Spectra Logic Spectra 10000 Bedienungsanleitung
Spectra®4000-10000
Unified Control Module (UCM) Board
Replacement Guide
Notices
EXCEPT AS EXPRESSLY STATED HEREIN, SPECTRA LOGIC CORPORATION MAKES AVAILABLE
ITS PRODUCTS AND ASSOCIATED DOCUMENTATION ON AN “AS IS” BASIS, WITHOUT
WARRANTY OF ANY KIND, EITHER EXPRESSED OR IMPLIED, INCLUDING BUT NOT LIMITED
TO THE IMPLIED WARRANTIES OR CONDITIONS OF MERCHANTABILITY AND FITNESS FOR A
PARTICULAR PURPOSE. IN NO EVENT SHALL SPECTRA LOGIC BE LIABLE FOR ANY LOSS OF
PROFITS, LOSS OF BUSINESS, LOSS OF USE OR DATA, INTERRUPTION OF BUSINESS, OR FOR
INDIRECT, SPECIAL, INCIDENTAL, OR CONSEQUENTIAL DAMAGES OF ANY KIND, EVEN IF
SPECTRA LOGIC HAS BEEN ADVISED OF THE POSSIBILITY OF SUCH DAMAGES ARISING
FROM ANY DEFECT OR ERROR.
Information furnished in this manual is believed to be accurate and reliable. However, no responsibility
is assumed by Spectra Logic for its use. Because of continuing research and development, Spectra Logic
may revise this publication from time to time without notice, and reserves the right to change any
product specification at any time without notice.
Some products or services mentioned in this manual are provided by companies other than Spectra
Logic. Inquiries about one or more of these products or services should be sent directly to the company
in question. This manual refers to the following brand or product names, registered trademarks, and
trademarks that are listed according to their respective owners. These trademarks may be registered in
this country, other countries, or both.
Copyright © 2003 Spectra Logic Corporation.
All rights reserved.
Spectra Logic Corporation
Spectra 4000TM
Spectra 5000TM
Spectra 5100TM
Spectra 9000TM
Spectra 10000TM
Spectra® 4000-10000 Unified Control Module (UCM) Board Replacement Guide
5
Contents
Introduction ................................................................................................ 6
Powering Down the Library ....................................................................... 8
Removing the Library Cover....................................................................... 9
Removing the UCM Board in Spectra 4000-9000 Libraries ..................... 10
Removing the UCM Board in the Spectra 10000 Library ........................ 13
Replacing the UCM Board in Spectra 4000-9000 Libraries...................... 17
Replacing the UCM Board in the Spectra 10000 Library......................... 19
Finish......................................................................................................... 22
Spectra® 4000-10000 Unified Control Module (UCM) Board Replacement Guide
6
Introduction
About this guide
This guide describes the procedure for replacing the Unified Control Module (UCM)
board assembly. This information is applicable to Spectra 4000, Spectra 5000, Spectra
5100, Spectra 9000, and Spectra 10000 tape libraries.
You will need:
A UCM Board Replacement Kit is needed to install a new UCM board into a Spectra
4000-10000 Tape Library. These kits are available from Spectra Logic, or an authorized
Spectra Logic reseller.
The UCM Board replacement kit has the following part numbers and contents:
4000: Part Number 90841600
• Replacement UCM Board
• Anti-Static Strap
5000: Part Number 90842002 (UCM-1)
• Replacement UCM Board
• Anti-Static Strap
5100: Part Number 90842003 (UCM-2)
• Replacement UCM Board
• Anti-Static Strap
9000: Part Number 90849009
• Replacement UCM Board
• Anti-Static Strap
10000: Part Number 92848052
• Replacement UCM Board
• Anti-Static Strap
Spectra® 4000-10000 Unified Control Module (UCM) Board Replacement Guide
7
You will also need:
• A #1 Phillips screwdriver
• A #2 Phillips screwdriver
• A flat head screwdriver
Time required:
This procedure should take less than one hour.
Spectra® 4000-10000 Unified Control Module (UCM) Board Replacement Guide
8
Powering Down the Library
Shut off all Power to the Library
1. Shut down the host system and switch off the power. Switch off the library power.
2. Remove the library’s AC power cord from the AC power outlet.
3. Carefully remove SCSI cable connections from the back of the library (Figure 1).
Figure 1 Remove SCSI cable.
Spectra® 4000-10000 Unified Control Module (UCM) Board Replacement Guide
9
Removing the Library Cover
1. Using the flat head screwdriver, loosen the three thumbscrews (four screws if it is a
vertical unit) which secure the library’s cover (Figure 2).
2. Slide the library cover back one half-inch away from the front panel to release the
cover’s side clips (Figure 3). Lift the cover off the library (Figure 4) and set it aside.
Figure 2 Remove thumbscrews.
Figure 3 Slide the cover back.
Figure 4 Lift the cover.
Spectra® 4000-10000 Unified Control Module (UCM) Board Replacement Guide
10
Removing the UCM Board in Spectra 4000-9000 Libraries
1. Locate the UCM board inside the library (Figure 5).
Caution: The UCM board is an Electrostatic Sensitive Device (ESD). Use
the static strap enclosed with the Spectra Logic UCM
replacement kit while handling assemblies inside the library.
Connect the static strap to your wrist and to the edge of the
library chassis to ensure a ground connection
.
2. Disconnect the gray SCSI ribbon cables from the drive(s).
3. Release the connector eject latches and remove the grey SCSI ribbon cable from the
UCM board (Figure 6).
Figure 5 UCM board location.
Figure 6 Connector eject latches.
Spectra® 4000-10000 Unified Control Module (UCM) Board Replacement Guide
11
4. Using the #1 Phillips screwdriver, unscrew the two captive screws on the bottom of
the UCM bracket (Figure 7).
5. Remove the UCM assembly (board and bracket) by gently lifting it straight up and
out of the library.
6. Use a #1 Phillips screwdriver to remove the two screws attaching the UCM bracket
to the UCM board (Figure 8).
Note: Previous product releases use an earlier version of the UCM
bracket. Use the new bracket shipped with the replacement part.
7. Remove the UCM board from the library.
Figure 7 Remove the two captive screws on the
UCM bracket.
Figure 8 Remove the screws attaching the UCM
bracket to the UCM board.
Spectra® 4000-10000 Unified Control Module (UCM) Board Replacement Guide
12
8. As soon as possible after removal, place the old UCM board into the anti-static bag
in which the new UCM board assembly was shipped.
Caution: Continue to keep the anti-static strap attached to your wrist and
to the library at all times while handling the UCM board.
9. Proceed to Replacing the UCM Board in Spectra 4000-9000 Libraries on page 17 to
continue the installation of the new UCM board.
Andere Handbücher für Spectra 10000
8
Dieses Handbuch passt für folgende Modelle
4
Inhaltsverzeichnis
Andere Spectra Logic Lagerung Handbücher
Spectra Logic
Spectra Logic Spectra 12K Bedienungsanleitung
Spectra Logic
Spectra Logic Spectra RXT150 Bedienungsanleitung
Spectra Logic
Spectra Logic T120 LIBRARY Bedienungsanleitung
Spectra Logic
Spectra Logic T-Series Spectra T200 Bedienungsanleitung
Spectra Logic
Spectra Logic Spectra 64K Bedienungsanleitung
Spectra Logic
Spectra Logic AIT-4 Handbuch
Spectra Logic
Spectra Logic T-Series Spectra T24 Bedienungsanleitung
Spectra Logic
Spectra Logic Spectra 20K Bedienungsanleitung
Spectra Logic
Spectra Logic NAStape 100 Bedienungsanleitung
Spectra Logic
Spectra Logic AIT-3 Handbuch
Spectra Logic
Spectra Logic Spectra 12000 Bedienungsanleitung
Spectra Logic
Spectra Logic T-Series Spectra T120 Bedienungsanleitung
Spectra Logic
Spectra Logic T-Series Spectra T50e Stücklistenhandbuch
Spectra Logic
Spectra Logic Spectra 20K Bedienungsanleitung
Spectra Logic
Spectra Logic T-Series Spectra T120 Bedienungsanleitung
Spectra Logic
Spectra Logic T-Series Spectra T200 Bedienungsanleitung
Spectra Logic
Spectra Logic DAStape 100 Bedienungsanleitung
Spectra Logic
Spectra Logic AIT-3 Bedienungsanleitung
Spectra Logic
Spectra Logic AIT-4 Handbuch
Spectra Logic
Spectra Logic Spectra 2k Bedienungsanleitung
Beliebte Lagerung Handbücher anderer Marken
Panasonic
Panasonic LKM-F931-1 Bedienungsanleitung
Tabernus
Tabernus Enterprise Erase E2400 Bedienungsanleitung
Rocstor
Rocstor COMMANDER 3F series Bedienungsanleitung
HP
HP P9000 Bedienungsanleitung
Western Digital
Western Digital Ultrastar Data60 Bedienungsanleitung
Dell
Dell PowerVault MD3600f Series Bedienungsanleitung