Ski-Doo 2006 MX Z Handbuch

Mmo-2006-007 suppl MX Z X.FH8 Tue Jun 21 08:14:45 2005 Page 1

Composite

C M Y CM MY CY CMY K

SAFETY WARNING

Disregarding any of the safety precautions and instructions

contained in this Operator’s Guide,Safety Videocassette or on-

product warnings may result in injury, including the possibility of

death.

This Operator’s Guide and Safety Videocassette should remain

with the unit at time of resale.

In USA, products are distributed by BRP US Inc.

In Canada, products are distributed by Bombardier Recreational Prod-

ucts Inc.

The following are trademarks of Bombardier Recreational Products

Inc. or its subsidiaries.

SKI-DOO ROTAX®‘

REV®MX-Z®

Printed in Canada. (mmo2006-007 DR)

®™ and the BRP logo are trademarks of Bombardier Recreational Products Inc. or its affiliates.

* Trademark of Bombardier Inc. used under license.

Dear 2006 MX Z XTM 440 owner, informations in the 2006 REV®

Series Operator's Guide (P/N 520 000 547) also apply to your MX

Z X 440 except for the following.

__________________________ 1

TABLE OF CONTENTS

VEHICLE INFORMATION

RACING APPLICATION........................................... 4

CONTROLS/INSTRUMENTS/EQUIPMENT .................... 5

1) Brake/Parking Brake PilotLamp (Red)...................... 5

12) Tether Cord Cut-Out System .............................. 6

13) Engine Cut-Out Switch .................................... 6

14) High Beam/Low Beam Switch ............................ 6

18) Fuel Level .................................................. 7

43) Pre-Heat Switch............................................ 8

44) Primer Button .............................................. 8

RECOMMENDED FUEL AND OIL................................ 9

OPERATING INSTRUCTIONS.................................... 13

Engine Starting Procedure..................................... 13

Suspensions Adjustments..................................... 13

SPECIFICATIONS ................................................. 15

MAINTENANCE INFORMATION

ENGINE SYSTEM................................................. 20

Coolant Pump Shaft Oil Reservoir............................. 20

Cooling System ................................................ 20

DRIVE SYSTEM................................................... 21

Brake Fluid Level............................................... 21

Drive Belt Removal/Installation................................ 21

WARRANTY

LIMITED WARRANTY VALIDATION............................. 26

2__________________________

VEHICLE

INFORMATION

__________________________ 3

RACING APPLICATION

For racing application, the main jets have to be replaced according to

thechartfoundonbeltguard.

4__________________________

CONTROLS/INSTRUMENTS/EQUIPMENT

A33A1RC

6 7 9 13

NOTE: See description of numbered items in 2006 REV Series Op-

erator’s Guide (P/N 520 000 547) except for the following.

1) Brake/Parking Brake Pilot Lamp (Red)

This pilot lamp is disabled (does not light up) on the MX Z X 440.

WARNING

Make sure parking brake is fully disengaged before operating

the snowmobile.

When you ride the vehicle, brake that are caused to drag by

a continuous pressure on the lever may cause damage to the

brake system and cause loss of braking capacity and/or fire.

__________________________ 5

12) Tether Cord Cut-Out System

General

The tether cord cut-out system prevents snowmobile to runaway, if

the operator accidently falls off, by shutting off the engine.

WARNING

Always disconnect tether cord when leaving vehicle unattend-

ed and keep in a secured location.

Operation

Attach tether cord to clothing eyelet then snap tether cord cap over

post before starting engine.

To stop engine, completely pull cap from post.

13) Engine Cut-Out Switch

Locatedonrightsideofhandlebarthisswitchisusedtostopthe

engine.

OFF

A33E0HB

OFF

14) High Beam/Low Beam Switch

Allows selection of headlamp high beam or low beam.

6__________________________

mmo2006-007-002_a

1. Low beam

2. High beam

18) Fuel Level

Open fabric door to see the fuel level through the translucent fuel

tank.

A33H1OA 1

1. Fabric door

__________________________ 7

43) Pre-Heat Switch

Racing Application Only

NOTE: This switch is disabled (not operative) on vehicles modified

forwarrantyvalidation. Torunenginewith91octanenumberfuel

(R + M)/2 inside North America (95 RON outside North America),

this switch must be disabled.

A33E0SA

1. Button depressed: Pre-heat timing curve

2. Button released: 108 (R + M)/2+ octane timing curve for North America

version (98 RON + Octane timing curve for outside North America)

After starting the engine, push and hold the pre-heat switch button

in order to pre-heat the tuned pipe. Release pre-heat switch button

once the tuned is pre-heated.

44) Primer Button

Pull and push button. It is not necessary when engine is warm.

To prime, activate button until a pumping resistance is felt. From

this point, pump 2 or 3 times to inject fuel in intake manifold. After

priming, ensure that primer button is pushed back.

NOTE: In very cold temperature, it is recommended to rotate primer

button 3-4 turns prior to pull it. This will eliminate the possibility of

sticking.

8__________________________

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Ski-Doo Geländefahrzeug Handbücher

Ski-Doo

Ski-Doo 2000 ZX series Handbuch

Ski-Doo

Ski-Doo 1997 Snowmobile Handbuch

Ski-Doo

Ski-Doo Tundra Skandic Series Handbuch

Ski-Doo

Ski-Doo 1989 Alpine II Bedienungsanleitung

Ski-Doo

Ski-Doo Scandic Tundra Series Handbuch

Ski-Doo

Ski-Doo Blizzard 5500 1981 Bedienungsanleitung

Ski-Doo

Ski-Doo Expedition LE Handbuch

Ski-Doo

Ski-Doo ALPINE II Bedienungsanleitung

Ski-Doo

Ski-Doo REV Series Handbuch

Ski-Doo

Ski-Doo Legend Handbuch

Ski-Doo

Ski-Doo Mini Z Handbuch

Ski-Doo

Ski-Doo 1981 Citation 3500 Bedienungsanleitung

Ski-Doo

Ski-Doo Skandic WT Handbuch

Ski-Doo

Ski-Doo Scandic WT 550F Handbuch

Ski-Doo

Ski-Doo Safari Scout Bedienungsanleitung

Ski-Doo

Ski-Doo Mini Z 2000 Installationsanleitung

Ski-Doo

Ski-Doo Skandic Series Handbuch

Ski-Doo

Ski-Doo EVEREST 444 L/C 1977 Bedienungsanleitung

Ski-Doo

Ski-Doo MX Z X 600 RS Handbuch

Ski-Doo

Ski-Doo Formula MACH 1 Bedienungsanleitung

Ski-Doo

Ski-Doo 2006 RF series Handbuch

Ski-Doo

Ski-Doo MX Zx 600 RS Handbuch

Ski-Doo

Ski-Doo RT series Handbuch

Ski-Doo

Ski-Doo Grand Touring SE 1997 Betriebsanleitung

Beliebte Geländefahrzeug Handbücher anderer Marken

Polaris

Polaris RANGER XP 1000 EPS 2018 Bedienungsanleitung

Yamaha

Yamaha Tri Moto 125 Bedienungsanleitung

Yamaha

Yamaha YFM350X Warrior Bedienungsanleitung

APRILIA

APRILIA QUASAR 100 Bedienungsanleitung

Polaris

Polaris RZR 900 Bedienungsanleitung

Suzuki

Suzuki LT-A700X Bedienungsanleitung

Suzuki

Suzuki LT-Z400 Bedienungsanleitung

Arctic Cat

Arctic Cat 120 sno pro Bedienungsanleitung

Yamaha

Yamaha RS90PB Bedienungsanleitung

Dinli

Dinli DL702 Bedienungsanleitung

Yamaha

Yamaha SXV70ML Bedienungsanleitung

Baja motorsports

Baja motorsports ATV 90 Handbuch

Polaris

Polaris Sportsman 550 XP EPS Bedienungsanleitung

Arctic Cat

Arctic Cat ALTERRA 450 Bedienungsanleitung

Polaris

Polaris Sportsman 9922233 Bedienungsanleitung

Yamaha

Yamaha YFM45FAT Handbuch

Polaris

Polaris RZR XP 1000 Bedienungsanleitung

Polaris

Polaris Outlaw 500 Bedienungsanleitung