Raypak MVB WHP-2004 Bedienungsanleitung

Catalog No.: 6000.29B Effective: 7-15-08 Replaces: 1-1-08

Job:

Engineer:

Contractor:

Prepared By: Date:

Model: Indoor/Outdoor:

85% Thermal Efficiency

100% Factory Fire Tested

Minimum Acceptable Inlet Water Temperature: 105°F

Full Safety Diagnostics with History

Footprint: Less Than 5-1/2 ft2

Limited Twenty-Year Thermal Shock Warranty

Limited Five-Year Heat Exchanger Warranty

On/Off Firing

Soft-Start Modulating Controller with LCD Display

Status Display Lights

Heat Exchanger

Bronze Headers

ASME HLW Stamped

160 PSIG Working Pressure

National Board Approved

Cupro Nickel Fin Tubing

ASME Powder-Coated Tube Sheet

Silicone High Temp O-Rings

ASME Pressure Relief Valve,

125 PSIG

Temperature and Pressure Gauge,

Shipped Loose

Stainless Steel Evaporator Plate

Bronze Pump (See table on pg. 2)

Drain Valves (2)

Air Vent

Control

120V, 60Hz, 1Ø, Power Supply

120/24V 60Hz Transformer

Ignition Module

3-Try – Standard

Single-Try – Option C-6

Hot Surface Ignition (HSI)

Remote Flame Sensor

High Limit, Auto Reset, Adj., 140°F

High Limit, Manual Reset, Fixed

Models 504-1504: 175°F

Models 2004: 200ºF

On/Off Power Switch

Flow Switch, Mtd

Blocked Vent Pressure Switch

Combustion Air Proving Switch

Pump Switch

Pump Time Delay

Diagnostics Panel

Control (cont.)

On/Off Digital Poolstat, 106°F Max

Water Temperature Sensors (3) with

Immersion Well

Burner

Ultra-Low NOx: Less than 20 PPM

Gas Train

Fuel

Natural Gas

Propane

Zero Governor Regulator

Dual-Seat Combination Valve

On/Off Firing with Soft-Start

Construction

Indoor/Outdoor Construction

Enclosed Front Controls

PolyTuf Powder Coat Finish

Rear Connections (Water, Electrical,

Gas, Vent, Combustion Air)

Design Certification

Models 504-1504: ANSI Z21.56/

CSA 4.7

Model 2004: ANSI Z21.10.3/CSA 4.3

Venting

Vent Termination Cap

Outdoor – Option D-11

Indoor, Horizontal – Option D-15

Indoor, Vertical (by others)

Combustion Air

In-Line Filter Kit – Option D-17

Air Intake Elbow – Option D-16

Extractor – Optional

By others

Not required

Temperature Controllers

B-26 TempTracker Digital Controller,

Up to 2 Heaters

B-21 TempTracker Digital Controller,

Up to 4 Heaters

Y-241 Electronic Sequencer,

Up to 4 Heaters

Y-281 Electronic Sequencer,

Up to 8 Heaters

Options

F-10 Low Water Cut-Off, Remote

Probe

P- Cold Water Run

P- H-style Bypass, Non-Ferrous

S-1 Low Gas Pressure Switch,

Manual Reset

S-2 High Gas Pressure Switch,

Manual Reset

Regulatory Agency Requirements

MVB®- Type P

Pool Heaters

Models 504-2004

Pump included

standard

Catalog No.: 6000.29B Effective: 7-15-08 Replaces: 1-1-08

MVB – Type P

Models 504-2004 Model

Shown without H-bypass or Cold Water Run options

Dimensions (in.)

MBTUH B D E F G H K M N P R V

Model

Input Output Height NPT NPT Flue Ø C/A Ø

Ship

Weight

(Lbs.)

Foot-

(Ft2)

Amps*

P-504 500 420 43 30 35 23-3/4 1 2 8 14-1/8 6 36 8 2 600 5.4 12

P-754 750 630 49 36 41 29-3/4 1 2 10 16 6 42 8 2 660 5.4 12

P-1104 1100 935 55 43 47 35-3/4 1-1/4 2-1/2 10 16 6 49 8 2 720 5.4 12

P-1504 1500 1275 61 50 53 41-3/4 1-1/4 2-1/2 12 18-1/8 8 53 8 2 780 5.4 12

WHP-2004 1900 1615 75 61 65 53-3/4 2 2-1/2 14 20-1/8 8 69 9 5 940 5.4 18

-Ratings shown are for elevations up to 4,500 feet. For installations at elevations

above 4,500 feet, please consult the factory for additional instructions.

* Current draw is for heater only.

(Supply breaker must have delayed trip.)

RATES OF FLOW

20°F ∆

∆∆

∆TMinimum Flow Maximum Flow

Model

GPM ∆

∆∆

∆P (ft.) GPM ∆

∆∆

∆P (ft.)

∆

∆∆

∆T (°F)

GPM ∆

∆∆

∆P (ft.)

∆

∆∆

∆T (°F)

P-504 N/A N/A 65 5.5 13 100 11.3 9

P-754 65 6.4 65 6.4 20 100 13.8 13

P-1104 94 13.6 85 11.5 22 113 18.6 17

P-1504 N/A N/A 102 18.7 25 113 22.2 23

WHP-2004 N/A N/A 102 22.7 32 113 27.2 29

Raypak, Inc.



2151 Eastman Avenue, Oxnard, CA 93030



(805) 278-5300



Fax (800) 872-9725



www.raypak.com

CLEARANCES

Certified

Minimum

Recomm.

Service

Front 24” 24”

Rear 12” 24”

Right 1” –

Left 1” –

Top 0” 10”

Floor 0” –

Vent 1” –

PUMP

Pump

Model Model HP Amps*

P-504 1611 ¼ 6

P-754 1630 ½ 7

P-1104 1630 ½ 7

P-1504 1634 1 14

WHP-2004 1636 1 ½ 22

* Current draw is for pump only

Dieses Handbuch passt für folgende Modelle

Andere Raypak Schwimmbadheizung Handbücher

Raypak

Raypak RP2100 ASME R185B Bedienungsanleitung

Raypak

Raypak Raytherm P-1826 Handbuch

Raypak

Raypak GEMINI 263 Bedienungsanleitung

Raypak

Raypak 105A VERSA Bedienungsanleitung

Raypak

Raypak VERSA 185B Handbuch

Raypak

Raypak Versa 105B Brass Bedienungsanleitung

Raypak

Raypak Xtherm 1505 Bedienungsanleitung

Raypak

Raypak HI DELTA 1802B Bedienungsanleitung

Raypak

Raypak RP-045 Bedienungsanleitung

Raypak

Raypak 130A Bedienungsanleitung

Raypak

Raypak X94 Handbuch

Raypak

Raypak 018222F Original Betriebsanleitung

Raypak

Raypak 180A Bedienungsanleitung

Raypak

Raypak 268 Handbuch

Raypak

Raypak XTherm Series Handbuch

Raypak

Raypak 206A Handbuch

Raypak

Raypak CR-206A Bedienungsanleitung

Raypak

Raypak VERSA 155C Bedienungsanleitung

Raypak

Raypak Hi Delta 992B-1262B Handbuch

Raypak

Raypak 6200.90 Gebrauchs- und Wartungshandbuch

Raypak

Raypak 155A VERSA Bedienungsanleitung

Raypak

Raypak 153A GEMINI Bedienungsanleitung

Raypak

Raypak RP2100 ASME R185B Bedienungsanleitung

Raypak

Raypak CHX Einrichtungshandbuch

Beliebte Schwimmbadheizung Handbücher anderer Marken

Nibe

Nibe S Series Benutzerhandbuch

Zodiac

Zodiac JXi 200 Bedienungsanleitung

Texsun

Texsun El Niño Bedienungsanleitung

Aqua Comfort

Aqua Comfort AC110 Bedienungsanleitung

HeatPRO

HeatPRO pool heat pump Bedienungsanleitung

Dickinson

Dickinson NEWPORT Bedienungsanleitung

Pentair Pool Products

Pentair Pool Products MiniMax CH 150 Bedienungsanleitung

Jandy

Jandy LJ Bedienungsanleitung

Pentair Pool Products

Pentair Pool Products MiniMax NT Series Bedienungsanleitung

Hayward Pool Products

Hayward Pool Products HP40A Service-Handbuch

Laars

Laars Lite 2 LC Bedienungsanleitung

SUPREME

SUPREME Heatseeker Solar Pool Heating Bedienungsanleitung

UTC

UTC ICP HMP-03 Montageanleitung

Pentair

Pentair ETi 400 Bedienungsanleitung

Hayward

Hayward ENP2M-9A Service-Handbuch

BriskHeat

BriskHeat TOT Series Bedienungsanleitung

Hayward

Hayward C-SPA-XI 5.5 Bedienungsanleitung

Aquacal

Aquacal AEROTEMP Bedienungsanleitung