Raypak 1005-2005 Bedienungsanleitung

Catalog No.: 6000.37 Effective: 9-15-08 Replaces: NEW

Job:

Engineer:

Contractor:

Prepared By: Date:

Model: Indoor/Outdoor:

97% Thermal Efficiency at Full Rate; Up to 99% at Part Load

100% Factory Fire Tested

Maximum Outlet Water Temperature: 160°F

Minimum Acceptable Inlet Water Temperature: 50°F

Full Safety Diagnostics with History

Footprint: Less Than 10.8 ft2

Limited Twenty-Five-Year Thermal Shock Warranty

Limited Ten-Year Primary Heat Exchanger Warranty

Limited Five-Year Secondary Heat Exchanger Warranty

Full Electronic Modulation, Constant Ratio 4:1 Turndown

Digital Controller with LCD Display

Status Display Lights

Heat Exchanger

Bronze Headers

ASME HLW Stamped; 160 PSIG

MAWP

National Board Listed

Cupro Nickel Fin Tubing

ASME Powder-Coated Tube Sheet

Silicone High Temp O-Rings

ASME Pressure Relief Valve

125 PSIG – Standard (Loose)

150 PSI Air Vent, Auto

T&P Gauge (Loose)

Stainless Steel Secondary Heat

Exchanger

Stainless Steel Evaporator Plate

Boiler Pump: Bronze, HP,

120V, 1∅, 60Hz

Control

120V, 60Hz, 1Ø, Power Supply

120/24V 60Hz Transformer

Ignition Module

3-Try – Standard

Single-Try – Option C-6

Hot Surface Ignition (HSI)

Remote Flame Sensor

High Limit Control, Auto Reset

On/Off Power Switch

Flow Switch

Blocked Vent Pressure Switch

Combustion Air Proving Switch

Freeze Protection

Pump Switch

Pump Time Delay

Blocked Condensate Switch

Control (cont.)

Diagnostics Panel with LCD Display,

2 lines, 20 characters

Digital Temperature Control

Water Temperature Sensors (3)

Cold Water Protection

Burner

Ultra-Low NOx: Less than 20 PPM

(Natural Gas Only)

Gas Train

Fuel

Natural Gas

Propane

Zero Governor Regulator

Dual-Seat Combination Valve

Electronic Firing Mode (WHP)

Construction

Indoor/Outdoor Construction

Front Controls Enclosed

PolyTuf Powder Coat Finish

Rear Connections (Water, Gas, Vent,

Electrical, Comb. Air, Cond. Drain)

Combustion Air Filter

Design Certified ANSI Z21.10.3/CSA 4.3

Venting

Vent Termination

Outdoor or Indoor, Vertical –

Option D-11

Indoor, Horizontal – Option D-15

Extractor - Optional

By others

Not required

Multi-Boiler Digital Temp Controllers

B-36 TempTracker Mod+,

2-4 Water Heaters

B-37 TempTracker Mod+,

5-10 Water Heaters

B-38 TempTracker Mod+,

11-16 Water Heaters

Options

F-10 Low Water Cut-Off, Remote

Probe

I-5 High Limit, Manual Reset,

Adj., 100-200°F

S-1 Low Gas Pressure Switch,

Manual Reset

S-2 High Gas Pressure Switch,

Manual Reset

Z-12 Condensate Neutralizer Kit

Regulatory Agency Requirements

XTherm

™

- Type WHP

Water Heaters

Models 1005-2005

Catalog No.: 6000.37 Effective: 9-15-08 Replaces: NEW

XTherm – Type WHP

Models 1005-2005 Model

Model

MBTUH Dimensions (in.) Amp Draw** Ship

Weight

(WHP-) B D E F G* K L M N P R Y

Heater w/ Pump (Lbs.)

Input Output Height NPT Flue Ø C/A Ø Pump

1005 999 969 55-1/8 45 47-1/8 36-1/2 1-1/4 6 40-1/16 11-1/2 6 47-1/8 8-1/16 6-1/16 22 1/2 – 7 1065

1505 1500 11455 67-1/8 57 59-1/16 38-1/2 1-1/4 8 52-1/16 12-5/8 8 59-1/8 8-3/16 6-1/16 26 3/4 -11 1234

2005 1999 1939 81-1/8 71 71-3/16 38-1/2 2 8 64-1/16 12-5/8 8 73-1/8 8-3/16 6-1/4 35 1 - 14 1461

Note: Ratings shown are for elevations up to 4,500 feet. For installations at elevations

above 4,500 feet, please consult the factory for additional instructions. * For Propane Gas, all models are 1”

** Supply breaker must have delayed trip.

RATES OF FLOW (GPM)

Maximum Flow Minimum Flow

Model

(WHP-) GPM ∆T (°F) GPM ∆T (°F)

1005 113 17 47 40

1505 113 25 71 40

2005 116 33 95 40

CLEARANCES (in.)

Front Rear Right Left Top Floor Vent

Certified Minimum 24 12 1 1 0 0 1

Recomm. Service 24 36 24 1 10 n/a n/a

NOTE: Primary/Secondary plumbing

is mandatory for proper operation.

Andere Handbücher für 1005-2005

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Raypak Boiler Handbücher

Raypak

Raypak RSIT30 Handbuch

Raypak

Raypak HI DELTA HD401 Handbuch

Raypak

Raypak 0133-4001 WH Bedienungsanleitung

Raypak

Raypak 090A Bedienungsanleitung

Raypak

Raypak MVB 503 Bedienungsanleitung

Raypak

Raypak Hot Water Supply LAUNDRY-PAK Bedienungsanleitung

Raypak

Raypak 122-322 Bedienungsanleitung

Raypak

Raypak ECONOPAK WH-260 Bedienungsanleitung

Raypak

Raypak FlexGas Betriebsanleitung

Raypak

Raypak 260-401 Bedienungsanleitung

Raypak

Raypak 115 To 2590 Gallons Bedienungsanleitung

Raypak

Raypak HIDELTA 992B Handbuch

Raypak

Raypak XFYRE NINETY PLUS 300 Bedienungsanleitung

Raypak

Raypak Asme Code 235 Bedienungsanleitung

Raypak

Raypak Raytherm WH-2100 Bedienungsanleitung

Raypak

Raypak FlexGas Hi Delta H 302CD-2342CD Bedienungsanleitung

Raypak

Raypak RAYTHERM 133-4001 Handbuch

Raypak

Raypak B0520 Bedienungsanleitung

Raypak

Raypak B0200 Bedienungsanleitung

Raypak

Raypak 910500 Technisches Dokument

Raypak

Raypak 185 Bedienungsanleitung

Raypak

Raypak Power Vent Raytherm 2100 Bedienungsanleitung

Raypak

Raypak Power Vent Raytherm 2100 Bedienungsanleitung

Raypak

Raypak HI DELTA HD101 THRU 2342B Handbuch

Beliebte Boiler Handbücher anderer Marken

Kenmore

Kenmore 153.582400 Bedienungsanleitung

Applimo

Applimo Edel AIR Bedienungsanleitung

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Bedienungsanleitung

clage

clage E-Mini Series Bedienungsanleitung

Toyotomi

Toyotomi Oil Miser OM-180 Bedienungsanleitung

Bradford White

Bradford White EF Series Bedienungsanleitung

Eccotemp

Eccotemp 40-H Bedienungsanleitung

Dimplex

Dimplex ECSd125-580 Leitfaden

Dux

Dux 32FCR6N Bedienungsanleitung

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Fehlerbehebungshandbuch

Noritz

Noritz N-132M Gebrauchsanweisung

TESY

TESY GCV7/4S 10047 Technisches Datenblatt

A.O. Smith

A.O. Smith Gphe 50 Bedienungsanleitung

Koryo

Koryo KWHZF15Y Bedienungsanleitung

Pentair

Pentair PSC-14-4-02 Bedienungsanleitung

GE 40M06AAG Montageanleitung

Thermor

Thermor AEROMAX SPLIT 2 Bedienungsanleitung

American Hometec

American Hometec AHQ-B03X Bedienungsanleitung