Spectra Logic Spectra 20K Bedienungsanleitung
P.N. 90920000 Revision A
Spectra®20K Library
Transport Tray Assembly
Replacement Guide
Spectra® 20K Library Transport Tray Assembly Replacement Guide
2
Notices
Except for Spectra Logic Corporation’s express repair/replacement warranty, Spectra Logic
provides the unit “as is” without warranty of any kind, either expressed or implied, including but
not limited to the implied warranties of merchantability or fitness for a particular purpose. In no
event shall Spectra Logic be liable for any loss of profits, loss of business, loss of use or data,
interruption of business, or for indirect, special, incidental, or consequential damages of any
kind, even if Spectra Logic has been advised of the possibility of such damages arising from any
defect or error.
Information furnished in this manual is believed to be accurate and reliable. However, no responsibility
is assumed by Spectra Logic for its use. Due to continuing research and development, Spectra Logic may
revise this publication from time to time without notice, and reserves the right to change any product
specification at any time without notice.
Spectra 20K Library Transport Tray Assembly Replacement Guide
Copyright © 2003 Spectra Logic Corporation. All rights reserved.
Spectra Logic Contact Information
Corporate Headquarters European Office
Address
Phone
Fax
Spectra Logic Corporation
1700 N 55th Street
Boulder CO 80301
USA
(800) 833-1132 or (303) 449-6400
(303) 939-8844
Address
Phone
Fax
Spectra Logic Europe Limited
Magdalen Centre
Robert Robinson Avenue
Oxford Science Park
Oxford
UK OX44 7 RW
+44 (0) 870 112 2150
+44 (0) 870 112 2175
Web Site http://www.SpectraLogic.com
Spectra® 20K Library Transport Tray Assembly Replacement Guide
3
Contents
Introduction ................................................................................................4
Prepare the Library and Host System ........................................................ 6
Remove the Robotic Rack Assembly .......................................................... 7
Remove the Transport Tray Assembly ..................................................... 12
Unpack the Replacement Transport Tray Assembly................................ 17
Install the Replacement Transport Tray Assembly .................................. 21
Replace the Robotic Rack Assembly ........................................................ 26
Prepare the Library for Tests.................................................................... 29
Tests .......................................................................................................... 30
Finish......................................................................................................... 33
Spectra® 20K Library Transport Tray Assembly Replacement Guide
4
Introduction
About this Manual
This manual describes the procedure for replacing the transport tray assembly in a
Spectra 20K library and how to configure and calibrate the assembly after it has been
installed.
About the Transport Tray Assembly
The transport tray assembly in Spectra 20K libraries moves within the robotic rack
assembly. Its job is to transport tape cartridges between the tape drives, tape slots, and
the entry/exit (E/E) port. The main component of the transport tray assembly is the
robotic picker, which handles the tape cartridges. The robotic picker has arms that
grab and hold one tape cartridge at a time while it travels along the transport tray. A
bar code reader located on the robotic picker reads the bar code label on each tape
cartridge to ensure accuracy.
Estimated Time Required
This procedure should take about one and one-half hours.
Figure 1 The transport tray assembly.
Robotic picker
Transport tray
Cable mast
Spectra® 20K Library Transport Tray Assembly Replacement Guide
5
Materials and Tools Required
You will need a transport tray assembly from Spectra Logic or an authorized reseller:
• Transport Tray Assembly, P.N. 90929001
You will also need the following tools:
• A #1 Phillips screwdriver
• A #2 Phillips screwdriver
• A flat head screwdriver
• A wire cutter
• Snap ring pliers
• The library door key
Spectra® 20K Library Transport Tray Assembly Replacement Guide
6
Prepare the Library and Host System
Shut down the library while keeping the host interface connected to the host system.
1. Disable any backup software that might try to access the library.
Warning: Electric shock inside the library can cause injury or death.
Disconnect AC power before opening the library door.
2. Turn off the power. The power switch is located at the rear of the library on the
lower left.
3. If necessary, move the library to a location where you have full access to the front
of the library.
Caution: The library weighs approximately 240 pounds (108.86 kg). Get
help when moving the library.
4. Use the library key to unlock and open the front door of the library.
5. Remove the drives from the drive bay and set them aside in a safe place.
Note: It is not necessary to remove the media.
6. Proceed to Remove the Robotic Rack Assembly on page 7.
Spectra® 20K Library Transport Tray Assembly Replacement Guide
7
Remove the Robotic Rack Assembly
1. Lower the transport tray to bottom of the robotic rack by gently raising the counter
weight (Figure 2).
Figure 2 The robotic rack counter weight is raised.
Spectra® 20K Library Transport Tray Assembly Replacement Guide
8
2. Rotate the picker so that the bar code scanner faces the rear of the library.
The location of the barcode scanner is shown in Figure 3.
3. Slide the picker along the transport tray to the front of the library (Figure 4).
Figure 3 The location of the bar code scanner.
Figure 4 The picker is slid to the front of the library.
Location of the
bar code scanner
Spectra® 20K Library Transport Tray Assembly Replacement Guide
9
4. Unplug the 25-wire black connector at the bottom front of the robotic rack
assembly (Figure 5).
5. Using the flat head screwdriver, remove the three cone head screws that hold the
robotic rack to the drive slot assembly (Figure 6).
Figure 5 The 25-wire black connector.
Figure 6 The cone head screws circled (the third cone head
screw is out of view.)
Spectra® 20K Library Transport Tray Assembly Replacement Guide
10
6. Using the #2 Phillips screwdriver, remove the screws that hold the robotic rack
assembly to the chassis: first the top, then the bottom (Figure 7).
7. From the front of the library, carefully slide the robotic rack assembly outward
about six inches (15.24 cm) (Figure 8).
Figure 7 The robotic rack screws.
Figure 8 The robotic rack assembly is moved outward.
Andere Handbücher für Spectra 20K
2
Inhaltsverzeichnis
Andere Spectra Logic Lagerung Handbücher
Spectra Logic
Spectra Logic T-Series Spectra T50 Bedienungsanleitung
Spectra Logic
Spectra Logic Spectra nTier700 Handbuch
Spectra Logic
Spectra Logic AIT-3 Bedienungsanleitung
Spectra Logic
Spectra Logic T-Series Spectra T50 Bedienungsanleitung
Spectra Logic
Spectra Logic T-Series Spectra T120 Bedienungsanleitung
Spectra Logic
Spectra Logic Spectra 10K Bedienungsanleitung
Spectra Logic
Spectra Logic T-Series Spectra T120 Handbuch
Spectra Logic
Spectra Logic Spectra 10000 Handbuch
Spectra Logic
Spectra Logic T-Series Spectra T200 Bedienungsanleitung
Spectra Logic
Spectra Logic T-Series Spectra T950 Bedienungsanleitung
Spectra Logic
Spectra Logic DAStape 100 Handbuch
Spectra Logic
Spectra Logic Spectra 2000 Handbuch
Spectra Logic
Spectra Logic T-Series Spectra T24 Bedienungsanleitung
Spectra Logic
Spectra Logic T-Series Spectra T200 Bedienungsanleitung
Spectra Logic
Spectra Logic T-Series Spectra T120 Leitfaden
Spectra Logic
Spectra Logic Spectra T950V Bedienungsanleitung
Spectra Logic
Spectra Logic Spectra 12K Bedienungsanleitung
Spectra Logic
Spectra Logic Spectra T950V Bedienungsanleitung
Spectra Logic
Spectra Logic T-Series Spectra T200 Bedienungsanleitung
Spectra Logic
Spectra Logic T-Series Spectra T50e Bedienungsanleitung
Beliebte Lagerung Handbücher anderer Marken
Panasonic
Panasonic LKM-F931-1 Bedienungsanleitung
Tabernus
Tabernus Enterprise Erase E2400 Bedienungsanleitung
Rocstor
Rocstor COMMANDER 3F series Bedienungsanleitung
HP
HP P9000 Bedienungsanleitung
Western Digital
Western Digital Ultrastar Data60 Bedienungsanleitung
Dell
Dell PowerVault MD3600f Series Bedienungsanleitung