Spectra Logic 10K Library Betriebsanleitung

Spectra® 10K Library

Preventative Maintenance Guide

SDOC 2001-1 Revision C

Spectra 10K Library Preventative Maintenance Guide

Contents

About Preventative Maintenance......................................................................................3

Preparing the Library .......................................................................................................4

Changing the Air Filter .....................................................................................................5

Cleaning the Door Sensor ................................................................................................ 6

Internal Maintenance and Cleaning ................................................................................. 7

Cleaning the Drives ........................................................................................................13

Final Testing.................................................................................................................... 15

Spectra 10K Library Preventative Maintenance Guide

About Preventative Maintenance

Purpose

The preventative maintenance procedure is intended to provide the best possible

operating results from the Spectra 10K library.

Time Involved

This procedure takes approximately two hours.

Tools Needed

◗A credit card or thin piece of plastic

◗A #1 Phillips screwdriver with a long handle (8-inch minimum)

◗A large flat head screwdriver

◗A can of compressed air

◗A vacuum cleaner with static-free attachment (hard plastic nozzle)

◗A new Spectra 10K library air filter

◗A Sony cleaning tape

◗Four bar-coded scratch tapes

Spectra 10K Library Preventative Maintenance Guide

Preparing the Library

1. Use your backup software to remove all tapes from the library, noting which tapes

were in which slots.

2. Shut off all power to the library.

3. Shut down the host system and switch off the power.

4. Remove the library’s AC power cord from the AC power outlet.

5. Carefully remove SCSI cable connections from the back of the library.

6. Move the library to a clean work space with plenty of room, so that you have access

to all sides of the library.

Spectra 10K Library Preventative Maintenance Guide

Changing the Air Filter

1. The front panel of the library has a grill on the left, and on the left end of the grill

is a groove. Use a credit card or other piece of plastic to open the grill.

2. Swing open the grill.

3. Remove the air filter.

4. Inspect the grill; if the grill is dirty, clean it.

5. Install the new air filter.

6. Close the grill and snap it shut.

Note: Filters should be checked on a monthly basis or after the library has

been moved. On average, the library filter needs changing once

every three months. If the environment is particularly dirty, the

filter needs to be replaced more frequently.

Spectra 10K Library Preventative Maintenance Guide

Cleaning the Door Sensor

1. Notice the four small holes in the top of the door for LED sensors: two holes toward

the back of the door and two holes near the front of the door. If these holes are

clogged with dust or other debris, the door sensors will fail to operate.

2. Use the can of compressed air to blow out the four holes and dislodge any debris.

Use a plastic attachment to direct air into the holes.

Note: The door sensor should be cleaned once every three months, at a

minimum.

Spectra 10K Library Preventative Maintenance Guide

Internal Maintenance and Cleaning

1. Use a large flat head screwdriver to remove the thumbscrews on the back of the

library.

Caution: The library contains static sensitive devices. Please use a static

dissipative wrist strap or other ESD equipment and tools for this

process.

2. Remove the cover by:

a. Sliding the cover backwards, then

b. Lifting up the cover.

3. Use a #1 Phillips screwdriver to loosen the two captive screws holding each drive in

place.

Spectra 10K Library Preventative Maintenance Guide

4. Slide the drives as far back as they will go, without removing the drive cables.

All drives in original positions.

All drives slid back.

Drive 2 slid back.

Spectra 10K Library Preventative Maintenance Guide

5. Use a #1 Phillips screwdriver with a long shaft to loosen the eight captive screws

holding the carousel to the library chassis.

Caution: Captive screws cannot be completely removed. Loosen the screws

sufficiently to disengage them from the chassis.

6. Rotate the robotic arm so that the gripper jaws point to the rear of the library, as

shown below; the carousel does not come out unless the gripper jaws face the rear

of the library.

A diagram

showing

how the

carousel

would be

seen from

the top

with the

library’s

cover

8 captive screws

Rear of Library

Guide Pins

Spectra 10K Library Preventative Maintenance Guide

Caution: Do not force the carousel out of the library. The base of the

robotic arm is not a circle, and the carousel does not lift straight

up and out. The carousel comes out easily if done correctly, as

outlined in Step 7, below.

7. Remove the carousel.

a. Lift the carousel up and off the guide pins, about 1/2 inch.

b. Lift the front of the carousel so that it is even with, or a little higher than, the

base of the robotic arm.

c. Move the carousel toward the rear of the library so that the front of the

carousel touches the robotic arm base.

d. Lift the rear of the carousel above the robotic arm base. The carousel should

now be clear of the robotic arm base.

e. Carefully lift the carousel up and out of the library.

8. Use a static-free vacuum cleaner to remove any debris from the bottom of the library.

9. Clean the tape guides in the carousel.

10. After vacuuming, use a can of compressed air to clean the boards, power supply,

components, and any section where a static-free vacuum might not be able to reach.

Caution: Blow dust and debris away from the tape drives.

Inhaltsverzeichnis

Andere Spectra Logic Lagerung Handbücher

Spectra Logic

Spectra Logic Spectra 10000 Bedienungsanleitung

Spectra Logic

Spectra Logic Spectra 12K Bedienungsanleitung

Spectra Logic

Spectra Logic T-Series Spectra T50 Bedienungsanleitung

Spectra Logic

Spectra Logic T-Series Spectra T200 Bedienungsanleitung

Spectra Logic

Spectra Logic Spectra 20K Bedienungsanleitung

Spectra Logic

Spectra Logic T-Series Spectra T50e Bedienungsanleitung

Spectra Logic

Spectra Logic Spectra 12K Bedienungsanleitung

Spectra Logic

Spectra Logic Spectra nTier500 Bedienungsanleitung

Spectra Logic

Spectra Logic Spectra 10K Bedienungsanleitung

Spectra Logic

Spectra Logic Spectra 12K Bedienungsanleitung

Spectra Logic

Spectra Logic Spectra 64K Handbuch

Spectra Logic

Spectra Logic T-Series Spectra T120 Bedienungsanleitung

Spectra Logic

Spectra Logic T-Series Spectra T200 Bedienungsanleitung

Spectra Logic

Spectra Logic T-Series Spectra T950 Bedienungsanleitung

Spectra Logic

Spectra Logic Spectra RXT350 Bedienungsanleitung

Spectra Logic

Spectra Logic T-Series Spectra T120 Betriebsanleitung

Spectra Logic

Spectra Logic Spectra 10000 Handbuch

Spectra Logic

Spectra Logic BlackPearl NAS Bedienungsanleitung

Spectra Logic

Spectra Logic Spectra 2k Merkblatt

Spectra Logic

Spectra Logic Spectra 2k Stücklistenhandbuch

Spectra Logic

Spectra Logic T120 LIBRARY Bedienungsanleitung

Spectra Logic

Spectra Logic Spectra nTier300 Bedienungsanleitung

Spectra Logic

Spectra Logic Spectra 12K Bedienungsanleitung

Spectra Logic

Spectra Logic AIT-4 Handbuch

Beliebte Lagerung Handbücher anderer Marken

QNAP

QNAP TS 32PXU Series Bedienungsanleitung

LaCie

LaCie RUGGED RAID Bedienungsanleitung

Freecom

Freecom CLS DOCK Bedienungsanleitung

PNY

PNY Attache P-FD64MBATT3 Bedienungsanleitung

HP StorageWorks MSL2024 Bedienungsanleitung

OLT

OLT 6x6 Maximizer Bedienungsanleitung

Transcend

Transcend JetFlash 160 Bedienungsanleitung

LaCie

LaCie RUGGED MINI Bedienungsanleitung

Thunderbolt

Thunderbolt 600 Bedienungsanleitung

Panasonic

Panasonic LB-DH8 series Handbuch

Intel

Intel RAID High Availability Bedienungsanleitung

LaCie

LaCie 12big Thunderbolt 3 Bedienungsanleitung

Panasonic

Panasonic LKM-F931-1 Bedienungsanleitung

Tabernus

Tabernus Enterprise Erase E2400 Bedienungsanleitung

Rocstor

Rocstor COMMANDER 3F series Bedienungsanleitung

HP P9000 Bedienungsanleitung

Western Digital

Western Digital Ultrastar Data60 Bedienungsanleitung

Dell

Dell PowerVault MD3600f Series Bedienungsanleitung