SportsPlay 511-107 Bedienungsanleitung

511-107 Balance Beam Page 1 of 1

Rev 04/04/03

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

* IMPORTANT *

PLEASE RETAIN THIS INSTRUCTION SHEET IN YOUR FILES. IT CONTAINS IMPORTANT REPLACEMENT

PARTS INFORMATION. ALL EQUIPMENT SHOULD BE INSTALLED IN ACCORDANCE WITH THESE

INSTRUCTIONS.

IT IS IMPORTANT TO USE AND MAINTAIN ALL PUBLIC PLAYGROUND EQUIPMENT PROPERLY. PLAYGROUND

EQUIPMENT, WHICH IS IMPROPERLY MAINTAINED, CAN CAUSE SERIOUS INJURY. PERIODICAL

INSPECTIONS, MAINTENANCE, REPAIR AND/OR REPLACEMENT OF DAMAGED PARTS IS NECESSARY FOR

SAFE OPERATION OF EQUIPMENT AND SAFETY OF USERS. RESILIENT SURFACING SHOULD BE USED

UNDER ALL PLAYGROUND EQUIPMENT. APPROPRIATE PUBLICATIONS, AVAILABLE AT NO CHARGE, FROM

THE CONSUMER PRODUCT SAFETY COMMISSION, INCLUDE “A HANDBOOK FOR PUBLIC PLAYGROUND

SAFETY.” YOU CAN RECEIVE YOUR FREE COPY BY CALLING 1-301-504-7908.

PACKING LIST HARDWARE BAG

1 CTN Hardware Bag 6 126-504 5/16” x 1” Carriage Bolt

1 513-932 Beam 12’ x 3” x 3 ½”W 6 316-501 5/16” Flat Washer

1 BDL 3 603-629 Leg 6 226-501 5/16” Lock Washer

6 216-501 5/16” Hex Nut

1 805-532 Warning Label

1 805-534 SportsPlay Label

1 Maintenance Checklist

1 CTN 1 BDL 2 TOTAL PCS WT 40# CLASS 70

511-107 Balance Beam Page 2 of 2

Rev 04/04/03

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

GENERAL USE/FALL ZONE & FOOTING RECOMMENDATIONS

STATIONARY & PORTABLE EQUIPMENT – USE/FALL ZONES SHOULD EXTEND A MINIMUM OF 6 FEET IN ALL

DIRECTIONS FROM THE PERIMETER OF THE EQUIPMENT GROUND SPACE. THIS AREA SHOULD BE COVERED

WITH THE REQUIRED AMOUNT OF RESILIENT SAFETY SURFACING MATERIAL. FOR SOME EQUIPMENT –

USE/FALL ZONES CAN OVERLAP. SEE CONSUMER PRODUCT SAFETY COMMISSION GUIDELINES.

DIAMETER & DEPTH OF FOOTING ILLUSTRATED ARE SATISFACTORY IN MOST APPLICATIONS FOR PIPE

SIZES UP TO 2 3/8” DIAMETER. VARYING SOIL & CLIMATIC CONDITIONS MAY REQUIRE DEEPER &

HEAVIER FOOTINGS IN SOME AREAS. CHECK LOCAL BUILDING CODES.

* If resilient surfacing is to be less than 12”, then additional pipe should be put in

concrete to maintain proper finish grade for equipment.

511-107 Balance Beam Page 3 of 3

Rev 04/04/03

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

GENERAL ASSEMBLY INSTRUCTIONS:

Check all the parts and hardware with the packing list to be sure you have received

everything needed to assemble this product. CONTACT YOUR LOCAL DISTRIBUTOR WITH

NOTIFICATION OF ANY MISSING OR DAMAGED PARTS. Contact must be made within ten days of

receipt of your order.

Only hand-tighten nuts & bolts on initial assembly. Final tightening should be done

EVENLY after final assembly when unit has been plumbed & leveled.

After assembly is complete, ANY ENDS OF BOLTS PROTRUDING BEYOND NUTS SHOULD BE CUT OFF

AND/OR PEENED OVER TO REMOVE ANY SHARP EDGES. Go over entire unit to file smooth any

sharp edges or projections that may have been caused by rough handling in shipping or

installation. T-Clamps are designed for both one and two bolt connections. In many

situations only one bolt is required. See specific assembly instructions.

On products with platforms install 1 – 2 degrees off level to facilitate water drainage.

GENERAL MAINTENANCE INSTRUCTIONS:

Check MONTHLY for loose bolts, damaged or broken parts. Tighten and/or replace

immediately.

SPECIFIC ASSEMBLY INSTRUCTIONS:

NOTE: All threaded ends of bolts protruding beyond nuts must be cut off and/or

peened to eliminate sharp edges. No more than two threads should extend

beyond face of nut.

All washers, “T” nuts, and other fastener hardware used on round pipe or

tubing must be hammered down to conform to the curved underlying surface to

eliminate catch points.

STEP #1: Mark & dig footing holes per SKETCH on PAGE #2.

STEP #2: Assemble Beam on the ground per SKETCH on Page 2.

STEP #3: Stand up and brace in footing holes. Height of beam above resilient

surfacing can be lowered from the 12” recommended by extending the depth of

footing holes.

STEP #4: Plumb & level. Tighten all nuts & bolts so that lock washers are flat.

Pour concrete and crown surface for drainage. Let stand 48 hours before

removing braces, installing resilient surfacing and using equipment.

STEP #5:

Attach Warning Label and Manufacturer’s Identification Label to a clean

surface. The labels should be attached in a location where they are clearly

visible and legibl3e and away from normal hand and foot placement areas.

The labels must be replaced if they become illegible, destroyed or removed.

Contact your distributor for replacement labels.

Inhaltsverzeichnis

Andere SportsPlay Spielgeräte und Spielplatzausstattung Handbücher

SportsPlay

SportsPlay Zack 911-131 Bedienungsanleitung

SportsPlay

SportsPlay 902-875 Bedienungsanleitung

SportsPlay

SportsPlay ZACK Bedienungsanleitung

SportsPlay

SportsPlay 581-238M Bedienungsanleitung

SportsPlay

SportsPlay MUSHROOM KOTTAGE Bedienungsanleitung

SportsPlay

SportsPlay 581-238F Bedienungsanleitung

SportsPlay

SportsPlay Seth Mega Installations- und Betriebshandbuch

SportsPlay

SportsPlay 581-242F Bedienungsanleitung

SportsPlay

SportsPlay 902-290 Bedienungsanleitung

SportsPlay

SportsPlay 581-630M Bedienungsanleitung

SportsPlay

SportsPlay Megan Bedienungsanleitung

SportsPlay

SportsPlay 581-842HD Bedienungsanleitung

SportsPlay

SportsPlay Ray 2 Bedienungsanleitung

SportsPlay

SportsPlay 581-442HD Bedienungsanleitung

SportsPlay

SportsPlay MODERN BIPOD ADA SWING Bedienungsanleitung

SportsPlay

SportsPlay 581-830-8F Bedienungsanleitung

SportsPlay

SportsPlay LAUREN Bedienungsanleitung

SportsPlay

SportsPlay 801-312-H Bedienungsanleitung

SportsPlay

SportsPlay Quick Ship 3 Modified Bedienungsanleitung

SportsPlay

SportsPlay 581-240HD Bedienungsanleitung

SportsPlay

SportsPlay 511-152 Bedienungsanleitung

SportsPlay

SportsPlay 902-706 Gebrauchsanweisung

SportsPlay

SportsPlay 581-630F Bedienungsanleitung

SportsPlay

SportsPlay 581-638M Bedienungsanleitung

Beliebte Spielgeräte und Spielplatzausstattung Handbücher anderer Marken

FUNormous

FUNormous Disney Junior MICKEY MOUSE Bedienungsanleitung

b4Adventure

b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Bedienungsanleitung

PoolMaster

PoolMaster 72775 Bedienungsanleitung

Palmako

Palmako 4743142009857 Installationshandbuch

BOERPLAY

BOERPLAY PSTE000.019 Bedienungsanleitung

MGA Entertainment

MGA Entertainment Little Tikes Dunk'n Toss Bouncer Benutzerhandbuch

stilum

stilum Erika Bedienungsanleitung

Costway

Costway NP10816 Bedienungsanleitung

Trigano

Trigano VABI Bedienungsanleitung

Outward

Outward OUT116 Bedienungsanleitung

GALOPIN

GALOPIN ARC02 Bedienungsanleitung

stilum

stilum levis Technische Daten

Ledon

Ledon BASIC Bai LB012 Bedienungsanleitung

BOERPLAY

BOERPLAY PSTE115.002 Bedienungsanleitung

Europlay

Europlay S306 Programmierhandbuch

SportsPlay Equipment

SportsPlay Equipment 361-509H Bedienungsanleitung

Ledon

Ledon 302250 Bedienungsanleitung

Costway

Costway NP10441 Bedienungsanleitung