Quadra-Fire 7100FP-GD-B Bedienungsanleitung

Installationandserviceofthisreplaceshouldbe

performedbyqualiedpersonnel.Hearth&Home

TechnologiesrecommendsNFIcertiedprofes-

sionals,ortechnicianssupervisedbyan

NFIcertiedprofessional.

EPA CERTIFIED WOODBURNING

FIREPLACE

Fire Risk.

WARNING

For use with solid wood fuel only.

Other fuels may overﬁ re and generate poisonous

gases (i.e. carbon monoxide).

O-T L

Tested and

Listed by

Portland

Oregon USA

OMNI-Test Laboratories, Inc.

CUS

Model(s):

Installation Manual

Installation and Fireplace Setup

WARNING

HOT SURFACES!

Glassandothersurfacesarehotduring

operationANDcooldown.

Hot glass will cause burns.

• DO NOTtouchglassuntilitiscooled

• NEVERallowchildrentotouchglass

• Keepchildrenaway

• CAREFULLY SUPERVISE children in same room as

replace.

• Alertchildrenandadultstohazardsofhightemperatures.

High temperatures may ignite clothing or other  ammable

materials.

• Keep clothing, furniture, draperies and other ammable

materialsaway.

INSTALLER: Leave this manual with party responsible for use and operation.

OWNER: Retain this manual for future reference.

7100FP-BK-B

7100FP-GD-B

7100FP-NL-B

NOTICE: DO NOT discard this manual!

• DO NOTstoreorusegasolineorotheram-

mablevaporsandliquidsinthevicinityofthis

oranyotherappliance.

• DO NOT overre.Overringwillvoid your

warranty.

• Complywithallminimumclearancestocom-

bustiblesasspecied.Failuretocomplymay

causehousere.

WARNING: If the information in these

instructions is not followed exactly, a  re

or explosion may result causing property

damage, personal injury, or death.

Pourdemanderunexemplaire

enfrançaisdeceManuel

dupropriétaire,visitezwww.

heatnglo.com/translations.

Quadra-Fire•7100FP•433-3610InstallationManual•RevG•5/27/14

Safety Alert Key:

• DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury.

• WARNING!Indicatesahazardoussituationwhich,ifnotavoidedcouldresultindeathorseriousinjury.

• CAUTION! Indicatesahazardoussituationwhich,ifnotavoided,couldresultinminorormoderateinjury.

• NOTICE:Indicatespracticeswhichmaycausedamagetothereplaceortoproperty.

Table of Contents

1 Product Specic & Important Safety Information

A.FireplaceCertication 4

B.GlassSpecications 4

C.Non-CombustibleMaterials 4

D.CombustibleMaterials 4

E.ElectricalCodes 5

2 Getting Started

A.TypicalFireplaceSystem 6

B.DesignandInstallationConsiderations 7

1.SelectingFireplaceLocations 7

2.LocatingFireplace&Chimney 8

C.ToolsandSuppliesNeeded 9

D.InspectFireplaceandComponents 9

E.FireplaceSystemRequirements 9

3 Framing and Clearances

A.FireplaceDimensions 10

B.Clearances 11

1.MinimumClearancestoCombustibles 12

C.ConstructtheChase 13

D.FrametheFireplace 14

E.SecureandLeveltheFireplace 14

F. ProtectiveMetalHearthStrips 15

G.FacingMaterial 15

H.OutsideAirKit 16

I. AuxiliaryConvectionAirSystem 18

J. HeatZoneKit(Optional) 20

4 Electrical Wiring

5 Chimney and Termination Requirements

A.ChimneyRequirements 24

B.Offsets/Returns 25

C.TerminationRequirements 26

6 Chimney Installation

A.TypicalChimneySystem 27

B.AssembleChimneySections 28

C.InstallChimneyAirkit(CAK4A) 28

D.SecureOffset/Return 30

E.InstallCeilingFirestops 30

F. InstallAtticInsulationShield 31

G.RoofPenetration 32

H.ManufacturedHomeInstallation 32

I. InstallChase/ChaseTop 33

J. TerminationCapRequirements 34

K.InstallTerminationCap 34

7 Finishing

A.Template 36

B FinishtheWall 36

1.Stone,BrickFinish 36

2.Tile,Granite,MarbleFinish 36

C.MantelandWallProjections 37

D.FinishingtheHearthExtension 37

E.Non-CombustibleSealantMaterial 39

8 Fireplace Setup

A.FirebrickPlacement 40

B.BafeandBlanketPlacement 41

C.InstallFascia(Fronts) 41

9 Reference Materials

A.ChimneyComponents 42

B.Accessories 46

MESH-HHTFirescreen 46

2Quadra-Fire • 7100 FP • 433-3610 Installation Manual • Rev G • 5/27/14

►

Customer:

Lot/Address

Model (circle one): 7100FP-BK-B 7100FP-GD-B

7100FP-NL-B

Fireplace Install YES IF NO, WHY?

Verifiedthatthechaseisinsulatedandsealed.(Pg.13)

Requirednon-combustibleboardisinstalled.(Pg.15)

Verifiedclearancestocombustibles.(Pg.11)

Fireplaceisleveledandsecured.(Pg.14)

Hearthextensionsize/heightdecided.(Pg.14&37)

Outsideairkitinstalled.(Pg.16)

OptionalHeatZonehasbeeninstalledbyaqualifiedservicetechnician.(Pg.18)

Chimne

Section 5 (Pg. 24)

Chimneyconfigurationcomplieswithdiagrams.

Chimneyinstalled,lockedandsecuredinplacewithproperclearance.

Roofflashinginstalledandsealed.

Terminationsinstalledandsealed.

Electrical Section 4 (Pg. 23)

Switchwiresproperlyinstalled.

Finishing Section 7 (Pg. 36)

Combustible materials not installed in non-combustible areas

Dealer/Distributor Phone #

Serial #:

WARNING! Risk of Fire or Explosion! Failure to install fireplace acording to these instructions can lead to a fire or

explosion.

Firestopsinstalled.

Chimneyairkitinstalled.

Atticinsulationshieldsinstalled.

ATTENTION INSTALLER:

Follow this Standard Work Checklist

Thisstandardworkchecklististobeusedbytheinstallerinconjuctionwith,notinsteadof,theinstructionscontainedinthis installation

manual.

Date Installed:

Location of Fireplace:

Installer:

Combustible materials not installed in non

combustible areas

Verifiedallclearancesmeetinstallationmanualrequirements.

Mantelsandwallprojectionscomplywithinstallationmanualrequirements.

Protectivehearthstripsandhearthextensioninstalledpermanualrequirements.

Fireplace Setup Section 8 (Pg. 40)

Allpackagingandprotectivematerialsremoved.

Firebrick,baffleandceramicblanketinstalledcorrectly.

Faciaanddoorsproperlyinstalled.

Allpackagingmaterialsareremovedfrominside/underthefireplace.

Hearth & Home Technologies recommends the following:

•Photographingtheinstallationandcopyingthischecklistforyourfile.

•Thatthischecklistremainvisibleatalltimesonthefireplaceuntiltheinstallationiscomplete.

Commentscommunicatedtopartyresponsible

Part#4017-254•RevB•01/29/13

__________________________by______________________on_________

(Builder/Gen.Contractor)(Installer)(Date)

Comments:Furtherdescriptionoftheissues,whoisresponsible(Installer/Builder/OtherTrades,etc.)andcorrectiveactionneeded:

_________________________________________________________________________________________________

Manualbagandallofitscontentsareremovedfrominside/underthefireplaceand

giventothepartyresponsibleforuseandoperation.

________________________________________________________________________________________________________

Quadra-Fire • 7100 FP • 433-3610 Installation Manual • Rev G • 5/27/14

1 Product Specic & Important Safety Information

A. Fireplace Certication

Thisreplacesystemhasbeentestedandlistedinac-

cordancewithUL127andULC-S610-M87and(UM)84-

HUDstandardsforinstallationandoperationintheUnited

StatesandCanadaasdescribedinthismanual.

Checkwithyourlocalbuildingcodeagencybeforeyou

beginyourinstallationtoensurecompliancewithlocal

codes,includingtheneedforpermitsandfollow-upin-

spections.Besurelocalbuildingcodesdonotsupersede

ULspecicationsandalwaysobtainabuildingpermitso

thatinsuranceprotectionbenetscannotbeunexpectedly

cancelled.

QuadrareisaregisteredtrademarkofHearth&Home

Technologies.

C. Non-Combustible Materials

• Materialswhich will notigniteandburn, composed of

anycombinationofthefollowing:

- Steel - Iron

- Brick - Tile

- Concrete - Slate

- Glass - Plasters

• MaterialsreportedaspassingASTM E 136, Standard

Test Method for Behavior of Metals, in a Vertical Tube

Furnace at 750° C

B. Glass Specications

Thisreplaceisequippedwith5mmceramicglass.Re-

placeglassonlywith5mmceramicglass.Pleasecontact

yourdealerforreplacementglass.

NOTICE: This installation must conform with local codes. In the

absence of local codes you must comply with the UL127, (UM)

84-HUD and NFPA211 in the U.S.A. and the ULC 610-M87

and CAN/CSA-B365 Installation Codes in Canada.

WARNING! Risk of Fire! Hearth & Home Technologies

disclaims any responsibility for, and the warranty and agen-

cy listing will be voided by the following actions.

DO NOT:

• installoroperatedamagedreplace

• modifyreplace

• install other than as instructed by Hearth & Home

Technologies

• operate the fireplace without fully assembling all

components

• overre

• installanygaslogset

• installanycomponentnotapprovedbyHearth&Home

Technologies

• installpartsorcomponentsnotListedorapproved

Improper installation, adjustment, alteration, service or

maintenance can cause injury or property damage. For

assistance or additional information, consult a qualied

installer, service agency or your dealer.

Model: 7100FPEPACertied

WoodburningFireplace

Laboratory: OMNITestLaboratories,Inc.

Report No: 061-S-41-2

Type: WoodFireplace

Standard: UL127andULC-S610-M87and

(UM)84-HUD,Manufactured

HomeApproved.

EPA# and Original Date: #5714-1-03

EPA Certied: 3.1gramsperhour

Efciency: upto77%

BTU Output

with EPA test fuel: 58,000/hr.

with Cord Wood: 90,000/hr.

Heating Capacity: upto3,500sqft

Chimney Size: 8inches

HHT SL300Series

DuraVent DuraPlus

Max Wood Length: 24inches

Fuel: CordWood

Shipping Weight: 670lbs

Firebox Size 3.4cubicfeet

WARNING! Risk of Fire!

Hearth & Home Technologies is not responsible for

discoloration, cracking or other material failures of

nishingmaterialsduetoheatexposureorsmoke.

 • Choosenishingmaterialscarefully.

4Quadra-Fire • 7100 FP • 433-3610 Installation Manual • Rev G • 5/27/14

E. Electrical Codes

NOTICE: This replace must be electrically wired and

grounded in accordance with local codes or, in the

absence of local codes, with National Electric Code ANSI/

NFPA 70-latest edition or the Canadian Electric Code

CSA C22.1.

• A110-120VACcircuitforthisproductmustbeprotected

with ground-fault circuit-interrupter protection, in

compliancewiththeapplicableelectricalcodes,when

itisinstalledindamplocations.

WARNING! Improper installation, adjustment, alteration,

service or maintenance can cause injury or property dam-

age.

D. Combustible Materials

• Materialsmadeoforsurfacedwithanyofthefollowing

materials:

- Wood - Compressedpaper

- Plantbers - Plastic

- Plywood/OSB - Sheetrock(drywall)

• Anymaterialthatcanigniteandburn;ameproofedor

not,plasteredorun-plastered

Quadra-Fire • 7100 FP • 433-3610 Installation Manual • Rev G • 5/27/14

2 Getting Started

Termination Cap

Chimney penetrates roof

preferably without affecting

roof rafters

Offset/Return

(with hanger straps)

Attic insulation shield

must be used to keep

insulation away

from chimney if

attic is insulated

Storm Collar

Framing headed

off in ceiling joists

Mantel

Chimney system

Combustible

framing/header

on top of V-shaped

standoffs (spacers)

Non-combustible material

Hearth extension

Non-combustible

roof flashing maintains

minimum clearance

around chimney

Additional lateral

support for chimney

above roof (or enclosed

in chase) if needed

Enclosed space above

and around fireplace

Ceiling firestop

on floor of attic

Support straps

on rafter supports

chimney (not shown)

Outside

combustion air

Outside

combustion air

Chimney Air Kit (CAK-4A) (not

shown) must be used with SL300

chimney

Protective metal

hearth strip(s)

A. Typical Fireplace System

Figure 2.1 Typical Fireplace System

6Quadra-Fire • 7100 FP • 433-3610 Installation Manual • Rev G • 5/27/14

In an exterior chase

or projecting into a

garage

Across a corner

Along a wall

As a

room

divider

24 in.

(610mm)

24 in.

(610mm)

24 in.

(610mm)

48 in.

(1219mm)

24 in.

(610mm)

Figure 2.2 Fireplace Locations

NOTICE:

• Illustrationsandphotosreecttypicalinstallationsand

are FOR DESIGN PURPOSES ONLY.

• Illustrations/diagramsarenotdrawntoscale.

• Actualinstallation/appearancemayvaryduetoindividual

design preference.

• Hearth&HomeTechnologiesreservestherighttoalter

its products.

NOTICE: In addition to these framing dimensions, also

reference the following section:

• Clearances (Section 3).

NOTICE:

A minimum 1/2 in. air clearance at the back and

a minimum 1 in. air clearance to the sides of the

replaceassemblymustbemaintained.

Chimney sections at any level require a 2 in. mini-

mum air space clearance between the framing

and chimney sections.

B. Design and Installation Considerations

NOTICE: Check building codes prior to installation.

• InstallationMUSTcomplywithlocal,regional,stateand

nationalcodesandregulations.

• Consultinsurancecarrier,localbuildinginspector,re

ofcialsorauthoritieshavingjurisdictionoverrestrictions,

installationinspectionandpermits.

1. Selecting Fireplace Locations

Thisreplacemaybeusedasaroomdivider,installed

alongawall,acrossacornerorusedinanexteriorchase.

SeeFigure2.2.

Locatingthereplaceinabasement,nearfrequently

openeddoors,centralheatoutletsorreturns,orother

locationsofconsiderableairmovementcanaffectthe

performance.

Outsideairmustbeusedforcombustion.The7100FP

comesequippedwithanoutsideairinlettofeedcombus-

tionairfromoutsidethehome,alongwithanoutsideair

terminationcap;therigidmetalductisrequiredbutnot

supplied.Considerationshouldbegiventothesefactors

beforedecidingonalocation.

Model#7100FP A BC D E F GHI

(Dimensionsfor

nishedwalls)

in. 42-1/4 16 89-1/2 63-5/16 22-7/16 44-3/4 14-1/16 55-15/16 50-7/8

mm 1063 406 2273 1608 570 1137 357 1421 1292

Quadra-Fire • 7100 FP • 433-3610 Installation Manual • Rev G • 5/27/14

2. Locating Fireplace & Chimney

Locationofthereplaceandchimneywillaffectperfor-

mance.

• Installwithinthewarmairspaceenclosedbythebuilding

envelope.Thishelpstoproducemoredraft,especially

duringlightinganddie-downofthere.

• Penetratethehighestpartoftheroof.Thisminimizes

theeffectsofwindloading.

• Locate termination cap away from trees, adjacent

structures,unevenrooflinesandotherobstructions.

• Minimizetheuseofchimneyoffsets.

• Considerthereplacelocationrelativetooorandceiling

andatticjoists.

• Takeintoconsiderationtheterminationrequirementsin

Sections5and6.

Marginal Location:

• Below peak

Location NOT recommended:

• Not the highest point of the roof

• Wind loading possible

Multi-level Roofs

Windward

Leeward

Recommended Location:

• Above peak

Recommended:

• Insulated exterior chase

in cooler climates

Recommended Location:

• Above peak

• Inside heated space

Location NOT recommended:

• Too close to tree

• Below adjacent structure

• Lower roof line

• Avoid outside wall

Marginal Location:

• Wind loading possible

Figure 2.3 Recommended Chimney Locations

• Installtheoutsideairkitwiththeintakefacingprevailing

windsduringtheheatingseason.

• Ensure adequate outdoor air for all combustion

appliancesandexhaustequipment.

• Ensurefurnaceandairconditioningreturnventsarenot

locatedintheimmediatevicinityofthereplace.

• Avoidinstallingthereplaceneardoors,walkwaysor

smallisolatedspaces.

• Recessedlightingshouldbea“sealedcan”design.

• Attichatchesweatherstrippedorsealed.

• Atticmountedductworkandairhandlerjointsandseams

tapedorsealed.

8Quadra-Fire • 7100 FP • 433-3610 Installation Manual • Rev G • 5/27/14

C. Tools and Supplies Needed

Beforebeginningtheinstallationbesurethefollowing

toolsandbuildingsuppliesareavailable:

Reciprocatingsaw Framingmaterial

Pliers Non-combustiblesealant

Hammer Gloves

Phillipsscrewdriver Framingsquare

Flatbladescrewdriver Electricdrillandbits

Plumbline Safetyglasses

Level Tapemeasure

1/2-3/4in.length,#6or#8self-drillingscrews

Misc.screwsandnails

D. Inspect Fireplace and Components

WARNING! Risk of Fire and/or Explosion! Damaged

parts could impair safe operation. DO NOT install dam-

aged,incompleteorsubstitutecomponents.Keepre-

place dry.

• Removereplaceandcomponentsfrompackagingand

inspectfordamage.

• Vent system components and doors are shipped in

separatepackages.

• Reporttoyourdealeranypartsdamagedinshipment.

• Read all the instructions before starting the

installation. Follow these instructions carefully

during the installation to ensure maximum safety

and benet.

E. Fireplace System Requirements

TheQuadra-Firereplacesystemrequirementsconsistof

thefollowing:

• Fireplace

- Firebrick(includedwithreplace)

- Door(includedwithreplace)

- Non-combustible facing material (included with

replace)

- HearthExtension

• OutsideAir System (hood and collars included with

replace)

• Fascia

• ChimneySystem

- Chimneyairkit(includedwithreplace,requiredwith

SL300serieschimney)

- AtticInsulationShield(includedwithreplace)

- Chimneyterminationcap

• Non-combustiblenishmaterial

Optionalcomponentsinclude:

• Firescreen

• LintelBar

• HeatZoneKit

Quadra-Fire • 7100 FP • 433-3610 Installation Manual • Rev G • 5/27/14

3 Framing and Clearances

A. Fireplace Dimensions

Blower Electric Access

(right side of fireplace)

3-1/2 in.

(89 mm)

32-1/2 in.

(826 mm)

38 in.

(965 mm)

40 in.

(1016 mm)

42-5/16 in.

(1075 mm)

45-13/16 in.

(1148 mm)

23-7/16 in.

(595 mm)

13-3/16 in.

(335 mm)

10-13/16 in.

(259 mm)

4-5/16 in.

(109 mm)

6 in.

(152 mm)

1 in.

(25 mm)

13-3/4 in.

(349 mm)

9-7/16 in.

(240 mm)

43 in.

(1092 mm)

Figure 3.1 Fireplace Dimensions

10 Quadra-Fire • 7100 FP • 433-3610 Installation Manual • Rev G • 5/27/14

Andere Handbücher für 7100FP-GD-B

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Quadra-Fire Kamin im Innenbereich Handbücher

Quadra-Fire

Quadra-Fire QV36DB-A Bedienungsanleitung

Quadra-Fire

Quadra-Fire CB1200I-C Bedienungsanleitung

Quadra-Fire

Quadra-Fire MTVERNINSAE-MBK Bedienungsanleitung

Quadra-Fire

Quadra-Fire QFP 30 Handbuch

Quadra-Fire

Quadra-Fire Quadra-Fire VOYAGEUR-MBK Bedienungsanleitung

Quadra-Fire

Quadra-Fire VOYAGEUR GRAND INSERT GRAND-MBK-AU Bedienungsanleitung

Quadra-Fire

Quadra-Fire HUDBAY-FS Bedienungsanleitung

Quadra-Fire

Quadra-Fire MTVERNINSAE-MBK Bedienungsanleitung

Quadra-Fire

Quadra-Fire 27I-ACC Bedienungsanleitung

Quadra-Fire

Quadra-Fire CASTILEI-MBK-C Bedienungsanleitung

Quadra-Fire

Quadra-Fire EXPEDITIONII-AU Bedienungsanleitung

Quadra-Fire

Quadra-Fire SANTAFEI-MBK Bedienungsanleitung

Quadra-Fire

Quadra-Fire REMINGTON QFP40 Bedienungsanleitung

Quadra-Fire

Quadra-Fire PIONEER-III-ABK Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5700 Bedienungsanleitung

Quadra-Fire

Quadra-Fire VOYAGEUR GRAND VOYA-GRAND-MBK Bedienungsanleitung

Quadra-Fire

Quadra-Fire EXPEDITION II Bedienungsanleitung

Quadra-Fire

Quadra-Fire VOYAGEUR GRAND VOYA-GRAND-MBK Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I Bedienungsanleitung

Quadra-Fire

Quadra-Fire Direct Vent Gas Appliance COLBAY-FS-B Betriebsanleitung

Quadra-Fire

Quadra-Fire QFP38-LP Bedienungsanleitung

Quadra-Fire

Quadra-Fire TREKKERI-MBK Bedienungsanleitung

Quadra-Fire

Quadra-Fire 57ST-ACC-AU Bedienungsanleitung

Quadra-Fire

Quadra-Fire QFI30FB Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch

Regency Fireplace Products

Regency Fireplace Products Pro Series Kurzanleitung