is dangerous which can result in personal injury and / or damaged equipment.

•Decreasing governing speed adds an excessive load and can damage equipment.

•Only when operating at the preset governing speed will this generator supply the correct rated frequency and voltage.

WARNING! Never modify this unit in any way or modify governed speed.

•Never handle the generator, electronic devices, or any cord while standing in water, while barefoot, or when hands or

feet are wet.

•Always keep the generator dry. Never operate generator in rain or under wet conditions.

•Use a ground fault circuit interrupter (GFCI) in a damp or highly conductive area, such as metal decking or steel work.

•Never plug electronic devices into generator having frayed, worn, or bare wires. Never touch bare wires or make

contact with receptacles.

•

generator at all times.

•If using the generator for back up power, notify the utility company.

•

install a transfer switch. Failure to isolate the generator from the power utility could result in serious injury or death to

electric utility workers.

WARNING! This generator produces a very high voltage which could result in burn or

electrocution causing serious injury or death.

•Only operate generator on a level surface.

•Always connect the nut and ground terminal on the frame to an appropriate ground source.

WARNING! Generator must be properly grounded to prevent electrocution.

PROP 65 WARNING: This product contains chemicals known to the state of California to cause cancer and birth defects or

other reproductive harm.

FEATURES

A - Spark Plug Cover

B - Spark Arrestor

D - Outer Casing (Side Panel)

E - Handle (Grip)

F - Air Vent

G - Fuel Cap

H - Recoil Starter

Q - Parallel Outlets

R - Ground Terminal

S - Circuit Breaker

T - 12V DC Port

U - 12V DC 8A

Circuit Breaker

CHOKEOFFI - Control Panel

J - Oil Warning Light

K - Overload Indicator Light

L - AC Pilot Light

M - 3 in 1 Start Switch (R N / OFF and Choke)

N - Economy Switch

O - Outlet 5VDC 1.5A

P -120V AC 15A Duplex Outlet

RUN

CONTROL PANEL FUNCTIONS

ON/OFF Start Switch and Choke

Start Switch “OFF”

When the Start Switch is in the “OFF” position the fuel valve is

switched off and the engine will not run.

Start Switch “CHOKE”

When the Start Switch is in the “CHOKE” position the fuel valve is

switched on and the engine can be started.

Start Switch “RUN”

When the Start Switch is in the “RUN” position the fuel valve is

switched on and the engine can run.

Note: The Choke is not required to start a warm engine

Oil Warning Indicator Light

When the oil falls below the minimum level, the oil warning indicator

light comes on and the engine stops automatically. The engine will not

Note: If the oil warning indicator light does not come on and the

engine stalls, turn the Start Switch to “RUN” and pull the recoil

starter.

Engine Overload Indicator Light

If the engine overload indicator light comes on, the generator s wattage

/ amperage capacity has been exceeded by connected electrical

devices or by a power surge. When this occurs, the green AC Pilot

Indicator Light will go off. The engine will continue to run, (but the red

Engine Overload Indicator Light will stay on and power will no longer be

supplied to connected electronic devices.)

Oil Warning

Indicator

light

Overload

Indicator

light

AC Pilot

Indicator

light CHOKEOFF,

start nutil the proper amount of oil is in the crank case.

USB Outlet

The Generator offers convenient (5V DC 1.5A) USB outlet to allow

SB GPS, Digital

Cameras and other USB chargable devices.

devices like Tabelets, MP3 players,

How to Correct

1. Disconnect any electronic devices then stop the engine.

2. Reduce the total wattage of connected electronic devices until it is

within the generator’s rated output.

3. Inspect the Air Inlet and Control Panel for any blockage. Remove

blockage if found.

4. Restart Engine.

charging of U

RUN

USB

AC Pilot Indicator Light

The green AC Pilot Indicator Light comes on when the engine starts

and generates power.

CONTROL PANEL FUNCTIONS

Oil Warning

Indicator

light

Overload

Indicator

light

AC Pilot

Indicator

light

DC Circuit Breaker

When the DC Circuit Breaker is in the “ON” position, the generator is able to supply power to connected electronic devices.

When the DC Circuit Breaker is in the “OFF” position, the generator will no longer supply power. The DC Circuit Breaker

automatically turns “OFF” when connecting electronic devices to the generator that exceed the generator’s rated output. If

the DC Circuit Breaker turns off, reduce the load of connected electronic devices until the load is within the specified rated

output. To re-establish power, return the DC Circuit Breaker back to the “ON” position.

CAUTION! If the DC Circuit Breaker turns off again, stop using the generator immediately and consult a

qualified electrician or small Engine repair shop.

Engine Economy Control

•When the Engine Economy switch is turned to the “ON” position, the economy control unit automatically determines the

generator’s proper engine speed based on the connected electronic load. This results in superior fuel economy and

reduces noise.

•When the Economy switch is turned to the “OFF” position, the engine runs at the rated speed of 4,1 0 r/min.

Note: The engine overload indicator light may turn on for a few sec-

onds when attaching a load due to a power surge. This is normal.

Oil Warning

Indicator

light

Overload

Indicator

light

AC Pilot

Indicator

light

CONTROL PANEL FUNCTIONS

Fuel Cap

Turn counterclockwise to remove the fuel cap.

The fuel cap is equipped with an air vent to stop fuel from flowing to the

carburetor. The Air Vent must be in the “ON” position to allow fuel to flow

so that the engine can run. Turn the Air Vent to the “OFF” position to stop

fuel flow.

Fuel Cap Air Vent

Ground Terminal

The generator’s ground terminal must always be used to connect the

generator to a driven ground rod. Connect the ground terminal to the driven

ground rod with a 12 AWG (American Wire Gage) copper wire. The wire

connects to the terminal between the lock washer and nut. Tighten the nut

securely to ensure good connection. Grounding the generator protects you

from electric shock that results from a build up of static electricity or

undetected ground faults.

•Only operate generator on a level surface.

•Always connect the nut and ground terminal on the frame to an appropriate ground source.

WARNING! Generator must be properly grounded to prevent electrocution.

ONOFFNote: The Economy switch must be turned to the “OFF” position when using electronic devices that require a large

starting current, such as a compressor.

Parallel Outlets

Located just above the Ground Terminal, the generator’s Parallel Outlets enable a user to run two G2319N generator’s

simultaneously. This operation requires special cables. When operating parallel generators, the rated output is 3.42kVA

and the rated current is 30A/120VAC. For cables and instructions consult a PULSAR dealer for a PARALLEL

OPERATION CCCAAABBBLLLEEEKKKIIITTT...

•Only connect this generator to another G2319N Standard Generator.

•Only use a parallel operation cable kit designed to work with this Generator.

WARNING! Never connect generators that are different models.

Inhaltsverzeichnis

Andere Pulsar Tragbarer Generator Handbücher

Pulsar

Pulsar PG7750BCO Bedienungsanleitung

Pulsar

Pulsar PG7500B Bedienungsanleitung

Pulsar

Pulsar PGDA70BiSCO Bedienungsanleitung

Pulsar

Pulsar PG7000DOF Bedienungsanleitung

Pulsar

Pulsar G10KBN Bedienungsanleitung

Pulsar

Pulsar PG2200 Bedienungsanleitung

Pulsar

Pulsar PG3500MR Bedienungsanleitung

Pulsar

Pulsar PG7750B Bedienungsanleitung

Pulsar

Pulsar PG5250BCO Bedienungsanleitung

Pulsar

Pulsar PGD105TiSCO Bedienungsanleitung

Pulsar

Pulsar PG15KVTWB Bedienungsanleitung

Pulsar

Pulsar PGD95BiSCO Bedienungsanleitung

Pulsar

Pulsar G65BN Bedienungsanleitung

Pulsar

Pulsar PG10000B Bedienungsanleitung

Pulsar

Pulsar PG1202S Bedienungsanleitung

Pulsar

Pulsar PG2000iS Bedienungsanleitung

Pulsar

Pulsar PG4000iSR Bedienungsanleitung

Pulsar

Pulsar GD400BN Bedienungsanleitung

Pulsar

Pulsar PG10000B16 Bedienungsanleitung

Pulsar

Pulsar PG2200BiS Bedienungsanleitung

Pulsar

Pulsar PG2300iS Bedienungsanleitung

Pulsar

Pulsar PG10000B Bedienungsanleitung

Pulsar

Pulsar PG6580BCO Bedienungsanleitung

Pulsar

Pulsar PG3500MRCO Bedienungsanleitung

Beliebte Tragbarer Generator Handbücher anderer Marken

Kohler

Kohler 20EORZ Bedienungsanleitung

Powerhorse

Powerhorse 83171 Bedienungsanleitung

HURST

HURST ML-630-SI Bedienungsanleitung

ETQ

ETQ TG4000 Bedienungsanleitung

Briggs & Stratton

Briggs & Stratton 40265 Einrichtungshandbuch

evertz

evertz 7700 Series Bedienungsanleitung

Firefly

Firefly Cygnus CYG2400/460/24 Bedienungsanleitung

Owon

Owon Waveform Generator Bedienungsanleitung

Draper

Draper PG950S Firmware-Update

SDMO

SDMO SH 4000 Bedienungsanleitung

EINHELL

EINHELL STE 5500 Bedienungsanleitung

Wanco

Wanco WI3000P Bedienungsanleitung

Full Boar

Full Boar FBT-3300 Bedienungsanleitung

Dwyer Instruments

Dwyer Instruments ASG Bedienungsanleitung

Westinghouse

Westinghouse WH1000i Series Bedienungsanleitung

Wallenstein

Wallenstein GF5000A Bedienungsanleitung

Leroy-Somer

Leroy-Somer LSA 49.1 Bedienungsanleitung

Yamakoyo

Yamakoyo SH2900DX Bedienungsanleitung