Quadra-Fire PIONEER-III-ABK Bedienungsanleitung

EPA CERTIFIED WOODBURNING

FIREPLACE

Model(s):

Installation Manual

Installation and Fireplace Setup

WARNING

HOT SURFACES!

Glass and other surfaces are hot during

operation AND cool down.

Hot glass will cause burns.

• DO NOT touch glass until it is cooled

• NEVER allow children to touch glass

• Keep children away

• CAREFULLY SUPERVISE children in same room as

replace.

• Alert children and adults to hazards of high temperatures.

High temperatures may ignite clothing or other ammable

materials.

• Keep clothing, furniture, draperies and other ammable

materials away.

INSTALLER: Leave this manual with party responsible for use and operation.

OWNER: Retain this manual for future reference.

PIONEER-III-ABK

PIONEER-III-RBK

Pour demander un exemplaire

en français de ce Manuel

du propriétaire, visitez www.

quadrare.com/translations.

Installation and service of this appliance should be performed by

qualied personnel, Hearth & Home Technologies recommends

HHTFactoryTrainedorNFIcertiedprofessionals.

Contact your dealer with questions on installation, operation, or service.

• Read all the instructions before starting

the installation. Follow these instructions

carefully during the installation to ensure

maximumsafetyandbenet.

• Comply with all minimum clearances to com-

bustiblesasspecied.Failuretocomplymay

causehousere.

WARNING! Risk of Fire and/or Asphyxiation!

Quadra-Fire • PIONEER - III • 4182-901 Installation Manual • Rev C • 07/19

Safety Alert Key:

• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.

• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.

• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.

• NOTICE:Indicatespracticeswhichmaycausedamagetothereplaceortoproperty.

Table of Contents

1 Product Specic & Important Safety Information

A.ApplianceCertication 4

B.BTUEfciencySpecications 4

C.MobileHomeApproved 4

D.GlassSpecications 5

E.Non-CombustibleMaterials 5

F.CombustibleMaterials 5

G.ElectricalCodes 5

2 Getting Started

A.TypicalFireplaceSystem 6

B. Design and Installation Considerations 7

1. Selecting Fireplace Locations 7

2.LocatingFireplace&Chimney 8

C.ToolsandSuppliesNeeded 9

D.InspectFireplaceandComponents 9

E.FireplaceSystemRequirements 9

3 Framing and Clearances

A. Fireplace Dimensions 10

B. Clearances 11

C. Construct the Chase 12

D. Frame the Fireplace 13

E. Secure and Level the Fireplace 13

F. InstallationofTopStandoffs 14

G.ProtectiveMetalHearthStrips 15

H.Non-CombustibleFacingBoard(Provided) 15

I. OutsideAirKit 15

J.FanAirKit(Required) 18

K.HeatZoneKit(Optional) 19

4 Electrical Wiring

A. Fireplace 23

B.ThermostatInstallation 23

5 Chimney and Termination Requirements

A.ChimneyRequirements 25

B.Offsets/Returns 26

C.TerminationRequirements 27

6 Chimney Installation

A.TypicalChimneySystem 28

B.AssembleChimneySections 29

C.InstallChimneyAirkit(CAK4A) 29

D.SecureOffset/Return 30

E. Install Ceiling Firestops 31

F. Install Attic Insulation Shield 32

G. Roof Penetration 33

H.ManufacturedHomeInstallation 33

I. InstallChase/ChaseTop 34

J. InstallTerminationCap 35

7 Finishing

A.Template 37

B.FinishtheWall 38

1.Stone,BrickFinish 38

2.Tile,Granite,MarbleFinish 38

C.MantelandWallProjections 38

D.FinishingtheHearthExtension 39

E.Non-CombustibleSealantMaterial 40

8 Fireplace Setup

A.FirebrickPlacement 41

B.BafeandBlanketPlacement 42

C.InstallFascia(Fronts) 42

9 Reference Materials

A.ChimneyComponents 43

B.Accessories 48

2Quadra-Fire • PIONEER - III • 4182-901 Installation Manual • Rev C • 07/19

►

Customer:

Lot/Address

Model: PIONEER III-ABK

PIONEER III-RBK

YES IF NO, WHY?Fireplace Install

Verified that the chase is insulated and sealed.

Requirednon-combustibleboardisinstalled.

Verifiedclearancestocombustibles.

Fireplace is leveled and secured.

Hearthextensionsize/heightdecided.

Outside air kit installed.

OptionalHeatZonehasbeeninstalledbyaqualifiedservicetechnician.

Fan air kit installed.

Chimney Section 5

Chimney configuration complies with diagrams.

Chimney installed, locked and secured in place with proper clearance.

Chimney air kit installed.

Firestops installed.

Attic insulation shields installed.

Roof flashing installed and sealed.

Terminationsinstalledandsealed.

Electrical Section 4

Switch wires properly installed.

Thermostat wires connected.

Dealer/Distributor Phone #

Serial #:

WARNING! Risk of Fire or Explosion! Failure to install fireplace acording to these instructions can lead to a fire or

explosion.

ATTENTION INSTALLER:

Follow this Standard Work Checklist

Thisstandardworkchecklististobeusedbytheinstallerinconjuctionwith,notinsteadof,theinstructionscontainedinthisinstallation

manual.

Date Installed:

Location of Fireplace:

Installer:

Finishing Section 7

CombustibleCombustiblematerialsmaterialsnotnotinstalledinstalledininnon-non-combustiblecombustibleareasareas.

Verified all clearances meet installation manual requirements.

Mantels and wall projections comply with installation manual requirements.

Protective hearth strips and hearth extension installed per manual requirements.

Fireplace Setup Section 8

All packaging and protective materials removed.

Firebrick,baffleandceramicblanketinstalledcorrectly.

Facia and doors properly installed.

Manualbagandallofitscontentsareremovedfrominside/underthefireplaceand

giventothepartyresponsibleforuseandoperation.

Allpackagingmaterialsareremovedfrominside/underthefireplace.

Hearth & Home Technologies recommends the following:

•

Photographing the installation and copying this checklist for your file.

•

Thatthischecklistremainvisibleatalltimesonthefireplaceuntiltheinstallationiscomplete.

Commentscommunicatedtopartyresponsible

Part # 4182-982 • Rev A•06/18

__________________________by______________________on_________

(Builder/Gen.Contractor)(Installer)(Date)

Comments:Furtherdescriptionoftheissues,whoisresponsible(Installer/Builder/OtherTrades,etc.)andcorrectiveactionneeded:

_________________________________________________________________________________________________

________________________________________________________________________________________________________

Quadra-Fire • PIONEER - III • 4182-901 Installation Manual • Rev C • 07/19

1 Product Specic & Important Safety Information

Model: PIONEER III

Laboratory: Underwriter’sLaboratories,Inc.

Report No: Project4788732172

Type: Wood Fireplace

Standard: UL127-2011andCAN/ULC-S610-

2018(A1998)and(UM)84-HUD,

ManufacturedHomeApproved.

A. Appliance Certication C. Mobile Home Approved

Thisapplianceisapprovedformobilehomeinstallations

when not installed in a sleeping room and when an outside

combustionairinletisprovided.Thestructuralintegrityof

the mobile home oor, ceiling, and walls must be main-

tained.Theappliancemustbeproperlygroundedtothe

frameofthemobilehomeanduseonlylisteddouble-wall

connector pipe.

D. Glass Specications

Thisapplianceisequippedwith5mmceramicglass.

Replaceglassonlywith5mmceramicglass.Please

contact your dealer for replacement glass.

B. BTU & Efciency Specications

Hearth & Home Technologies WILL NOT warranty appli-

ances that exhibit evidence of over-ring.  Evidence of

over-ringincludes,butisnotlimitedto:

 • Warpedairtube

 • Deterioratedrefractorybrickretainers

 • Deterioratedbafeandotherinteriorcomponents

NOTE: Thisinstallationmustconformwithlocalcodes.Inthe

absenceoflocalcodesyoumustcomplywiththeUL127-2011,

(UM) 84-HUD and NPFA211 intheU.S.A.andtheCAN/ULC

S610-2018 (A1998) and CAN/CSA-B365 Installation Codes

in Canada.

ThePIONEERIIIWoodAppliancemeetstheU.S.ENVI-

RONMENTALPROTECTIONAGENCYCertiedtocomply

with 2020 particulate emission standards using cord wood.

EPACertiedEmissions: 2.0g/hr

*LHVTestedEfciency: 74.3%

**HHVTestedEfciency: 69.1%

***EPABTUOutput: 14,700-72,800/hr

VentSize: 8inches

FireboxSize: 4.07cubicfeet

RecommendedLogLength: 24inches

Fuel Seasoned Cord Wood less

than20%moisture

HHT: SL300 Series

DuraVent: DuraPlus

*WeightedaverageLHV(LowHeatingValue)efciencyusing

cordwoodanddatacollectedduringEPAemissiontest.LHV

assumes the moisture is already in a vapor state so there is no

loss in energy to vaporize.

**WeightedaverageHHV(HighHeatingValue)efciencyus-

ing cord wood and data collected during EPA emission test.

HHVincludestheenergyrequiredtovaporizethewaterinthe

fuel.

***ArangeofBTUoutputsbasedonHHV(HighHeatingValue)

andtheburnratesfromthelowandhighEPAtests,usingcord

wood.

The Pioneer III is Certied to

comply with 2020 particulate

emission standards.

DO NOT:

• installoroperatedamagedreplace

• modifyreplace

• install other than as instructed by Hearth & Home

Technologies

• operate the fireplace without fully assembling all

components

• install unvented gas log set

• install any component not approved by Hearth & Home

Technologies

• install parts or components not Listed or approved

Improper installation, adjustment, alteration, service or

maintenance can cause injury or property damage. For

assistance or additional information, consult a qualied

installer, service agency or your dealer.

WARNING! Risk of Fire! Hearth & Home Technologies

disclaims any responsibility for, and the warranty and

agency listing will be voided by the above actions.

4Quadra-Fire • PIONEER - III • 4182-901 Installation Manual • Rev C • 07/19

G. Electrical Codes

NOTICE: This replace must be electrically wired and

grounded in accordance with local codes or, in the

absence of local codes, with National Electric Code ANSI/

NFPA 70-latest edition or the Canadian Electric Code

CSA C22.1.

• A110-120VACcircuitforthisproductmustbeprotected

with ground-fault circuit-interrupter protection, in

compliancewiththeapplicableelectricalcodes,when

it is installed in damp locations.

WARNING! Improper installation, adjustment, alteration,

service or maintenance can cause injury or property dam-

age.

E. Non-Combustible Materials

Materialwhichwillnotigniteandburn,composedofany

combinationofthefollowing:

- Steel - Plaster

- Brick - Iron

 -Concrete  -Tile

- Glass - Slate

Materials reported as passing ASTM E 136, Standard

Test Method for Behavior of Metals, in a Vertical Tube

Furnace of 750° C.

F. Combustible Materials

Material made of or surfaced with any of the following

materials:

- Wood - Compressed Paper

 -PlantFibers  -Plastic

 -Plywood/OSB  -SheetRock(drywall)

 -Foaminsulation&sealants

Anymaterialthatcanigniteandburn:ameproofedor

not, plastered or un-plastered.

Quadra-Fire • PIONEER - III • 4182-901 Installation Manual • Rev C • 07/19

2 Getting Started

Termination Cap

Chimney penetrates roof

preferably without affecting

roof rafters

Offset/Return

(with hanger straps)

Attic insulation shield

must be used to keep

insulation away

from chimney if

attic is insulated

Storm Collar

Framing headed

off in ceiling joists

Mantel

Chimney system

Combustible

framing/header

Non-combustible material

Hearth extension

Non-combustible

roof flashing maintains

minimum clearance

around chimney

Additional lateral

support for chimney

above roof (or enclosed

in chase) if needed

Enclosed space above

and around fireplace

Ceiling firestop

on floor of attic

Support straps

on rafter supports

chimney (not shown)

Outside

combustion air

Outside

combustion air

Chimney Air Kit (CAK-4A) (not

shown) must be used with SL300

chimney

Protective metal

hearth strip(s)

Figure 2.1 Typical Fireplace System

6Quadra-Fire • PIONEER - III • 4182-901 Installation Manual • Rev C • 07/19

Figure 2.2 Fireplace Locations

NOTICE:

• Illustrationsandphotosreecttypicalinstallationsand

are FOR DESIGN PURPOSES ONLY.

• Illustrations/diagrams are not drawn to scale.

• Actual installation/appearance may vary due to individual

design preference.

• Hearth & Home Technologies reserves the right to alter

its products.

NOTICE: In addition to these framing dimensions, also

reference the following section:

• Clearances (Section 3).

NOTICE:

A minimum 1 in. air clearance at the back and a

minimum 1½ in. air clearance to the sides of the

replaceassemblymustbemaintained.

Chimney sections at any level require a 2 in. mini-

mum air space clearance between the framing and

chimney sections.

B. Design and Installation Considerations

NOTICE: Check building codes prior to installation.

• InstallationMUSTcomplywithlocal,regional,stateand

national codes and regulations.

• Consultinsurancecarrier,localbuildinginspector,re

ofcialsorauthoritieshavingjurisdictionoverrestrictions,

installation inspection and permits.

1. Selecting Fireplace Locations

This replace may be used as a room divider, installed

along a wall, across a corner or used in an exterior chase.

See Figure 2.2.

Locating the replace in a basement, near frequently

opened doors, central heat outlets or returns, or other loca-

tionsofconsiderableairmovementcanaffecttheperfor-

mance.

Outsideairmustbeusedforcombustion.ThePIONEER

III comes equipped with an outside air inlet to feed com-

bustionairfromoutsidethehome,alongwithanoutsideair

terminationcap;themetalductisrequiredbutnotsupplied.

Considerationshouldbegiventothesefactorsbeforede-

ciding on a location.

24-1/2*

[622]

51 [1295]

16 [406]

51 [1295]

[1562]

16 [406]

24-1/2*

[622]

24-1/2*

[622]

[1295]

[406]

48 [1219]

103

[2616]

[1295]

73 [1854]

51-1/2

[1308]

27-1/2

[699]

27-1/2

[699]

Across a corner

In an exterior chase

As a divider

Along a wall

*If interior of chase will be

drywalled, add the thickness

to this measurement.

Faceplate to sidewall 16 inches

61-1/2

[1562]

61-1/2

[1562]61-1/2

Quadra-Fire • PIONEER - III • 4182-901 Installation Manual • Rev C • 07/19

2. Locating Fireplace & Chimney

Locationofthereplaceandchimneywillaffectperfor-

mance.

• Installwithinthewarmairspaceenclosedbythebuilding

envelope.Thishelpstoproducemoredraft,especially

duringlightinganddie-downofthere.

• Penetratethehighestpartoftheroof.Thisminimizes

the effects of wind loading.

• Locate termination cap away from trees, adjacent

structures,unevenrooflinesandotherobstructions.

• Minimize the use of chimney offsets.

• Considerthereplacelocationrelativetooorandceiling

and attic joists.

• Takeintoconsiderationtheterminationrequirementsin

Sections5and6.

Marginal Location:

• Below peak

Location NOT recommended:

• Not the highest point of the roof

• Wind loading possible

Multi-level Roofs

Windward

Leeward

Recommended Location:

• Above peak

Recommended:

• Insulated exterior chase

in cooler climates

Recommended Location:

• Above peak

• Inside heated space

Location NOT recommended:

• Too close to tree

• Below adjacent structure

• Lower roof line

• Avoid outside wall

Marginal Location:

• Wind loading possible

Not recommended in basement due

to high negative pressure concerns

that effect draft

Figure 2.3 Recommended Chimney Locations

• InstalltheoutsideairkitandCAK(chimneyairkit)with

the intake facing prevailing winds during the heating

season.

• Ensure adequate outdoor air for all combustion

appliances and exhaust equipment.

• Ensure furnace and air conditioning return vents are not

locatedintheimmediatevicinityofthereplace.

• Avoidinstallingthereplaceneardoors,walkwaysor

small isolated spaces.

• Recessedlightingshouldbea“sealedcan”design.

• Attic hatches weather stripped or sealed.

• Attic mounted duct work and air handler joints and seams

taped or sealed.

8Quadra-Fire • PIONEER - III • 4182-901 Installation Manual • Rev C • 07/19

C. Tools and Supplies Needed

Beforebeginningtheinstallationbesurethefollowing

toolsandbuildingsuppliesareavailable:

Reciprocating saw Framing material

Pliers Non-combustiblesealant

Hammer Gloves

Phillips screwdriver Framing square

Flatbladescrewdriver Electricdrillandbits

Plumbline Safetyglasses

Level Tapemeasure

1/2-3/4in.length,#6or#8self-drillingscrews

Misc. screws and nails

D. Inspect Fireplace and Components

E. Fireplace System Requirements

TheQuadra-Firereplacesystemrequirementsconsistof

thefollowing:

• Fireplace

- Firebrick(includedwithreplace)

- Door(includedwithreplace)

- Non-combustible facing material (included with

replace)

- HearthExtension

• OutsideAir System (hood and collars included with

replace)

• Fascia

• Chimney System

- Chimneyairkit(includedwithreplace,requiredwith

SL300serieschimney)

- AtticInsulationShield(includedwithreplace)

- Chimney termination cap

• Non-combustiblenishmaterial

• FanAirSystem(grillandcollarincludedwithreplace)

Optionalcomponentsinclude:

• Lintel Bar

• HeatZoneKit

• WirelessThermostat

WARNING! Risk of Fire and Asphyxiation! Damaged

parts could impair safe operation. DO NOT install dam-

aged, incomplete or substitute components.

• Removereplaceandcomponentsfrompackagingand

inspect for damage.

• Chimney system components and other optional

components are shipped separately.

• Report to your dealer any parts damaged in shipment.

Quadra-Fire • PIONEER - III • 4182-901 Installation Manual • Rev C • 07/19

3 Framing and Clearances

A. Fireplace Dimensions

Figure 3.1 Fireplace Dimensions

1 in.

(25 mm)

23 ½ in.

(597 mm)

12 ¾ in.

(324 mm)

16 in.

(406 mm)

63 ¼ in.

(1607 mm)

39 in.

(991 mm)

47 ¼ in.

(1200 mm)

5 -7/8 in.

(149 mm)

1 ½ in.

(38 mm)

28-1/8 in.

(714 mm)

39 in.

(991 mm)

47-7/8 in.

(1216 mm) 50-7/8 in.

(1292 mm)

19-1/8 in.

(486 mm)

15 in.

(381mm)

1½ in.

(38 mm)

1 in.

(25 mm)

9 ¾ in.

(248 mm) 17 ¼ in.

(428 mm)

8 ¼ in.

(210 mm)

6½ in.

(165 mm)

1 in.

(25 mm)

23 ½ in.

(597 mm)

12 ¾ in.

(324 mm)

16 in.

(406 mm)

63 ¼ in.

(1607 mm)

36 ½ in.

(927 mm)

47 ¼ in.

(1200 mm)

5 -7/8 in.

(149 mm)

1 ½ in.

(38 mm)

28-1/8 in.

(714 mm)

39 in.

(991 mm)

47-7/8 in.

(1216 mm) 50-7/8 in.

(1292 mm)

15 in.

(381mm)

1½ in.

(38 mm)

18-1/8 in.

(460 mm)

1 in.

(25 mm)

9 ¾ in.

(248 mm) 17 ¼ in.

(428 mm)

8 ¼ in.

(210 mm)

6½ in.

(165 mm)

10 Quadra-Fire • PIONEER - III • 4182-901 Installation Manual • Rev C • 07/19

Andere Handbücher für PIONEER-III-ABK

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Quadra-Fire Kamin im Innenbereich Handbücher

Quadra-Fire

Quadra-Fire DVI-32 Bedienungsanleitung

Quadra-Fire

Quadra-Fire 27I-ACC Bedienungsanleitung

Quadra-Fire

Quadra-Fire HUDBAY-FS Bedienungsanleitung

Quadra-Fire

Quadra-Fire VOYA-GRAND-MBK Bedienungsanleitung

Quadra-Fire

Quadra-Fire 31I-ACC Bedienungsanleitung

Quadra-Fire

Quadra-Fire 2100-I Leitfaden

Quadra-Fire

Quadra-Fire QVI-35FB-S Bedienungsanleitung

Quadra-Fire

Quadra-Fire EXPEDITION II Bedienungsanleitung

Quadra-Fire

Quadra-Fire SANTAFEI-MBK Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100 ACC Bedienungsanleitung

Quadra-Fire

Quadra-Fire COLUMBIA BAY Installationsanleitung

Quadra-Fire

Quadra-Fire 43M-ACC-MBK Bedienungsanleitung

Quadra-Fire

Quadra-Fire QFP44 Bedienungsanleitung

Quadra-Fire

Quadra-Fire 4100I-GD-B Bedienungsanleitung

Quadra-Fire

Quadra-Fire 31I-ACC Bedienungsanleitung

Quadra-Fire

Quadra-Fire 4300 Series Handbuch

Quadra-Fire

Quadra-Fire 27I-ACC Bedienungsanleitung

Quadra-Fire

Quadra-Fire COLBAY-INS Bedienungsanleitung

Quadra-Fire

Quadra-Fire HUDBAY-INS Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I Bedienungsanleitung

Quadra-Fire

Quadra-Fire CASTILE Series Bedienungsanleitung

Quadra-Fire

Quadra-Fire EXPEDITION II Bedienungsanleitung

Quadra-Fire

Quadra-Fire VOYA-GRAND-MBK Bedienungsanleitung

Quadra-Fire

Quadra-Fire SANTAFEI-MBK Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch

Regency Fireplace Products

Regency Fireplace Products Pro Series Kurzanleitung