Ricoh FT5535 Bedienungsanleitung

FT5535/5035/4527/4027/4522/4022

FIELD SERVICE MANUAL

IMPORTANT SAFETY NOTICES

PREVENTION OF PHYSICAL INJURY

1. Before disassembling or assembling parts of the copier and peripherals,

make sure that the copier power cord is unplugged.

2. The wall outlet should be near the copier and easily accessible.

3. Note that the drum heater and the optional anti-condensation heaters are

supplied with electrical voltage even if the main switch is turned off.

4. If any adjustment or operation check has to be made with exterior covers

off or open while the main switch is turned on, keep hands away from

electrified or mechanically driven components.

5. The inside and the metal parts of the fusing unit become extremely hot

while the copier is operating. Be careful to avoid touching those

components with your bare hands.

HEALTH SAFETY CONDITIONS

1. Toner and developer are non-toxic, but if you get either of them in your

eyes by accident, it may cause temporary eye discomfort. Try to remove

with eye drops or flush with water as first aid. If unsuccessful, get medical

attention.

OBSERVANCE OF ELECTRICAL SAFETY STANDARDS

1. The copier and its peripherals must be installed and maintained by a

customer service representative who has completed the training course

on those models.

!CAUTION

2. The RAM board has a lithium battery which can explode if handled

incorrectly. Replace only with the same type of RAM board. Do not

recharge or burn this battery. Used RAM boards must be handled

in accordance with local regulations.

FSM aFT5535/4527/4522

SAFETY AND ECOLOGICAL NOTES FOR DISPOSAL

1. Do not incinerate toner cartridges or used toner. Toner dust may ignite

suddenly when exposed to open flame.

2. Dispose of used toner, developer, and organic photoconductors in

accordance with local regulations. (These are non-toxic supplies.)

3. Dispose of replaced parts in accordance with local regulations.

4. When keeping used lithium batteries (from the main control boards) in

order to dispose of them later, do not store more than 100 batteries (from

the main control boards) per sealed box. Storing larger numbers or not

sealing them apart may lead to chemical reactions and heat build-up.

FT5535/4527/4522 bFSM

SECTION 1

OVERALL MACHINE

INFORMATION

1. SPECIFICATIONS

Configuration: Desktop

Copy Process: Dry electrostatic transfer system

Originals: Sheet/Book

Original Size: Maximum A3/11" x 17"

Copy Paper Size: Maximum

A3/11" x17" (Paper trays)

Minimum

A5/81/2" x 51/2" sideways (Paper trays)

A4/11" x 81/2" sideways (LCT)

A6/51/2" x 81/2" lengthwise (By-pass)

Duplex Copying: Maximum

A3/11" x 17"

Minimum

A5/81/2" x 51/2" (sideways)

Copy Paper Weight: Paper tray:

52 ~ 128 g/m2, 14 ~34 lb

(A153, A155, and A156 copiers)

64 ~ 90 g/m2, 17 ~ 24 lb

(A157, A159, and A160 copiers)

By-pass:

52 ~ 157 g/m2, 14 ~42 lb

LCT: 52 ~ 128 g/m2, 14 ~ 34 lb

Duplex copying:

64 ~ 105 g/m2, 17 ~ 24 lb

Reproduction Ratios: 4 Enlargement and 6 Reduction

A4/A3 Version LT/DLT Version

Enlargement

200%

141%

122%

115%

200%

155%

129%

121%

Full size 100% 100%

Reduction

93%

82%

75%

71%

65%

50%

93%

85%

77%

74%

65%

50%

Power Source: 120V/60Hz:

More than 12 A (for North America)

Rev. 7/95

FSM 1-1 FT5535/4527/4522

Power Consumption:

A153, and A156 copiers A157, and A160 copiers

Copier Only Full System Copier Only Full System

Maximum 1.45 KW 1.50 KW 1.45 KW 1.50 KW

Copying 1.00 KW 1.00 KW 0.80 KW 0.80 KW

Warm-up 0.90 KW 0.92 KW 0.90 KW 0.92 KW

Stand-by 0.16 KW 0.19 KW 0.15 KW 0.17 KW

Energy

Saver

1 0.15 KW 0.17 KW 0.14 KW 0.16 KW

2 0.13 KW 0.15 KW 0.12 KW 0.13 KW

3 0.12 KW 0.14 KW 0.09 KW 0.10 KW

4 0.11 KW 0.12 KW 0.07 KW 0.08 KW

5 0.09 KW 0.11 KW 0.05 KW 0.06 KW

6 0.07 KW 0.09 KW – –

Auto Off 0.02 KW 0.04 KW 0.02 KW 0.04 KW

NOTE: 1) Full System: Copier + ADF + Paper Tray Unit + 20 Bin S/S

2) Energy Saver: See SP1-105-002

3) Auto Off: See SP5-305

A161 and A162 Copiers

Copier Only Full System

Maximum 1.45 KW 1.50 KW

Copying 0.64 KW 0.72 KW

Warm-up 0.95 KW 0.97 KW

Stand-by 0.15 KW 0.17 KW

Energy Saver

1 0.14 KW 0.16 KW

2 0.12 KW 0.13 KW

3 0.09 KW 0.10 KW

4 0.07 KW 0.08 KW

5 0.05 KW 0.06 KW

Auto Off 0.02 KW 0.04 KW

NOTE: 1) Full System: Copier + ADF + Paper Tray Unit + 10 Bin S/S

2) Energy Saver: See SP1-105-002

3) Auto Off: See SP5-305

Noise Emission:

A153, and A156 copiers A157, and A160 copiers

Copier Only Full System* Copier Only Full System*

1. Sound Power Level

Copying 66 dB(A) 68 dB(A) 61 dB(A) 67 dB(A) (LWA)

Warm-up 41 dB(A) 41 dB(A) 39 dB(A) 40 dB(A) (LWA)

Stand-by 41 dB(A) 41 dB(A) 39 dB(A) 40 dB(A) (LWA)

2. Sound Pressure Level at the operator position

Copying 58 dB(A) 57 dB(A) 54 dB(A) 56 dB(A) (LPA)

Warm-up 33 dB(A) 27 dB(A) 32 dB(A) 27 dB(A) (LPA)

Stand-by 33 dB(A) 27 dB(A) 32 dB(A) 27 dB(A) (LPA)

NOTE: The above measurements are to be made according to ISO 7779.

* : Full System: Copier + ADF + Paper Tray Unit +10 Bin S/S.

Rev. 7/95

FT5535/4527/4522 1-2 FSM

Dimensions:

Width Depth Height

A153 copier 1030 mm (40.6") 655 mm (25.8") 606 mm (23.9")

A157/A161 copier 900 mm (35.5") 655 mm (25.8") 606 mm (23.9")

A156 copiers 1258 mm (49.6") 655 mm (25.8") 606 mm (23.9")

A160/A162 copiers 1128 mm (44.5") 655 mm (25.8") 606 mm (23.9")

Measurement Conditions

1) With by-pass feed table closed

2) With platen cover and copy tray attached

3) With LCT cover closed

Weight:

Weight

FT5035 A153 copier About 70 kg (154.2 lb)

FT5535 A156 copier About 82 kg (180.7 lb)

FT4027 A157 copier About 67 kg (147.7 lb)

FT4527 A160 copier About 80 kg (176.4 lb)

FT4022 A161 copier About 67 kg (147.7 lb)

FT4522 A162 copier About 80 kg (176.4 lb)

Zoom: From 50% to 200% in 1% steps

Copying Speed (copies/minute):

A4 sideways/

11" x 81/2"A3/11" x 17" B4/81/2" x 14"

A153, and A156

copiers 35 20/19 22

A157, and A160

copiers 27 15/14 17

A161, and A162

copiers 22 12 -

Warm-Up Time A153, and A156 copiers:

Less than 110 seconds (20°C)

A157, and A160 copiers:

Less than 80 seconds (20°C)

A161, and A162 copiers:

Less than 60 seconds (20°C)

First Copy Time:

Paper Feed Station A4/11" x 81/2" (sideways)

A153, and A156

copiers A157, and A160

copiers A161 and A162

copiers

1st Tray 5.2 s (except for A156) 5.9 s (except for A160) 5.9 s (except for A162)

2nd Tray 5.7 s 6.6 s 6.6 s

By-pass 4.8 s 5.6 s 5.6 s

LCT 5.0 s 5.9 s 5.9 s

Note: In A156 and A160 copiers, the 2nd tray in the above table is called the

1st tray (see Installation - Paper Feed Station Definition).

Rev. 7/95

FSM 1-3 FT5535/4527/4522

Copy Number Input: Ten-key pad, 1 to 999 (count up or count down)

Manual Image Density

Selection: 7 steps

Automatic Reset: 1 minute is the standard setting; it can be changed to

a maximum of 999 seconds or no auto reset by SP

mode.

Copy Paper Capacity:

Paper Tray By-pass Feed LCT

A153 copier About 500 sheets x2 About 40 sheets –

A156 copier About 500 sheets x1 About 40 sheets About 1000 sheets

A157 copier About 250 sheets x2 About 40 sheets –

A160 copier About 250 sheets x1 About 40 sheets About 1000 sheets

A161 copier About 250 sheets x2 About 40 sheets –

A162 copier About 250 sheets x1 About 40 sheets About 1000 sheets

Duplex Tray Capacity

[A156/A160/A162]: 50 sheets (30 sheets for A3/11"x17"

81 ~ 105g/m2, 21.5 ~ 27.9 lb paper)

Toner Replenishment: Cartridge exchange (415 g/cartridge)

Toner Yield: 17K Copies/cartridge

Developer Replenisment: Type 1 (1Kg.)

Developer Yield: A153/A156 @ 120K

A157/A160 @ 100K

A161/A162 @ 100K

Optional Equipment: •Platen cover

•Document feeder

•Paper tray unit with two paper trays

•Paper tray unit with three paper trays

•10 bin micro sorter

•20 bin mini sorter

•10 bin sorter stapler

•20 bin sorter stapler(Not used with A161/A162 copiers)

•Sorter adapter (required when installing 20 bin

mini sorter, 10 bin sorter stapler, or 20 bin sorter

stapler for A157, A160, A161, and A162 copiers)

•Key counter

•Tray heater

•Optical anti-condensation heater

•Original length sensor for 11" x 15" size paper

(only for LT/DLT version)

•ADS sensor for particular types of red original

•Zoom (10 Key) Function Decal *

•Margin Adjustment Function Decal*

Rev. 7/95

*Not used on FT4022/4522 (A161/A162)

FT5535/4527/4522 1-4 FSM

SECTION 2

COMPONENT LAYOUT AND

DESCRIPTION

1. MACHINE CONFIGURATION

1.1 COPIER

Rev. 7/95

FSM 2-1 FT5535/4527/4522

Andere Handbücher für FT5535

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Ricoh Drucker Handbücher

Ricoh

Ricoh C4500 Bedienungsanleitung

Ricoh

Ricoh Aficio SP 5200DN Betriebsanleitung

Ricoh

Ricoh CL7000 - Aficio D Color Laser Printer Bedienungsanleitung

Ricoh

Ricoh InfoPrint 1754dn Bedienungsanleitung

Ricoh

Ricoh BP20 - Aficio B/W Laser Printer Bedienungsanleitung

Ricoh

Ricoh Aficio SP C811DN Series Kurzanleitung

Ricoh

Ricoh Aficio SP C320DN Bedienungsanleitung

Ricoh

Ricoh G112 Bedienungsanleitung

Ricoh

Ricoh Ri 1000 Installationsanleitung

Ricoh

Ricoh PRO C7200 Gebrauchsanweisung

Ricoh

Ricoh G1398501 Bedienungsanleitung

Ricoh

Ricoh 3590DNP Bedienungsanleitung

Ricoh

Ricoh MPC6000 Montage- und Wartungsanleitung

Ricoh

Ricoh Aficio MP W3600 Montage- und Wartungsanleitung

Ricoh

Ricoh Pro 8300 Series Installationsanleitung

Ricoh

Ricoh SP3 Bedienungsanleitung

Ricoh

Ricoh Pro C9500 Einrichtungshandbuch

Ricoh

Ricoh Aficio SP 1210N Bedienungsanleitung

Ricoh

Ricoh 2238 Bedienungsanleitung

Ricoh

Ricoh Aficio GX7000 Bedienungsanleitung

Ricoh

Ricoh MP 6503 Series Bedienungsanleitung

Ricoh

Ricoh MP 2501SP Gebrauchsanweisung

Ricoh

Ricoh LS3000 Bedienungsanleitung

Ricoh

Ricoh Aficio GX3050N Bedienungsanleitung

Beliebte Drucker Handbücher anderer Marken

Lexmark

Lexmark 1400 Series Handbuch

Canon

Canon i70 Series Bedienungsanleitung

Evolis

Evolis Elypso Bedienungsanleitung

Kyocera

Kyocera FS-9530DN Bedienungsanleitung

Canon

Canon LASER SHOT LBP-1210 Bedienungsanleitung

Samsung

Samsung BIXOLON SRP-350plusF Bedienungsanleitung

Canon

Canon PIXMA PRO-1 Series Bedienungsanleitung

Canon

Canon PIXMA G3560 Einrichtungshandbuch

Dell

Dell Color Laser Printer 2130cn Bedienungsanleitung

Tektronix

Tektronix Phaser 840 Bedienungsanleitung

Epson

Epson ET-7750 Betriebsanleitung

Canon

Canon CLBR 460ps Bedienungsanleitung

Eltron

Eltron P210 Guide Bedienungsanleitung

Epson

Epson SC-F7100 series Bedienungsanleitung

Epson

Epson Stylus C40UX Bedienungsanleitung

Canon

Canon imagePASS-A2 Bedienungsanleitung

Canon

Canon S820D Bedienungsanleitung

IRA3D

IRA3D POETRY4 Bedienungsanleitung