Sport-thieme 1151666 Bedienungsanleitung

Sport-Thieme

Mini Handball Goal, 3.00x1.60 m

Art.-Nr.: 1151666

1151679

1151682

Assembly instructions

D-38367 Grasleben ·Germany

sport-thieme.com · info @sport-thieme.com

Phone: +49 53 57 181 543 · Fax: +49 53 57 181 921

Assembly instructions for Art.-Nr. 1151666, 1151679, 1151682

1. Scope of delivery

Please check the following content before assembly.

The following in dicated quantities refer to 1 street soccer goal. In case of a delivery in pairs we double the

amount.

Content:

1x Crossbar, prole 80 x 80 mm

2x Upright, prole 80 x 80 mm

2x Net hoop

1x Net

Accessories:

2x Hinge of U-prole

4x Hexagon screw M8 x 60, DIN 933

2x Flat head screw with groove M8 x 60, DIN 963

6x Washer Ø 8.4 mm, DIN 125

4x Washer Ø 7.4 mm, DIN 9021

2x Hexagon socket screw M8 x 16, DIN 7991

8x Hexagon screw M8 x 50, DIN 931

4x Self-locking nut M8, DIN 985

4x Self-locking cap nut M6, DIN 986

2x Wing nut M8, DIN 315

2x Corner joint with welded hinges

2x Steel corner joint

8x Steel plate for corner joint

2x Upright cap

1x Accessories

4x Ring nut M6 x 50

2x Nut M8, 20 mm

8x Plug pin

30x Safety system net holder

2x Plastic plug Ø 28mm, schwarz

2x Plastic cap 40 x 40 mm, schwarz

10x Plastic holder

1x Fixing cord for the net

1x Hexagon screwdriver SW5, DIN 911, schwarz

1x Assembly instruction

Assembly instructions for Art.-Nr. 1151666, 1151679, 1151682

2. Assembly of the goal

The following tools are necessary:

- 2 wrench/ring spanners 13 mm

- 1 wrench/ring spanner 10 mm

- 1 mallet/hammer

- 1 drill Ø 1.5 mm

- 1 thin screwdriver

- 1 scissors or knife (to cut o the plastic holders)

We recommend to mount the goal on the grass or on a suitable surface to avoid damages of the proles!

a) Assembly of crossbar/uprights:

Lay crossbar and uprights on the ground, groove facing upwards and mitres joining. Stick 4 steel plates on steel corner joint (see

1st picture bottom left). Then stick crossbar and upright on steel corner joint (see bottom pictures).

Assembly instructions for Art.-Nr. 1151666, 1151679, 1151682

b) Assembly of upper steel hinges:

Place steel hinges/angles on the edges of crossbar/upright construction and adjust holes, the open sides of the U proles facing

to the goal inside (see picture bottom left). Then screw hexagon screws DIN 931, M8 x 50 and x them (see picture bottom right).

Adjust corners and tighten all screws.

c) Assembly of lower steel hinges:

Stick from the bottom (upright’s end) 1 nut 20 mm, M8 into the groove of both uprights. Place lower hinge of U prole (see bottom

pictures), the countersunk hole facing to the upright’s end. Push nut 20 mm, M 8 below the hole of the hinge and x it slightly at

the upright with hexagon socket screw M8 x16, DIN 7991.

d) Assembly of caps:

Stick caps in the open ends of uprights (see picture bottom left). Bore them with drill 1.5 mm through the holes provided in the

uprights. Then x plug pins with a hammer/mallet (see picture bottom right). Adjust lower hinge and tighten screws. The hinge

has to be flush with the upright’s cap.

Assembly instructions for Art.-Nr. 1151666, 1151679, 1151682

e) Assembly of net hoops:

Fix net hoops in hinges. Consider that net hoop ends with 2

holes (round tube) are inserted in the upper hinges and the

ends with 1 hole (square tube) in the lower hinges. Adjust

holes of net hoops with holes of the hinges.

f) Fixing of the net hoop at the upper hinge:

Stick hexagon socket screw DIN 933, M8 x 60 from the top through 1st hole of hinge and hoop. Add washer DIN 125, Ø 8.4 mm from

the hinge bottom, screw self-locking nut DIN 985, M8 and x it slightly so that the net hoop can still be moved (see picture bottom

mid).

Now press the net hoop to the outside. Stick hexagon socket screw DIN 933, M 8 x 60 from the top through 2nd hole of upper hinge

and the hoop. Add washer DIN 125, Ø 8.4 mm from the hinge bottom and screw wing nut DIN 315, M 8 (see picture bottom right).

g) Fixing of net hoop at the lower hinge:

Stick flat head screw DIN 963, M8 x 60 from the bottom through

hinge and hoop. Add washer DIN 125, Ø 8.4 mm from the hinge

top, screw self-locking nut DIN 985, M8 and x it slightly so that

the net hoop can still be moved.

h) Fix plastic caps

40 x 40 mm in net hoop ends (square

tube).

Stick ring nuts M6x50 through net hoop holes

(position see picture bottom right), add washer

DIN 9021, 7.4 x 22 and x self locking cap nut

DIN 986, M6.

Take care that rings point to the inside.

Assembly instructions for Art.-Nr. 1151666, 1151679, 1151682

3. Assembly of the net

a) At rst x net holders at the net rope. Bend open net holders a little and press rope into the holders. We recommend the fol-

lowing distribution of net holders.

crossbar : 16 pieces

uprights : 7 pieces each

c) Fix net at each side with 5 plastic

holders in the bottom part of net

hoops. Cut o protruding ends of

plastic holders.

b) After having mounted all net hol-

ders x net at the goal construc-

tion. Stick net holders in the net

hook rail and x them with a 90

degrees’ rotation. Use a thin screw

driver if necessary.

d) Fix the end of the enclosed cord at the

bottom in one ring nut and knot it

well. Pull the cord through the net

meshes and x it at the top in the 2nd

ring nut and knot it well.

e) Dismantling of the net is also done by rotation of the net holders through 90 degrees. Use again a thin screw driver if neces-

sary.

Assembly instructions for Art.-Nr. 1151666, 1151679, 1151682

4. torage of the goal

To store the goal unscrew wing nuts at the upper hinges and remove screws.

Fold net hoops. Then screw slightly wing nuts and screws into the 2nd holes of the upper hinges so that they don’t get lost.

5. Ground xing

The ground bars are equipped with boreholes of 25 mm which serve to x the special anchoring systems for the goal. Dierent

systems are available (see Sport-Thieme accessories).

The anchoring system is not part of the delivery. The use of the goal without corresponding anchoring system is at your own risk.

If you do not use any anchoring system close both boreholes (positions see picture bottom right) with the supplied caps for safety

reasons. Use a mallet if necessary.

6. Maintenance, safety and storage instructions

This goal is constructed only for soccer matches and not for other purposes. Check all screwed

fastenings before use and repeat it from time to time. It has to protected against overturning at

any time. Do not climb net or goal frame.

It is not allowed to x additional parts or extensions at the goal frame which may impair the

safety of the goal (according to DIN EN 16579).

Check screwed fastenings regularly and change damaged and wearing parts if need be.

Notice: Due to our continuous quality check of products and equipment technical modications are possible.

To avoid damage and misuse goals have to be stored secured and in an upright position when not in use.

Only use water for cleaning the surfaces. Do not use alcohol or any aggressive chemicals!

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sport-thieme Sport & Outdoor Handbücher

Sport-thieme

Sport-thieme Quick-Net-Rail Bedienungsanleitung

Sport-thieme

Sport-thieme 3386200 Bedienungsanleitung

Sport-thieme

Sport-thieme 11 200 5805 Handbuch

Sport-thieme

Sport-thieme 2577106 Bedienungsanleitung

Sport-thieme

Sport-thieme Safe Bedienungsanleitung

Sport-thieme

Sport-thieme Pro Bedienungsanleitung

Sport-thieme

Sport-thieme 1145700 Bedienungsanleitung

Sport-thieme

Sport-thieme Fair Play 115 8104 Bedienungsanleitung

Sport-thieme

Sport-thieme 2619516 Bedienungsanleitung

Sport-thieme

Sport-thieme 115 2308 Bedienungsanleitung

Sport-thieme

Sport-thieme 11 112 1823 Bedienungsanleitung

Sport-thieme

Sport-thieme 202 6103 Bedienungsanleitung

Sport-thieme

Sport-thieme 167 8303 Bedienungsanleitung

Sport-thieme

Sport-thieme 11 244 8901 Montageanleitung

Sport-thieme

Sport-thieme Single wall bars 122 6557 Bedienungsanleitung

Sport-thieme

Sport-thieme 3286207 Handbuch

Sport-thieme

Sport-thieme Fair Play 2.0 Bedienungsanleitung

Sport-thieme

Sport-thieme 115 2207 Bedienungsanleitung

Sport-thieme

Sport-thieme 11 115 2568 Montageanleitung

Sport-thieme

Sport-thieme Kompakt 206 9539 Bedienungsanleitung

Sport-thieme

Sport-thieme Champ 306 5802 Bedienungsanleitung

Sport-thieme

Sport-thieme 2996107 Benutzerhandbuch

Sport-thieme

Sport-thieme 2577311 Bedienungsanleitung

Sport-thieme

Sport-thieme 115 6603 Bedienungsanleitung

Beliebte Sport & Outdoor Handbücher anderer Marken

Flybar

Flybar POGO TRICK BOARD Bedienungsanleitung

Crivit

Crivit 93713 Bedienungsanleitung

Lifetime

Lifetime POWER LIFT 90865 Bedienungsanleitung

Hudora

Hudora 76171 Montageanleitung

Axler

Axler GSU-1 Bedienungsanleitung

Aquaglide

Aquaglide FREEFALL 6 LANDING PAD Bedienungsanleitung

Cap Strength

Cap Strength POWER RACK FM-CS7000F Bedienungsanleitung

La Sportiva

La Sportiva RACE BORG Bedienungsanleitung

Crivit

Crivit 302640 Bedienungsanleitung

Sportime

Sportime Equalizer Bedienungsanleitung

T&R Sports

T&R Sports 5FT FOOSBALL TABLE Bedienungsanleitung

Salewa

Salewa VERT Bedienungsanleitung

KICK

KICK Decagon Bedienungsanleitung

byox

byox FJ-4.5FT Bedienungsanleitung

CHINESPORT Spa

CHINESPORT Spa 01325 Bedienungsanleitung

AXI.COM

AXI.COM ConesPro101 Bedienungsanleitung

Insportline

Insportline IN 2052 Bedienungsanleitung

Rugged Interactive

Rugged Interactive CardioWall Compact Kurzanleitung